5UXCR6C52KLL229132019 BMW X5xDrive40i

The oil pump failed on my X5. The factory installed oil pump has a plastic housing that cracks and leads to oil pump failure. BMW replaced the part with a newer model that has a metal housing.

I was shocked by the failure of the oil pump on my 2019 BMW X5. Furthermore, through my research and discussions within the BMW community, it is evident that this specific oil pump associated with 2019 engine component has a documented history of premature failure and known defects (plastic). Given that this is a known vulnerability rather than standard wear-and-tear, I do not believe that I should bear the full burden of such an exorbitant repair cost of $6890. Why is issue has not been recalled by BMW??

I always service and baby my vehicle. Had recently got starter recall & fresh oil change done 2 months at my local BMW Atlantic City NJ dealership. On June 27th, as I was driving the vehicle normally a message popped on the dash stating engine oil is at a minimum level, add 1 liter of engine oil, refill oil immediately. So I went to my earliest autozone bought quart of mobile 1 oil and refilled it. After that the warning message went away and came felt fine. Unfortunately the next day same message popped up, so drove over to BMW service to get diagnosed. Due to the computer system in the vehicle not being able to read the oil level measurement. It would go from 0-18% oil level reading then message would pop up saying unable to read to try again or make sure vehicle is on ground level which I made sure it was. So next day I dropped it off at BMW dealership for diagnosing. After 1 day and half they came to the conclusion that it is a bad oil pump and wants to charge $6,362.31 for repairs. Advisor stated its due to older gen bmw b58 engines using plastic oil pumps inside which causes to break and cause leaks. So they are aware its an common issue but won’t do an recall or service bulletin to fix issue which is very dangerous because the engine could seize up and stall anytime I’m driving around due to not knowing the oil level measurements. It is super risky and unfair for consumers to pay for such a big bill repair. I hope there is recalls or something to help remedy this cause for current & future BMW affected vehicles. BMW is aware of this issue but won’t resolve it.

* Intelligent Braking system. * yes it is available for inspection * I was inches from colliding with the vehicle in front of me when my car finally stopped. * Yes local official BMW dealership inspected and diagnosed the IBS module is defective. * there was no prior warning.

The vehicle is at A&L Motors in Monroeville Pa. The vehicle has suffered a catastrophic, cascading electrical failure caused by a known manufacturing defect in the roof antenna seal. Rainwater entered the vehicle through the defective shark fin antenna seal and flooded the Telematics Control Unit(TCU). Because the TCU communicates directly with the main iDrive head unit via the vehicle's MOST/bus central data network, the water-damaged TCU short-circuited and flooded the network with corrupt electrical data, hard-bricking the iDrive system. A dealership engineer confirmed that water did not physically touch the head unit, eliminating user-error fluid spills. This cascading electrical failure has completely disabled vital safety systems, including the backup camera, forward collision driver-assist radar warnings, blind-spot monitoring alerts, and critical dashboard diagnostic notifications, creating an immediate highway safety hazard. Simultaneously, the active grille shutters (active air flaps) failed due to a defective internal actuator motor, creating a severe risk of sudden engine overheating and thermal shutdown. This component is under a 150K mile manufacturer warranty extension(SIB01 12 19 and later sib01 03 25). BMW of North America Claims Manager Joe 1-800-831-1117Ext1427 has issued an arbitrary final denial for these repairs based on a hearsay rock wedged/strike despite no apparent physical damage and zero photographic evidence. BMW is actively evading its extended warranty obligations for the air dam and a pending class-action settlement framework (Craft v. BMW NA) on the IDrive components. Additionally, this vehicle is actively subject to the critical BMW Starter Motor Overheating Fire Risk Recall NHTSA Campaign No.25V644/26V056. The dealership is unable to complete this urgent fire-safety remedy due to the same bricked Idrive unit. Grounding an owner in an un-safe car with a bricked safety display and an outstanding unremedied recall

Oil pump with plastic parts failing

The engine oil pump failed internally. The vehicle is equipped with a factory-installed variable-displacement oil pump that utilizes an internal thermoplastic adjusting ring. Due to heat cycles and mechanical stress, this plastic component degrades, becomes brittle, and catastrophically shatters or cracks.The first symptom appeared when the vehicle became entirely unable to complete an electronic engine oil level measurement via the iDrive system, consistently freezing and aborting the test at approximately 15% to 20%. This defect directly compromises road safety. A sudden drop in oil pressure causes severe internal engine friction, leading to immediate engine seizure or a total loss of motive power without adequate warning. Experiencing a sudden engine stall while driving at highway speeds places the driver, passengers, and surrounding motorists at extreme risk of a high-speed rear-end collision. Furthermore, a total engine shutdown disables power-assist steering and braking, making the vehicle incredibly difficult to control and maneuver to safety. Catastrophic mechanical failure from oil starvation also presents a severe under-hood fire hazard if oil leaks onto hot exhaust components.The problem has been officially reproduced and confirmed. The vehicle was brought to Bavarian Werkstatte, where certified technicians diagnosed the issue as an internal structural failure of the variable-displacement oil pump's plastic adjusting ring. The component is currently available for inspection upon request. BMW is fully aware of this defective design. They updated this exact component in mid-2020 to an all-metal oil pump to prevent plastic fragmentation. Despite knowing that the 2019 thermoplastic rings degrade, become brittle, and shatter under normal operating heat cycles, the manufacturer has failed to issue a safety recall in the United States, leaving drivers exposed to dangerous sudden engine failure.

I am writing regarding my BMW X5 xDrive40i, model year 2019, engine code B58TU. The vehicle has been serviced at authorized BMW dealerships. For this engine type B58TU especially years 2018-2021, repeated oil pump failures have been reported due to a known design issue: an internal plastic component can develop cracks, potentially leading to a complete oil pump failure. BMW silently replaced the oil pump with the updated version by keeping the same part number but featuring metal internals. Once there is a fail on the oil pumps with plastic components, engine loses access to get the oil an immediate stop is needed. This creates a huge safety concern cause: 1) If you are on a highway at highway speeds it might not be possible to move to the shoulder safely with no engine power or even worse: with a locked engine. 2) If there is a maintenance on the road with no shoulder access or if this is a bridge where there is no shoulder, it creates a huge risk to safely move the vehicle. An unavoidable sudden stop can create a huge accident risk for everybody. Of course any car can get a engine problem on those occasions but this is a very known and very common problem for BMW cars equipped with B58TU engine especially years 2018-2021. BMW is also definitely aware of that and this safety concern cause they updated the design silently. But, when contacted with BMW NA, they refused to help, refused to admit there is a design problem. They also refused to change the oil pump with the updated oil pump even with my proposal of goodwill pricing.

I am writing regarding my BMW X5 xDrive40i, model year 2019. For this G05 model coded cars, repeated transfer case failures have been reported due to a known issue: on the factory they put a wrong oil in it and then published a Technical Bulletin about it as if they are not the ones responsible for that. The problem is, due to that mistake, transfer cases of cars manufactured between 2018-2020 becomes dead in time. Cars shudders, jerking at low speeds, cannot deliver the power to the ground effectively due to intermittent and very disturbing, powerful shudders. This creates a huge safety concern cause: 1) if you are on an intersection the car might not join safely to the traffic in a perceived timing due to the shudders, intermittent power delivery. 2) If you are on a driveway and moving to the street the car might not move to the street for the perceived timing or once moved cannot move safely to join the traffic. 3) If there is a failure on the transfer case and if there is a sudden stop is needed. On the road with no shoulder access or if this is a bridge where there is no shoulder, it creates a huge risk to safely move the vehicle. An unavoidable sudden stop can create a huge accident risk for everybody. This is a very known and very common problem for BMW cars equipped with B58TU engine especially years 2018-2020. BMW is also definitely aware of that and this safety concern but instead of fixing it they moved away their responsibility as if they are not the ones made the mistake. But, when contacted with BMW NA, they refused to help.

The evaporator for the air conditioning failed. BMW used an aluminum evaporator with yf coolant. Those combined cause the coolant to eat away the evaporator. Once the yf comes in contact to the air it turns toxic. This shouldn't fail at 82,000 miles.

I am reporting a safety concern involving BMW vehicles equipped with the B58 Technical Update (B58TU) engine, commonly found in model years 2019–2021. These vehicles utilize a variable-displacement engine oil pump containing an internal thermoplastic adjusting component responsible for regulating oil pressure. Field failures are increasingly being reported in which this internal component fractures, resulting in sudden loss or instability of engine oil pressure. The failure frequently occurs during cold-start operation in low ambient temperatures. When the component fails, oil pressure regulation becomes erratic or is lost entirely. In many cases, drivers receive little or no actionable warning prior to engine damage or vehicle disablement. Reported precursor symptoms include inability to electronically measure engine oil level, abnormal oil pressure behavior, or sudden drivetrain malfunction warnings. Failures may rapidly progress to engine shutdown or severe mechanical damage caused by oil starvation. Loss of lubrication can cause the vehicle to become disabled without warning while driving or shortly after startup. This creates a safety hazard, particularly when vehicles become immobilized in active traffic or during winter conditions the cold is when they fail the most, where occupants may be exposed to freezing temperatures while awaiting assistance. Replacement of the oil pump requires extensive disassembly of the vehicle and repairs commonly exceed $6,000–$8,000 for just the pump, assuming the motor is unharmed. Owners are currently unable to determine whether their vehicles contain the original thermoplastic oil pump design or a later revised version utilizing metal internal components, as VIN-based parts information now identifies updated components in the car even when no replacement has occurred and the old components are actually in the car. Also, BMW has actively removed the plastic part number out of all dealer networks as well.

I am reporting a safety concern involving BMW vehicles equipped with the B58 Technical Update (B58TU) engine, commonly found in model years 2019–2021. These vehicles utilize a variable-displacement engine oil pump containing an internal thermoplastic adjusting component responsible for regulating oil pressure. Field failures are increasingly being reported in which this internal component fractures, resulting in sudden loss or instability of engine oil pressure. The failure frequently occurs during cold-start operation in low ambient temperatures. When the component fails, oil pressure regulation becomes erratic or is lost entirely. In many cases, drivers receive little or no actionable warning prior to engine damage or vehicle disablement. Reported precursor symptoms include inability to electronically measure engine oil level, abnormal oil pressure behavior, or sudden drivetrain malfunction warnings. Failures may rapidly progress to engine shutdown or severe mechanical damage caused by oil starvation. Loss of lubrication can cause the vehicle to become disabled without warning while driving or shortly after startup. This creates a safety hazard, particularly when vehicles become immobilized in active traffic or during winter conditions the cold is when they fail the most, where occupants may be exposed to freezing temperatures while awaiting assistance. Replacement of the oil pump requires extensive disassembly of the vehicle and repairs commonly exceed $6,000–$8,000 for just the pump, assuming the motor is unharmed. Failures have been reported across multiple production years, and affected vehicle population boundaries remain unclear. Because this condition can result in sudden vehicle disablement without adequate warning especially in the cold, I believe this issue warrants investigation as a potential safety-related defect.

1 - Parking Brake inoperative - Unable to disengage parking brake: Recalled part for same year/make/model (Different production MONTH in recall) NHTSA safety recall OMB Control No: 2127-0004 2 - Air conditioner (Evaporator failure) - Releasing chemicals from enclosed HVAC system: Common knowledge failure point, requires entire dashboard disassembly w/High Labor cost Unsafe driving conditions in excessive heat (Las Vegas, local area driven) History: August 2025 - Parking brake stopped working: I obtained a diagnosis from independent service shop stating the center console control panel - containing the Body Domain Controller (BDC) requires replacement. The parking brake is currently inoperable Under NHTSA safety recall OMB Control No: 2127-0004 - Part 573 Safety Recall Report 18V-732: This specific part for this specific vehicle (year, make and model) has been recalled under a different production month. March 2026 - Air Conditioner Failure: The A/C system stopped working (Blowing hot air only). I filled the A/C system on 3/12/2026, and within 2 weeks the system chemicals had been released into the environment due to a leak in the evaporator. The evaporator was diagnosed by two (2) independent mechanics as the failure point of the AC system. The Air conditioner is currently inoperable and I reside in Las Vegas - Temperatures average well over 100 degrees and we are approaching summer. Common knowledge failure point: A/C Evaporator - Located deep within the dashboard at the firewall, requiring an interior disassembly - Skilled labor and time Manufacturer's defect: Upon research, these are very common failure point as a result of the improper engineering of the AC system on this particular vehicle.

I am reporting a safety concern involving a 2019 BMW X5 that experienced a sudden and catastrophic engine failure at approximately 75,000–80,000 miles. The failure occurred without any prior warning indicators, dashboard alerts, or fault codes. The vehicle lost engine function and required inspection by an authorized BMW dealership. The dealership documented internal engine damage, including metallic debris in the oil system, oil contamination, and bottom-end engine knocking. A full engine replacement was recommended. This raises safety concerns because: The failure occurred without warning Sudden engine failure could create hazardous driving conditions depending on speed and location There may be a broader pattern of similar failures BMW of North America has denied assistance and has not provided any explanation for the cause of the failure. I am submitting this complaint so the incident can be recorded and evaluated as part of any potential defect investigation.

During the last service at the dealership. While they are replacing the battery, they found a melted bolt on the auxiliary battery that causes a loose cable connection and informed me that its a fire hazard. The car has 85k at the moment and all services were done at the dealership. No incident or any repairs. This is not a wear and tear. How can a bolt just melt. It might even melted a while ago and putting drivers in hazard without know because they would not noticed this unless a battery is getting replaced.

My daughter was driving my BMW X5, it went to neutral and not moving, she was panicked and stopped the car and ignition. After restarting the car, it worked for a day, then it happened again, also, I see notifications on dashboard for restraint warning, saying, airbag, and seat belt tension are reduced. I took to Fairfax BMW in VA, BMW quoted $2662, informed that my BMW went out of extended warranty over a month, I asked Goodwill request to BMW, still declined.

I recently took my 2019 X5 to the BMW dealership because of the recall (Engine starter) and the code P0456 (NVLD Minor Leak Fault). At the same time, there's a warning that says, "Oil at a minimum level. Add 1 liter immediately". I have the 3 Year Oil Plan and asked them to put some oil, but the dealership said that they can't add oil because the oil level wouldn’t read properly. They told me they couldn’t diagnose it without charging me an extra 300 for further testing. Then, I read a lot of threads online and it seems that BMW quietly changed the pump to an all-metal design around 2020 but never issued a recall or extended warranty for the earlier cars. There's a lot of customers complaining with the B58TU engine found in many 2019–2021 BMWs (X5 xDrive40i, 540i, 340i, etc.). The variable oil pump uses a plastic internal adjusting ring that cracks over time. When it fails, oil pressure becomes unstable or is lost, often with little warning. A common early symptom is the oil level sensor test failing and stopping around 12-20%. In the worst cases, it can lead to sudden engine damage or the car shutting down while driving. I called up my mechanic, and he said that this is a common problem and it could be an oil pump issue that needs to be replaced. I asked him for a quote and he said approximately 5k or more. I believe this is a safety defect that deserves investigation Hoping for your kind consideration. I plan to keep my car as long as possible Thanks, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Emergency call system malfunction. Vehicle available for inspection. Warning appears and verified by dealer as common issue with vehicle type due to shark fin antenna seal leaks, causing corrosion in the module when in contact with water (including rain). Cause loss of GPS and wireless capability.

