2T3P1RFV1SC4953272025 TOYOTA RAV4

UNKNOWN - On XXX, at just 7,741 miles, my 2025 Toyota RAV4 XLE Premium AWD (VIN: [XXX]) suffered a catastrophic and life-threatening complete mechanical and hydraulic transmission failure. The vehicle completely lost forward propulsion when placed in Drive mode, rendering it entirely immobile. When placed in Reverse gear, the transmission violently over-pressurized, causing the vehicle to suddenly surge and jump uncontrollably. Simultaneously, the dashboard displayed 6 critical safety system failures: 1. Check Engine — electronic control malfunction 2. Vehicle Stability Control System (VSC/TRAC) malfunction 3. Secondary Collision Brake System malfunction 4. Pre-Collision System malfunction 5. Parking Brake System malfunction 6. Advanced Ultrasonic Detecting and Ranging System malfunction Ourisman Toyota Chantilly (RO# XXX) has confirmed complete transmission failure. Fault codes found: P28167F — Pressure Control Solenoid H Actuator Stuck Off, P08BA7F — Pressure Control Solenoid L Actuator Stuck Off. Estimated repair cost: $11,347.42. While this failure fortunately occurred on a local road, had it occurred while merging onto I-66 or I-95 at highway speeds, it would have inevitably caused a catastrophic high-speed collision. This represents an extreme manufacturing defect and life-threatening safety hazard. Toyota Corporate Cases opened: #XXX (original case) and #XXX (full replacement request). I am requesting full vehicle replacement. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2025 Toyota RAV4. The contact stated that while driving under normal conditions, the contact heard an abnormally loud, violent, and shattering sound. The contact then noticed that the moonroof glass panel had exploded without impact, causing shattered glass to fall inside the cabin. A police report was filed. The dealer was notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 12,838.

I purchased this car used in December 2025 with 10k miles on it. After 15k mileage, the rear tires were bald and I had to buy new tires. I then took it back to the dealer and had to pay to get an allignment, as I was concerned that is what was causing the tires to go bald so fast. That was less than 2 months ago and now I'm in getting the 20k service appointment and the rear allignment is now off way more than when I paid to get it checked. Apparently the rear wheels cannot be adjusted? The right rear is way off and this is for sure causing uneven wear on my tires. It is for sure an issue and should not be, in that the car is new. It is obvious it is a fault in design and for sure can cause major safety issues, let alone burn my money up in needing new tires every less than a year.

2 incidents of Sudden Unintended Acceleration. No warning lights etc in either. Car damaged but available for inspection. Now encountering difficulties initating Toyota investigation. 1st incident (4/18/25; mileage 967) occurred after a hard left turn. After turn onto uphill street, I took my foot from accelerator to slow and maintain distance from a car backing down hill ahead. Instead, car self-accelerated and shot uphill, over speed bump with increasing speed. Did not respond to braking until it was close to hitting a parked car. Stopped with a slam; probably brake assistance engaged. No damage or injury, but I was shaken. Took car immediately to Toyota dealer to inspect. Was told RoB confirmed an event but not its nature or cause; identified nothing wrong. They hypothesized cruise control might have been triggered accidentally (no evidence, not plausible). Claimed they submitted report to Toyota national center. After 2nd incident, Toyota national said they had no record of 1st event. Their standard safety inspection protocols were not followed. Returned car to me without repair or follow up. 2nd incident ensued. 2nd self-acceleration event (2026) also occurred after hard left turn to make U turn at low speed, braking while completing turn. When I took my foot off brake, before I could press it on accelerator, car shot diagonally across street. Jumped curb and traveled at considerable speed 100' up landscaped slope. Destroyed 6 large shrubs and 3 trees 9' tall. Did not stop despite constant driver braking. Forward collision prevention system did not engage to prevent uprooting trees. Car stopped only after I turned steering wheel sharply to left to avoid hitting a full-size tree trunk. Then car responded to braking, acceleration ended, car stopped next to tree without impact. Terrifying life-threatening event but only damaged landscape and car. Police came, assessed incident, determined not a police matter, did not file police report.

The brakes have been overly sensitive... but then, without warning, braking power is completely lost. This has happened on 2 separate occasions... the pedal goes all the way to the floor and provides ZERO braking power. We can no longer trust this car on the road. Toyota sent someone to inspect the vehicle and they claim that they have found no problems or issues and that they have not been able to reproduce the problem. There were no warning lamps or message; there were no prior symptoms, other than the brakes were overly sensitive. These symptoms occurred immediately after purchasing the car. Toyota refuses to purchased the car back from us, and now we are stuck with a very dangerous vehicle. Interestingly, I have found others talking about EXACTLY the same symptoms on other Toyota Rav4 vehicles.

