1FTBR1C8XLKB182332020 FORD TransitMedium Roof

The contact owns a 2020 Ford Transit. The contact stated that while driving 50 MPH, the vehicle unexpectedly lost motive power and came to a complete stop in traffic. There was no warning light illuminated. The vehicle was unable to be restarted. The vehicle was towed to the dealer and was diagnosed with internal transmission failure involving the sleeve and cylinder of the 10-speed transmission. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure by email, and a case was opened. The failure mileage was approximately 87,000.

Odometer Fraud. The contact purchased a 2020 Ford Transit. The contact stated that while attempting to register the vehicle, it was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 69,000, which was confirmed by a fraudulent Carfax report the seller provided to the contact. However, upon searching the VIN on a Ford mobile app, it was discovered that the mileage was 168,000.

My Tire pressure Monitor give me alert while driving I select to view tire pressures for display show 3 tires fail send reading One of the three back sending reading two stay off For few days same then all tires reading went off just 1 tire send reading on /off every few miles This is first time happened

Rear brake issues. Upon taking off the brake pads on the driver's back the caliper piston would not turn in as it should. So I ordered a new one. Then I started on the passenger rear. When I tried to press and turn the piston back in it did the same thing as the other one. The piston came out of the passenger rear caliper. Upon further inspection I noticed the interior housing for the piston has a portion of it missing.

The bolts holding the axle together to the driveshaft failed on the rear right wheel, nearly causing an accident but fortunately it was 6am with little traffic on the interstate. The axle came out and destroyed our driveshaft, requiring a full replacement. We have had the vehicle serviced regularly since our purchase.

Transmission intermittently struggling to reach 3rd, 4th, 5th gears. Performed IDS diag at shop, found hitorical code P0734 for "Incorrect gear 4 ratio" TSB 26-2046 to overhaul transmission.

Vehicle shakes violently on or about 65 to 70 mph. Upon slowing to approximately 60 mph the shaking stops. Also at slower speeds the vehicle pulls to the right. Contacted Ford Fairfield, California dealer two days ago; left voicemail no reply at this writing.

We started experiencing slight transmission shifting issues in early-mid 2024. More issues in December 2024/January 2025 - this time it was really hard and jerky shifting. It was sporadic at this time, but it was often. My wife and I have 7 children. This vehicle is usually driven by my wife to pick up kids from school, run errands, etc. At the beginning of March 2025, my wife was merging onto the highway, but it didn't want to shift. She stated that a big rig was coming behind her and the van was not shifting and picking up speed. She said the engine was revving but just was not shifting up. She said the big rig honked and had to change lanes or else he would have hit her and my kids. Several seconds after the big rig passed was when the transmission hard shifted and jerked and it began to pick up more speed, but from that point on, the transmission was not operating properly. We have not driven it since March 2025. I have been saving up to fix the transmission, but I read so many other Ford owners have the same issue with this particular transmission. The Ford dealer confirmed it had a TSB on this exact issue and that many other 10r80 transmissions were doing the same. The issue was reproduced by the Ford dealer. It states the CDF issue in the invoice. There were no warning lamps or messages prior to the experience merging on to the highway. I reached out to a local independent mechanic and he upgrades the parts in these Ford transmissions all the time - proving it is a very common issue. This is a huge safety risk for anyone operating or riding in a Ford with this transmission.

Back up camera image is reversed, distorted and goes black/blue from time to time.

The rear back up camera stopped working completely I took it to Faricy boys Ford in Canon City Co Waited 45 days for them to get the part and then they told me they weren’t comfortable changing the camera out so I have been with out back up camera on this 22 foot van needing assistance for almost every single move Please help me get this vin on the recall Thank you [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2020 Ford Transit. The contact stated that whenever the vehicle was started, the contact stated that several unknown warning lights and the ABS warning light were illuminated. The contact stated that the right front wheel activated, and the ABS activated while making a hard right turn. The contact was not depressing the brake pedal during the failure. In addition, the contact was informed that the brake lights remained activated. The contact stated that several functions were deactivated. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to take the vehicle to the dealer for diagnostic testing. The failure mileage was approximately 33,000.