The starter on my BMW failed, and it overheated and damaged my alternator to the point that I needed to replace it. The dealer and independent service center confirmed that this was the cause, but BMW is refusing to reimburse the cost of the alternator replacement. I was at the exit of a highway and could not even put the car in neutral, so my safety was significantly at risk.

The contact owns a 2019 BMW X5. The contact stated that while driving at an undisclosed speed, the vehicle unexpectedly overheated, and the engine temperature warning light illuminated. The vehicle was taken to a dealer, where it was diagnosed that the coolant line to the cylinder had failed and needed to be replaced. The vehicle was repaired. The contact later received notification of NHTSA Campaign Number: 25V644 (Electrical System). The manufacturer was not made aware of the failure. The approximate failure mileage was 101,187.

The AC evaporator failed due to a known manufacturing defect common across the BMW G-chassis platform (G05, G07, G30). This has created two severe safety hazards: The refrigerant leak causes the windshield to fog up instantly and unexpectedly while driving, completely obstructing my visibility and nearly causing an accident. Chemical fumes and oil from the leaking evaporator are entering the cabin through the vents, causing dizziness and respiratory irritation for the occupants. BMW is aware of this systemic issue through numerous owner reports and petitions but refuses to issue a recall or provide assistance. This is a critical component failure that directly impacts vehicle safety and occupant health.

I am writing to report a significant safety issue associated with BMW vehicles equipped with the B58TU engine, particularly the 2019-2021 models. These vehicles feature an oil pump containing an internal plastic component responsible for regulating oil pressure. There have been numerous instances of this part fracturing in the field, leading to a sudden loss of oil pressure. The failure predominantly occurs during cold starts in low temperatures. When this occurs, oil pressure can fluctuate erratically or be lost completely, often with minimal warning. Potential warning signs include difficulties in electronically measuring the oil level, abnormal oil pressure readings, or sudden drivetrain malfunction alerts. These issues can escalate quickly, resulting in engine shutdown or severe damage due to oil starvation. This situation poses a serious risk, as the vehicle may become inoperable without warning while driving or immediately after startup. Such failures are particularly hazardous when vehicles become immobilized in traffic or during winter conditions, leaving occupants vulnerable to harsh temperatures while awaiting roadside assistance. The replacement of the oil pump necessitates extensive disassembly and typically incurs a cost of $6,000-$8,000, assuming no engine damage has occurred. A significant concern is that owners cannot easily ascertain whether their vehicle is equipped with the original plastic pump or a revised metal component. BMW's VIN-based parts lookup now indicates updated components even if the original plastic parts are still installed. Additionally, the original plastic part number has been removed from dealer networks. Failures have been reported across multiple production years, and the full extent of affected vehicles remains uncertain. Given that this condition can lead to abrupt vehicle disablement without adequate warning—especially in cold weather—this situation warrants investigation as a potential safety-related defect.

I bought the car from the dealership, and they said there were no problems with it, but they cheated me. The car broke down twice. The first time, it was parked in a private lot for several hours, and I paid a large sum for parking. The second time, it broke down on the street, and I waited eight hours for help to tow it back to the dealership. 1-recall message 2- emergency call system

Subject: 2019 BMW X5 xDrive40i – Oil Pump Defect Causing Oil Measurement Failure and Safety Risk I am reporting a safety defect in my 2019 BMW X5 xDrive40i with the 3.0L B58 inline-6 engine. The vehicle currently has approximately 70,000 miles. The vehicle is unable to properly measure or display engine oil level due to incorrect oil readings, which have been attributed to a failing oil pump assembly containing internal plastic components. Because this vehicle does not have a traditional dipstick, the electronic oil level monitoring system is the only way to verify proper oil level. Due to the defective oil pump design, I am unable to confirm whether the engine has sufficient oil. This creates a serious safety concern because: •The vehicle may be operating with low oil pressure without accurate warning •Sudden oil pressure loss could cause engine shutdown while driving •Loss of power at highway speeds could result in an accident •Catastrophic engine failure could occur without proper oil monitoring This is not normal wear and tear. BMW has reportedly updated the oil pump design in newer model years to use metal internal components, suggesting awareness of a design weakness. However, no recall has been issued for 2019 models. An oil pump that prevents accurate oil level measurement and may fail prematurely presents a significant safety hazard. I respectfully request that this defect be formally investigated and that BMW be required to issue a recall to replace the defective oil pump assembly with the updated metal design.

The contact owns a 2019 BMW X5. The contact stated that while driving approximately 45 MPH, the red oil light suddenly illuminated and the messages "Stop Carefully and Turn Off Engine", “Engine Oil Pressure Too Low", "Continued Driving will Result in Engine Damage". The vehicle was towed to the local mechanic, who discovered that the engine oil was black and thick. The vehicle was later towed to the local dealer, who confirmed that the engine oil was thick and dark, and the engine needed to be replaced. The failure mileage was 85,000.

BMW knowingly did NOT NOTIFY it's 2019 BMW X5 M40i (engine B58) vehicle owners. This is in reference to the faulty design and made plastic engine oil pump. It has been known to fail prematurely due to weaken parts. Some analysis done was from certain oil viscosity's applying additional unneeded stressful pressures. This later was recognized by BMW and a newer design and/or metal sturdier one had taken it's place in subsequent model years starting in 2020. Some owners were able to remediate the oil pump failure and new replacement either covered under intact warranties, and some were covered through quieter negotiations with BMW Customer Care's authorizations. To my understanding, no recalls were made nor were any techical service bulletins (TSB) made to it's owners. I don't see how BMW can be allowed to get away with an issue of safety which could cause a catastrophic failure of the affected engine? Under the circumstances, BMW should be fully reimbursing me for the repairs here, and be glad there were NO serious injuries OR worse, DEATHS! I have been in contact with their Customer Care and nothing has been done to date.

Premature oil pump failure. 2019 BMW x5 with only 46k miles has been diagnosed with an oil pump failure. Vehicle needed to be quickly pulled over and shut off to avoid catastrophic engine failure or engine seize. If this happens on the highway or at any speed the vehicle will lose power and be unsafe to control likely ending in an accident. This is a known Issue. BMW produced the vehicle with a flawed oil pump design that has a plastic ring around the impeller. The ring deteriorates and cracks leading to pump failure and loss of oil pressure It is only on limited models early 2019 X5. BMW redesigned with an all metal pump quietly. This issue needs to be addressed with BMW as it is unsafe for these family vehicles to be on the road with such a significant risk to its passengers and others. The failure happens with little to no warning. When contacting BMW they told me they would not consider helping with repairs. The repair for this part is upward of $8k which in turn will likely limit consumers ability to fix proactively. This is totally unacceptable and needs to be addressed by the NHTSA directly with BMW. P

The engine warning system came on and warned of low oil pressure. Knowing the oil level was good I stopped the vehicle to check oil leaks. Found none. Knowing engine mechanics I assumed it was a faulty oil pump. had it towed to BMW and told it was so. The replacement would be $8,000. Found out after lengthy research that the oil pump of the 2019 X5 (which I have) was made with plastic internal parts that would be a matter of when not if, the plastic parts would fail because the acidic nature of used oil. Presented this info to BMW and they lowered the price to $3986.16. Then I discovered BMW knew about the problem and changed the oil pump design from 2020 on.

Engine Starter overheating. Car won't start until engine cools down. Car would not let my shift into neutral in order to move to a safe location. Was stuck in front of several cars in an unsafe location. No warning message showed up. Car was just inspected and serviced with no indication that this was a problem. Car taken to dealer after incident and inspected produced the same results.

Car randomly wouldn’t start and was getting error starter message on message center

The emergency call system and hands free microphone does not work due to the telematic control unit getting wet as a result of the shark fin antenna leaking. As a result I cannot rely on communication through this system in the event of an emergency which was one of the features that lead me to the decision to buy this car. The vehicle has been inspected by the dealer. The first warning lamp brought to the attention of the dealer in February.

Transfer case on 2019 X5,yes available for inspection upon request. At stop position making right turn or left turn the vehicle jutters,also in reverse. Yes - confirmed by the bmw service center who tried to charge for diagnostic fee. Manufacturer knows of issue on 2019 X5 models. Video of these transfer case issues all over online in videos. Issue started about 6 - 9 months ago.

Parking brakes can only be applied but cannot be released due to faulty design of the parking switch. This will cause the vehicle not able to move or be towed in an emergency especially when an engine failed to start. This problem confirmed by an independent repair shop and also has highlighted in several BMW group chats.

I am reporting a recurring safety-related defect with the infotainment/iDrive head-unit in my 2019 BMW X5 xDrive40i. The central display repeatedly goes completely black or shows “No Signal” while the vehicle is otherwise drivable. When this happens, iDrive is unusable and I lose: 1. Rearview camera and visual parking aids 2. Parking sensor visuals 3. Navigation and key vehicle information 4. Access to settings that only exist in iDrive BMW service says this is due to the vehicle’s “age” and recommends a full head-unit (hardware) replacement at my expense, even though this is a software-driven system. A previous identical failure on this car resolved on its own with no hardware change, which strongly suggests a software/firmware defect, not a worn-out part. This problem is widespread, not just my car. Many BMW owners report the same black-screen/“No Signal” iDrive behavior on similar models and years, often after software updates and even after multiple head-unit replacements, with no lasting fix. One example thread: [XXX] As a long-time BMW owner, it is extremely frustrating that BMW has not given a convincing engineering explanation or solution and keeps falling back on expensive hardware swaps. 1. Driving risks when the display/iDrive fails include: 2. Reversing or parking without a rearview camera 3. Low-speed maneuvering without visual parking sensors 4. Driver distraction from a sudden blank screen 5. Loss of navigation and information needed for safe route choice and lane changes I respectfully request that NHTSA investigate whether there is a systemic defect in the infotainment/iDrive system and software on the 2019 BMW X5 xDrive40i (and related BMW models), and whether BMW’s remedies and owner guidance are adequate from a safety standpoint. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I am reporting a serious safety defect involving the oil pump assembly on my 2019 BMW X5 xDrive40i. While driving at low speed in normal conditions, a sudden dashboard warning appeared stating: “Engine oil pressure too low — stop carefully.” I immediately pulled over and shut off the engine. My vehicle had been serviced by an authorized BMW dealership less than one week earlier, and no faults or issues were identified. There were no warning signs or symptoms prior to the failure. An independent licensed repair facility inspected the vehicle after the incident and confirmed that the oil pump had failed due to a defective plastic internal component used in the pump’s design. The failed parts are available for inspection upon request. This failure created a significant safety risk, as sudden loss of oil pressure can cause engine seizure, loss of power steering, loss of braking assist, and an inability to safely control the vehicle. Had this occurred at highway speeds, the consequences could have been severe. I have since learned that this exact issue has been reported by other owners of 2019 BMW X5 vehicles and other BMW models using the B58 engine, which were equipped with an oil pump containing plastic internal drive components prone to cracking or separating. BMW appears to have updated the oil pump design to a metal version in 2020 and later models, suggesting the manufacturer was aware of the weakness of the earlier design. The defect was confirmed by an independent service center. The vehicle had also been inspected by BMW one week prior during scheduled service, yet no issues were detected. Because this failure presents a clear safety hazard and appears to be related to a widespread design flaw, I respectfully request that NHTSA open an investigation into the oil pump used in 2019 BMW X5 vehicles and consider issuing a safety recall.

while stopped in traffic on a freeway in fast lane, the vehicle was in the "stop/go" mode. When I pressed the accelerator, the engine failed to start. On multiple attempts engine would not start and I could smell electrical burn. The CHP was on site and we attempted to push the car to the side and out of the fast lane. However, since the engine would not start, there was no way to shift the car into Neutral gear. This is a design flaw and could lead a serious injury of fatality if the drive is stuck on the freeway and unable to move car. Even with Tow Truck, the car had to be dragged onto the truck bed. This is related to recall no. 25V-644. The recall should be elevated to "critical" status.

The contact owns a 2019 BMW X5. The contact stated that while his wife was driving approximately 30-40 MPH, the message “Low Engine Oil” and to pull over to avoid engine destruction was displayed. The driver pulled over. The vehicle was towed to the dealer, where it was diagnosed, and determined that the internal parts of the oil filter made of plastic had deteriorated. The dealer determined that the engine needed to be taken apart to replace the filter. The vehicle was repaired. The manufacturer was notified of the failure and covered half the cost of the repair. The failure mileage was approximately 80,000.

The shark fin is leaking and can’t be in rain or drive in rain bc it can cause wires to catch fire or shorten out. I have two babies that are at risk every time I drive this car. It’s my only way to go and BMW won’t fix it and I can’t afford to fix it bc it’s over 3 thousand dollars.

HVAC. Misty and mold smell from ac vent. Health concerns F or people with aasthma and respiratory health issues. All bmw of this year has this issue. Took it to dealer and got evporater cleaned vut smaell returns again in 2 months. Evaporator leak is very common. Most owners have had this issue fixed and repaired at $7k cost of out of warranty. BMW dealer ship admits issue with this year of bmw but declines to fix it for free. bMW itself ignores all the conversations bout it.

a concern regarding my BMW x5 it’s a 2019 x50i it’s my only vehicle that I have to get to and from work and drive my family around. I have been having starting issues at random times I can go a week no issues than randomly. My vehicle doesn’t want to start. Also, I have engine codes that are the same ones that apply to other recalls my starter is my main concern because it is an unsafe situation in certain circumstances because it’s happened at a light due to the auto stop switch I have to turn it off so that problem wouldn’t occur anymore because it also happened on the freeway during traffic that was a scary scenario when I had my family with me luckily it did turn on as I was steering out the way of traffic, I love the car unfortunately it is giving me safety concerns ,I seen there is a recall on NHTSA Campaign Number: 24V-576 subject : Starter Motor May Fail and Overheat according to this my vehicle meets all these criteria’s I need help with further assistance please if you can and thank you for your time.

My shark fin has water damage and can’t drive or be in rain and this is the only car I have to take my young kids back and forth to school and do my grocery shopping or whatever I need

I bought the car 8 months ago from Fred Anderson Acura in Greenville was told the car was inspected and serviced and I’m was in great condition. 8 months later I have 10 thousand worth safety issues wrong with the car that I have to fix .

gas pedal broke while driving on the interstate causing driver to briefly lose control of car at the same time signal was lost from pedal to engine resulting in surge in the coolant system via ECm computer that blew radiator hose a moment after pedal broke. Pulled over and had car towed.