My daughter reported an incident that occurred on XXX while driving this vehicle. As she drove, it slammed on the brakes (without any input from her) causing her to skid. The vehicle brought itself to a stop and the engine turned off. She reported that there were no vehicles or other object close to the front of her vehicle. The incident did not cause a crash or cause anyone to be injured. It was, however, a very scary situation that almost caused her to be rear-ended by the vehicles that were following her. The car was taken to Cobb County Toyota in Kennesaw, Georgia for an inspection the morning of May 28, 2026. As of this submission, the vehicle is still at the dealership service department for inspection.

The multimedia screen which shows the map and direction guidance became to blank occasionally, just white grey since February 2026. I immediately lost the direction. It could be back by restarting the engine at the beginning. The problem got worse, happened more often, some times the screen couldn't be back by restarting engine, but I found that it could be reset by pressing the volume button for long time. I reported to Toyota local dealer - Hendrick Toyota Apex and Toyota Brand Engagement center, the case manager is Freddy. The local dealer run diagnosis twice, couldn't detect any problem. On May 11, the screen totally died, black, no any light. Restarting engine or pressing the volume Botton couldn't get the screen back any more. the audio system is still working, I tried to use the map on my iPhone, the direction map couldn't be showed, only the text direction shows. Because the system let map show on screen, it assumes that the map shows one screen but it is not. I lost car screen and the phone direction at the same time. Plus the backup camera doesn't show on the screen. Therefore, it is underivable in any unfamiliar area, and dangerous to drive in neighborhoods. I reported to local dealer and Toyota Brand Engagement center with videos. May 18, the local dealer run diagnosis again, found nothing wrong. But before I leave, the screen became blank. This morning it happened again. The problem is not fixed. Freddy told me he suggested to local dealer to replace the screen, I am waiting Hendrick Toyota Apex call me for the appointment. I can't upload videos. If you want to see the videos, please tell me where and how to upload the videos. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

COMPONENT: Electronic Throttle Control System (ETCS) / accelerator pedal. Vehicle is available for inspection at Autocentro Toyota, San Juan, PR, where it has been retained since 2/28/2026. INCIDENT: On 2/28/2026 at 7:45 AM, while entering a private driveway at under 5 MPH to park, my 2025 Toyota RAV4 Hybrid SE (VIN [XXX] , 3,164 miles) suddenly and involuntarily accelerated without driver input. I categorically affirm I did NOT press the accelerator. The vehicle struck a metal gate, causing frontal damage. Airbags did not deploy. OEM floor mat was properly secured; no aftermarket parts installed. SAFETY RISK: Sudden unintended acceleration at low-speed parking maneuver. Had a pedestrian, child, or another vehicle been in the path, this would have caused serious injury or death. The defect is unpredictable and the driver cannot anticipate or override it. INSPECTION: Vehicle inspected 3/20/2026 by Engineering Analysis Associates (EAA), a firm contracted and paid by Toyota — NOT independent. EAA downloaded electronic data and concluded the accelerator was pressed 1 second before impact. I dispute this finding: I did not press the pedal. No independent inspection has been allowed. Full EAA report was never provided to me. On 4/23/2026, Toyota Motor North America (Ms. Delve L., Legal Claims Administrator) declined assistance based solely on EAA's data. WARNING SIGNS: UNKNOWN. No warning lamps, messages, or prior symptoms appeared before the incident. The vehicle had functioned normally since purchase on 4/25/2025. ADDITIONAL: Vehicle retained by dealer 73+ days without repair or substitute vehicle. Consumer complaint filed with Puerto Rico DACO (Case XXX). Similar unintended acceleration incidents reported in 2024 RAV4 Hybrid and Prime models in NHTSA database. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2025 Toyota RAV4 XLE 4 door utility 2.5L 4 Cyl Gas A AWD unexpected sudden acceleration My safety as well as other vehicles and occupants as could have been at risk. National Transportation Safety Boaed has confirmed 57 cpmplaints of same issue. Vehicle determined total loss by insurance inspector, Va State Police. No warning lamps, messages, or other symptoms proir to the problem.

The Toyota app has stopped updating vehicle data and there’s information missing entirely. The satellite symbol has a line through it on the media screen as well. When I try to opt out on the app, I get an unexpected error and to try again. It seems as though the DCM in my car has stopped communicating with Toyota’s servers.