Only I have 88,000 k on 2020 transit the transmission have problems with shifting while driving on highway start with delay on 2nd gear now fault code for gear 10

Driveshaft both front and rear failed as pieces broke off while driving at different times requiring tow and repair

Loss of power while driving with no warning. Almost crashed. Shifting violently. After a few months it wasn't safe for anyone and was happening all the time . It's at the dealer getting the transmission rebuilt with re engineered parts . That's what the dealer told me . He said this will resolve the problem for good . 8000$$ 67k miles ford is not helping with cost. Ford had to re engineer the parts that are going in my van , isn't that them admitting they have a transmission that was no good from the start

Mid 2023 the backup camera would sporadically stop working and produce a blue screen and a message "camera is unavailable contact your dealership". I would check for an update and then it would start working. This has happened 8 times since 2023- 2024, in August 2024 it has quit working completely.

While I driving my 4-year-old Ford Transit Connect with 65,000 miles, I noticed a transmission issue. At low speeds, the vehicle struggled to accelerate, which caused me significant stress and felt very unsafe. However, once on the highway, the transmission gradually returned to normal. In March, I took it to a Ford dealership, where it was diagnosed with a faulty transmission. After discussing this issue with others, I found that many people have also complained about serious safety concerns with Ford’s transmissions.

A few months ago, my 2020 Ford Transit had a transmission issue, and the dealer replaced the torque converter. Now, at 101,300 miles, I’m experiencing loss of power, jerking, and rough shifting, and I have to replace the entire transmission. After researching online, I’ve found that many others have experienced the same issue.

The contact owns a 2020 Ford Transit. The contact stated that while attempting to drive from a complete stop, the vehicle briefly hesitated before suddenly jolting forward, prompting the contact to pull over to the shoulder of the roadway. The vehicle returned to normal functionality, but the failure became a regular occurrence. The vehicle was taken to the dealer, who diagnosed a failure with the transmission. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 136,000.

The contact owns a 2020 Ford Transit. The contact stated that the AWD and air bag warning lights were illuminated. The vehicle was taken to the local dealer, where it was diagnosed and determined that the actuator and sensor needed to be replaced, and a software update needed to be performed. The vehicle was repaired, but the failure recurred. The dealer determined that the transfer switch, new air bag, and seat repair kit were needed. The vehicle was not repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 68,000.

The van will not start on a regular basis. Usually within a week the battery voltage has depleted to the point the van will not start. Have to put a charger on it often. This is a commonly reported problem on many forums.

The contact owns a 2020 Ford Transit equipped with Hankook Tires, Tire Line: Dynapro HT, Tire size: 205/75/16, DOT Number: (NA). The contact stated that while pulling into a gas station there was a thumping noise coming from the trailer. The contact inspected the trailer and observed that the front driver’s tire was flat. A mobile mechanic was called to the location and replaced the flat tire with the spare tire. The vehicle was then taken to a tire shop where it was determined that the front driver’s tire was worn down to the metal and experience a blowout. The tire was replaced. The contact stated that on the same day while driving 62 MPH, the tire pressure warning light illuminated, indicating that the tire was deflating quickly. The vehicle was pulled over to the side of the road and the contact became aware that the front passenger’s tire was flat. The vehicle was taken to tire shop and the front tires were replaced. The manufacturer was notified of the failure. The vehicle and tire failure mileages were approximately 20,250.

