ZASPAJAN1K7C407362019 ALFA ROMEO Stelvio

I'm driving and all of a sudden - while I'm on the highway - a service engine pops up on the dashboard, and my car looses all power and drive ability. I immediately loose any gas/drive ability to accelerate or maintain legal speeds. I read about the recent recall with the fuel system and it's exactly what my car is experiencing, but somehow my VIN is both telling me that my car has a recall at one place, and then doesn't have a recall at another. It's confusing and I"m not sure what the database issue is because my car is experiencing the same exact feul system problem is that I"m reading on line for recall of my car's year.

1. COMPONENT FAILED & INSPECTION: The transmission ground strap (uninsulated, bare braided copper cable) completely corroded/severed from environmental decay. This open ground circuit forced high engine-cranking currents into secondary low-voltage paths, causing an extreme thermal surge that melted and shorted out the main engine compartment wiring harness. Both failed components are preserved by the owner and are available for forensic inspection upon request. 2. SAFETY RISK: This manufacturing flaw causes a severe thermal fire hazard and an instantaneous, catastrophic loss of all vehicle propulsion, power steering, braking assist, and lighting systems while operating on public roadways. This abrupt deactivation threatens occupant safety and surrounding traffic by risking high-speed highway collisions or engine bay fires without warning. 3. CONFIRMATION: The exact failure cascade was formally diagnosed, itemized, and verified by Maranello Alfa Romeo of [XXX] ([XXX]) under a repair estimate of $7,203.10. 4. INSPECTIONS: Formally inspected by factory-certified technicians at the local authorized dealership center. No insurance, police, or outside authority investigations have occurred yet, as the car was towed immediately to avoid an active open highway fire. 5. SYMPTOMS & WARNINGS: There were absolutely no warning lamps, messages, check engine lights, or symptoms prior to the incident. Failure occurred instantly on XXX. The vulnerability was hidden from plain sight until the primary ground pathway severed completely during engine startup. 6. MANUFACTURER KNOWLEDGE: Alfa Romeo engineering has recognized this danger on 2017-early 2023 models, releasing a redesigned, fully sheathed/insulated ground cable (Part No. 68648999AA) to prevent this environmental decay. The consumer was never proactively notified of this critical safety vulnerability INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

There were no warning lights prior to driving and the vehicle stopping on the highway 2 times. Now the warning lights is constant and referencing the recall from 09/2025. Still no remedy for the recall. Mopar and the Alfa Romeo dealership have not contacted me regarding fixing the problem. A class action lawsuit needs to be filed

The contact owns a 2019 Alfa Romeo Stelvio. The contact stated that while driving approximately 45 MPH, the vehicle suddenly stalled. On another occasion, the vehicle stalled while in a parking lot. The fuel warning light, the auto-stop warning light, and the traction control warning light were illuminated. The vehicle was initially towed to a relative's residence and later towed to a local dealer, where an unknown repair was performed; however, the stalling failure recurred. The vehicle was then taken to an independent mechanic, who diagnosed the failure as a faulty fuel module requiring replacement. The vehicle was not repaired. The manufacturer was contacted, but offered no financial assistance and advised the contact not to drive the vehicle. The contact confirmed that the remedy part for NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline) was not yet available. The failure mileage was approximately 43,250.

The vehicle randomly has a yellow A! error code, then it loses power while driving, when going up a hill, sometimes barely makes it. No mechanics can figure this out and its a topic of complaints amongst numerous forums regarding this vehicle. Why isn't there a recall on this?

The contact owns a 2019 Alfa Romeo Stelvio. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving, the vehicle failed to exceed 60 MPH and the vehicle went into LIMP Mode. The vehicle was taken to the dealer, and the failure was associated with the recall and confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 95,000.