On April 29, 2026 around 10:00 PM, my 2025 Toyota RAV4 experienced sudden brake failure. The pedal became hard and I lost stopping and steering power. At the same time, Check Engine, battery warning, steering warning, and ‘Not Ready to Drive’ all appeared simultaneously with no prior warning. I brought it to a Toyota dealer the next morning and they found no fault. The vehicle is available for inspection.

There is a parasitic drain on my battery coming from the ECM and electrical system causing it to drain my 12V battery.

The left mirror is a blind site when making a left turn at stop signs. The front hood is too high. In a parking lot you can't see the curbs. Toyota said jack up the seat. That does not help. kids can't be seen in front of the car. This is a safety issue. The number of selections to set the car for driving don't work for older people. The gas and break petal don't work for disabled people.

My car say front camera not working

My 2025 Toyota RAV4 (39,919 miles) has a permanent "Check Engine" light. On March 18, 2026, diagnostic codes P24517F and P214502a were found, indicating a failure in the switching valve and fuel tank pressure sensor. Toyota USA and the dealer are refusing to honor the 60,000-mile Powertrain Warranty and Federal Emissions Warranty. I am reporting this as a safety defect because the vehicle may lose power or stall on the highway, creating an immediate crash risk. The manufacturer's refusal to repair a known emission/fuel defect in a new 2025 model has left me with an unsafe vehicle for over 15days.

SUPPLEMENTAL TO COMPLAINT ID: 11728745. My 2025 RAV4 failed at 39,919 miles. Toyota Corporate is acting in bad faith to deny the 60,000-mile Powertrain Warranty. The Case Manager repeatedly calls only after 6:30 PM when the dealership is closed to avoid resolution. Furthermore, the representative is now using "legal threats"-directing me to their legal department-as a tactic to stop me from pursuing this valid warranty claim. This is a safety hazard and a violation of federal warranty law.

On two separate occasions, my car has shaken violently and stopped both times while idling one in my driveway one at a stoplight and then an alert that says engine stopped steering power low came on

info center went real dark in bright sun light--march 26 2026

There is a stress fracture to the windshield starting at the bottom of the glass where it attaches to the body of the car, below the wipers. It’s not a chip nor was it caused by an object. It’s a semi circle crack. Two employees at the dealer glass department concurred that it’s not damage from a foreign object hitting and that it’s a stress crack. Yet dealer refuses to cover hands warranty. Car has less than 12,000 when this cracked.

The contact owns a 2025 Toyota Rav4. The contact stated that while driving approximately 60 MPH, the rear driver’s side window suddenly shattered after an abnormally loud bang was heard. The local dealer was contacted; however, the vehicle was not diagnosed or repaired because there were no recalls associated with the VIN. The manufacturer was not made aware of the failure. The failure mileage was approximately 30,000.

The infotainment display screen frequently goes black while the audio and navigation continues. It requires repeated forced reboots and glitches between the CarPlay and Toyota UI screen.

This 2025 RAV4 hybrid XLE Premium is in permanent shape of inoperable due to continues electrical system that drains the 12v battery. Anytime I want to drive the car I have to charge the 12v battery for 3-4 hours before I can attempt to drive the car. This is all the time problems that start about 2 weeks into the purchase of the vehicle.

Nothing happened

This 2025 RAV4 will randomly move or jerk to the left while driving straight. It does not matter where you are in relation to the center of the lane. Sometime the movement is gentile and other time it is very strong bordering on violent. It will do the same thing with the lane keeping assistance, and pre-collision warning active or disabled. This issue could cause an accident if the jerky movement happened at the wrong time with another car alongside or approaching from the opposite direction. The movement has pushed me across the line a couple of times and it has happened at 15 mph all the way up to 65mph. The dealer did an alignment which did not change the problem. Now they want 425 to recalibrate the forward camara which 'might correct the issue'. This could get very expensive very fast when it should be covered under warranty. There are no warning lamps or messages to indicate the problem. This is a dangerous issue not just an inconvenience.

We were on a funeral procession when suddenly the car accelerated at a very high speed and hit the end of guard rail head on. My wife on the passenger side and two people at the back were all taken to the emergency room. I got pinned on the steering column and taken out via the roof. I had severe abrasions on both legs, wife has 3 broken ribs,the 2 passengers suffered whiplash and complains of chest pains. Car was purchased 11/3/2025 and I took it for a recall fix about a month ago at Burien Toyota dealership where we bought it. Incident # 2026-55959 Seattle police. At present our car insurance is investigating and our claim # is 082 0356939 Allstate.

