5XYRL4JC2SG3147932025 KIA SorentoS

I am submitting this revised complaint to correct a prior report that was not accurately documented during a phone submission. Vehicle: 2025 Kia Sorento (259 miles at purchase) Within approximately two months of ownership (~3,000 miles), the vehicle began experiencing serious safety-related issues, including intermittent stalling, braking problems, and electrical malfunctions. Symptoms include: •Vehicle stalled and failed to restart, leaving me stranded •Radio/display screen went blank •Heating/climate system became nonfunctional •Vehicle would not shift into neutral •Persistent burning odor inside and outside the vehicle These issues raise concern about a potential fire risk. In May 2025, the vehicle was inspected by two separate dealerships, both of which reported no issues. The condition worsened, resulting in a complete failure requiring towing. A dealership later identified “electrical issues,” but key symptoms were not documented. A second dealership has since stated the vehicle is operating normally; I disagree, as I believe the root cause has not been resolved. Issues began at ~3,000 miles, with major failure at ~22,000 miles. I have contacted Kia and requested a buyback due to repeated failures and safety concerns. This request was denied twice; a goodwill credit was offered but not accepted. This complaint is submitted to report ongoing safety defects involving stalling, braking, electrical failure, and a potential fire risk.

The contact owns a 2025 Kia Sorento. The contact stated that while driving at an undisclosed speed, the vehicle unexpectedly stalled. There was no warning light illuminated. The contact stated that the braking system became inoperable and failed to function properly. Additionally, while the vehicle was parked, it failed to start and lost motive power. There was no warning light illuminated. The vehicle was towed to the dealer, where it was diagnosed that the electrical system had failed and needed to be repaired. The vehicle was repaired; however, the failure recurred. The vehicle was then taken to another dealer, where it was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 22,000.

Sunroof exploded when driving sounded like a shotgun. This is a known issue by kia.the glass blow upward.

In December I submitted a complaint about the powertrain not knowing the extent of the problem. My 2025 Kia Sorento X-Line SX prestige with shy of 48000 miles had a catastrophic and potentially life threatening malfunction with the powertrain. The technicians revealed that the transmission housing actually exploded, launching shrapnel into the surrounding area. This had the potential to impact other drivers on the road, and had the blast gone in my direction it may have pierced the shielding and struck me or my passenger. It was far beyond a regular breakdown. The damage was so severe that while under warranty i still as of today 4/18/2026 do not have my vehicle back. They seem to be unable to fix the problem.

I have a 2025 KIA Sorento Hybrid and several months a go Car play stoped working correctly If car developers like to replace the car stereo with Car Play or a new Tecnology they better make shore that the Tecnology is working correctly before they Install it in people vehicle don't let the consumer develop the product for Tham, Car play is not working, at times sounds stop playing ,navigation stop talking and there is no AI I'm a Uber Driver wen I"m in the car I need to concentrate on the road driving I should not trying to figure out how to fix the sound, or what is wrong with Car Play. I would like for Apple to make a Recall. Car Play is a very dangers issue that no one is been able to fix. Please I hope you take this in cosideration it's a Sefty issue. Mahalo

Driving 40 mph coming around a bend. There was a car stopped about to rear off to the left and when coming up around the turn I saw and tried to stop. I was about two car lengths behind the car when I pressed the brake down and I pushed it all the way down and nothing happened. It was grinding and shaky when pressing it down. Not tight or anything. I feel like I normally would have that tension right away to be able to stop. There was no warning or anything and the car always has warnings when something is close.

I am reporting a loss of propulsion event in a 2025 Kia Sorento S AWD. The vehicle experienced a sudden loss of drive power when pressing the accelerator. The engine did not respond normally and the vehicle entered a reduced power (limp mode) condition. Stopping in the middle of major intersections, [XXX] and then [XXX] and [XXX] at 4:30 pm. This vehicle is subject to Recall 25V548 involving engine connecting rod bolts, which warns of possible engine damage and loss of propulsion. The dealership (Gettel Kia of Bradenton, FL) stated they were unable to duplicate the issue. The recall language states that engine damage or loss of propulsion may occur and could create a safety hazard. This event occurred at approximately moving from a stop position to ? mph on [XXX]] with approximately 1,936 miles on the vehicle. As I drove it home it would disengage and reengage. I am concerned about the safety of continued operation given the recall notice and the propulsion failure experienced. VIN: [XXX] Please advise. [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