The contact owns a 2019 Alfa Romeo Stelvio. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

Subject: Formal Demand for Remedy – Safety Recall / 2019 Alfa Romeo Stelvio (VIN: [XXX] ) To Whom It May Concern, I am writing to formally demand immediate resolution regarding a serious safety recall affecting my 2019 Alfa Romeo Stelvio (VIN: [XXX] ). The recall, issued in September 2025, involves a defect in the fuel delivery module that may result in a loss of motive power. This defect presents a significant safety hazard, increasing the risk of a crash, injury, or worse. Despite the severity of this issue, I have not been provided with a remedy, repair timeline, or adequate alternative solution. It is unacceptable that I am expected to continue operating—or assume the risk of operating—a vehicle with a known safety defect and no available fix. This situation has caused ongoing concern, inconvenience, and diminished confidence in the safety and reliability of the vehicle. Given the lack of a timely and effective remedy, I am formally requesting that Alfa Romeo take one of the following actions immediately: Provide a permanent repair within a reasonable and clearly defined timeframe; OR Repurchase (buy back) the vehicle at fair market value; OR Provide a comparable replacement vehicle at no cost to me If this matter is not resolved promptly, I am prepared to pursue further action, including but not limited to filing additional complaints with the National Highway Traffic Safety Administration (NHTSA), seeking relief under applicable state lemon laws, and exploring other legal remedies available to me. Please treat this matter with the urgency it requires. I request a written response within 10 business days of receipt of this letter outlining the steps Alfa Romeo will take to resolve this issue. Thank you for your immediate attention to this serious safety concern. [XXX] and [XXX] [XXX] [XXX] or [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Despite the seriousness of the outstanding recall (25V-586), which Stellantis acknowledges can result in a sudden and complete loss of engine power at high speeds, Alfa Romeo/Stellantis have provided exactly zero updates in nearly 8 months since the recall was announced. In speaking with my dealer, I’ve learned that Alfa Romeo/Stellantis were initially providing vague estimates for when they expected a recall fix to be available but have since stopped providing information to the dealers altogether. The manufacturer’s behavior in the face of such a serious safety risk is alarming and leads me to question whether a fix is actually even under development or will ever be available. Without action or the threat of action by the government to force the manufacturer to comply with their obligations to vehicle owners I have no confidence that this serious safety issue will be satisfactorily addressed at all, much less in a timely manner.

The contact owns a 2019 Alfa Romeo Stelvio. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

The contact owns a 2019 Alfa Romeo Stelvio. The contact stated that the check engine warning light was illuminated. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline). Additionally, the contact was unable to renew the registration due to the open recall. The local dealer was contacted and confirmed that parts for the recall repair were on back order. The vehicle was not diagnosed or repaired. The manufacturer was contacted and provided a reference number, but no additional assistance was provided. The failure mileage was approximately 93,400.

While pulling out, vehicle decelerated as I was pressing the gas. Almost hit by another vehicle. Managed to avoid being hit and car still would not accelerate. Ultimately, pulling over at store and parking. Contacted manufacter because it was related to the recall, but they wasnt able to do anything about it. Im unable to drive it and im still paying for it. no remedies were offered

the vehicle has developed the exact symptoms described in the recall, including: Loss of power Check Engine Light Excessive oil consumption Electronic throttle control warnings / drivability issues My authorized dealer has confirmed that the recall is open but states parts are not available. This leaves me with an unsafe and unreliable vehicle.

The contact owns a 2019 Alfa Romeo Stelvio. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

The contact owns a 2019 Alfa Romeo Stelvio. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed, but the vehicle failed to accelerate as intended, nearly causing a crash. The contact shifted to neutral(N), and the vehicle was pushed back to the nearby residence. The contact stated that a mobile independent mechanic diagnosed the vehicle at the residence. The dealer was made aware of the failure. In addition, the contact stated that several dealers were contacted, and the contact was informed that the parts were not available for an unknown repair. The contact received a recall notification NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the parts to do the recall repair were not available. The manufacturer was not made aware of the failure because the manufacturer's contact information was inoperable. The failure mileage was approximately 68,480.

The contact owns a 2019 Alfa Romeo Stelvio. The contact stated that while driving at various speeds, the vehicle would hesitate upon depression of the accelerator pedal, and the check engine warning light would illuminate. The vehicle was taken to a dealer, where it was diagnosed with an EVAP system leak; however, the origin of the leak could not be determined. The contact stated that the vehicle later failed to start, and both the check engine and auto Start/Stop warning lights were illuminated. The vehicle was towed to an independent mechanic, where it was diagnosed with a defective fuel pump, and the fuel pump was replaced; however, the failure recurred a month later. The contact stated that the vehicle failed to start after multiple attempts. The contact left the vehicle and returned to the vehicle the following day. The contact managed to drive the vehicle to the residence. The vehicle was then taken back to the dealer, where an unknown repair was performed; however, the failure recurred two days later. The contact later received a recall notice for NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The dealer was notified of the failure but refused to acknowledge the recall. The manufacturer had yet to be notified of the failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The vehicle was not repaired. The failure mileage was unknown.