The contact’s sister owns a 2025 Toyota Rav4. The owner received notification of NHTSA Campaign Number: 25V595000 (Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The instrument panel intermittently went black. The failure became persistent over time. The dealer was contacted and confirmed that the part was not yet available for the repair. The manufacturer was made aware of the issue and confirmed that the part was not yet available. The manufacturer referred the owner to the dealer for assistance. The failure mileage was approximately 3,000.

Sidewall randomly cracked while traveling late at night on sparsely populated interstate. No debris on road or potholes encountered to explain why this occurred.

Traveling on interstate, 60 mph. All of a sudden, I heard a loud noise followed by a thump. Managed to get off the exit and pulled over onto the shoulder. Noticed the sidewall had separated from the tread of the tire. 5343 miles on vehicle. Original equipment tires.

When driving our Rav 4 we heard loud bang type noise. We stopped and pulled over and looked all around the Rav 4 and didn't see anything. When I checked the roof I found our sunroof had shattered. The sunroof was closed at the time. No one was injured at the time.

I am aware of a recall for the screens turning off randomly while driving, especially in reverse while using the back up camera. My VIN was not included in the recall, though this has been happening to me. It happened for the first time when I was in reverse yesterday trying to use the back up camera, it typically happens while I’m driving forward on the road. I am including the date of the incident that happened while in reverse, but please know this has been happening since about a month after I purchased the car completely new.

I was driving the speed limit (75) when I heard an explosion. I immediately pulled over to see if I had a flat tire or if someone had shot my car. I could see no damage and nothing was showing up on my dashboard so I continued to drive but heard a whistling sound. I checked all my windows and then my sunroof. Somehow the sunroof had exploded. There were no cars close to me and no overpasses or trees in the vicinity. I have had the car for almost 3 months and have never opened the sunroof.

The contact owns a 2025 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 25V595000 (Electrical System); however, the part to do the recall repair was not yet available. An unknown dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. The VIN was not available.

WHY a Brand NEW 2025 Toyota RAV4 EV ONLY 6 months old needed a brand New Battery? Car on the Highway could only reach speed of 40 MPH. I did not receive any RECALL on my NEW RAV4 EV Took it to the Toyota dealer in Wausau Wi they said they had NO CLUE what the issue was and put in a brand new battery. Said it was under warranty BUT could not tell me what tge issue was?I need to know why I never got a answer or a recall notification from toyota? On a BRAND New SUV

On [XXX], at approximately [XXX], in Greenwich CT, while I was very slowly driving into a parking space, the engine suddenly and unexpectedly surged,. The vehicle overcame the brakes and raced forward and collided with a stone wall, about 3 ft away. This was a new (since May 2025) vehicle with only approx 3,500 miles on it. I had not had any previous problems with it and there were no warning lights on the instrument panel. At the time, I was proceeding at a very low rate of speed, 1 - 3 mph. I drive only with my right foot which was on the brake, not on the gas. The vehicle accelerated with NO action on my part and collided with a stone wall approx 3 ft away and bounced back several feet. Fortunately I was close to the wall so the vehicle did not have a long distance to accelerate and I was wearing my seat belt which probably protected me from injury. No other vehicle was involved. I was the sole occupant of the vehicle. I was wearing my seat-belt, the OEM rubber mats were securely in place. The airbags did not deploy and I was not injured. I had the car towed to the Toyota dealership by AAA because I was afraid it might accelerate into traffic at a red light or stop sign if I drove it before the problem was repaired. I have reported this incident to Toyota Motor Corporation USA, through their Brand Engagement Center (as instructed by the dealership) and they are sending out an engineer to the dealership to inspect the vehicle. I do not know which part malfunctioned or failed. The vehicle is at a Toyota dealership and presumably could be inspected (unless they replace some parts). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

1)I purchased my car during daylight hours. A few days later I drove my car in the evening and could not see street signs or the road 1/3 of the way up through my windshield. There is a definitive line where the windshield turns black. It is extremely dangerous. The Toyota engagement center told me to take my car to the dealership where it was purchased. I also took photos of what I could not see while driving. The dealership said there is nothing they can do and this is normal. The engagement center called back after they received the photos and told me their head technician could not see the street signs looking at my photos either. I was told to take the car back again to the dealership and once again told " there is nothing that can be done." They told me to put on my automatic brights. This feature does not help. The dealership also told me I could just put on my brights manually. This blinds other drivers on the road and then they put on their brights driving towards me, which decreases my ability to see while driving. the Toyota engagement center dropped the ball after 3 months of trying to report how dangerous this situation is. I am now reaching out to your department because of serious safety issues. I did not buy a car to be placed in a dangerous situation where I can't see to drive at night up. It is very dangerous driving up and down hills. 2)I also want to report - most of the time my gas milage ranges between 18 - 22 mph. This is way below the stats that were given to me when the car was purchased. 3)The phone table does not charge my phone and is a complete fail. 4)The visors are too short and hardly serve a purpose.