This is the 4th time car is unable to start after being parked for one day and it had to be jump starting. At first I thought it was some accessory, specifically a dashcam and aftermarket ambient lights, so I disconnected both and I even turned off the wireless charging pad and disable the function to turn the lights on when doors open and it didn't help, dead car again after 1 day parked. Car was purchased new in august of 2025 and this issue started this past january coincidentally after an OTA update in december. Today, I got the 12v battery tested at my local Advance Auto Parts and battery health came out good, battery level was low (as supposed after a jump start) and it only recommended a recharge. So the issue lies inside the electrical system of the car and to my surprise this parasitic draw is not new, in online forums a lot of owners talk and complaint about this specific issue, even here I found a similar complaint and I wonder why there's not at least a technical bulletin from KIA addressing this issue. Finding out the cause of the battery draining fast is imperative because if overlook this can evolve into something more serious because we don't know what it is that is "always on" drawing big amounts of power and can clearly be classified as a fire hazard. I remember having the same issue with my old car, a 2019 Kia Sorento EX, and it was solved with a simple computer update (NOT the map or infotainment update), it was a firmware only available at the dealership. I just hope this could be the case this time and KIA can respond in a timely manner to solve this issue.

The Kia Connect fuse was confirmed by Gerald Kia of Naperville to cause a parasitic draw that cannot be fixed. The dealership had to remove the fuse after stating that no software update is yet available, and that numerous owners have had the issue. My car has died 7x with less than 7K miles on it and less than a year old. Bought new. They still have not put the fuse back in and Kia has refused to issue a recall.

The sunroof spontaneously shattered while I was driving in the highway. No one was injured but glass did fly off of the vehicle and luckily the cover inside was closed so no glass got in the vehicle. There was no warning just an explosion sound. The sunroof glass was blowing outward once I was able to pull over and inspect it. The dealership did replace the sunroof and said it was covered under my warranty. I did try to contact Kia directly first and they were taking weeks to reply and eventually said they would do a good faith one time repair but I never messaged them back since my dealership took control and told me it was covered under my warranty and proceeded to order and fix it. They also had to replace the sunroof cover because they said it was also damaged from the pressure of it spontaneously shattering.

While driving on a freeway I hear a crashing sound of glass and heard loose glass above me. When I pulled over I looked to see that my sunroof shattered. There was nothing above me for something to fall from and hit my car. There was also nothing found that would have struck the glass

While driving the engine stops running and only runs on battery power. The only remedy that is partially successful is to stop and restart the vehicle. Problem often repeats itself and makes driving unsafe as the battery cannot fully power the engine. Upon restart the check engine light will be on and report this error: "Powertrain P112000 A possible condition with your Engine Control System has been detected. A full system check is recommended to be done when convenient. Please contact your local dealership to schedule an appointment." This is the 3rd time this has happened since December. Has been at dealership twice and they essentially just reset the error condition, only for it to happen again after a couple weeks of driving. Most recent occurrence was yesterday morning.

Was merging onto the San Tan L202 Freeway from the SR24 On Ramp. While accelerating to up to roughly 65mph, what sounded like a gunshot went off and it became very loud in the cabin of my car. I then noticed glass flying around the outside of my car, so I immediately pulled over onto the shoulder to see what happened. When I got out and looked up I noticed that the sunroof had completely exploded out in the center and that the glass was facing upwards. My husband came to help me take the vehicle to Horne Kia Dealership and we left it with them that day. There was no any indication of anything hitting or striking the vehicle, anything falling down onto it, or any external factors that could have contributed to the sunroof exploding.

My wife was slowly pulling into a parking spot at kohls and the car lunged like the gas pedal was pressed all the way down and hit parking pole in spot . I googled to see if this was an issue reports and found information on this not actual recall but reports on this issue . Kia has done nothing with this case

Vehicle only has 5839 miles and this is the 2nd time the battery has been dead. First time was Dec 18th 2025. Vehicle purchased 7/5/25. 2nd time 2/5/26. First time the outside lights flickered for a long time before finally going off. 2nd time the outside lights didnt flicker and key fob wont even lock the car. We took the vehicle in for service after 1st dead battery instance and they told us we must've not closed a door or left a light on which drained the battery. Will be scheduling another service so they can fix the issue. There were no messages or symptoms of the problem prior to the failures. I am requesting that NHTSA document this as a potential electrical system safety defect.

Driver attention warning light coming on frequently for no reason, is distracting for driver and will cause and accident, today we almost hit a horse and buggy

The DCT transmission causes significant hesitation at slow speeds or starting from a stop. This often leaves the driver and it’s occupants in a vulnerable position if the car hesitates when trying to navigate through traffic. I have taken it to the dealership and they stated that nothing is wrong with it, However, in reviewing online forums, it is obviously a significant concern.