Water leaked into the Electric panel that controls the emergency call system & creates a malfunction.

Car wouldn't start anymore, starter malfunction. couldnt go into neutral

Failed components 1. oil pump $8769.41 2. Cylinder Head Assembly- Valve Cover $4280.83 3. center console control panel $3051.93 4. transfer case replacement TBD 2019 BMW X5 xDrive40i has multiple major component failures at 70,000 miles. Oil pump failed causing loss of oil-level monitoring. The cylinder head assembly was diagnosed with oil consumption, the transfer case exhibited driveline shuddering, and the center console control panel developed internal electrical faults that affect vital vehicle components. All have been diagnosed by BMW of North Haven, CT. The oil pump and transfer case failures have created potential loss of engine lubrication and vehicle control putting my safety at risk. The oil-level test aborts at 16% making it impossible to verify oil quantity or pressure while driving. The shuddering occurs during low-speed turns and acceleration. BMW North America reviewed my case and approved goodwill coverage for transfer-case fluid change ALL other safety-related repairs have been denied. Supporting BMW Service Bulletins: •SIB 27 02 20: Jerking or Shuddering from Driveline xDrive Transfer Case ATX13-X (faulty factory oil specification). •SIB 11 03 17: N20/N26 Engine Timing Chain and Oil-Pump Drive Chain Warranty Extension (pattern of oil-pump failures in prior engines). •SIB B01 13 23: Front Center Console Cupholder Liquid Ingress (electrical faults from liquid intrusion in 2019–2022 G05 X5). •SIB 65 12 22: Roof-Mounted Antenna Housing Seal Not Adhering (water ingress from shark-fin antenna affecting interior electronics). Note: I paid out of pocket to replace and reprogram theTelematics Communication Box (TCB) due to faulty seal around shark fin. A class action lawsuit is currently in happening for this exact issue in California. These issues are not normal wear and tear. They represent premature mechanical and electrical failures on a well-maintained vehicle as well as posing a safety risk to me and other drivers.

MY STARTER MOTOR OVERHEATED AND MY CAR WOULD NOT START AND MY CAR INDICATED THE FLUIDS AND COMPONENTS WERE OVERHEATED - MY DEALERSHIP CONFIRMED THE PROBLEM WITH A VIDEO THEY SENT ME. IF I WAS STILL DRIVING THE CAR, I DON'T KNOW WHAT WOULD HAVE HAPPENED TO ME MY DAUGHTER AND HUSBAND IN THE VEHICLE. i CALLED MY SERVICE REP AND THE DEALERSHIP IS LOOKING INTO IT AS MY VIN DOES NOT HAVE THE RECALL. NOTHING WAS WRONG AND NO LIGHTS WERE ON THE VEHICLE PRIOR TO THE CAR NOT STARTING. I HAD BEEN DRIVING IT FOR ABOUT 25 MINUTES. In MAY of this year, not even 6 months ago, they had to replace a "heat management module", which cost me $2500 and they said it is not related. They found 8 fault codes at a frequency of 255. The dealership is telling me this is not related, but I have a hard time believing that.

The contact owns a 2019 BMW X5. The contact stated that while attempting to cold-start the vehicle, the contact needed several attempts to start the vehicle. The contact stated that several times, the contact was unable to restart the vehicle. The contact stated that while making several attempts to start the vehicle, the message "System Overheated - Restarting Engine Possible After Cooling" was displayed on the instrument cluster, and the contact had to wait 120 seconds before further attempts to restart the vehicle were possible. The contact had taken the vehicle to a local dealer, where it was diagnosed, and determined that the starter needed to be replaced. The vehicle was not repaired. The contact was informed by the dealer that there was a recall for the failure, NHTSA Campaign Number: 25V644000 (Electrical System), and the VIN was covered under the recall. However, the VIN tool showed no recall related to the VIN. The manufacturer was informed of the failure. The failure mileage was approximately 80,000.

The electronic oil level sensor was unable to complete an oil level measurement on the iDrive screen. Diagnostic inspection at a BMW Dealership (Mt. Kiso) and EuroTech Auto Repair (Larchmont, NY) revealed that the oil pump had degraded internally, specifically due to failure of plastic components. All Sensors were working fine and showed no faults. This failure could not be detected by regular maintenance and posed a risk to engine reliability and potential sudden loss of lubrication. The car had approx 55,000 miles, was purchased purchased after my 3-year lease (original owner of new vehicle), and the incident occurred during normal use. There were no warning lights or symptoms before the oil measurement stopped working. This defect appears to be a design/materials issue affecting other similar vehicles. The failed oil pump has been replaced at my expense. I am concerned this part presents a broader safety and reliability risk and should be considered for recall.

I noticed one of my daytime running lights on the driver’s side laser headlight had turned yellow, instead of white like the others. I took the vehicle to the dealership and they said that the LED module that powers that daytime running light has overheated and caused the light tube to burn and melt. The dealership advised that the passenger side is also slowly starting to do the same thing. The repair the dealership recommended is to replace both headlights, at a cost of almost $18k! I’ve seen numerous BMWs on the roads with this same issue, and this should be addressed by BMW as a design flaw. If these modules are burning plastic pieces inside the housing, they could start a fire if they get hot enough.

While driving down the Long Island Expressway at around 60 miles per hour, the retractable part of my panoramic sun roof shattered. It felt like an explosion. Luckily, the sunroof and cloth cover was fully extended so the glass didn't fall in the car. The traffic was light, no one in front of me and wasn't driving under any structure. There were no construction or debris on the road. It's clearly a manufacturer defect. Thanks, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Emergency Call System Failure!! My 2019 BMW x5 xdrive M50 has the failure from the Telematic Control Module like thousands of other people. This needs to be a recall and shouldn’t have to pay $1500-3000 out of pocket for something that is a manufacture problem. Apparently water gets in the shark fin area and causing the module to fail!

The oil pump contains a plastic housing that fractured during regular use. (Yes, I did retain the part for inspection and can include photos of the defect here). Yes, the problem has been confirmed by my mechanic and the general public with multiple posts and videos shared widely across the internet and in vehicle forums. This failure caused the engine to lose oil pressure abruptly. Had this occurred at highway speeds or in heavy traffic, it could have resulted in a serious accident. BMW is aware of the problem and has redesigned the oil pumps for all X5s starting in 2020. There is no real warning for this potential failure which would cause the engine to cease. The problem is most commonly diagnosed by checking the oil level via the I-Drive System electronically, (there is no dipstick for these cars). The oil level cannot be provided on the screen due to significant pressure fluctuations caused by the damaged oil pump- and that's how you know you're at risk of engine failure. There has been no recall for the 2019 vehicles. All 2019 BMWs with the B58 engine, (and the Toyota Supra), include this dangerous and expensive design flaw and I believe a recall should be issued; the majority of these cars are still on the road. I estimate the total number of cars to be 250,000 cars. My oil pump had to be replaced or the car would be rendered undriveable. The estimate from BMW dealership #1 exceeded 11,000; the estimate from BMW dealership #2 exceeded 8,000. The car has less than 70,000 miles on it and this is a known issue for this model year.

The automatic emergency braking is activating when nothing is on the road. It has happened three times in six months. Once in a drive thru, once in the middle of a clear intersection while moving at 30pmh and today while traveling at 35mph on a city street. The car acts as if it's attempting to prevent a forward collision. The red car icon displays and blinks on the instrument panel, fast beeps sound, the car hard brakes. It nearly caused the car behind me to rear end me today.

Car started hesitating to start then messaged popped up on screen saying my system was overheating I had to pay for a new starter.

Frequent Passenger Restraint System Issue

Recently purchased a 2019 BMW X5 xdrive40i with 77k miles, after only owning for 3 weeks after a heavy rain storm. My dash lit up with “Emergency call system malfunction”, upon review online it seems to be a common issue with these BMW models and no recall has been issued. The sos malfunction causes the vehicle not to function properly and unable to use the integrated idrive head unit system. It also dials emergency services on its own and won’t let me end call. After taking it to bmw dealership they found the telematics module battery to be low and suggested replacing. Previous owner had similar issue back in January of 2023 and the shark fin antenna by the roof was replaced , resealed and TCB telematics unit replaced. So only after 2 weeks of replacing the TCB battery, same issue appeared again after a heavy rain storm. I took it back to bmw for diagnose and they had to have one of there engineers test it and found out the actual sos button ecu system unit to have a short causing the sos malfunction and it dialing emergency services on its own. Vehicle is not driveable and has been at bmw they are trying to charge me additional $1,547.58 plus taxes and fees for the repair. I feel as if this is a defect on bmw and should be addressed and issued as an recall for there customers.

Known issue regarding failing oil pump in BMW B58 engines.

starter failed at 48k miles. This is a known issue of starters failing early and a recall should be done for all impacted cars. Currently there is only a subset that are recalled for software program update to prevent burning out the starter, but the starter itself is failing, and recall should be issued for replacing the starter [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I purchased a used BMW from a local dealership, unaware that the vehicle had unresolved safety and mechanical issues. Over time, I began experiencing repeated problems including: •Power loss and hesitation while driving •Malfunctioning engine and drivetrain components •Electrical system glitches including dashboard warnings that would disappear before I could document them The car has been in and out of shops for diagnostics, and no lasting fix has been found. These defects have created safety concerns for me and my children, as I transport them daily. The vehicle feels unsafe to operate. I believe I may have been sold a lemon and am now pursuing legal remedies, including this formal safety complaint to report the issue.

The emergency call warning on the dash was activated. GPS and Heads-up display no longer functioned correctly. BMW Dealership replaced TCB2 Box and battery at a cost of $2956.63. In researching this issue found numerous complaints from other owners. Contacted BMW and was told they were not responsible, car was out of warranty (4yr / 50,000 mi). This is an electronic component that is positioned in the least hostile environment of the vehicle. It has NO moving parts, is located in a dry / protected area (above the headliner), has NO knobs to turn / buttons to push / or screens to touch and is not subject to normal wear and tear. One of 2 things seem to be the case: This is a rare failure of this component - in which case I would think BMW and the manufacturer would be not only interested to investigate but also responsible. This is a regular failure of this component and since it is an integral part of the car's safety system BMW does not want to acknowledge a known defect.

Attached is a detailed description of my complaint. I'm attaching it because it is more than 2,000 characters.

My car said it overheated and would not start. After about 4 hours it did start and I took it to the dealer. They are saying that the battery and starter need replacement. I read that there was a recall for this exact reason on some specific VINs for my car model and year. Even though mine doesn't fall under that category it seems like the same issue that was recalled for others. Doing some online searches it seems this issue has happened to quite a few people.

I received a recall on my vehicle for an electrical update and was out of town when it malfunctioned. The vehicle would not start on the first try. Tried again and it immediately overheated, with smoke and a burning smell coming from the hood. It was towed to the dealership, and the starter and battery ended up needing to be replaced. I believe the failure of these parts was caused by the software issue that the recall was for. The dealership refused to compensate for the replacement of the battery and starter, claiming that it was not under the recall. When I reached out to corporate, they also refused to help. The car was at the dealership for a month, and the total cost of repairs was $2,200.

The contact owns a 2019 BMW X5. The contact stated while the vehicle was parked, the vehicle failed to start as intended. No warning light was illuminated. The vehicle was towed to the dealer where it was diagnosed with a failed alternator. The contact was informed that the alternator needed to be replaced. The vehicle was not repaired. The contact referenced an unknown recall repair; however, the VIN was not included. The manufacturer was not made aware of the failure. The failure mileage was approximately 49,302.

While driving in the city, I came across a red light. When the light turned green, my car's engine shut off and the power steering turned off (unable to turn). The screen remained on but I could not start the car. This has only happened in the city when I am driving at a speed of up to 15 miles/hr. under comfort mode with the auto/stop feature on. This happened about 5 times on different dates where my car shut off but the screen was on. My car shut down in the middle of traffic, causing more traffic and an unsafe situation. Since then, I have turned off the auto/stop feature and have not yet encountered the problem again.

The contact owns a 2019 BMW X5. The contact stated while starting the vehicle, the vehicle hesitated to start immediately. The vehicle was taken to the dealer, who determined that the starter motor needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 24V576000 (Electrical System, Engine and Engine Cooling); however, the VIN was not included in the recall. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was unknown.

The vehicle's electrical system experienced a starter malfunction, which led to a complete failure of the starter. As a result, the car would not start, ultimately causing the battery to fail as well. This failure posed a serious safety risk. I could have been left stranded in the middle of traffic, increasing the risk of a collision that could have caused injury to myself and others. If the malfunction had occurred in a remote location, I could have been left stranded, placing me in a potentially dangerous situation. The issue was confirmed by the dealership. Although there is an active NHTSA recall related to this exact problem, my vehicle’s VIN was not included. However, it should have been—my vehicle was manufactured during the affected production period and experienced the same failure described in the recall. As a result, I had to pay out of pocket for these substantial repairs. The manufacturer failed to include my VIN in the recall, despite clear evidence that my vehicle was subject to the same defect. The manufacturer inspected the vehicle and confirmed that the failure involved both the starter and the battery; however, I was required to pay out of pocket for the replacement of both components. There were no warning lights, error messages, or other symptoms prior to the failure—the vehicle simply stopped functioning without notice. Further research revealed that many other owners have reported the same starter malfunction, frequently resulting in battery failure and the need to replace both components. Although the manufacturer is aware of this widespread issue, they have not issued a comprehensive recall for all affected vehicles. Had they done so, this failure—and the associated safety risks, inconvenience, and significant repair costs—could have been avoided.

The contact owns a 2019 BMW X5. The contact stated that while attempting to start the vehicle, the vehicle failed to start. There was no warning light illuminated. The vehicle was towed to a local dealer where the vehicle was diagnosed, and the contact was advised that the starter had failed and needed to be replaced. The vehicle was not repaired. The contact referenced NHTSA Campaign Number: 24V576000 (ELECTRICAL SYSTEM, ENGINE AND ENGINE COOLING) as a possible cause for the failure. The manufacturer was notified of the failure. The approximate failure mileage was 80,100.

The contact owns a 2019 BMW X5. The contact stated while driving 70 MPH and attempting to depress the accelerator pedal, the vehicle failed to accelerate as needed. No warning lights were illuminated. The contact stated that the oil pressure failed after 20% usage. The vehicle was taken to an independent mechanic, where it was diagnosed that the oil pump had failed, and there were plastic particles inside the oil pump. The contact was informed that the oil pump needed to be replaced. The manufacturer was not made aware of the failure. The failure mileage was approximately 90,000.