My Balmar 2nd alternator on my Winnebago Ekko has just failed. This is a Winnebago installed electrical system component mounted in the Ford Transit chassis engine bay that provides electrical charging to the RV coach batteries. There was an initial NHTSA Safety Recall 23V-234 issued in 2023 after numerous Balmar units failed; in some cases the Balmar unit failure caused a fire in the engine bay. I had the Safety Recall work performed in July 2023 by authorized dealer Dennis Dillion RV in Boise Idaho per the attached invoice and the Balmar charging system had been working well until now. I am aware that there are ongoing reports by other Ekko owners of the Balmar alternator failures reoccurring after the Safety Recall work was performed, and in some cases even after Balmar 2nd alternators' were replaced, which suggests the initial solution provided by the Safety Recall was not sufficient to prevent a failure. Within minutes of starting to drive my RV today I noticed an unfamiliar whining sound from somewhere under the hood that I had not heard before and immediately checked my coach batteries while driving a short distance and went from the batteries discharging significantly to not charging at all. I opened the engine hood and had smoke visible and a strong burning smell coming from the passenger side of the engine bay where the Balmar unit is located. I was very concerned about the potential for an engine bay fire, but fortunately was very close to my home, so my RV is now parked in my driveway. See attached screenshots showing the initial voltage discharge while driving and then the batteries not getting any charge while under power. Also attached is the Recall 23V-234 repair instructions. I plan to unplug the Balmar alternator to prevent the potential for a fire while awaiting a response from Winnebago how to proceed. Despite the NHTSA Safety Recall having been performed, there are reports of alternator's failing and risk of vehicle fires remains.

In march 2024 my vehicle unexpectedly cutoff on [XXX] heading into wash. Dc. Called a tow to my mechanic and had the alternator and battery replaced. Mechanic noticed that the vehicles battery light remained and investigated further. After amonth in the shop we observed that components were utilizing battery power when the system should be off. We heard mechanical diagnostic sounds, and the battery would not maintain a charge after being driven. Upon getting it home and a day later upon jump starting again and when i began to turn the wheel, a violent jerking response came from the steering column. Cheched the dash and several popup windows had to be closed. AWD, BATTERY, and low fuel. There was also the wrench light on the dash itself. Went on the Ford forum and many others were describing the same issues, mainly battery drain. I thought i had disconnected the cargo area lights only to find out i did disconnect part but not them all only to further discover Ford engineered the vehicle where most of the features that were described in the forum not so accessible such as the fuse panel 'fuse 32' because theres no clear indication of where that is exactly on the diagrams. Ive have pretty much used the vehicle on occasions where im moving my equipment. As of september, i received a letter from fords "Customer Satisfaction Program" in which i responded only to be told from Bannister Ford that the Software Update that would fix High-Torque launches would not be installed because the battery light was on. Now to me, this sounds like a catch-22 because the issue is with their electrical design where if one problem occurs they have a fix but you wont get it until you fix the prom (ideally with them). all the while I'm setting up the appointment im being served ads for add-on services. Its october 2024 and i am just sick of this van. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2020 Ford Transit. The contact stated that whenever it rained, the door seal towards the rear of the passenger’s side sliding door was leaking. The contact stated that the leak was allowing water to accumulate in the pillar located at the rear on the passenger’s side. The contact stated that the pillar was filling nearly to where the pillar joined the ceiling. The contact stated that water was forming puddles on the floorboards and was draining from the pillar. The contact had taken the vehicle to a local dealer but had not had the vehicle diagnosed. The vehicle was not repaired. Additionally, the contact had observed that the seam on the roof of the vehicle where the two roof panels were joined was also showing extreme deterioration of the caulking; however, there was no water leaking into the vehicle yet. The manufacturer was informed of the failure. The failure mileage was approximately 3,100.

I have encountered an issue multiple times now on multiple Ford Transit vans. The "lug wrench" included with the vehicle as part of the spare tire tool kit does not allow me to remove the lug nuts. I am a Fleet customer and I own many Ford Transit AWD vans. When they are brand new, the spare tire lug wrench barely reaches the lug nut as it is not a very deep socket. After a couple of tire rotations I believe the lug studs possibly stretch slightly and the lug wrench tool no longer reaches the lug nut. This issue has caused my drivers to be stranded multiple times. I believe it is an oversight by Ford and it should be addressed. Thank you