Hit a deer going 80, airbags did not deploy and car did not attempt to brake

This incident started within the first 100 miles of ownership. The dealership hasn’t been able to recreate the incident. I put my 2025 Kia Sorento in the “automatic” drive position. I start driving and my transmission won’t shift gears. I looked down at my dashboard and it shows the vehicle is in “manual” drive gear 1. I look at my gear shift and it shows the vehicle is in “automatic” drive position. If I push the vehicle to its redline or approximately 5000 RPM’s the vehicle shifts and dashboard changes from “1” to “D”. In summary my transmission is malfunctioning and shifting intermittently on its own from automatic to manual drive and the gear shifter is always in the automatic shift position. This happens several times a month. I video taped the incident because the dealership didn’t believe me when I told them this keeps happening.

Instrument gauge cluster freezes while driving. Cannot view current speed, blinker status, cruise control settings, tachometer information, fuel status, or ADAAS items. Also gear select indicator light freezes and does not show correct gear/park. Can only be reset by disconnecting negative battery cable and discharging system.

Today is 12/15/2025 About a month or 2 ago i was on the highway coming from South Carolina to North Carolina when the engine revved up unexpectedly without input. It has HDA2 and that was doing most of the work. The vehicle started to speed up beyond the set limit and once i hit the brakes and manually shifted i was able to regain control. Last week the vehicle made a small noise that I wasn’t sure about. I called the dealership thinking that it could be a transmission problem. When i called they didn’t seem concerned and asked me to bring it in Monday (today). I had no lights or error codes (and still don’t) on the dash and they did not recommend that I don’t drive it so i continued using the car. Last night it made a horrendous noise started revving on its own and shifting very hard ans if something was coming apart. This morning on my way to the dealership the car completely seized up at an intersection. The car has 47900 miles on it. It’s a 2025 and the transmission seems to have completely blown. Ive read online several complaints about the transmission on these vehicles and think that they may be a major concern. For a new car to have this type of issue locking up while on public roads and smoking is absolutely a hazard. My only saving grace is that it happened at an intersection and not on the highway where an accident would have been inevitable. Please look into the DCT transmission on Kia Sorentos. Particularly X-Line SX prestige models. It is a highly unsafe vehicle. Another issue that the car is having is a clicking noise on the steering column that seems to be getting much worse over time and im afraid will result in loss of steering. Im having them check it out as well. The vehicle never showed a malfunction and I’ve attached a screenshot of the app showing it in perfect health despite being undrivable. I still have no invoice and no police report was made.

Road debris under normal driving conditions caused a puncture of the inverter radiator resulting in a total loss of coolant in the inverter and battery system. Inspection of the system at a Kia dealer confirmed the problem. The first sign of concern was an error displayed on the driver screen stating, "Check drive motor cooling system". There is no mention of this error in the owner's manual for the vehicle, though I did find several online discussions surrounding similar issues and warnings. I was driving on the highway at the time, and outside temperature was just under 40 degrees F. The car continued to drive normally for roughly 15 miles while utilizing the gas engine on the highway but eventually began struggling to accelerate or brake when switching to the electrical system after moving to residential streets. There is not a means of turning off the hybrid system. I received further warnings for several various driver assist functions becoming unavailable and the car became difficult to steer. I parked in a parking lot until the car could be towed for evaluation.

There is an electronic glitch with the gear shifting system where it will randomly / sporadically not allow shifting from reverse to drive and provides the error message "gear already selected." This has happened numerous times and resolves itself after 1-2 minutes. However, the vehicle remains in the wrong gear (reverse) while waiting, creating a significant safety issue. I purchased this vehicle brand new from Kia Coughlin in Dublin, OH. After two service visits where they were unable to recreate the problem (it happens randomly / sporatically), they have not provided resolution or a way ahead. I have multiple videos of this issue taken while it was happening.