Vehicle Safety Complaint Report – BMW Engine Starter Failure Make: BMW Model: X5 xDrive40i Year: 2019 Mileage at Incident: ~40,000 km Component/System That Malfunctioned The engine starter system failed to function. Despite repeated attempts, the engine would not start. The vehicle showed no prior warnings or dashboard alerts before the failure. The part has not yet been replaced, and the car is unable to start still. Incident Description On a recent trip, while lined up at a ferry terminal waiting to board, our BMW X5 unexpectedly failed to start. There was no warning light or error code displayed. The car was completely unresponsive, despite repeated starting attempts. We were in the middle of the boarding line, blocking all vehicles behind us. We had to request assistance from ferry staff, who helped tow the car to a parkade. This incident led to the cancellation of our trip, caused significant stress and public disruption, and exposed us to serious safety and liability risks. We immediately contacted BMW roadside assistance, who were unable to diagnose the issue remotely and only suggested continued restart attempts, which were ineffective. We recently learned of NHTSA Recall 24V-576, issued on August 1, 2024, by BMW of North America. The recall involves the engine starter in 2019–2020 BMW X5 models, due to engine no-start issues and potential electrical overloads that can result in a thermal event. While our vehicle matches the make, model, and year, we were informed by BMW that our specific VIN is not currently listed under the recall. However, we are experiencing exactly the same problem described in the recall notice—an engine that suddenly fails to start, with no warning, and with the potential for unsafe repeated ignition attempts. I strongly believe that our vehicle should be included in BMW’s official recall list for 24V-576. The symptoms, risk profile, and component behavior align perfect with the recall description.

vehicle has been vibrating at low speeds when turning or when backing up. Took vehicle to BMW dealership (BMW of Nashville in Franklin, TN) multiple times during the past 18 months without resolution. On my visit for the same issue this month, dealership finally recognized the issue and said there was a BMW bulletin out about the issue SIB 27 02 20. It is very frustrating that 1. The dealership kept stalling and despite test driving the car with me and feeling the vibration, they kept blaming tires or saying it was normal while the bulletin about the issues was generated in 05.20.2020 2. It cost me over $627 for them to change the transfer case oil to diagnose and repair the issue. I am still in the testing phase after the transfer case oil change as the vehicle needs to be driven 300+ miles. The dealership and BMW should issue a recall since it is a know issue that the wrong oil was used in the manufacturing process and reimburse the cost charged for diagnostic and transfer case oil replacement. The vehicle is furthermore still under warranty so I should not be paying anything for diagnostics or repairs.

I have a 2019 BMW X5 that experienced engine failure and required a new battery and starter to be installed. I feel certain that it is related to a recall on some 2019/2020 models but my vin is not included. [XXX] I received a fault warning for drivetrain malfunction. I took the car to the bmw dealership and was told it was an upper radiator blind failure and had it replaced. The dealership performed a software update per recall SIB 120524. The mileage was 36,981. While visiting family in New Orleans[XXX] @ [XXX] in the afternoon, on Decatur (heart of French Quarter) the car died in the middle of rush hour traffic. Fault came up that said ”engine overheat will attempt restart in 180 sec.” Car would not start and had to be towed to local BMW. Highly stressful as I was with my daughter. We had people honking horns, screaming at us, police threatening to ticket us, etc. ordeal lasted 2 hrs until tow arrived. After 4 days in the BMW shop I was advised a new battery was needed. No indication the starter was checked at this time. Mileage was 40,168. The next day [XXX] when driving home to Dallas I pull over to get gas in Natchitoches, La. I fill up and try to start car and failure notice shows up ”engine overheat will attempt restart in 180 sec”. Same thing as before new battery installed. The car did not restart even after an hr of waiting. Would not take a jump so we had to be towed to Shreveport(1 1/2 hrs away) to closest BMW dealership. I was traveling with My son and was beyond grateful at the kindness of the tow driver as he took us to get food and a hotel that was safe after delivering the car to the dealership. The next afternoon the Shreveport dealership determined that the starter failed and it had to be replaced. Mileage was 40,423. I feel I am due repayment for the tows and repairs on what I feel are recall related. I have contacted all 3 dealerships and North America BMW to get the run around. No one wants to take accountability! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I bought this car brand new and a couple of weeks after purchasing it, I would notice a creaking noise and/or a slight bump when I would put on the brakes. I have a lot of paperwork where I contacted the dealer to tell them about this noise over the years. They continued to tell me they didn’t hear or feel anything when I would take it in to be checked. I even had one of their mechanics to get in the car with me, so I could point it out. He told me that was normal. Over the years they said things like the brakes are cold and just have to warm up or that the sound was the auto hold and was designed that way, along with other opinions. It’s continued to get louder over the years and it bumps when you reverse the car or if you cut the wheel far. Now, they’re saying it’s the chassis and a thrust arm needs to be repaired. This was a defect from the beginning and I have the paperwork to show that I contacted them repeatedly about it.

As my vehicle has an electronic oil level check system, I am unable to check my oil level. It gets to around 20% and then stops checking. As per my research, this is due to the oil pump on this particular model year that causes pressure fluctuations and results in this issue. It is unsafe to drive my vehicle as I am unable to check the oil level.

Vehicle didn’t move after coming to a full stop at a traffic light. And it displayed a message stating the starter has overheated and that it needed to cool down. The timer for the cooldown period kept on increasing up to 180 seconds and consequent attempts to start the vehicle after the cooldown period didn’t help.

The starter motor overheats when the vehicle tries to start. The car does not always start. You can smell the starter burning. I have had the BMW dealership confirm that the starter is overheating and needs to be replaced. 2 independent mechanics witnessed this happen to my vehicle and confirmed as well. Other 2019 BMW X5 vehicles have been recalled for this exact issue and the fire hazard this causes. But not all X5’sfall under the recall - even though when reading through forums many many 2019 X5 owners have vehicles that are not named in the recall but are having this same exact problem. This is a family vehicle and is proving a fire hazard for my family, including my [XXX] son. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Starter stopped working. VEHICLES Body Style : 2019-2020 BMW X5 (X5 sDrive40i, X5 xDrive40i) SUV Descriptive Information : Power Train : GAS Production Dates : Approximately 68,105 vehicles have been manufactured with an engine starter of a certain production configuration. Basis for recall population determination: Vehicle assembly information and supplier production records were used to determine the specific dates of potentially affected vehicles. Recall component difference to non-recall component: Potentially affected vehicles have an engine starter with a certain production configuration. AUG 01, 2018 - MAY 31, 2020 VIN Range 1 : Begin : NR End : NR Not sequential

Emergency call malfunction light came on. System is an important vehicle safety features. Vehicle taken to dealership for inspection. No visual damage present on vehicle however water ingress from roof shark fin is causing damage to electrical components, TCB and emergency call function. Shark fin antenna cover determined to be causing water ingress after inspection by BMW dealership. Per their recommendation, further water ingress could damage additional electrical components, some critical and therefore immediate need to replace TCB, Aerial antenna, and emergency battery. Vehicle warranty not covering this type of issue. Cost of repair estimated at $2500.

We experienced a serious malfunction in our vehicle’s emergency call system and Bluetooth connectivity, which began immediately after the shark fin cover fell off. This issue appears to be a known defect, as numerous reports suggest that water intrusion through the exposed area can cause damage to the emergency communication system and GPS functionality. This is a major safety concern, as it compromises critical emergency features and wireless connectivity, impacting the vehicle’s overall functionality. Despite this being a design flaw, the dealership is charging us over $5,000 for repairs, which is an unreasonable burden for a defect that should have been properly sealed and protected during manufacturing. For the safety of all drivers, this defective shark fin assembly must be recalled, redesigned, and properly sealed to prevent further failures. We urge the manufacturer to take immediate action to address this safety hazard.

I have a 2019 BMW x5. My starter failed and I got a notification at the same time through my BMW app that there was a safety recall "RE: Recall 24V-576: Engine Starter – B12 05 24". The recall instructs the dealer that the Correction is "DME software update that will prevent the engine starter from being overloaded". This is all fine. It then gives the instruction "Note: Some vehicles may also be affected by the following technical campaign: 0012240600 Check and, if necessary, replace starter motor Please ensure that, if possible, both technical actions are processed at the same time." My issue is that the initial Recall is the clear issue causing the starter failure and they have acknowledged this in the technical campaign following. However, my vehicle's VIN is not included in the technical campaign that instructs them to replace the starter even though it was their negligence which caused the failure which they have acknowledged. What component or system failed or malfunctioned, and is it available for inspection upon request? No I paid to have the starter replaced. How was your safety or the safety of others put at risk? Me and my vehicle were left stranded, sometimes In the road due to auto start, multiple times. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, by the dealer. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Yes, inspected by the dealer. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No there were no warnings.

Oil pressure warning

Passenger seatbelt restraint

I received an Important Safety Recall notice indicating that a manufacturing defect could cause my vehicle to catch fire. I brought the car to New Country BMW in Hartford, CT to have this corrected and was advised that I would be charged $2,200 to replace the "TCB" in order to address the safety recall. This does not seem right to charge me to correct a safety defect mandated by NHTSA. The vehicle is owned by and registered to Slade & Company, LLC. Please advise.

Passenger Restraint warning light kept coming on. Dealer was able to reset twice and now they are telling me I need a new pad sensor under the seat and estimate is $1800.00 Reading BMW blogs this is an ongoing problem that BMW is aware of but will not recall.

Subject: Complaint Regarding Water Intrusion and Electrical Failures in 2019 BMW X5 To Whom It May Concern, I am writing to formally lodge a complaint regarding a recurring and potentially hazardous issue with my 2019 BMW X5. The issue involves water intrusion through the shark fin antenna, which has caused significant electrical malfunctions in my vehicle. Description of the Problem Water appears to be leaking into the vehicle through the shark fin antenna located on the roof. This has resulted in: 1.Failure of the infotainment system (screen not functioning). 2.Inability to start the car (starter not activating). 3.Turn signals operating without the typical cabin clicking sound. This issue has left the vehicle inoperable on multiple occasions and poses a safety risk, as critical systems such as the emergency call function and vehicle ignition are affected. Impact on Safety •A malfunctioning starter prevents the vehicle from being driven, potentially leaving me stranded in unsafe locations. •Turn signal failures reduce the audible warning, increasing the risk of accidents. •Water-damaged electrical components could lead to further issues, such as shorts or fires. Research and Observations After researching, I found that other BMW owners have reported similar issues involving water intrusion through the shark fin antenna, leading to widespread electrical problems. This suggests a potential design or manufacturing defect. Request for Action I respectfully request that the NHTSA investigate this issue to determine whether it constitutes a safety defect requiring a recall or service bulletin from BMW. Vehicle Information •Make/Model: BMW X5 •Year: 2019 •VIN: [XXX] •Mileage at Time of Failure: 72,000 •start Date of Incident(s): [XXX] Supporting Documentation I am happy to provide photos, repair bills, or any other supporting evidence upon request. Thank you for your attention to this matter. I look forward to INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Our 2019 BMW X5 triggered a warning light requiring us to pull over immediately and tow the vehicle to the nearest dealer. It currently has 35,000 miles and the dealer informed us that the oil pump failed. After research and discussion with the dealer this has occurred with multiple 2019 X5's at that particular dealer as well as others. BMW has not issued a recall or extended warranty for the oil pump that is included in the B58 Engine. That particular oil pump has casing that is made of plastic that is known to fail. In the 2020 model they then replaced that casing with metal. It is clear BMW knows of this issue and is not taking action to ensure the consumer's safety and investment is addressed.

I am writing to file a complaint against BMW for the replacement of the starter in my 2019 BMW X5 (VIN # [XXX] ) which I had to pay for out of pocket in March 2024. My vehicle failed to start after repeated attempts. After a call to the dealership they told me I would have to have it towed to the dealership at my own expense at a total of $266 for them to assess. The dealership confirmed that the starter needed replacement which cost me an additional $1736.78 out of pocket. After receiving a recall notice from BMW, I learned that this issue is related to a known safety defect with the starter which can lead to electrical overload, overheating, and in rare cases a fire risk. Given that I had to replace the faulty starter before the recall was issued, I am requesting reimbursement for the costs I incurred -$2002.78 which includes the towing charges and starter replacement. I reached out to Joseph Battle (Service Advisor) at BMW of Nashville, and he informed me that reimbursement is not possible only a software upgrade. This response is unacceptable, as I should not have to bear the cost for a safety issue BMW has since acknowledged. I kindly request reimbursement for the full amount of $2002.78. Please review the attached invoices and recall notice. I look forward to your prompt response and resolution of this matter. [XXX] and [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Starter: The vehicle did not start at 44,000 miles. The local repair shop replaced a new starter for $1,100

The contact owns a 2019 BMW X5. The contact received notification of NHTSA Campaign Number: 24V576000(Electrical System, Engine and Engine Cooling). The vehicle was taken to the dealer where it was discovered that the recall software update remedy could not be completed due to the telemarket control module failing and needing to be replaced prior to the recall remedy. The vehicle was not repaired. The manufacturer was made aware of the issue and referred the contact to the NHTSA Hotline to file a safety complaint. The failure mileage was 60,000. Parts distribution disconnect.

Driver seat is ripped at the base interior The seat frame is not mounted to the base.

Fuel door does not open. BMW is fixing it under warranty. Other vehicle owners may not have an extended warrants and this fix is expensive. Not being able to put gas in your car is a serious problem. Please look into this.

Factory seal on headlight assembly weakens causing headlamp to retain water

The contact owns a 2019 BMW X5. While the contact's wife was stopped and sitting in the drive-thru, the vehicle shut off. The vehicle was restarted; however, the vehicle failed to start as intended. In addition, the contact stated that the failure occurred while his minor children were inside the vehicle. The vehicle was towed to the residence. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The dealer was made aware of the failure. The contact received notification NHTSA Campaign Number: 24V576000 (Electrical System, Engine and Engine Cooling). The manufacturer was not made aware of the failure. The failure mileage was approximately 68,000.

At 112,589 miles the oil level is never reaching full capacity, replaced oil levelling sensor, that did not resolve issue. Dealer stated oil pump starting to fail.

The contact owns 2019 BMW X5. The contact stated that the vehicle was designed with the engine Auto Start/Stop system. The contact stated while at a complete stop and releasing the brake pedal, the engine failed to restart automatically. The contact stated that upon depressing the Push to Start button, the vehicle failed to start. The vehicle was towed to an independent mechanic, where it was diagnosed and determined that the starter needed to be replaced. The vehicle was repaired. The contact later received notification of NHTSA Campaign Number: 24V576000 (Electrical System, Engine and Engine Cooling) which the contact related to the failure. The manufacturer was contacted for reimbursement and referred the contact to the dealer. The vehicle was taken to the local dealer, where it was inspected, and the dealer confirmed that the independent mechanic had installed the correct part; however, the dealer later informed the contact that the manufacturer had denied the claim for reimbursement. The failure mileage was approximately 140,000.