The contact owns a 2019 Alfa Romeo Stelvio. The contact stated that the vehicle failed to drive forward. The vehicle was towed to the dealer, where the vehicle was diagnosed with a failed oil solenoid and battery failure. The contact was informed that the oil solenoid and battery needed to be replaced. The vehicle was repaired. The contact stated that the failure reoccurred a month later. The vehicle was towed back to the dealer. The contact was informed that the engine bolt needed to be cleaned, and the spark plugs needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The contact researched NHTSA Campaign Number: 25V586000 (Fuel system, Gasoline); however, the parts were unavailable for the recall repair. The dealer was made aware of the recall. In addition, the contact was without a vehicle because of the unrepaired recall. The contact stated that the dealer never mentioned the unrepaired recall and attempted to perform a temporary repair. The contact stated that whenever the check engine warning light illuminated on Alfa Romeo vehicles, the vehicle remained undrivable until the vehicle was repaired. The vehicle was undrivable and had been undriveable since June 2024. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 62,000. The VIN was unavailable.

The contact owns a 2019 Alfa Romeo Stelvio. The contact stated that while driving at 50 MPH, the contact became aware of water entering the cabin of the vehicle from under the glove compartment on the passenger’s side. A dealer was contacted. The vehicle was taken to dealer where it was diagnosed and determined the electrical system needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 18V205000 (EQUIPMENT); however, the VIN was not included in the recall. The manufacturer was not notified of the failure. The failure mileage was 34,000.

Recall Issue Sep 09,2025 Manufacturer Recall Number93C NHTSA Recall Number25V-586 Recall StatusRecall Incomplete, remedy not yet available I would like to submit a compliant that it has been two months since the recall was issue and there still is no formal remedy provided.

My car stopped and would not turn back on while in the middle lane of a busy highway. We were stopped on the highway >20min until police arrived to block the lanes so we could safely exit the vehicle and a tow truck could safely retrieve it. The ground strap underneath the vehicle that grounds the main engine harness was broken. As a result the electrical short resulted in burning/melting of several spots on the harness. There was no warning ahead of time and I’ve learned that this is a known issue. We are very lucky that this did not lead to a crash, injury or death.

The contact owns a 2019 Alfa Romeo Stelvio. The contact stated that the vehicle was unintendedly stopping and starting. While driving at 15 MPH, the vehicle shut off. The vehicle was jump-started. The driver was able to continue driving. The contact had the battery replaced at an independent mechanic. The vehicle was taken to the local dealer, who confirmed that the battery was not operating properly. The ABW warning light was illuminated. While pulling into the fuel station, the vehicle shut off. The vehicle was jump-started, and the contact drove to the local dealer, but the vehicle was not diagnosed or repaired. The contact became aware of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline). The manufacturer was not contacted. The failure mileage was approximately 69,000.

The contact owns a 2019 Alfa Romeo Stelvio. The contact stated that the vehicle intermittently failed to exceed 30 MPH while driving and depressing the accelerator pedal all the way to the floorboard. The message that the throttle and the ignition were inoperable was displayed. The vehicle was taken to the dealer, where it was diagnosed and determined that the fuel pump and the fuel pump sensor had failed. The dealer related the failure to NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the VIN was not included. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 55,000.

The vehicle has been in the shop since August 2025 attempting to be fixed. I have been making monthly payments and have not been offered any rental assistance or vehicle loaner assistance. My vehicle has multiple safety recalls and no current remedy.

I received Safety Recall 25V-586 regarding the fuel pump defect on my 2019 Alfa Romeo Stelvio. The notice states that the vehicle can lose drive power without warning, which could lead to a crash. However, the letter also says that the remedy for this condition is not currently available. I am extremely concerned for my safety because I rely on this vehicle for daily driving, and I do not feel it is safe to operate a car that could suddenly lose power at any time. The manufacturer has acknowledged the risk, but no repair or interim solution has been provided. I have also noticed occasional hesitation and reduced power while driving, which makes me worry that the issue may already be occurring. I am requesting that NHTSA review this issue and require Alfa Romeo to provide an immediate remedy, loaner vehicle, or buyback for affected owners until the fix becomes available. This situation places drivers and passengers at serious risk.