Vehicle: 2025 Kia Sorento (leased) VIN: [XXX] Mileage at failure: 11,345 Incident dates: March 23, April 27, November 28–December 1 Type: Loss of power / electrical failure / safety hazard Complaint Description: I am reporting repeated electrical failures and complete loss of power in my 2025 Kia Sorento that created unsafe situations for myself and my children. The first failure occurred on March 23, approximately 2½ weeks after leasing the vehicle. The vehicle died without warning and had to be jumped. I brought it to the Kia dealership, but service would not perform a diagnostic without an appointment and sent me home with no repair. The second failure occurred on April 27. This time the vehicle was completely dead again. Kia’s service manager retrieved the vehicle from my home, diagnosed a failed battery cell, and replaced the battery. The third failure occurred between November 28 and December 1. The vehicle was again completely inoperable. I attempted to jump the vehicle on multiple days, but it would not hold a charge. I was stranded without transportation. The interior doors and trunk would not unlock because the power locks failed, and my belongings and large business related were inaccessible. Headlights flickered like a strobe light before the vehicle lost power entirely. Kia towed the vehicle from my home on December 1. These repeated electrical failures have resulted in multiple incidents of being stranded, including with my children, and have caused loss of use of the vehicle for several days. The defect is unpredictable and creates a serious safety concern, especially because the vehicle can lose power without warning and i am unable to unlock the doors. This raises a SERIOUS safety concern when transporting children. I am requesting that NHTSA document this as a potential electrical system safety defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My vehicle repeatedly fails to recognize the key fob even when it is in my hand or inside the vehicle. Because it is a push-button start system, proper fob communication is required for unlocking and driving. When recognition fails, the vehicle will not start and I have been stranded. During the first of these failures, I called the dealership because I was stranded and needed immediate assistance. They instructed me to remove all passengers, close the doors, and then hold the unlock button on the key fob for 10 seconds and press lock/unlock six times in sequence. They also advised me not to use the door-handle lock/unlock button and to use only the fob buttons. This temporarily restored function, but a new vehicle should not require a manual reset procedure to start and operate normally. On two separate occasions, this problem also triggered the vehicle alarm, which was extremely difficult to silence. This does not happen every time, making the vehicle unreliable. One incident occurred while transporting special-needs children and an elderly passenger, and removing them from the vehicle to perform the reset was difficult and unsafe. The dealership later ran diagnostics and found no fault codes. I also replaced the key fob battery, but the issue continues. I have seen other owners online describing the same key-recognition failures, indicating that I may not be the only person experiencing this. This is a safety concern because the vehicle can fail to start without warning, and the alarm activation increases confusion and stress. The issue remains unresolved.

My vehicle has an ongoing acceleration problem that feels like the engine and transmission are not communicating correctly. There are times when the vehicle will not accelerate even though the RPMs increase. Instead of picking up speed, it feels like the engine is pulling the vehicle back. This creates hesitation and uncertainty about whether the car will respond when I press the accelerator. This happens most noticeably at lower speeds (around 30–40 mph, often near 30 mph), where the RPMs may rise on their own even if I am maintaining steady pressure on the gas pedal. It also occurs when I need to accelerate quickly — such as merging onto the freeway or joining the flow of traffic — and the vehicle feels like it resists gaining speed. Even when I press the pedal gradually and correctly, the vehicle struggles to accelerate and the engine revs without the car moving forward as it should. I reported this to the dealership. They ran diagnostics and told me no issues were detected. They also stated they cannot take action unless they can re-create the problem themselves. Because this does not happen every time, recreating it on command is very unlikely, leaving me without a solution. This is a safety concern because hesitation or failure to accelerate properly during merging or crossing traffic increases the risk of collisions. The problem remains unresolved.

Sunroof randomly shattered with no vehicles in front of me while driving.

Fourth time we've had the car go into limp mode. Now at the dealer for third time. Driver was driving and the car went into limp mode after activating the cruise control follow function. Husband was behind in our Toyota Tacoma truck and was able to pick her up with California Highway Patrol to get off the highway into a parking lot to tow her. No warnings, no messages on the dash. She was unable to accelerate to highway speeds and was capped, and felt that there was very little to no predictable responsiveness in the car's acceleration. Car now at dealership.

Our 2025 Kia Sorento has exhibited several issues with shifting into gears especially from 1-2 gear there is hesitation, hard shifting, where it has delayed engagement, rough or jerky shifts, and a feeling of power loss while driving. It has a hard time getting into 3rd gear and just stalls, dragging at 1st/2nd when attempting to accelerate and coming down from 4th gear back into 2nd and 3rd. A "check transmission' warning light has appeared on the dashboard. This is teh second time we have had this issue. The car only has 16K miles on it, we have had it for 12 months exactly now and only drive it locally.