We own a fleet of these vans and 5 out of the last 7 purchased from 2020-2023 have had total rear brake system failure. The calipers are not retracting and are overheating and freezing up the rear brake system. In some cases leaving our employee(s) stranded on the side of the road in the middle of winter storm waiting to get towed putting their safety at risk. The problem has been reproduced as it has happened on 5 of the last 7 vehicles we purchased. Our local Ford dealer has inspected these issues and we contacted the Ford Consumer phone today - spoke with Rena at Ford on 6/19/24 at approximately 2pm - 2:15pm PDT. No warning lamps or message alerts. Brakes are making a squeaky noise and hot smell prior to seizing. We have had to pay thousands of dollars for some of these repairs and towing. We wanted to alert Ford and you as we are noticing an alarming trend. In speaking with Ford Motor Company, they correlate this issue as a maintenance issue but if it was a maintenance issue, the front brakes would have failed before the rear. I will be completing this form for the additional VIN numbers. Thank you.

We own a fleet of these vans and 5 out of the last 7 purchased from 2020-2023 have had total rear brake system failure. The calipers are not retracting and are overheating and freezing up the rear brake system. In some cases leaving our employee(s) stranded on the side of the road in the middle of winter storm waiting to get towed putting their safety at risk. The problem has been reproduced as it has happened on 5 of the last 7 vehicles we purchased. Our local Ford dealer has inspected these issues and we contacted the Ford Consumer phone today - spoke with Rena at Ford on 6/19/24 at approximately 2pm - 2:15pm PDT. No warning lamps or message alerts. Brakes are making a squeaky noise and hot smell prior to seizing. We have had to pay thousands of dollars for some of these repairs and towing. We wanted to alert Ford and you as we are noticing an alarming trend. In speaking with Ford Motor Company, they correlate this issue as a maintenance issue but if it was a maintenance issue, the front brakes would have failed before the rear. I will be completing this form for the additional VIN numbers. Thank you.

The contact owns a 2020 Ford Transit. The contact stated that on several occasions while in reverse(R), the rearview camera became static, blue, and black and failed to work as intended. The vehicle was taken to a dealer where it was diagnosed and determined that the rearview camera needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 28,000.

The contact owns a 2020 Ford Transit. The contact stated that while driving at an undisclosed speed, the rear camera unavailable message was displayed. The vehicle was taken to the dealer; however, the failure was unable to be duplicated. The vehicle was not repaired. The contact stated that the vehicle had been taken to the dealer several times because of the persistent failure. The manufacturer was made aware of the failure and the contact was informed about an unknown recall however, the VIN was not associated with the recall. The contact was advised to report the failure to the NHTSA Hotline. The failure mileage was approximately 3,000.

The Vehicle head light comes on while the vehicle head light switch is at off position and when you hit the remote on off button the light turns off. And later comes back on again . And at night driving the light goes off and on some time .it just black out on road can we get advise if this is recall issue since we seen many customers having complaints about the same issue on website and also on ford forums

Windshield wiper motor, working only in high speed, found overheated ground wire, melted insulation for approximately 1 foot of wire. If dry leaves were nearby there would be a possibility of a fire. Replaced wiper motor and wire harness work done by Brewster Ford in New York found that the new motor has not been updated which means this problem may happen again went on Google website found many owners having same problem. As you can see from the wiper motor connector, there is a pin that shows signs of overheating the wiper motor was the cause of the problem as the wiper motor was drawing excessive current

Tire was a Continental 235/65 R16 C 121/119R Van Light Truck M.S Radial Tubeless - Name of Tire was Con Vancontact A/S - On October 07 2023 [XXX] was driving on IH35 North South of Waco TX at around 70 MPG and the tire had a blowout/explosion doing multiple damage to the vehicle before it could be brought to a full stop INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6

While driving on the freeway at about 75 mph, the rear passenger tire exploded causing our driver to almost lose control of the vehicle before coming to a stop on the side of the road. No lamps or warnings were given. No inspections have been completed but I have retained the tire if needed.

The contact owns a 2020 Ford Transit. The contact stated while starting the vehicle and shifting into drive, the vehicle failed to accelerate. There was no warning light illuminated. The vehicle was taken to an independent mechanic and the contact was informed that the transmission coolant was leaking, and that the transmission needed to be replaced. The contact was advised to contact the local dealer. The dealer was contacted and advised that there was a service bulletin for the failure, but the VIN was not included in the service bulletin. The vehicle was not repaired. The manufacturer was contacted and stated that the vehicle needed to be diagnosed. The contact was also informed that there was no recall on the VIN for the failure. The failure mileage was 95,000.