The contact owns a 2019 BMW X5. The contact received notification of NHTSA Campaign Number: 24V576000 (Electrical System; Engine and Engine Cooling). The vehicle was taken to the dealer and the recall repair was performed. The contact stated that after the repair was performed, the vehicle failed to start after several attempts. The contact was eventually able to start the vehicle and the vehicle was driven to the dealer. A diagnostic test was performed, and it was determined that the starter was weak and needed to be replaced. The contact was referred to the manufacturer but was offered no assistance. The contact was then referred to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 50,000.

The contact's husband owns a 2019 BMW X5. The contact stated while her husband was at a complete stop at the red traffic light, the vehicle stalled. The vehicle failed to restart and was towed to the dealer, where it was diagnosed that the starter had failed and needed to be replaced. The vehicle was repaired at the contact's expense. The contact later received notification of NHTSA Campaign Number: 24V576000 (Electrical System, Engine and Engine Cooling), which the contact related to the failure. The vehicle was taken to the dealer, where the recall repair was completed. Additionally, the dealer was contacted for reimbursement regarding the expenses sustained due to a failure related to the safety recall, but did not provide assistance. The manufacturer was not notified of the failure. The failure mileage was 84,433.

“shark fin” GPS antenna because unglued allowing water into the electrical system in the roof. This caused a malfunction that disabled the emergency call functions, GPS location service for emergency calls and GPS functions. The issue is the TCB component due to faulty waterproofing. It also makes hands free calling impossible which makes following hands free laws more difficult. Upon investigation and BMW’s admission, it is a very common problem for 2019 X5s unrelated to any driving conditions etc.

The contact owns a 2019 BMX X5. The contact stated while parked, the vehicle stalled; there was an abnormal odor coming from the outside of the vehicle. No warning light was illuminated; however, the "Engine Overheating" message was displayed on the instrument panel. The failure occurred on several different occasions. The vehicle was taken to a dealer where it was diagnosed that the vehicle needed to be reprogrammed. The vehicle was repaired however, the failure still occurred. The vehicle was towed back to the dealer to get a diagnosis; the contact received a diagnosis stating that the starter motor needed to be replaced. The contact did research and was made aware of NHTSA Campaign Number: 24V576000 (ELECTRICAL SYSTEM, ENGINE AND ENGINE COOLING) however, the VIN was not included. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 65,397.

BMW jerking and shuttering sensation and rough grinding noise when driving at low speed 2-5 mph and while turning at 2-5 mph. Safety was put at risk with while turning with oncoming traffic and when vehicles directly behind me. The problem has been reproduced and confirmed by the BMW dealership service department. The service department change the left tire and replaced the transfer oil on 5/10/23. This did not solve the problem. The vehicle was returned to dealership for same reason on 7/19/24 and the dealership replaced the right tire. The problem still exists. The vehicle has been not been inspected by the manufacturer, police, insurance representative. No warning lamps or messages appear to diagnose the problem.

Reference recall No. 24V-576, I believe the issue reported in the recall is related to the 'Auto Start' feature of the vehicle. As a result of this failure, the safety issue can be much serious than what is stated in recall. In addition to the electrical overload of the starter, leading to risk of fire, the vehicle will not start, unable to shift out of Park therefore, potential of stranding the vehicle and the passengers in the middle of the road. The following occurred on [XXX]. at 2:30pm, we( my wife, 2 daughters and I) were traveling [XXX] in Tracy, in the fast lane in our 2019 X5. Auto Start feature was active, when I pressed on the gas pedal, engine suddenly turned off. The car would not start. There was no warning or any error message. We were stuck in the middle of the fast lane in heavy traffic and cars were passing on the both sides, making it impossible to be even get out and walk to safety. I tried to restart the car multiple times with success. We felt in danger of being struck by another vehicle. Luckily, the CHP was a few minutes behind us and stopped to help us. We tried to put the vehicle in Neutral so it can be pushed out to the side and not block traffic. I called the East Bay BMW and the Road Assistance for help with putting the vehicle in Neutral but I was told it can’t be done. The CHP (2 officers) and I tried to put the car in neutral but without any success. I with EastBay BMW and was told that noting can be done to put the vehicle in Neutral. The only way to shift the car in Neutral is from under the car and requires a mechanic . There was electrical burning smell coming from the engine compartment. The vehicle was towed to the EastBay Dealership in Pleasanton, CA. Upon inspection, the Dealer stated the issue is due to bad battery and it caused the starter to overload as I attempted to start the car. I was told that none of it's covered by warranty and I had to pay for the repairs. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

On November 9, 2023, I was driving out of town to visit a friend. I had been on the road for 1.5 hours and driven approximately 100 miles. When the vehicle approached a stop sign and came to a stop, the auto stop function turned the engine off. When it was my turn to proceed, I disengaged the brake, but the vehicle's auto start function failed to turn on the engine. I put the car in park and pushed the start button once. In doing so, the car attempted to restart itself multiple times, without success. I could hear the vehicle "cranking", but the car never started. Shortly thereafter, the cranking sound stopped, and white smoke filled the cabin through the air vents. It smelled like burning plastic. I grabbed my belongings and evacuated the area. Once outside of the vehicle, I could see white smoke bellowing out from underneath the vehicle. There were no warning messages or any other issues prior to the failure. The car was towed over 100 miles to the dealership where they confirmed an internal short circuit caused the starter to fail. The dealership replaced the starter. I do see there is a recall for the starter. However, I believe my issue is different. The vehicle failed to restart due to the recently identified programming issue, causing the starter to malfunction. The starter failure was not due to excessive attempts to start the vehicle, as I only pushed the start button one time.

The contact owns a 2019 BMW X5. The contact stated that after starting the vehicle and driving at an undisclosed speed, the vehicle made abnormal sounds. No warning light was illuminated. The vehicle was taken to the dealer, where the contact was informed that the engine oil pump needed to be replaced; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 78,000.

plastic oil pump housing/internals start to deteriorate and get metal debris into engine. 2019 ONLY.. bmw silently fixed this issue in 2020 models leaving anyone with the previous year stranded

The contact owns a 2019 BMW X5. The contact stated that the vehicle failed to start. The vehicle was towed to the dealer to be diagnosed. The contact was informed that the starter had failed, causing the battery failure. The contact was informed that the starter and battery needed to be replaced. The vehicle was repaired. The contact stated that after the vehicle was repaired, the contact became aware of NHTSA Campaign Number: 24V576000 (Electrical System, Engine and Engine Cooling); which the contact related to the failure however, the part to do the recall repair was not available. The contact called the dealer, and it was confirmed that the VIN was not included in the recall. The manufacturer was not made aware of the failure. The failure mileage was 67,000.

BMWUSA failed to advise me of B120524 starter recall. As a result of their failure I have incurred damages that the manufacturer is unwilling to reimburse.

The contact owns a 2019 BMW X5. The contact stated that when attempting to start the vehicle, it failed to start and a burning odor was present. The starter had begun smoking. The smoke had settled itself. The fire department was not at the scene. No police report was filed. There were no injuries reported. The vehicle had been towed to the dealer where it was diagnosed that the starter failed causing the starter to catch fire internally and needed to be replaced. The starter was replaced. After having the vehicle repaired the contact did some research and discovered that the failure was related to NHTSA Campaign Number: 24V576000 (Electrical System, Engine and Engine Cooling). The dealer was then contacted a second time and confirmed that the VIN was not included in the recall. The manufacturer was not made aware of the failure. The failure mileage was 50,000.

The contact owns a 2019 BMW X5. The contact stated while the vehicle was parked, the vehicle failed to start. Additionally, there was a burning odor on the inside and outside of the vehicle while the vehicle was occupied. The contact stated that the VIN was not included in NHTSA Campaign Number: 24V576000 (Electrical System, Engine and Engine Cooling). No warning light was illuminated. The vehicle was not drivable and was towed to an independent mechanic who diagnosed the vehicle with starter failure. The vehicle was towed to a dealer and the dealer confirmed that the starter needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the VIN was included in the recall; however, the contact had not yet received the recall notification letter. The failure mileage was 43,699.

My Engine starter failed at 43234 miles and left stranded at traffic light. when the traffic light turned green. It would not start again. I took it to the dealership and they replaced the starter.

The contact owns a 2019 BMW X5. The contact stated that while at a stop light, the vehicle suddenly shut off and failed to restart. During the failure, the message "System Overheated" was displayed. The vehicle was towed to the local dealer who replaced the battery, but the failure persisted. The vehicle was taken back to the dealer who diagnosed that the starter motor was faulty and needed to be replaced. The starter motor was replaced, and the failure was remedied. The manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in NHTSA Campaign Number: 24V576000 (Electrical System, Engine and Engine Cooling). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 41,000.

The emergency call system malfunction displayed. Upon taking vehicle to a BMW dealer for inspection, I was informed that the antenna needed to be replaced for $2000.00 to fix the problem. I did research and found that other owners of the same make and model as well as prior and later models have had the same issue. The shark fin antenna allows water ingress into the components which causes internal damage, this could possibly lead to other electrical problems that could present while the vehicle is in motion. What if an owner gets into an accident and the SOS/emergency call is unable to deploy due to this faulty antenna leakage.

My backup camera is so dim at night I cannot see many obstacles. The dealer adjusted the camera to maximum brightness, but it's still so dim that I cannot see pedestrians wearing dark clothing and other obstacles behind me. Only the acoustic warning has prevented me from hitting an object or running into a person. I have talked to many other owners of this year BMW X5, and all of them have a similar complaint. The dealer adjusted the camera to its maximum night-time brightness but to no avail. The dealer then told me BMW designed the camera to be hard to see at night. I have normal night vision, as confirmed at my yearly vision exam by a licensed ophthalmologist, so I find it dubious that BMW would make their backup camera too dark to use at night. I found that shinning a bright light at the lower-left area of the instrument binacle causes the backup camera image to become much brighter and solves the visibility problem. Therefore, I think there is a BMW SW problem that dims the rearview camera too much when it believes it is night time.

The contact owns a 2019 BMW X5. The contact stated that the vehicle was communicating with the SOS department while no incident had occurred. The vehicle was taken to the dealer, where it was determined that a water leak in the rear antenna of the vehicle had caused the electronic malfunction. The vehicle was repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 44,500.

After receiving a very expensive repair quote, I looked on here and read multiple complaints of emergency call system malfunction causing gps not to work/ malfunction due to leaking in the shark fin. This is a major safety concern due to poor design and build quality of the vehicle.

Driver Restraint Malfunction warning light turned on while driving and stated dangerous driving conditions and to see a Dealer immediately. The Dealer diagnosis was a faulty airbag wire harness due to rubbing against the metal which caused the airbag light to malfunction. Car had 47500 miles but BMW did not cover this faulty wiring under warranty. Should be a recall on faulty wiring.

The contact owns a 2019 BMW X5. The contact stated that the vehicle failed to start as needed. There were no warning lights illuminated. The vehicle was towed to the dealer and a diagnostic test was performed. The dealer stated that a software in the key fob and the vehicle needed to be updated. The contacted had not been notified of the update. The dealer informed the contact that had the vehicle had been brought to the dealer for the last oil change, the contact would have been informed of the necessary software update. The manufacture was not made aware of the failure. The failure mileage was unknown.

Dash lights dim to the point where they are barely visible. Safety concern issue by not being able to see in daytime. Yes and was told its a issue from BMW. There are no warnings or messages, just purchased the vehicle used and thought it was something that needed repaired. Very concerned about safety!

On the date below, a warning banner and chime signaled that our car's emergency communication system was not functional. Soon after, we noticed that the navigation system was "lost"; ie, showing our car in a different state, sometimes in water, incorrect displays of speed limits being shown, etc. Vehicle was evaluated at a BMW dealership, and the primary defective part was found to be the "sharkfin" on the roof. Water entered the roof structure (not the interior of the car) via this sharkfin, and resulted in damage to the TCB, which reportedly controls many of the car's more-advanced electrical functions. Due to unfortunate clauses in warrantees on the car--both BMW certified pre-owned coverage, and also a 3rd party service contract that was purchased at the time of purchase, from the BMW dealer, as a bumper-to-bumper "platinum" supplement to the certified pre-owned warranty, are currently in effect for this car--this defect is NOT covered. Cost to repair all involvedf parts is approximately $5,000. As a consequence of this expense, it has not been repaired, and likely will not be in the near future. A Google search about this issue yielded numerous identical incidents involving this same model/year of BMW. Several owners wondered if a recall was needed, since it is clearly a manufacturer defect with clear-cut and repeated ramifications, is very costly to repair (so is likely to NOT be repaired, in many instances), and is subject to a loophole in warranty coverage. My impression from this internet search is that other systems in the car might soon stop working. I believe it is a safety issue, now, given the failure of the emergency communication function controlled by the TCB, and might become more of an issue in the future, when/if additional functions fail.

This vehicle has only 36,000 miles, and there is a known issue with the knee airbags. See attached notice. My driver's side knee airbag warning light recently went on, but BMW refuses to remedy the problem. They should be required to recall and cover the cost of the repair.

Car will not start until many attempts are made. Walking up to the car with key in hand causes alarm to go off. Car remote fails to unlock the door and must be unlocked manually but alarm still does not turn off. Time and date reset to the wrong time and date after turning off car and turning it back on.

Seems I have read multiple complaints of emergency call system malfunction causing gps not to work/ malfunction due to leaking in the shark fin. This is a major safety concern due to poor design and build quality of the vehicle. This concern should be up most important that this area is recalled, replaced, and sealed to ensure safety for all.

The contact owns a 2019 BMW X5. The contact stated that while at a stop light, the automatic engine shut off was activated but after releasing the brake pedal, the transmission erroneously shifted to neutral, and the engine did not restart. The contact stated that the failure had occurred on multiple occasions while in traffic. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the failure, but no assistance was provided. The VIN was not available. The failure mileage was 55,000.

Vehicle is out of warranty. Car only has 36K miles and passengers restraint system malfunction appeared. It basically says that the passenger airbag won't deploy due to this malfunction. Union diagnosis ilthe culprit is a defective seat occupancy mat sensor module and the seat mat. Both parts should be recalled as this failure occured without outside influence. This is a extremely important component that can fail at any moment in the 2019 X5 Xdrive50i.

A portion on the Airbag system was/is disabled due to an issue, known to BMW, with the wiring harness connected to the passenger seat. It is available for inspection if requested. Normal movement of the electric seat in turn pulls a wiring harness that failed by being "chaffed". This flaw results in a "Restraint System Error", passenger side - a significant problem since this harness controls an integral safety system of the vehicle and ultimately disables part of the airbag system until repaired. During inspection at the dealer's service center, the car was connected to a fault reader that reported a wiring harness/module failure due to "chaffing". This chaffing caused a short that triggered the warning light and deactivated a key air bag safety feature. I was told that normal movement of the passenger seat moves the wires and causes the system failure. After consulting with my Service Advisor, the repair was explained as "installation of a new, modified (longer) wiring harness that allows for rerouting of the wires so that the condition is corrected" What alarmed me as a consumer was when I asked if they were sure this would fix the problem, the dealer told me they see it quite often and 99% of the time it is a problem with the original design and routing of the harness. From my perspective, this indicates BMW acknowledges this is a known problem impacting the safe operation of the vehicle. The repair requires removal of the entire center console and replacing and rerouting a newly designed wiring harness. The estimate for repair to the consumer is almost $1300 - making it likely that many consumers would delay this important repair. In my opinion, this engineering flaw should be the subject of a voluntary recall at the least.