The contact owns a 2025 Kia Sorento. The contact stated while driving on the highway at 60-65 MPH, the vehicle unexpectedly decelerated to 20 MPH and the vehicle went into LIMP Mode. The contact stated that the message “Vehicle Speed Restricted to 20 MPH” was displayed. The failure had occurred four times while driving. The vehicle was taken to the local dealer, who was unable to identify or duplicate the failure. The vehicle was not repaired. The manufacturer was contacted and opened a case. The failure mileage was approximately 4,000.

The inverter radiator is punctured during typical road use by road debris. This results in a total loss of circulating coolant in the inverter/electric motor cooling system. This renders the car undrivable, with a concern for electric motor overheating, given that the hydrid mode and electric power can not be turned off. This is available for inspection. It is unclear whether the electric motor will shut down when overheated, but seizing of the motor or fire seems possible. Reproducibility: There are many examples online of this occurring during normal road use of Kia electric and hybrid vehicles. There is a warning 'Check drive motor cooling system' in this model. This appeared during driving and reamined on while the coolant was depleted. Refilling coolant turned the light off but with coolant being actively sprayed out of the pin hole in the radiator at all times (the pump does not turn off when the engine is cold) resulting in rapid coolant loss.

While driving at speeds below 25 mph, my transmission seems to get caught between gears. When I press the accelerator, the engine revs, but the car doesn’t accelerate as it should. It feels like the power just drops out. There were no warning lights or indicators on the dashboard. The exact same thing happened again the very next day, at low speed, in the same general area. Both times, the car suddenly lost power in traffic, leaving me unable to move normally. This is extremely dangerous — other drivers have no idea that my vehicle isn’t responding, which puts me and everyone around me at risk. It’s clear there’s a serious issue with the transmission malfunctioning.

I am unable to disable the "consider taking a break" warning, this is highly distracting and I don't understand why I can disable ever other warning on the vehicle. This warning goes off so easily even when I'm not distracted or tired and it's unsafe!

While operating the vehicle and utilizing the cruise control, the Electronic Stability Control (ESC) and the Antilock Braking System (ABS) warning lights turn on. These lights will remain on until the vehicle is turned off and a new drive begins. They only activate during the use of cruise control and at times it has caused the brake pedal to become extremely tough to press. This is a concern if maintaining cruise control and an emergency braking situation arises, the brake may not engage it is designed to do and cause a vehicle accident.

We have a brand new 2025 Kia Sorento and suddenly the AC stopped working. Took it into the service center who could not identify the problem but didn't see any damage. They got it working again and we drove it for a couple of days and it stopped working again as anticipated. We brought it back in and they now report debri damage, now not covered by kia warranty. I searched online and this seems to be a common issue with the unit and that the grill design does not protect the engine and is prone to significant damage to the vehicles engine components that Kia will not cover under warranty.

The driver’s door windows/lock button cluster on my 2025 Kia Sorrento LX will randomly not work. None of the buttons will work so I am unable to roll any of the windows down or lock or unlock the doors. The only way to fix this is to turn off the car and restart it.

While driving this warning alert will show up on the screen of my vehicle. It is important to note that this happens WHILE driving and when NO ONE is using their phone or using the touchscreen of the car. No one is ever searching something on their phone OR on the car’s touchscreen system.

On 10/3 driving at roughly 60mph on the freeway, when going to accelerate, the vehicle would not accelerate with no power going to the engine. The gas motor was not engaging, and the car rapidly decelerated to around 20mph in an incredibly unsafe situation. Coasting it off the freeway, it was towed to the local Kia dealership. No warning lights or any indicators went off during that event. 10/9/2025, I picked up the vehicle after they replaced the high-pressure fuel pump and high-pressure fuel line, I noticed the battery was very low and thought it would charge while driving. As I left the dealership, the vehicle did not engage the gas engine and quickly avoided acceleration - no power was going to the engine. The battery reached a catastrophic low, and the engine failed in a busy intersection - creating another extremely unsafe situation - as I was turning around to return to the dealership. This time the hybrid system warning system went off and the battery and oil lights went on. While waiting for the tow truck, the vehicle would not turn off. It is currently with the dealership, 41k miles on vehicle, 1 year old.

Transmission concern. Randomly rolls forward (about 1-2 feet) when placed in reverse. It rolls forward before it finally catches to reverse. I have rolled into and tapped another vehicle when exiting a parking spot. I have taken it to two different Dealers and they said basically it does that and I need to account for it. This car is a liability.

My Sorento has a transmission issue or something similar. It slips, it dies down and sometimes when I come to a stop and try to move, it won’t move. I have to put it back in park and then put it in drive. I have had several near miss accidents due to all these issues. It has been repaired twice but it has never fixed the issue and the dealer claims there is nothing wrong.