The seats have sank into the springs making it undriveable. This has happened on all our Ford Transit Vans. Ford dealerships won't repair because they are now out of warranty but this was reported prior to warranty expiration but we were told parts were not available.

The battery's junction box in the engine compartment is melting. While I was driving, I heard a loud pop, I opened the hood, and saw smoke coming from the junction box. I noticed the box was melting around a fuse. The melting is significant, and the vehicle looked to be on fire. The smoke stopped, but I feel the vehicle could easily have caught on fire completely. There are recalls for this same exact issue but for other Ford Models. I have a fleet of these vans, and this has now occurred to 6 of them. I know other owners that this occurred to as well. I have called Ford Goodwill and they have declined to cover it under the 3-year, extended warranty. The melting was so bad on one that the actual harness was burnt as well. This is a dangerous issue that Ford already knows this happens. I have receipts for all of these repairs and the technician acknowledging the junction box melting. I have emails from Ford where they apologize for the issue, and they say they cannot cover it under warranty. They refuse to comment on the safety danger this poses on all. This is an amazon delivery van and there are thousands of these that could catch fire in someone's house or business.

THIS IS A SECOND CASE FOR A DIFFERENT VIN WITH THE SAME ISSUE. 11524889. The battery's junction box in the engine compartment is melting. While I was driving, I heard a loud pop, I opened the hood, and saw smoke coming from the junction box. I noticed the box was melting around a fuse. The melting is significant, and the vehicle looked to be on fire. The smoke stopped, but I feel the vehicle could easily have caught on fire completely. There are recalls for this same exact issue but for other Ford Models. I have a fleet of these vans, and this has now occurred to 6 of them. I know other owners that this occurred to as well. I have called Ford Goodwill and they have declined to cover it under the 3-year, extended warranty. The melting was so bad on one that the actual harness was burnt as well. This is a dangerous issue that Ford already knows this happens. I have receipts for all of these repairs and the technician acknowledging the junction box melting. I have emails from Ford where they apologize for the issue, and they say they cannot cover it under warranty. They refuse to comment on the safety danger this poses on all. This is an amazon delivery van and there are thousands of these that could catch fire in someone's house or business.

seat collapse. Available to be inspected. Unable to see over wheel or reach the acceleration and break pedals. Airbag light comes on due to the collapsed seat either cutting the airbag electrical cable, or puncturing the airbag itself. Vehicle has only been inspected by our fleet manager, our in house mechanic, and the dealership. No prior warning(s) before the failures.

seat collapse. Available to be inspected. Unable to see over wheel or reach the acceleration and break pedals. Airbag light comes on due to the collapsed seat either cutting the airbag electrical cable, or puncturing the airbag itself. Vehicle has only been inspected by our fleet manager, our in house mechanic, and the dealership. No prior warning(s) before the failures.

seat collapse. Available to be inspected. Unable to see over wheel or reach the acceleration and break pedals. Airbag light comes on due to the collapsed seat either cutting the airbag electrical cable, or puncturing the airbag itself. Vehicle has only been inspected by our fleet manager, our in house mechanic, and the dealership. No prior warning(s) before the failures.

seat collapse. Available to be inspected. Unable to see over wheel or reach the acceleration and break pedals. Airbag light comes on due to the collapsed seat either cutting the airbag electrical cable, or puncturing the airbag itself. Vehicle has only been inspected by our fleet manager, our in house mechanic, and the dealership. No prior warning(s) before the failures.

seat collapse. Available to be inspected. Unable to see over wheel or reach the acceleration and break pedals. Airbag light comes on due to the collapsed seat either cutting the airbag electrical cable, or puncturing the airbag itself. Vehicle has only been inspected by our fleet manager, our in house mechanic, and the dealership. No prior warning(s) before the failures.