The contact owns a 2025 Toyota Rav4. The contact stated that while operating the vehicle, the interior digital rearview mirror image was distorted, hazy and foggy. The contact stated that the rearview mirror image was distorted while operating the vehicle at night, but the image was clear while operating the vehicle during the day time. The contact had cleaned the rear window and the rearview mirror camera lens, but the failure persisted, which the contact considered a visibility hazard for the driver. The local dealer was notified of the failure and advised the contact that no failure was found, and the rearview mirror camera was operating as designed. The manufacturer was not yet contacted. The failure mileage was 30.

Unknow

The front camera fails which does not allow for the cruise control to operate. The speed odometer does not specify the correct speed when driving the car. The feature of telling you how fast you are supposed to go does not operate correctly specifying the wrong speed you are supposed to go. The tires have already been replaced because the metal was coming out of the tires causing the car to not operate correctly there was wobbling in the tires causing the car to feel like the tires were about to come off the tires. The transmission not shifting properly in eco mode.

Formal Complaint to Toyota Motor Corporation (Manufacturing) Regarding: Serious Manufacturing Defect and Failure of New Vehicle Safety Customer: [XXX] Customer Contact: Phone – [XXX] | Email – [XXX] Vehicle Purchased: (New/Recently Purchased Toyota Model) Date of Purchase: [XXX] Selling Dealership: Round Rock Toyota Vehicle Identification Number (VIN) (Last 4 Digits): [XXX] ________________________________________ I. Overview of Complaint: Critical Safety Defect I am filing this formal complaint directly with Toyota Motor Corporation regarding a vehicle that, due to an apparent critical manufacturing defect, failed dangerously and repeatedly within days of purchase. This failure represents a lapse in Toyota's quality control and a serious threat to consumer safety. The vehicle, purchased new or recently, on [XXX], exhibited critical operational defects less than three days after leaving the dealership. This vehicle is demonstrably defective and unsafe, having compromised my life during a near-fatal failure on a major interstate. As the manufacturer, Toyota is ultimately responsible for the quality and safety of the product delivered to consumers. II. Factual Timeline of Critical Defects and Safety Incidents The vehicle exhibited multiple critical failures less than 77 miles and three days after purchase, severely compromising my safety and confidence in the quality of the Toyota product: •Immediate Operational Failures: The vehicle began experiencing multiple mechanical failures shortly after purchase. •Near-Fatal Highway Stall: The most severe incident involved the vehicle suddenly failing and stalling while traveling on a major interstate. This catastrophic failure is indicative of a serious underlying manufacturing or component defect and severely endangered my life and the lives of others. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I discovered early rust formation on my vehicle shortly after purchase. The dealership only proposed painting over the rust instead of investigating the underlying cause. This may indicate a factory-related structural defect and could pose a long-term safety risk. I am requesting an investigation.

Stress fracture in the windshield

2025 RAV4 - While driving the car, changing from reverse to drive the steering wheel got stuck and would not go back to straight position. This causes an accident and hit another car. There was not indicator that there is a problem. Inspection was done by the dealership and asap and they identified and confirmed of faulty steering wheel angle. This car was bought end of June and accident happened first week of October. The car is since with the dealership with no resolution yet. Dealership have us call Toyota, but we were not provided with any help. One and half month in, we continue to pay insurance but we do not have the car.

While waiting in a drive-thru with “hold” feature enabled, car vibrated abnormally and shut off by itself. When I attempted to restart the vehicle, I received an error message “Engine Stopped. Steering Power Low” and another screen also appeared that said, “Not Ready to Drive. Press Brake and Push Engine Start Switch.” I followed those instructions several times and the car wouldn’t start. Eventually had to put in neutral to get out of drive-thru. Once out of drive-thru, I once again attempted to restart the car, but this time it worked. Should mention it was raining pretty heavily outside when this happened.

While reversing vehicle screen went blank once and another time flickering on screen, felt safety issue reversing.