Today, we experienced a some kind of sudden stop in a normal speed driving. Red alert car symbol flashed on our dashboard. It is without stepping on a break but it’s like our car is braking or like abrupt stopping. No car or any object that may hinder in front of us. It was scary coz there’s car behind us in a good speed. I don’t feel like it’s safe for what we had experienced today. Please try to look at it before anything like this scenario to happen again. I am and anyone else is into safety that’s why we choose this vehicle.

TELEMATICS CONTROL UNIT HAS FAILED AND HAS WATER INGRESS. THIS CAUSES THE ONBOARD EMERGENCY SOS SYSTEM TO FAIL AND NOT WORK, MAKE FALSE CALLS AND RISK A DRIVER ABILITY TO MAKE AN EMERGENCY CALL OR FOR THE VEHICLE TO CALL FOR HELP. THIS ALSO POSES A RISK IN THAT WATER SEEPS INTO THE INTERIOR OF THE CARS SHELL THROUGH THE ANTENNA. CREATING RUST, MOLD AND DECAY. WHICH WILL EVENTUALLY AFFECT THE INTERIOR OF THE VEHICLE, HEAD LINER AND EVENTUALLY PASSENGERS THROUGH ENVIRONMENTAL FACTORS. THE CAR EVENTUALLY HAS TO BE GARAGED OR COVERED AT ALL TIMES IN EVENT OF RAIN OR SNOW. THIS HAS BEEN SEEN WIRH OWNERS OF THIS PARTICULAR MAKE, MODEL, YEAR SERIES. UNFORTUNATELY, MORE PEOPLE HAS YET TO EXPERIENCE THIS ISSUE IF THEOR VEHICLE IS ALWAYS GARAGED OR COVERED

Recently, the display behind the steering wheel has turned off twice while driving on the highway. This display contains the speedometer, meaning there was no way to gauge vehicle speed while driving. The problem is random; no warnings were shown, but keeping the car off for a couple of hours before turning it back on has brought the display back temporarily.

passenger restraint system failed message states bring to dealer ASAP dealer states there will be a charge seems to be a common problem recall???

BMW "did not" issue a recall notice for this known issue for my VIN. They were aware of this issue and corrected it based on the latest software update 11/2022.56. The problem is older software versions can cause the battery to completely drain even when the engine is not running and make you deserted anywhere, which is a safety issue. Also, since the battery can be fully drained, your booster brakes also will not work during the start of the engine, which can again cause risk when starting. BMW did not advise customers regarding this safety issue. In my case, My battery was completely drained, and I had to replace my battery. Details of the defect from the latest software update release notes are mentioned below. The concern is why BMW did not issue a recall notice to customers like me. I hope NHTSA can take the necessary action on this and issue a proper recall notice. "Recall of automatic transmission/ EGSsoftware:(USA/CANADA) The current software version of your vehicle may mean that the electronic transmission control continues to consume energy after parking the vehicle and may result in the total discharge of the 12 V vehicle battery. A Vehicle start can no longer be ensured in this case. This malfunction is rectified by the upgrade 11/2022.56. The corresponding special defect code is 0024720100" (Photo attached)

Dealer service finally diagnosed AC refrigerant leak through evaporator on a vehicle less than 40,000 miles and just over 4 years. The symptom (hissing sound from vent) has started before 30,000 miles or 3 years, but dealer service indicated it is just a fan noise. Unsafe to drive in 90 degF+ weather without an AC.

The contact owns a 2019 BMW X5. The contact stated while having the vehicle washed, the technician became aware that the floor carpeting on the front driver’s side was wet and had mold and mildew. The vehicle was taken to the dealer that stated that the vehicle was experiencing the failure listed in TSB: SIB 64 04 21; however, the vehicle was not covered under the service bulletin and advised to contact the manufacturer. The vehicle was not repaired. The manufacturer was contacted, and a case was filed but no assistance was provided. The failure mileage was 59,000.

Dear Sir This is regarding my 2019 BMW X5 VIN [XXX] , purchased on 5/28/2019 from BMW Orland Park IL. I encountered ‘Reduced engine power’ message on 5/8/2023. This vehicle was driven about 40000 miles at that time. BMW Orland park diagnosed the root cause and fixed it on 5/10/2023. They replaced faulty lower radiator blind. I am surprised and worried that top luxury brand SUV had this problem so early and right around warranty expired. I asked service advisor of any recall, but unfortunately he didn’t find anything. I spent $802.37 + tax, for this repair very early in the BMW vehicle’s life. I would appreciate if you can research/investigate this problem with 2019 BMW X5, whether it’s eligible for recall or free repair. Thank you [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2019 BMW X5. The contact stated while driving at an undisclosed speed, the horn and turn signals were inoperable. Additionally, the windshield wipers remained on constantly and failed to deactivate. The vehicle was taken to the dealer, where it was diagnosed that the steering column needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,000. The VIN was unavailable.

Vehicle airbag/seatbelt warning light on 9/2022. Airbag (seatbelt) module replaced. Caused by condensation or leak due to BMW not sealing cupholders and placing KEY SAFETY EQUIPMENT directly under unsealed cupholders. I was told other modules likely damaged but airbags and seatbelt were first to go out. 2023 April/May - steering issues. Windshield wipers run continuously and cannot be turned off. Horn and turn signal also stopped working. Need steering column replaced. BMW said possibly also related to cupholder defect. I am concerned the unsealed cupholders are going to kill someone if airbags deploy unnecessarily or seatbelt/airbags fail. BMW should have not placed KEY safety equipment under unsealed drink holders.

I was turning left on a residential street when the steering wheel locked, the brakes would not work to stop the car from going straight and the engine would not turn off when I attempted to stop the engine once realizing that everything was failing. The electrical panel went black and I collided with a residential home. Airbags deployed, EMS, fire and Police were called to the scene and the Tow truck driver noted that all systems had failed and the car basically shut off all functionality. They had to manually push the vehicle onto the flatbed tow truck. I am concerned as this issue was a safety concern while I was driving the car and it seemed all systems failed.

1.Cross traffic warning will warn me so late or sometimes not at all.No sound the most of the time.Can’t trust the safety of this future if it’s not alerting right on time. 2.forward Collision warning doesn’t work

Driving on an interstate in an open area (no overpass). The rear moon roof (fixed glass) shattered like an explosion. We do not believe that anything impacted the glass. It just happened.

Front Windshield trim panels gets loose from multiple places. I can hear wind noise inside the cabin clearly at speeds of 50 mph and higher. Its a known issue with 2019 BMW X5. Took it to dealer under warranty and decline to fix it.

I received notification that my passenger restraint system has a malfunction. The car threw up a code, I received a phone call and text message from the dealer. I thought this was important so I took the car to the dealer. They said the detection mat needs replace and the cost would be $1811.00. The dealer asked me if something spilled on it? The answer was no. I believe this is a safety defect an a recall should be initiated!

Since February of this year, my X5 has suddenly gone into neutral gear while driving in stop and go traffic on multiple occasions over the past 3 months. This incident first started on 2/26/2022, wherein my car abruptly went into neutral, coming to a complete stop in the midst of heavy stop and go traffic, while approaching George Washington Bridge. This happened twice within a 20 minute interval during that same trip. The car wouldn’t start back again for several minutes each time. Following this, I took my X5 to my local dealership to get it checked out. The dealership kept the car for a few days, ran some tests, but were unable to replicate the issue. The car was subsequently released to me. (Ref: dealership service invoice dated 3/8/2022) The exact issue recurred on 5/22/2022, again in heavy stop and go traffic, approaching George Washington Bridge. This time the car wouldn’t start for more than 10-15 minutes. Following this, I had to call 911 to help me out. The car eventually started after 20 minutes. I took it back to the same dealership. Once again, the issue couldn’t be replicated. However, after consulting with the factory technicians, the dealership replaced the gear shifter. (Ref: dealership service invoice dated 6/8/2022) Unfortunately, this exact issue recurred on 6/24/2022 – heavy stop and go traffic, on the approach to Whitestone Bridge. The car abruptly went into neutral from drive mode, stopped completely and wouldn’t start back again for a few minutes. Please note that the Automatic Start/Stop (MSA) system on the vehicle was always set to OFF. It is a miracle I did not get into an accident when this issue manifested each time. I have made yet another appointment with my local dealer for 7/11/2022 to re-evaluate the issue. In the meanwhile, I called the main office at BMW USA and got a case started as well.

The car has a faulty cup holder that allows fluid to leak. Below the cup holder is Crash Module, which controls the airbags and all the safety restraint system. I had a minor amount of fluid leak. This caused corrosion on the ASCM module. BMW is fighting me in paying for this. Based on my research there have been hundreds of incidents and a class action lawsuit. This is clearly a defect in design. If this would have happened when I was driving with an accident that followed, none of the safety equipment would have worked Thanks, [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

About a year ago, coffee began leaking from below from a paper cup in the plastic cupholder of my x5. I immediately noticed it and cleaned it up. Approximately 1-2 ounces of liquid leaked into the plastic cupholder. On May 11, 2022, the Passenger Restraint System faulted and the light came on. The vehicle was inspected by BMW of Austin and stated that liquid seeped onto the Airbag Control Module and some of the pins were corroded. This would not be covered by the Warranty as it was deemed an "external" factor that caused the failure. The estimate to fix this issue and get the airbag functioning again is $2,005.00. BMW placed the Airbag Control Module right under the plastic cupholder, and does not seal the plastic cupholder or the important Airbag Control Module right under the plastic cupholder. Luckily, the airbag system did not automatically stop the vehicle as has been the case with other vehicles- X7 and X5. This is a design failure that BMW is aware of that leaves its customers at risk of injury due to the airbag system faulting. This issue is ongoing and affects all X5 and X7 models. BMW needs to provide a remedy to this design and safety flaw. Owners should not have to pay $2,000 to remedy. There is a class action lawsuit filed in December 2021 for this exact issue.

I recently acquired a 2019 BMW X5. When I requested seat belt extenders as your web site suggests, "If you need a roomier belt, contact your vehicle manufacturer to obtain seat belt extenders." my dealer told me that they "cannot get them." I contacted BMW corporate customer services and while the gentleman I have been dealing with is trying and is very courteous, he can't seem to find any information. I regularly transport two people who cannot use the seatbelt and I am concerned for their safety.

Traveling west on I-70 at the Eagle Colorado exit the brakes failed as we pulled off the highway the brakes failed. Went up the ramp at 50-60 MPH. Missed the cars waiting to enter the round-a-bout and went over a decorative divider about 3 feet high. Went in the air and was then traveling on the wrong side of street. Saw a fireplug and hit it at 20-30 MPH and that stopped us. No airbags deployed at either hit. Four in the car and no serious medical issues, just soreness. Had police and fire test the brakes to show they didn't work. Obviously the air bags Hadn't deployed. Filed police report with Eagle City, 2021-000417 and AIG insurance report 80255229. Car was declared totaled.

Driving my vehicle and on my screen popped up driver seat restraint malfunction, also rear seat restraint malfunction please go to closest dealership. I bring my vehicle to BMW dealership in my town and rep calls me and advise that the cup holders sit above the srs wiring and that liquid gets thru the cup holders and dripped on to the wires causing them to no longer work. This is a design flaw i have never spilled a drink in my cup holder and even if someone did on accident why is the AIRBAG wires not covered in plastic if going below cup holders that leak any type of liquid. I am unable to afford, I do have warranty however BMW stating that this is an outside interferance and will not be covered under warranty, so I am having to drive with no airbags. I researched and many others are having same issue with this same year and make different models. This is something that definatly needs to be recalled as it is a design flaw and a safety hazard.

Over the 2 years of ownership I had about 5 incident where I lost control of my 2019 BMW X5 40i. The specific trim was XLine with standard brake option. It occurred rather randomly so I was not able to identify the pattern to reproduce. Right after the ignition to leave a parking space (and while still holding the brake since starting the car) the car would push my foot up and I would lose control of the brake. After a few seconds of desperate tries to press the brake, I was able to stop the car from drifting backwards as I engaged "Park" gear. Similar situation occurred and each time I was fortunate that there wasn't a car directly heading towards me. However I experienced this life threatening experience and BMW seems to acknowledge with their service bulletin of "SIB 34 04 19" but no fix was given to me.

WHILE I WAS DRIVING THE CAR ALONE AROUND 7:30PM 5/13/2021 ON THE WAY TO A RESTAURANT, AFTER I PUSHED THE GAS PEDAL TO PASS ANOTHER CAR (ACCELERATED TO ABOUT 50MILE-55MILE/HR), THE CAR ALL OF A SUDDEN ACCELERATED ON ITSELF. I NOTICED RIGHT AWAY AFTER MY RIGHT FOOT MOVED AWAY FROM THE GAS PEDAL (FROM 50 TO 55 THEN UP TO 65MILE/HR, I STOPPED MY OBSERVATION SINCE IT WAS GETTING TOO FAST). I HAVE TO CONSTANTLY HIT THE BRAKE PEDAL TO REDUCE THE SPEED FOR ABOUT A MILE OR TWO. AFTER I REACHED THE NEXT TRAFFIC LIGHT, I HAD TO PUSH THE BRAKE PEDAL VERY HARD TO MAKE THE CAR FULLY STOP, SO I DECIDED TO SWITCH THE TRANSMISSION FROM D TO P TO SEE IF IT COULD GET OUT OF ACCELERATION PROBLEM. ONCE I SWITCHED TO PARK, I TRIED TO SWITCH IT BACK TO DRIVE MODE, HOWEVER THE CAR DID NOT RESPOND AND STAYED IN PARKING MODE. I THEN TRIED TO TURN OFF THE ENGINE AND TURNED IT BACK TWO TO THREE TIMES, IT JUST DIDN'T ALLOW ME TO CHANGE BACK TO DRIVE MODE. I ALSO NOTICED THAT THE CAR MADE A LOT OF NOISE SINCE IT ACCELERATED ON ITS OWN. I REALIZED IT WAS TOO DANGEROUS TO SIT IN THE CAR IN FRONT OF THE TRAFFIC LIGHT EVEN WITH THE EMERGENCY LIGHT ON. SO I DECIDED TO TURN IT OFF AND LEFT THE CAR. I SMELLED A VERY STRONG BURNING SMELL EVEN THOUGH I QUICKLY MOVED AWAY FROM THE CAR. I WAITED ON THE STREET SIDE FOR ABOUT 2-3 MINUTES AND WENT BACK TO THE CAR, I WAS FINALLY ABLE TO SWITCH TO D MODE AND DROVE AWAY SLOWLY. I HAD SIMILAR PROBLEM HAPPENED LAST YEAR AROUND OCTOBER FOR 3-4 TIMES (NOT AS BAD AS IT WAS TODAY, I CAN TURN ENGINE OFF AND TURN IT BACK ON, IT WILL RETURN TO NORMAL) AND I BROUGHT THE CAR BACK TO BMW DEALERSHIP (BMW AT GWINNETT PLACE IN DULUTH GA, WHERE I BOUGHT THE CAR IN NOV 2019) AND THEY WON'T BE ABLE TO CREATE THE PROBLEM. THE TECHNICIAN JUST TOLD ME TO DRIVE SLOWLY (25-35MILE/HR FOR THE FIRST 3-4 MIN) EVERYDAY AT THE BEGINNING. I RECORDED TWO VIDEOS AT THE TRAFFIC LIGHT.