On July 5th 2025 round 5:15 pm EST, while driving in the center lane of the highway at approximately 73 mph, the check engine light and multiple amber warning lights suddenly turned on. This occurred at just 1,920 miles on a brand-new vehicle. At the time of the incident, the vehicle stopped responding to the accelerator and would not move forward. Fortunately, traffic was light, and I was able to steer safely to the shoulder. However, I was traveling with my family, and under heavier traffic conditions or with vehicles closely following, this sudden loss of power could easily have resulted in a serious multi-vehicle accident. Following the above incident, I brought my vehicle to the Kia dealership for a diagnostic check. However, they did not take any corrective action, stating that the check engine light was not currently illuminated—even though I provided photo evidence and the fault code P069811 captured from the Kia app. This raises serious concerns, as I cannot predict when the issue might occur again. According to multiple reports on Kia forums and blogs, many owners of new vehicles have experienced the same problem, yet Kia has not addressed it. This is a serious, life-threatening safety issue while driving, and this trim should be publicly acknowledged as having low reliability and safety concerns until a resolution is found.

The contact owns a 2025 Kia Sorento. Upon starting the vehicle and shifting into reverse(R); the vehicle failed to respond with the message "Service In" displayed on the instrument panel. The contact repeatedly depressed the accelerator pedal, but the vehicle failed to respond. The contact placed the gear shifter back into park(P) and then shifted back into reverse(R) and the vehicle started to accelerate slightly before coming to a complete stop with the accelerator pedal depressed. After repeatedly depressing the accelerator pedal, the vehicle jolted backwards. The contact decided to park(P) the vehicle and scheduled an appointment with the dealer for service. The manufacturer was not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was 4,850.

At highway speeds and in windy conditions, both side view mirrors partially fold inwards obstructing the ability to check blinds spots. The vehicle was purchased new from a dealership a month ago. The dealership has been notified of this issue as well as the check engine light being on since the vehicle was 5 days old and we were told they are unable to take the vehicle in until they have a loaner car available. Attached are two images of the driver's sideview mirror showing the approximate distance the mirror folds inwards with little effort.

Transmission caught between gears at speeds below 25mph. Engine revs without acceleration: Drivers report pressing the accelerator, and the engine's RPMs increase, but the vehicle does not speed up as expected. Driver returned the vehicle to Dealership and reported the incident. Dealership reported, malfunction could not be replicated. No indicator or warning lights present. The same incident occurred the following day for second time. Both incidents occurred around [XXX].on [XXX] at low operating speeds. Sudden loss of power places you and those around you in harm's Way when traveling at/below posted speed limits. Other Drivers around you don't know that your car is unable to move. This is a safety hazard. Clearly the transmission is failing in malfunctioning. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

August 18, 2025 at 3pm PT; My 2025 Kia Sorento X-Line was parked in my driveway facing the street. I had the engine on, and in Park mode, AC on, back hatch door open. No one was in the vehicle. I was standing behind the vehicle when it then started to go in reverse, then stopped for 2 seconds. It then proceeded to go into reverse again. The garage door was open. The vehicle pushed me into the blades of our lawn mower (it is stored in the garage on its end, so the blades face the garage door), and continued to push me and the lawn mower into our gardening tool supply rack. I did all I could to stop the vehicle with my body and yell for help. I was trapped. The vehicle eventually stopped because the back hatch door was open and caught on the upper part of the garage frame. I got myself unstuck and got out to the right, and went straight to the passenger front door to check out the gear shift. It was still in Park mode. All was captured on our Ring camera. I called Kia corporate customer service and received a case number (25476533) and was told I would hear back in 10 business days. This was after calling the dealership twice directly (Elk Grove Kia) leaving a detailed message with no response.

NHTSA Complaint – Kia Sorento Vehicle: 2025 Kia Sorento Component/System: Engine, Fuel/Propulsion System, Power Train Date of Incident: [XXX] Location: [XXX] , southbound Description of the Problem: While driving my 2025 Kia Sorento southbound on [XXX] , the accelerator did not respond properly both on a flat road and while going uphill. The engine failed to provide adequate power, creating a serious safety risk on the highway. The vehicle is currently at the dealer for inspection, which will take place on Monday. However, I am extremely frustrated that I have not been provided a loaner or rental vehicle, even though I need transportation immediately. Additionally, as a U.S. citizen, I feel I am being treated unfairly and receiving discriminatory service compared to others in similar situations. No warning lights or messages appeared before the incident. The dealer has not confirmed or fixed the issue yet. The vehicle has not been inspected by the manufacturer, police, or insurance representatives. I am reporting this issue to document the safety risk, service denial, and potential discrimination, and to seek proper investigation. Inspection Availability: UNKNOWN – vehicle can be inspected upon request. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