El día 2 de octubre compré una Rav 4 2025.El día 14 de octubre me doy cuenta que los cristales se encontraban rayados como por dentro del cristal, entiendo que esto pudo haber puesto en riesgo mi seguridad ya que si cualquiera de los cristales se rompe puede cortarme a mi o a un pasajero. En la primera inspección no notaron nada luego llamaron a un especialista de Toyota para verificarlo y en conclusión si noto dicho defecto en los cristales pero noto que en el mismo concesionario había varios vehículos con el mismo problema me notificó que su deber es reportar este problema pero que por el momento no hay nada que hacer con mi auto estos rayones por dentro del cristal únicamente son vistos específicamente bajo los rayos de la luz solar.No hubo ningún símbolo ni falla antes de notarlo el día 14 de octubre2025

I rented the Toyota RAV4 from Fox Rent a Car (855 571-8414) at the Denver International Airport for a trip to Boulder, CO. On November 9 evening, I drove to the Sugarloaf Mountain Trail Head (GPS: 40.05, -105.425) for a time-lapse photography. Date/Time: 2025-11-09 6:29 PM Location Description: Uneven dirt parking area commonly used by sightseers. Visibility was completely dark at the time of arrival. After arriving at the hilltop, as I parked the vehicle, while applying very light pressure to the accelerator pedal with my right foot, I felt a gradual drop of several inches on the passenger side of the vehicle. Instinctively, I moved my right foot to the brake pedal and applied pressure. However, I immediately sensed that the vehicle was not decelerating; instead, it was accelerating forward. I pressed the brake pedal more firmly, and the vehicle accelerated further until it came to a complete stop after colliding with a rock on the driver's side approximately 15 feet from the point of initial acceleration. Once the situation stabilized, I exited the vehicle and observed a red, non-oily liquid of normal viscosity leaking from underneath the vehicle on the front driver's side, which I later identified as coolant. Upon opening the hood, I confirmed that approximately half of the coolant had been depleted. I Googled AI Mode: Question: For a Toyota RAV4 HEV, is it possible for the vehicle to accelerate when the brakes are applied forcefully and abruptly? Answer (Source): [XXX] Potential Perceptions and Known Issues While the car will not accelerate due to the brakes being applied correctly, drivers have occasionally reported sensations that might be might be misinterpreted as acceleration, such as a slight "lurch" when the braking system transitions between regenerative and friction braking, ** especially at very low speeds or over rough surfaces. ** INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The windshield is warped and distorted. The dealership also told me that they can also see the warp in it. The original windshield was replaced, and the new one also has the same issue. The brand engagement rep I spoke with at Toyota told me that he has received multiple calls about the windshield issue. This vehicle was purchased 7/30/2025, and only has 271 miles on it and is on the original tank of gas. I have to rely on other people to give me rides places, as I am unable to drive this vehicle. The safety risk is due to the dizziness, nausea and migraine it causes me to drive it. My eyes feel like they are going cross eye, and I have to look out the driver's side window to get any kind of relief, which isn't allowing me to be alert while driving. This causes a huge issue for my safety as well as others. The Toyota Brand engagement rep that I spoke with said it is an issue and he has received multiple calls about it. The dealership has also acknowledged that they were able to see the defect.

The power rear liftgate will close on a person or object and cannot be stopped except if one presses on a very specific part of the edge of the liftgate, towards its center. This happens no matter how much upward force is applied to the area of the pull handles and the edges. When my wife pulled the handle, the liftgate closed with force that she could not resist. This obviously creates a serious safety hazard for small children, pets, or really anyone trying to close the liftgate or who may have inadvertently hit the button or pulled the handle.

The vehicle's CarPlay is malfunctioning, showing incorrect vehicle location and navigation directions. The vehicle's screen often shows incorrect location and directions, and changes directions as it updates where it thinks the car is. This is available for inspection upon request. The safety of the driver and passengers is put at risk because the screen showing incorrect location and directions causes a constant distraction, taking your eyes away from the road to figure out if the map is showing you the correct location or not. Sometimes, when the carplay is looking for the correct location, the map spins around and shifts location which is also distracting even when you try to ignore it. The consistent distraction this causes while trying to navigate through unknown streets has caused both my wife and I to get lost, take the wrong turns, or get stressed and confused while driving because we don't know what the directions are telling us, or we don't know if we are following the right directions. We are worried we will hit a car or person during these times of confusion. This has been repeated multiple times at Toyota dealership and is a known issue acknowledged by Toyota corporate. The vehicle has been inspected by Toyota's regional technician who installed an unreleased software update at my last visit, but the problem persists without improvement. There isn't a warning sign. I have requested a replacement or reimbursement for this vehicle from Toyota but their Dispute Resolution team says I have not given enough opportunity for Toyota to repair the car. I then brought the car back in and they kept it for three weeks and installed an unreleased software update. The loaner car they provided me was the same car different year and had no carplay issues. I am trying to bring it back but the dealership cancelled my appointment telling me they won't accept the car because they can't fix it. I am trying to escalate again to corporate.