WE LEFT OUR RESIDENCE TO TAKE OUR KIDS TO SCHOOL WHEN THE OPERATING PORTION OF THE SUNROOF EXPLODED. WE WERE TRAVELING AT AROUND 65 MPH THROUGH A RURAL ROAD WITH THE SUNROOF CLOSED. CLEAR SKIES, NO RAIN. AT FIRST WE THOUGHT SOMETHING HAD FALLEN THROUGH BUT THERE WAS NOTHING INSIDE EXCEPT SHARDS OF GLASS. WHEN WE WERE ABLE TO PULL OVER, WE INSPECTED THE VEHICLE FOR SIGNS OF EXTERNAL DAMAGE BUT THEN NOTICED THE LEFTOVER GLASS WAS PROTRUDING OUTWARD.

MY BRAND NEW BMW X 5 COULD NOT BE STOPPED ON THE TRAFFICS TIME IN AM THIS HAPPENED TWO TIMES BMW DOESN'T WANT TO HELP ME THIS CAR NOT SAFE AND DANGEROUS TO DRIVE MAKES A LOTS OF MOUNDED FROM THE ENGINE AND CANNOT STOP THE CAR

I WAS DRIVING ON 10 FREEWAY WEST 750 AM ON 2/23 THERE WAS TRAFFICS EVERYBODY WAS BEHAVING I WAS KEEPING DISTANCE OF AT LEAST 2-3 CAR DISTANCE ALL OF SUDDEN MY CAR ACCELERATED MAKING A LOUD NOISE FROM THE HOOD MY FOOT WAS ON THE BRAKES BUT I COULD NOT STOP THE CAR I HIT FROM CAR MY FOOT WAS ALTHE WAY ON THE BRAKES I LET IT GO AFTER THE IMPACT BMW DOESN'T NOT WANT TO TAKE RESPONSIBILITY I HAVE A POLICE REPORT FROM ME AND FROM DRIVER THAT WE HAD A GOOD DISTANCE BETWEEN TWO CARS IT WAS AT THE BALDWIN PARK CITY ON 10 FREEWAY

VEHICLE HAS HAD THE MAIN DRIVER GAUGES/DASH CLUSTER RANDOMLY TURN OFF WITH NO WARNING WHILE DRIVING, MULTIPLE TIMES A DAY NOW FOR THE LAST SEVERAL MONTHS, WITH INSTANCES HAPPENING AT ALL SORTS OF SPEEDS AND ON LOCAL ROADS AND HIGHWAYS. THERE APPEARS TO BE NO WAY TO RECOVER THE ELECTRONIC DASH CLUSTER UNTIL THE VEHICLE IS LEFT TO FULLY SHUT OFF FOR A FEW MINUTES AND THEN RESTARTED. BMW SERVICE AS WELL AS BMWNA HAVE ATTEMPTED TO ASSIST IN 8+ SERVICE VISITS AND HAVE NOT BEEN ABLE TO RECTIFY WHAT'S A CLEAR SAFETY HAZARD, AS IT HAS LED TO MULTIPLE NEAR ACCIDENTS NOW. THIS STARTED IN JANUARY 2020, WHEN THE VEHICLE WAS RELATIVELY NEW (<2000 MILES) AND PERSISTS TO THIS DAY (12K MILES).

OUR VEHICLE IS IN FOR THE 4TH VISIT FOR A PERSISTENT OIL LEAK. THE FIRST 2 VISITS RESULTED IN A VEHICLE INSPECTION AND CLEANING OF ENGINE AREA WITH NO LEAK FOUND, STATING IS WAS MOST LIKELY LEFT OVER OIL FROM MESSY OIL CHANGE. THE 3RD VISIT RESULTED IN REPLACING THE REAR MAIN SEAL AND PROBLEM WAS RESOLVED PER DEALER. VEHICLE CONTINUED TO LEAK AFTER WE BROUGHT IT HOME. 4TH VISIT RESULTED IN REPLACING OIL PAN GASKET BUT LEAKS ARE NOW POPPING UP IN OTHER AREAS. BMW ENGINEER HAS BEEN REQUESTED BY DEALER. IN TH PROCESS THE VEHICLE WAS DAMAGED FOR THE SECOND TIME BY THE DEALER REQUIRING BODY WORK/PAINT.

2 MONTHS AFTER PURCHASING THE VEHICLE A RATTLING SOUND COMES UP WHEN I START THE VEHICLE I TOOK IT IN FOR SERVICING AND I'M TOLD THEY DON'T FIND THE PROBLEM, BUT IT SOUNDS LIKE SOMETHING IS LOOSE. FINALLY, MY DASHBOARD GOES BLUE AFTER LONG DRIVES. AGAIN, THIS WAS REPORTED AND PICTURES WERE TAKEN AND I'M TOLD THEY CAN'T FIND A PROBLEM. *TR

THIS VEHICLE WAS PURCHASED IN AUGUST OF 2019 AND HAS HAD THIS PROBLEM FROM DAY ONE. THE DASH DISPLAY AND INFORMATION DISPLAY NEXT TO THE DASH ARE HARD TO SEE DURING THE DAY. THE CLUSTERS CAN GET VERY DIM AND YOU HAVE TO STARE AT IT FOR SEVERAL SECONDS TO SEE WHAT YOU NEED TO SEE. THIS IS DANGEROUS WHILE DRIVING. I'VE HAD IT AT THE DEALER AND HAVE CALL BMW OF NORTH AMERICA ON THIS AS WELL AND THEY HAVE NOT FIXED THE PROBLEM. THEY BLAME IT ON THE WINDOW TINT THAT THEY DID AND AT THE SAME TIME INDICATE NO ONE ELSE THAT GOT THE WINDOW TINT HAVE THIS PROBLEM. *TR

THE WIPERS OVER SHOOT HITTING THE PILAR. I HAVE SWITCHED MY WIPERS THREE TIMES IN ONE YEAR; I THOUGHT THE WIPERS WHERE OF POOR QUALITY BUT EVERYONE IN THE FORUMS COMPLAINS THAT THE WIPERS JUMP CERTAIN SECTIONS IN THE WINDSHIELD AND THEN OVERSHOOT HITTING THE PILAR. IT?S INCREDIBLY DIFFICULT TO DRIVE IN THE RAIN DUE TO THIS PROBLEM. THERE ARE GOING TO BE SERIOUS ACCIDENTS BECAUSE WHEN YOUR IN A CITY MANAGING WITH TRAFFIC AND PEDESTRIANS AND YOU CAN?T SEE RIGHT IN FRONT OF YOU BECAUSE THAT?S PART OF WHAT THE WIPER MISSES . *TR

BMW AUTO START/STOP WILL TURN OFF ENGINE BEFORE THE CAR COMES TO A COMPLETE STOP CAUSING A LOSS OF STEERING. THIS CAN HAPPEN UP TO WHILE THE CAR IS STILL MOVING AS HIGH AS 5MPH, OFTEN OCCURS BETWEEN 3-1 MPH WHEN COMING TO A STOP. *TR

I AM WRITING TO ASK FOR YOUR ASSISTANCE IN MY MATTER OF MY 2019 BMW X5 I40 SUV, WHICH UNFORTUNATELY HAS BEEN REPAIRED 6 TIMES FOR NUMEROUS ELECTRONIC STABILITY CONTROL, ELECTRICAL, AND SUSPENSION FAILURES SERVICED AT 3 DIFFERENT BMW COLORADO DEALERSHIPS. THE VEHICLE WAS PURCHASED NEW WITH LEASE JUNE 2019, AND CONTINUOUSLY REPORTED & EXPERIENCED FAILURES/ISSUES BY OWNER, NUMEROUS PASSENGERS, INCLUDING MULTIPLE BMW SERVICE MANAGERS: ENGINE BUTTONS NOT TURNING OFF THE ENGINE INTERMITTENTLY, OR NOT TURNING OFF THE VEHICLE ELECTRICAL POWER. AFTER HIGH ACCELERATION ON A INTERSTATE HIGHWAY COMING TO A COMPLETE STOP THE ENGINE WOULD TERMINATE AND THEREBY HAVING TO QUICKLY PLACE THE VEHICLE INTO PARK TO RESTART THE ENGINE, THIS HAD TO BE DONE RAPIDLY DUE TO HIGH SPEED TRAFFIC. VEHICLE WOULD REPEAT ISSUE ON RURAL ROADWAY STOPS, BUT NOT AS OFTEN ON INTERSTATE ABOVE 60MPH. GPS HAD SOFTWARE MALFUNCTIONS AFTER BEING REPAIRED 2X FOR ELECTRICAL STABILITY ISSUES THIS CONTINUED TO MALFUNCTION THEN CORRECTED AT AN ALTERNATIVE BMW DEALERSHIP. SIDE ASSIST ALERTS AND NOTIFICATIONS WERE CONTINUING TO FAIL AFTER 4-5 ATTEMPTS TO REMEDY. KEY FAB WOULD FAIL TO COMMUNICATE AND FAIL TO LOCK VEHICLE AFTER SEVERAL ATTEMPTS TO FIX BY BMW. VEHICLE SOFTWARE PROGRAMMING WOULD NOT MAINTAIN CONSISTENCY WITH VARIOUS COMPONENT RESPONSE FOR BACK DOORS, TRUNK/TAILGATE FAILURE TO RESPOND MOST IMPORTANTLY VEHICLE POWER OVERALL. FINALLY, THE VEHICLE HAS SUSPENSION ISSUES, STILL A CONCERN THIS COULD HAVE BEEN CAUSED BY THE NUMEROUS TIMES UNDER BMW REPAIR SHOPS BEING LIFTED BY PRESSURIZED COMPONENTS; OR WHEN IT WAS INITIALLY DELIVERED OFF THE TRUCK FROM MANUFACTURER TO DEALERSHIP? THE VEHICLE IS DEFECTIVE & HAS BEEN DEFECTIVE SINCE PURCHASED. THIS IS CONSIDERED A LEMON PER THE COLORADO LEMON LAWS, IN ADDITION PER THE NUMEROUS BMW SERVICE MANAGERS WHO HAVE REPAIRED THE DEFECTIVE VEHICLE.

I PARKED MY CAR IN MY GARAGE, TURNED IT OFF (THE ELECTRONICS POWERED DOWN INSIDE THE CAR), AND WENT INSIDE. APPROXIMATELY 4.5 HOURS LATER, MY CARBON MONOXIDE DETECTORS WENT OFF. I SEARCHED THE HOME FOR THE SOURCE AND WHEN I OPENED MY GARAGE DOOR I DISCOVERED MY VEHICLE ENGINE HAD BEEN RUNNING FOR ABOUT 4.5 HOURS IN THE CLOSED THE GARAGE. I ATTEMPTED TO TURN THE ENGINE OFF, BUT IT DID NOT WORK. I HAD TO POWER THE CAR ON BEFORE IT WOULD THEN ALLOW ME TO TURN THE VEHICLE OFF, INCLUDING THE ENGINE. IT WAS VERY SCARY. I HAVE ALSO MADE A REPORT TO THE DEALERSHIP I PURCHASED THE CAR FROM.

I WAS DRIVING ABOUT 25 TO 35 MPH WHEN THE EMERGENCY ACTION SYSTEM GOT ACTIVATED THAT I WAS POSSIBLY GOING TO GET SOMETHING IN FRONT OF ME THERE WERE NO CARS IN FRONT OF THE VEHICLE I ALMOST GOT REAR-ENDED AND ALMOST BROKE MY FINGER ON THE STEERING WHEEL AS IT TURNED AROUND. THE VEHICLE STOPPED FOR ABSOLUTELY NO REASON. IT STOPPED LIKE IT WAS GOING TO CRASH INTO SOMETHING. THIS COULD'VE KILLED ME AS THIS WAS VERY DANGEROUS. I HAVE DROP THIS OFF AT THE BMW DEALER AND THEY HAVE NO IDEA WHAT HAPPENED.

SUNROOF EXPLODED. ON FREEWAY DRIVING APPROX 70 MPH. NO DEBRIS IN ROAD, NOT NEAR OVER PASS, WEATHER CLEAR AND 65 DEGREES. LOUD BANG LIKE A GUN SHOT, SUN SCREEN WAS CLOSED SO IT KEPT MOST GLASS OUT OF VEHICLE.

INTERMITTENTLY AND WITHOUT EXPLANATION THE VEHICLE CANNOT BE STARTED USING NORMAL PROCEDURE EVEN THOUGH THE KEY FOB IS ON THE DRIVER'S PERSON. SINCE THE VEHICLE WAS PURCHASED NEW IN APRIL 2019, THE DEALERSHIP HAS HAD FIVE OPPORTUNITIES TO ADDRESS THIS PROBLEM WITHOUT SUCCESS. I HAVE BEEN INSTRUCTED THAT SHOULD THE VEHICLE FAIL TO START NORMALLY, RETRIEVE THE FOB; LOCK AND UNLOCK THE VEHICLE USING THE KEY FOB AND THEN START THE VEHICLE USING THE FOB WHICH (DEALERSHIP LANGUAGE HERE) HAS BEEN "AWAKENED." AS A SEMI DISABLED 73 YEAR OLD MALE THIS NECESSITATES THAT I EXIT THE VEHICLE AND, IN STANDING POSITION, CREATE THE ABILITY TO REMOVE THE KEY FOB FROM MY FRONT PANT POCKET IN ORDER TO FOLLOW THE PROCEDURE TO "AWAKEN" THE KEY FOB FOR PURPOSES OF STARTING THE VEHICLE. I CAN THINK OF ANY NUMBER OF SITUATIONS IN WHICH THIS COULD CREATE A HAZARDOUS SITUATION AND AM THEREFORE SUBMITTING THE PROBLEM TO NTSB FOR REVIEW.