Fuel pump failed as in recall 25V586000 , vehicle stalled in middle of an intersection of a busy road , could not get vehicle into neutral to push out of road. Manufacturers recall does not include my vehicle vin (yet)

The contact owns a 2019 Alfa Romeo Stelvio. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted. The manufacturer was made aware of the issue, and a case was opened. The contact had not experienced a failure.

A corroded faulty ground strap under the car, which is connected to the transmission caused the engine wiring harness to overload a smaller ground wire in the wheel well, then continued to melt other sections of the main engine wiring harness when trying to start the car. This is only a $200 part, but caused $6k+ of damages calling for a labor intensive job of replacing the entire engine wiring harness. The manufacturer does not provide any information on this to the owner as a maintenance issue or something to keep an eye on to prevent this issue. It's obviously a defect.

Sensors for engine turned on and brakes.

Hello i was driving this morning with my alfa rimeo stelvio on freeway going 65 approximately and just heard explosion like granate or gun shot wich triger my anxiety and ptsd i have trauma from war back home when i was kid i stoped and was looking what happen and heard noise from outside and figured that was sun roof just ecploded randomly i dont knkw is there any legal action or anything becouse this is not right at all and looking onkine a lot ppl complain about that issue

The engine cooling hose is failing and may be made of similar materials under the same recall as the Stelvio Qudrofiligo NHTSA CAMPAIGN ID Number: 18V635000. Mine has a leak which can cause a loss of coolant and cause a crash. The engine cooling hose may have inadequate webbing material allowing a coolant leak.

The contact owns a 2019 Alfa Romeo Stelvio. The contact stated while driving approximately 35 MPH, the engine seized without warning. The vehicle was towed to the local dealer, where it was diagnosed that coolant had entered the engine. The vehicle was not repaired. The contact stated that the failure was related to NHTSA Campaign Number: 18V635000 (Engine and Engine Cooling). The manufacturer was contacted and opened a case, but no assistance was provided. The failure mileage was approximately 45,000.

Driving on the highway at 60mph, my sunroof exploded very unexpectedly and very loudly. It shattered along the front and sides but not anywhere at the center. Sunroof was closed and had only been used 1 time in the month I had the vehicle. Nothing hit me as no vehicles were anywhere near. The dealership managment is saying it had to be caused externally yet their own technicians said it was defective.

TL* THE CONTACT OWNS A 2019 ALFA ROMEO STELVIO. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE VEHICLE HAD AN OIL CHANGE. AFTER LEAVING THE INDEPENDENT MECHANIC, THE CONTACT WAS DRIVING AT 65 MPH APPROACHING AN INTERSECTION, THE ANI-COLLISION WARNING LIGHT ILLUMINATED. THE CONTACT APPLIED THE BRAKE PEDAL WHICH FAILED TO OPERATE CORRECTLY AND BECAME DIFFICULT TO DEPRESS CAUSING THE CONTACT TO CRASH INTO THE VEHICLE LOCATED IN FRONT OF HER VEHICLE. NO AIR BAGS DEPLOYED. NO INJURIES SUSTAINED. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A COLLISION SHOP AS THE VEHICLE WAS ASSISTED FOR DAMAGES WITH THE CONTACT INSURANCE COMPANY. TO VEHICLE THEN WAS TOWED TO HER RESIDENTS AND THEN TOWED AGAIN TO ALFA ROMEO OF WESTBURY 928 JERICHO TPKE, WESTBURY, NY 11590 (888) 411-8719 WHERE IT WAS AWAITING REPAIR OPTIONS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STARTED AN INVESTIGATION HOWEVER WAS UNABLE TO DUPLICATE THE CAUSE OF FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 6,300.*LN*JB