On [XXX], while driving home at highway speeds, I attempted to accelerate and the vehicle bucked and sputtered violently. The check engine light came on, and my OBD scanner showed multiple misfires in Cylinder 1. I have also experienced suspected transmission slipping from a full stop and during highway driving—RPMs will spike (up to ~5,500) with little or no increase in speed, sometimes after releasing the accelerator. These issues have occurred multiple times prior to [XXX]. On [XXX], while traveling 80–85 mph, I released the accelerator and the RPMs again spiked to ~5,500 while the vehicle rapidly lost speed and barely moved. Starting mileage at first occurrence is unknown, but Kia should have this documented from a prior service visit. The condition is ongoing and worsening, creating a serious safety risk by causing loss of acceleration and unpredictable power surges while in traffic. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

It feels like the engine is starting to cut out and as soon as that happens, the electronics in the car seem to start fighting each other. They adaptive steering and the lane assist it feels like they don’t work together anymore and I’m always fighting it or it won’t stay in the right lane and the car jerks from line to line. If I turned the lane assist off then it drives OK but the engine still is doing something funny.

On numerous occasions during extreme ambient hot temperatures, one of the body sensors keeps malfunctioning giving me an error message about the front parking sensor malfunction. I have reported this to my local dealership on a number of occasions, but as soon as I place the vehicle in park the message clears. The error has shown up on a history report with they connect a scanner to the OBD port but have yet to rectify this issue. Started before I hit 15k miles and is randomly generated.

Have had an issue of losing power while on an interstate traveling back from work twice now. After the second time I reported to my local dealership. While driving home, my vehicle lost power and was extremely slow and unresponsive. Check engine light came on but when checked under the diagnostics of the entertainment system, showed no issues present. Light turn off but still was having issues with responsiveness. When arriving home connected my personal ODB scanner tool to the vehicle and showed 1 code P0301Cylinder 1 Misfire. Had take. Pics of the code and of my OBD tool and cleared the code. Car started functioning correctly again. But still took to dealership for analysis. Dealership could not find any issues or codes, probably cause I cleared the code which allowed the vehicle to run normally again.

While traveling to VA from TX, [XXX] and on [XXX] the vehicle hesitated to accelerate multiple times. Some were from a complete stop, and other times it occurred when accelerating to merge on the highway. On [XXX], I pulled out of a driveway onto a very busy road and upon increasing pressure on the gas, the vehicle shook (similar to the behavior of a manual when letting up off the clutch and not applying even pressure to the gas. Due to the vehicle's hesitation, I as almost hit by a large truck traveling on my exact path. This was the sole instance that warranted a call to Kia Corporate, as I feel the issue is a significant safety concern. I placed the vehicle in service 11-12 JUN and the attached receipt highlights that the dealer was unable to replicate the issue. As of 16 JUN, the vehicle is still exhibiting the same issue intermittently, along with the break pedal popping when ascending or descending on a hill/ramp. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2025 Kia Sorento. The contact stated that while her husband was driving 50 MPH, the vehicle hesitated while depressing the accelerator pedal. There was no warning light illuminated. Due to the failure, the contact's husband coasted the vehicle off to the shoulder of the highway. The vehicle was restarted; however, the failure persisted. The contact called the dealer and made an appointment to have the vehicle serviced. The contact drove the vehicle without failure. The dealer performed a diagnostic test, but no fault was found with vehicle. The contact was instructed to pick up the vehicle. The manufacturer was notified of the failure and a case was filed. The vehicle was not repaired and remained with the dealer. The failure mileage was 213.

Driver Attn Warning randomly goes off frequently for no reason, this malfunction involves the front camera causing this frequent warning for no reason. This faulty issue gives the driver the sense that it should be ignored as it goes off for no reason, this makes this safety system null and void. It is equivalent to the blind spot warning going off so that the driver ignores it over time leading to them pulling in front of a car in there blind spot. The dealer and manufacturer know about this issue but refuse to do anything to fix it, the dealer says it's in the software of the car and they can't change it and Kia refers me back to the dealer, it's a frustrating run around for the customer. No it has not been inspected by insurance or police. The driver attention warning feature with a coffee cup began flashing a warning as soon as we pulled it off the lot