DRIVING ON I-95, DASHBOARD DISPLAYED: "VEHICLE ON FIRE." IMMEDIATE CALL TO BMW. NO SUCH ICON OR POSSIBLE ENTRY IN BMW VEHICLES (2 DEALERSHIPS). DRIVE TO DEALERSHIP AND DIAGNOSTICS RUN WITH NO ISSUE WITH SYSTEM. BMW MAINTAINS THAT NO SUCH DIAGNOSTIC CODE OR WARNING TO CUSTOMERS EVER EMPLOYED IN ANY BMW VEHICLE.

WHEN DRIVING THE VEHICLE UNDER 30 DEGREES F, THE STEERING WILL PULL LEFT OR RIGHT ON ITS OWN, CAUSING THE VEHICLE TO SLIDE IN SLIPPERY CONDITIONS. SPEED DOES NOT MATTER AND IT WILL PULL/TWITCH THE STEERING RIGHT CONSISTENTLY OR SOMETIMES LEFT. VERY UNSETTLING AND EXTREMELY DANGEROUS WITH NO FIX AVAILABLE. CAR WILL DO THIS FROM SPEEDS OF 1-65 MPH.

ISSUE: MY RIGHT HAND RESTS OFTEN RESTS ON THE SHIFT LEVER WHILE DRIVING. SIX TO SEVEN TIMES MY BRAKING HAS INADVERTENTLY CAUSED THE SHIFT LEVER TO MOVE FORWARD TO NEUTRAL WITHOUT MY REALIZING IT. THEN, WHEN I ATTEMPT TO ACCELERATE I AM NOT MOVING WHEN TRAFFIC APPROACHING FROM THE REAR ANTICIPATES MY MOVEMENT. TWICE THERE HAS BEEN VERY CLOSE CALLS TO ME GETTING STRUCK FROM THE REAR. THIS IS DANGEROUS! MY OTHER CAR (LINCOLN MKT) REQUIRES THE SHIFT LEVER RELEASE TRIGGER BE DEPRESSED BEFORE I CAN MOVE THE SHIFT LEVER. THIS IS NOT THE CASE IN THIS BMW. PLEASE ADVISE.

WHILE I WAS DRIVING THE VEHICLE IT SUDDENLY FELT AS IF THE CAR DOWNSHIFTED AGGRESSIVELY AND AT THE SAME TIME I LOST POWER STEERING, POWER BRAKES, AND MY HUD FOR SPEEDOMETER, ETC. THE CAR DISPLAYED SEVERAL WARNINGS SIMULTANEOUSLY AS WELL.

VEHICLE HAS AGGRESSIVE STEERING CORRECTIONS/INTERVENTION. THE VEHICLE IS DIFFICULT TO KEEP IN THE LANE DUE TO STEERING WHEEL PLAY/WOBBLE.

THE VEHICLE HAS HAD ERRONEOUS, EXTREME, AND UNEXPECTED BEHAVIORS RELATED TO THE ACTIVE DRIVING ASSISTANT FEATURES. WHERE THE SYSTEM ACTIVATES TOO EARLY, TOO LATE, OR UNEXPECTEDLY. AFTER VEHICLE WAS DELIVERED IN NOVEMBER 2018 THE CAR TOOK AN UNCOMMANDED LEFT TURN NEARLY HITTING THE MOVEABLE CONCRETE BARRIER TRAVELING WESTBOUND ON THE WALT WHITMAN BRIDGE DURING HEAVY RAIN. CAR WAS RETURNED TO THE DEALERSHIP. WAS ADVISED TO TURN OFF ACTIVE STEERING INTERVENTION AS A SUB-FEATURE OF LANE DEPARTURE WARNING. SYSTEM REMAINED OFF. ON JUNE 10TH THE ACTIVE STEERING INTERVENTION WAS REACTIVATED AND PULLED THE VEHICLE INTO ANOTHER LANE OF TRAFFIC THAT WOULD HAVE RESULTED IN A CRASH IF THE DRIVER OF THE OTHER VEHICLE HAD NOT PULLED OFF INTO THE SIDE MEDIAN. THE ACTIVE STEERING INTERVENTION WAS CHECKED 'OFF' AND SHOULD NOT HAVE ACTIVATED AND THERE WERE NO VISUAL CUES THAT THE SYSTEM WAS ON, ACTIVE, AND COULD TAKE CONTROL OF THE VEHICLE. CAR WAS RETURNED TO THE SERVICE DEPARTMENT. SHOP FOREMAN DROVE AND CONFIRMED THE SAME ACTION. TOOK VEHICLE BACK, AND STILL CAN ACTIVATE STEERING INTERVENTION WHEN IT IS IN THE 'OFF' POSITION. SERVICE MANAGER SAID THAT BMW ENGINEERING HAS CONFIRMED THAT THIS IS HOW THE SYSTEM WAS DESIGNED. AUTOMATION THAT WAS NOT PROPERLY DISCLOSED KILLED 300+ PEOPLE IN 2 SEPARATE AIRCRAFT ACCIDENTS. THIS VEHICLE DOES NOT NOTIFY, DISCLOSE OR IN ANY WAY WARN THE DRIVER THAT AN AUTOMATED SYSTEM MAY TAKE CONTROL AND IF THIS IS THE DESIGN OF THE VEHICLE IT IS NOT SAFE AND COULD CAUSE SERIOUS INJURY OR DEATH.

DURING COLD TEMPERATURES, THE STEERING HAS A TWITCH WHICH CAUSES SMALL MOVEMENTS LEFT AND RIGHT WITHOUT ANY MANUAL INPUT. IT HAS THE FEEL THAT IT IS RECEIVING INPUTS FROM A SENSOR OR OTHER SYSTEM, WHICH REQUIRES OVERRIDE BY THE DRIVER. IT CREATES A DANGEROUS SITUATION.

1) SEVERAL INSTANCES OF DRIVING AT HIGHWAY SPEEDS IN DRY CONDITIONS, THE STEERING DRIFTS SLIGHTLY TO THE LEFT AND RIGHT REQUIRING CONSTANT STEERING CORRECTIONS. I HAVE THE STEERING WHEEL CENTERED IN THE LANE BUT THE CAR WILL SLIGHTLY DRIFT IN ONE DIRECTION, ONCE CORRECTED IT WILL DRIFT IN THE OTHER DIRECTION. IT DOESN'T HAPPEN ALL THE TIME BUT IS NOTICEABLE WHEN IT DOES. WIND AND ROAD CROWN WERE NOT A FACTOR. IT REMINDS ME OF CARS BUILT IN THE 1970'S THAT HAD A BIT OF "PLAY" IN THE STEERING. 2) X5 WAS PARKED OUTSIDE ON A ROAD TRIP THROUGH DES MOINES IN EARLY FEBRUARY. OVERNIGHT TEMPERATURES WERE IN THE MID-TEENS. DEPARTING THE NEXT MORNING AND IMMEDIATELY DRIVING (DRY ROAD CONDITIONS) ON THE HIGHWAY THE STEERING WHEEL HAD SLIGHT JERKING MOVEMENTS TAKING THE CAR LEFT OR RIGHT AT HIGHWAY SPEEDS. YOU COULD DEFINITELY FEEL THE MOVEMENT IN THE STEERING AND IT REQUIRED CONSTANT ADJUSTMENT. THIS WENT AWAY AFTER ABOUT 15 MINUTES. IT APPEARS THE STEERING IS RECEIVING UNCOMMANDED INPUTS FROM SENSORS OR SOFTWARE WHICH IS UNSETTLING WHEN IT OCCURS.

STEERING IS ALWAYS MOVING EITHER RIGHT OR LEFT. WILL NEVER STAY IN CENTER FEELS KIND OF FILMSY. WHEN TURNING CAR SOMETIMES SLIPS AND WILL CHANGE DIRECTION OF WHEEL AND AFFECT ACCELERATION

WHEN TEMPERATURES ARE <10 DEGREES, STEERING WHEEL TWITCHES AND PULLS LEFT AND RIGHT, THE COLDER THE TEMPERATURES, ESPECIALLY IN SUB ZERO TEMPS, PROBLEM WORSENS GREATLY!! VERY DANGEROUS AND SCARY TO DRIVE CAR. TOOK THE CAR TO BMW SERVICE, THEY COULDNT FIND ANYTHING WRONG, DID SOFTWARE UPDATE WHICH MADE ABSOLUTELY NO DIFFERENCE. ACCORDING TO BMW BLOG, MANY MANY COMPLIANT ABOUT THIS ISSUE FOR PEOPLE LIVING IN COLD CLIMATES IN WINTER. APPEARS BMW IS AWARE OF THE ISSUE BUT SO FAR HAS NOT DONE ANYTHING TO CORRECT THE ISSUE, AGAIN, THIS IS EXTREMELY DANGEROUS AND NEEDS TO BE CORRECTED ASAP. THIS HAPPENS AT ALL SPEEDS. ONCE THE OUTSIDE TEMPERATURES ARE ABOVE 15 DEGREES, PROBLEM GOES AWAY.

WHEN THE CAR HAS SAT OUTSIDE AND THE COLD THE STEERING IS VERY LOOSE CAUSING THE CAR TO BE UNRESPONSIVE TO TURNING. THE DRIVER ASSIST IS ALMOST NO. FUNCTIONAL TURNS ON AND OFF ON ITS OWN. SHUTTING DOWN THE BLIND SPOT AWARENESS AS WELL AS FRONT COLLISION AUTO BRAKING

WHEN THE VEHICLE IS OPERATED IN COLD TEMPERATURES (<10 DEGREES F), THE STEERING WILL RANDOMLY "TWITCH". THE WHEEL WILL MOVE SEVERAL DEGREES IN EITHER DIRECTION USUALLY OPPOSITE THE DIRECTION OF THE CURRENT WHEEL POSITION. THIS PULL IS NOT CAUSED BY THE DRIVER OR EXTERNAL FACTORS -- THE CAR'S AUTONOMOUS DRIVING MECHANISMS SEEM TO BE MALFUNCTIONING. THE CAR ESSENTIALLY FEELS LIKE IT IS SLIPPING OR "FLOATING". THIS HAPPENS AT ALL SPEEDS, BUT ONLY WHEN THE TEMPERATURE IS VERY COLD. THIS IS AN EXTREMELY HAZARDOUS PROBLEM, WHICH MAKES THE CAR A DANGER TO ANYONE INSIDE IT, OR WITHIN THE VICINITY OF IT. BMW IS SUPPOSEDLY AWARE OF THE ISSUE, BUT NO FIX HAS ANNOUNCED. THE WEBSITE BELOW DETAILS OTHER USERS ISSUES AND COMPLAINTS. HTTPS://G05.BIMMERPOST.COM/FORUMS/SHOWTHREAD.PHP?T=1577605

DURING VERY COLD CONDITIONS (BELOW 10 DEGREES FAHRENHEIT), THE VEHICLE'S STEERING FEELS LOOSE, NUMB AND DISCONNECTED. AT FIRST I THOUGHT IT WAS AN ISSUE WITH THE DRIVER ASSISTANCE SYSTEMS/LANE KEEP ASSIST. I TURNED ALL THOSE SYSTEMS OFF AND THE ISSUE PERSISTED. WHEN CONDITIONS BECAME WARMER, THE ISSUE WENT AWAY. IT HAS ONLY OCCURRED IN EXTREME COLD. MY BMW DEALER ADVISED THAT THEY WERE AWARE OF THE ISSUE AND THAT THE SERVICE MANAGER'S VEHICLE IS DOING A SAME THING. THEY INDICATED THAT BMW ADVISES A SOFTWARE UPDATE IS FORTHCOMING, BUT WHEN? WE HAVE HAD A NUMBER OF ISSUES WITH THIS VEHICLE SINCE DELIVERY IN NOVEMBER. ALL SOFTWARE RELATED, AND NONE HAVE BEEN CORRECTED BY UPDATES YET. THE REST OF THEM ARE ANNOYANCES, UNACCEPTABLE YES, BUT THIS STEERING ISSUE IS A SAFETY ISSUE. IT IS CONCERNING THAT IT EXISTS IN THE FIRST PLACE AND SHOCKING THAT WEEKS LATER, IT STILL HAS NOT BEEN ADDRESSED. OTHER OWNERS ARE REPORTING THE SAME ISSUE IN OWNERS' FORUMS.

IN TEMPERATURES BELOW 15 DEGREES, THE STEERING BECOMES ERRATIC AND WILL PUSH THE CAR IS DIRECTIONS WHEN DRIVING AT LOWER SPEEDS (BELOW 35). AT HIGHER SPEEDS ON FREEWAYS THE STEERING IS REQUIRES CONSTANT ADJUSTMENTS, VEHICLE FEELS LIKE IT IS DRIVING THROUGH HIGH WINDS. BOTH SITUATIONS ARE DANGEROUS.

THE DRIVERS ASSIST SYSTEM DISABLES ITSELF FREQUENTLY IN COLDER AND SNOWY WEATHER. THIS REMOVES A NUMBER OF SAFETY SYSTEMS FROM THE VEHICLE.

#1: STEERING WHEEL JERKS FROM SIDE TO SIDE ALMOST LIKE A TWITCH IN VERY COLD WEATHER ON A COLD START. ALMOST FEELS LIKE DRIVING ON ICE. TAKEN TO DEALER TWICE AND THEY SAID "BMW IS AWARE OF THIS ISSUE AND NOT SURE ON ETA FOR FIX". UNACCEPTABLE AND UNSAFE IN COLD CLIMATES. #2: AUTOMATIC EMERGENCY BRAKING DOESN'T WORK. I'VE HAD MULTIPLE INSTANCES WHEN THE CAR DID NOT RESPOND TO EMERGENCY SITUATIONS. BOTH ON CITY STREETS AND HIGHWAY DRIVING

TL* THE CONTACT OWNS A 2019 BMW X5. WHILE DRIVING 35 MPH, "LEVELER SELECT DEFECT" APPEARED ON THE INSTRUMENT PANEL FOLLOWED BY "TRANSMISSION DEFECT, DO NOT TURN VEHICLE OFF". THE CONTACT STATED THAT THE VEHICLE WAS ABLE TO SHIFT INTO DRIVE, NEUTRAL, AND REVERSE, BUT COULD NOT SHIFT INTO PARK. IN ADDITION, THE SERVICE TRANSMISSION WARNING INDICATOR ILLUMINATED. WHEN THE VEHICLE WAS FINALLY ABLE TO BE PLACED INTO PARK, IT AUTOMATICALLY SHUT OFF AND WOULD NOT RESTART. THE VEHICLE WAS TAKEN TO DAVIS AUTOMOTIVE GROUP (6135 KRUSE DRIVE, SOLON, OHIO 44139, (440) 542-0600) WHERE IT WAS DIAGNOSED THAT THE ENTIRE GEAR SHIFT AND TRANSMISSION NEEDED TO BE REPLACED. THE DEALER WAS UNABLE TO RESTART THE ENGINE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND THE CONTACT FILED A COMPLAINT WITH THE CORPORATE OFFICE. THE CONTACT WAS AWAITING A RESPONSE FROM BMW. THE FAILURE MILEAGE WAS 860.