During an AWS outage on 10/20/2025, the connect app which can turn on or off the vehicle, unlock/lock doors, etc had issues where it performed an unlock on our vehicle 5 times in 24hrs without us doing anything. Key fob was in sleep mode / low power mode (cannot signal vehicle). Reports of this happening to others found online, but Toyota dealership states no reports on any of this happening.

component: main engine wiring harness. cause: rodent caused damage: the rodent severely damaged this component and made the vehicle inoperable. fix: required the replacement of this component. insurance covered the 8,500 repair bill (minus deductible). a check engine light appeared eventually.

The contact owns a 2025 Toyota Rav4 equipped with Michelin Tires, Tire Line: Primacy A/S, Tire Size: 225/60/R16, DOT Number: (N/A). The contact stated while driving 70 MPH, the rear passenger’s tire detached from the rim. The contact stated that the failure had occurred while driving on a three-lane highway. The vehicle was driven over to the shoulder of the roadway. The contact inspected the vehicle and noticed that the passenger’s side rear tire had detached from the rim. Roadside Assistance was contacted and replaced the wheel with the spare tire. The manufacturer was made aware of the failure but provided no assistance. The contact was advised that without a part of the tire, no assistance would be provided. The failure mileage was approximately 7,000.

I was driving on CA Highway 20 on Thursday afternoon, Oct. 2, when the sunroof spontaneously shattered. I was not driving under a bridge or overpass or tree. There were no vehicles directly in front of me. I heard a loud pop, like an exploding bottle, but could see no damage inside the car. Within a few miles, glass was flying off the roof and striking cars behind me. That's when I pulled off the road and saw the roof was shattered. The shape of the break mounded up in the middle, implying the roof had broken upward. There were no rocks inside on the sunroof cover, nor any other debris than shattered glass.

Stopped to allow a car to pass. Once the car passed, there was acceleration of the engine but the car would not move. When the car gear was changed to park and then back to drive, it would not move. In order to get the car out of the traffic lane, the car was placed in neutral but the car brakes were locked. All this time the red 'park' on the dash and the red button on the console kept flashing. We called AAA and they arrived in 40 minutes. The man got in the car and stated they sometimes reset themselves. The car did start and he was able to drive it as the brakes were no longer locked. We took it to Toyota of Orange but they were unable to find the cause. They stated that they elevated this incident to a test case. TA252650358 This car only has 2,689 miles on it !!

Unintended/unwanted sudden acceleration - we are aware of this happening 5 times while I was driving, all times coasting to proceed into a turn. (I DO NOT DRIVE WITH 2 FEET). In each instance, while coasting my right foot covered (above) the brake pedal. BOTH feet were off the gas and brake pedal. Tachometer suddenly and rapidly spiked and car appeared/sounded like it would surge forward. In hopes of avoiding this sudden surge forward, I quickly put car in neutral and applied brake. Car slows and tachometer returns to normal. Brought to dealer, they stated from black box inspection that I was applying brake and gas simultaneously. THIS IS NEARLY IMPOSSIBLE FOR ME; as I demonstrated to folks at dealer I physically cannot do this without causing the arthritic pain in my ankle/foot to rise to a very noticeable level. The pain would be prolonged while doing what they claimed I was doing. I vehemently deny their explanation for these occurrences. No accidents occurred, nobody was injured (in these incidents). Obviously those in my car and others near my vehicle on the road should this happen again could be injured. No warning lights, messages etc were displayed. Sporadic occurrences. Purchased vehicle July 11,2025, first occurrence (I noticed) at July 31, 2025. Dealer stated their case is closed on this as of 9/04/25. Today 9/17/25 another occurrence happened. Car is available for inspection upon request.

The contact owns a 2025 Toyota Rav4. The contact stated that upon leaving the keys in the ignition overnight, the battery was drained. The contact stated that the jumper cables were in a compartment located inside the trunk. The contact stated that due to the battery failure, the contact was unable to unlock the vehicle. In addition, there was no keyhole for the trunk of the vehicle. The contact entered the trunk through the inside of the vehicle; however, the compartment where the jumper cables were located had failed to open due to the battery failure. The manufacturer was notified of the failure but offered no assistance. The contact was referred to the NHTSA Hotline to file a complaint. The vehicle was not repaired. The failure mileage was approximately 5,500.