Was turning right onto the road when the steering locked up and every safety warning light came on. My car literally stopped moving in the middle of the road. I wasn't literally right down the road from my house so thankfully I was able to get the car back to my house. The steering felt worse than not having power steering. I called and the dealership Matt Blac KIA of Toms River, and they had my car towed to the dealership around 10 am on April 4th. Around 4pm I was told they still had no idea what was wrong with my car, and to come pick up a loaner car. On April 5th at 4:42 pm I received a text stating the wiring harness wasn't secured properly and rubbed the steering shaft, and they had to contact Kia to see how to proceed. April 11th was told the part arrived and hopefully sometime next week I would get my vehicle. As of right now I still don't have my vehicle and have no idea of when I will get it back. My main concern is that this was a serious oversight on the assembly of this car, and could have had very different results if I was not in my neighborhood and was on a busier road.

The contact owns a 2025 Kia Sorento. The contact stated that upon purchasing the vehicle brand new from the dealer and driving the vehicle to the residence, the contact became aware that the VIN was included in NHTSA Campaign Number: 25V006000 (Electrical System, Exterior Lighting) after conducting a VIN search the same day. The dealer and the manufacturer were not contacted. The mileage on the vehicle was 10. The actual mileage was 530.

Outside temp was 33 degrees F with a slightly lower windchill. I started the car and, when I accelerated to 30 mph, my car began to beep and the dashboard indicated the speed was limited to 30 mph. It went into limp mode and resisted when I tried to go above 30. We were towed to Kia but they could not replicate the issue and said it may have been due to the cold. A Google search showed others with 2025 model Kias also had the issue and they also happened during colder temps. I was glad I was on a 40 mph road and not a highway or it could have been a dangerous issue. There was no indication of any issue until I tried to accelerate to 30 mph. It drove fine the night before when it was also below freezing.

While driving my 2025 Kia Sorento on the highway, I noticed a coolant leak and an overheating warning. I immediately pulled over, and the vehicle was towed to a Kia dealership for inspection. After diagnosing the issue, the dealership claimed that small pebbles had damaged the radiator, leading to the coolant leak. They stated that this was considered an accident, not a defect, and therefore was not covered under warranty. Why This is a Concern: After researching online, I discovered that many other Kia owners are experiencing the same issue, suggesting that the radiator may be vulnerable to road debris due to poor design or insufficient protection. A radiator should be durable enough to withstand normal highway driving conditions. A failure like this could cause engine overheating and sudden breakdowns, posing a serious safety risk to drivers and passengers. Request for Investigation: Since this issue is affecting multiple Kia Sorento owners, I believe it should be investigated as a possible design flaw. If the radiator is too fragile to handle everyday road debris, Kia should issue a recall or Technical Service Bulletin (TSB) to address the defect and ensure driver safety.

The contact owns a 2025 Kia Sorento. The contact stated while his wife was driving approximately 25 MPH in the snow with the windshield wipers activated, the windshield wipers became stuck in the middle of the windshield due to snow accumulation in the area between the windshield and the hood. The contact's wife pulled over to the side of the road and noticed that the accumulated snow had turned into built-up ice, which obstructed the windshield wipers functionality. The contact's wife removed the ice in the area between the windshield and the hood and continued driving. The contact stated that the failure recurred while driving. The vehicle was taken to the dealer, where it was diagnosed that the windshield wiper gear shaft was damaged and the arm that originated from the windshield wiper motor was bent due to the built-up ice. The dealer determined that the windshield wipers motor assembly needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 1,600.

The contact leased a 2025 Kia Sorento. The contact stated that while driving, the vehicle failed to increase over 20 MPH. The 20 MPH limited message was displayed. The brake pedal was hard to depress. The driver pulled over and called the salesman at the dealer, who discussed red flags. The contact turned the vehicle off and restarted. While driving 45 MPH, turning left, the brake pedal was applied, but the brakes violently pumped upwards for about nine car lengths. The vehicle eventually slowed down. The speed decreased from 40 MPH to 20 MPH, and he crashed into a Toyota Corolla stopped at the light. There was an unknown abnormal warning sound detected. There were no reported injuries, airbags, fire, or police report filed. The vehicle was towed to the local dealer, where it was diagnosed that the bumper was cracked and two unknown sensors were damaged. The vehicle was not repaired. The manufacturer was contacted, who investigated the failure and determined that the brakes and smart cruise control were working as designed. Additionally, informed  him not to utilize the cruise control in the city, read the manual, and learn the vehicle. The approximate failure mileage was 65.