I PURCHASED MY CAR IN JAN. 2020. ON JUNE 21, 2020, I AWOKE TO MY ALARM GOING OFF. I TRIED TO USE MY KEY FOB TO TURN THAT ALARM OFF AND IT DID. NOT WORK. THE ALARM STOPPED AND I HAD TO USE THE HARD KEY TO ENTER MY CAR. THE CAR WOULD NOT START AND I HAD TO GET A JUMP FROM AAA. THE CAR WAS NEW WITH LESS THAN 3000 MILES ON IT. I TOOK IT TO THE DEALER TO FOR A DIAGNOSTIC AND THEY KEPT IT FOR 5 DAYS. THEY HAD TO REPLACE THE BCM. THE BCM WAS LISTED AS PROBLEM IN PRIOR YEAR VERSIONS OF THIS VEHICLE. THIS APPEARS TO BE A CONTINUING PROBLEM WITH THIS VEHICLE. THE VEHICLE WAS PARKED AND WAS NOT BEING DISTURBED WHEN THE ALARM WENT OFF.

WHILE DRIVING ON A HIGHWAY AROUND 3 AM IN DARK ENVIRONMENT, GOING AT 63MPH, THE VEHICLE COMPLETELY SHUT OFF IN LESS THAN 1 SECOND WITH NO WARNING AT ALL. BRAKES FAILED, STEERING FAILED, ENGINE SHUT OFF, ALL GAUGES INCLUDING SPEEDOMETER AND TACHOMETER STOPPED FUNCTIONING, ALL ELECTRICAL RELATED FUNCTIONS FAILED, HEADLIGHT AND TAILLIGHT SHUT OFF, UNABLE TO TURN ON HAZARD LIGHT. RIGHT AFTER THE COMPLETE FAILURE, I TRIED TO RESTART THE VEHICLE ON THE HIGHWAY WHILE STILL IN MOTION BUT THE VEHICLE WAS COMPLETELY UNRESPONSIVE. THE VEHICLE IS BARELY STEERABLE WITH THE STEERING ASSIST FAIL AND HAD TO SWITCH FROM THE LEFT LANE TO THE RIGHT LANE WITH NO TURN SIGNALS ON, AND HAD TO COAST TO A HIGHWAY EXIT BECAUSE OF THE BRAKES AND ENGINE FAILURE. AFTER STOPPING AT THE EXIT, I WAS UNABLE TO TURN ON THE HAZARDS LIGHT AND ALL DOORS ARE LOCKED EXCEPT THE DRIVER SIDE DOOR, THEN I CALLED ROADSIDE ASSIST FOR HELP, THE VEHICLE WAS THEN TOWED AWAY.

TL* THE CONTACT OWNED A 2019 ALFA ROMEO STELIO. THE CONTACT RECEIVED NOTIFICATION OF THE NHTSA CAMPAIGN NUMBER: 19V148000 (FORWARD COLLISION AVOIDANCE, SERVICE BRAKES, HYDRAULIC) HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER FERRARI AND MASERATI (525 SOUTH LAKE DESTINY DRIVE, ORLANDO, FL 32810 (407)-667-43000) WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE. THE CONTACT HAD EXPERIENCED A FAILURE. THE CONTACT STATED THAT WHILE DRIVING AT 45 MPH, THE BRAKE PEDAL WAS DEPRESSED BUT FAILED TO ENGAGE CAUSING THE FRONT OF THE VEHICLE TO CRASH INTO ANOTHER VEHICLE WITHOUT WARNING. THE AIR BAGS DEPLOYED. A POLICE REPORT WAS FILED. THE CONTACT HAD A MINOR INJURY TO HIS RIGHT SHOULDER BUT MEDICAL ATTENTION WAS NOT SOUGHT. THE OTHER DRIVER OF THE VEHICLE SUSTAINED UNKNOWN INJURIES AND IT WAS UNKNOWN IF MEDICAL ATTENTION WAS REQUIRED. THE VEHICLE WAS TOTALED AND TOWED ON THREE OCCASIONS TO 2 COLLISION CENTERS AND A SALVAGE LOT. THE SAME DEALER WAS CONTACTED ABOUT THE RECALL PARTS THAT WERE NOT AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OPENED AN INVESTIGATION WITH CASE NUMBER 58350517. THE FAILURE MILEAGE WAS 3,000. THE PARTS DISTRIBUTION DISCONNECTED.