Back up camera delay in lighting up when car is started

On 9/5, a car darted out in front of me while I was traveling straight at 45 miles per hour. I hit the brakes but t-boned him. The car then spins around and hits me again on the passenger quarter panel. No emergency brake, precollision no warning light came on. The airbag didnt deploy. I hit my chest on the steering while and my head on the window. The seat belt didnt lock me down. I purchased the brand new Rav4 a week prior.

I noted the body is made up of soft materials that slightly bend when push lightly with hand. I put a magnet to see if it’s made up of metal but noted a weak attraction of the magnet to the body. When I used my buttock to push the door to close ( my hands were not free and held several grocery bags), my buttock sunk to the part of the area I pressed on. I heard and felt the bending and clicking sound of plastic then it lifted back to its shape. I almost lost my balance since I’m not expecting the door that soft. I was scared that I dented the door. So how safety is this 2025 RAV4 ? We also have 2023 RAV4 of same model XLE AWD Premier. I wonder what will happen if it has accident with another vehicles on the road. With this body materials will save me from any kind of collisions ? I just noticed this brought by my experience today.

I was driving on the Highway at 70 mph and the rear passenger tire blew out. Thank God I was able to stopped the car safely and no one was injured. It was a scary moment and it is still is.My safety and other was at risk It is a brand new car with only 4397 miles. I took the car to the dealership and they replaced the tire. They found NO indications of a puncture or road hazard. Tire split at the shoulder and sidewall. Tire description Dunlop Grantrek 225/60 R 18

Enter water when open doors after to rain. All the doors. Dealer in Puerto Rico not resolver problem.

Check engine light came on as well as hybrid malfunction message. While on the highway could not accel or go past 60 mph, gas pedal would then not work and speed went down, I pulled car over to breakdown lane and car abruptly stopped and would not move. Many warnings flashed and car needed to be towed. Temperature rose and ignition messages came up, steering wheel locked and car was not drivable.

Sunroof leaks during rain events. If this continues to be a problem can cause rust, mildew and mold issues which can lead to respiratory issues. This was noted by the dealership today as well.

The contact owns a 2025 Toyota Rav4. The contact was experiencing dizziness, nausea, and lack of focus in vision while in the driver's seat and looking through the windshield. The contact took the vehicle to the dealer who sat in the driver’s seat and noticed the glass was magnified in certain areas causing visual distortion and warping in certain areas of the windshield. The windshield was replaced. The contact experienced the same physical reaction to the new windshield. The dealer was contacted, and a message was left. The contact learned that the manufacturer had outsourced the manufacturing of the windshields from a company called AGC. The windshield was not replaced a second time. The manufacturer was not informed of the failure. The failure mileage was approximately 495.

I have owned this new vehicle for only approximately 2 months and have had at least 4 instances where the vehicle does not respond immediately to my foot on the accelerator when attempting to restart from a stop. Three times I was at a stop light and when I attempted to go as the light turned green there was no acceleration response from the gas pedal for a couple of seconds, and in two of the instances because I had my foot pressed far on the gas attempting to get power, there was a sudden acceleration and lurch forward. Most recently, on the fourth occasion I was turning out into traffic from a parking lot after being at a standstill and got no response and instead rolled slowly out in front of an oncoming car until after a few seconds the accelerator finally responded and I could go. I believe this is a safety risk as it could happen when I was attempting a left turn in traffic, which would subject me and my passengers/children to an extreme risk of being hit. I took the car into the dealership after the first two instances and they were not able to reproduce the incidents and offered no help. There are no warning lamps or indicators that appear when this occurs. The first incident occurred about three weeks into my ownership of the vehicle.

When remote starting the vehicle. The vehicle allows you to put the vehicle in gear from inside and turn off the parking brake allowing the vehicle to roll freely. The vehicle does shut off 1-2 seconds after but the vehicle is already in gear. To reproduce the defect you must remote start the vehicle using either the Toyota app or smart key fob. You then must be sitting in the vehicle once the vehicle is started you quickly depress the brake pedal shift into gear and turn off the parking brake quickly. The vehicle then shuts off while in gear allowing the vehicle to roll freely. This increases the risk of accident as the driver may not be in the vehicle and a child or other person may accidentally put the vehicle in gear while remote started. I believe this issue affects many other Toyota and Lexus vehicles as many share the same platforms and systems. You may contact me at my email address listed for more information or a video recording of the defect. Thanks.