seat collapse. Available to be inspected. Unable to see over wheel or reach the acceleration and break pedals. Airbag light comes on due to the collapsed seat either cutting the airbag electrical cable, or puncturing the airbag itself. Vehicle has only been inspected by our fleet manager, our in house mechanic, and the dealership. No prior warning(s) before the failures.

seat collapse. Available to be inspected. Unable to see over wheel or reach the acceleration and break pedals. Airbag light comes on due to the collapsed seat either cutting the airbag electrical cable, or puncturing the airbag itself. Vehicle has only been inspected by our fleet manager, our in house mechanic, and the dealership. No prior warning(s) before the failures.

seat collapse. Available to be inspected. Unable to see over wheel or reach the acceleration and break pedals. Airbag light comes on due to the collapsed seat either cutting the airbag electrical cable, or puncturing the airbag itself. Vehicle has only been inspected by our fleet manager, our in house mechanic, and the dealership. No prior warning(s) before the failures.

seat collapse. Available to be inspected. Unable to see over wheel or reach the acceleration and break pedals. Airbag light comes on due to the collapsed seat either cutting the airbag electrical cable, or puncturing the airbag itself. Vehicle has only been inspected by our fleet manager, our in house mechanic, and the dealership. No prior warning(s) before the failures.

seat collapse. Available to be inspected. Unable to see over wheel or reach the acceleration and break pedals. Airbag light comes on due to the collapsed seat either cutting the airbag electrical cable, or puncturing the airbag itself. Vehicle has only been inspected by our fleet manager, our in house mechanic, and the dealership. No prior warning(s) before the failures.

seat collapse. Available to be inspected. Unable to see over wheel or reach the acceleration and break pedals. Airbag light comes on due to the collapsed seat either cutting the airbag electrical cable, or puncturing the airbag itself. Vehicle has only been inspected by our fleet manager, our in house mechanic, and the dealership. No prior warning(s) before the failures.

seat collapse. Available to be inspected. Unable to see over wheel or reach the acceleration and break pedals. Airbag light comes on due to the collapsed seat either cutting the airbag electrical cable, or puncturing the airbag itself. Vehicle has only been inspected by our fleet manager, our in house mechanic, and the dealership. No prior warning(s) before the failures.

seat collapse. Available to be inspected. Unable to see over wheel or reach the acceleration and break pedals. Airbag light comes on due to the collapsed seat either cutting the airbag electrical cable, or puncturing the airbag itself. Vehicle has only been inspected by our fleet manager, our in house mechanic, and the dealership. No prior warning(s) before the failures.

seat collapse. Available to be inspected. Unable to see over wheel or reach the acceleration and break pedals. Airbag light comes on due to the collapsed seat either cutting the airbag electrical cable, or puncturing the airbag itself. Vehicle has only been inspected by our fleet manager, our in house mechanic, and the dealership. No prior warning(s) before the failures.

seat collapse. Available to be inspected. Unable to see over wheel or reach the acceleration and break pedals. Airbag light comes on due to the collapsed seat either cutting the airbag electrical cable, or puncturing the airbag itself. Vehicle has only been inspected by our fleet manager, our in house mechanic, and the dealership. No prior warning(s) before the failures.

seat collapse. Available to be inspected. Unable to see over wheel or reach the acceleration and break pedals. Airbag light comes on due to the collapsed seat either cutting the airbag electrical cable, or puncturing the airbag itself. Vehicle has only been inspected by our fleet manager, our in house mechanic, and the dealership. No prior warning(s) before the failures.

seat collapse. Available to be inspected. Unable to see over wheel or reach the acceleration and break pedals. Airbag light comes on due to the collapsed seat either cutting the airbag electrical cable, or puncturing the airbag itself. Vehicle has only been inspected by our fleet manager, our in house mechanic, and the dealership. No prior warning(s) before the failures.

seat collapse. Available to be inspected. Unable to see over wheel or reach the acceleration and break pedals. Airbag light comes on due to the collapsed seat either cutting the airbag electrical cable, or puncturing the airbag itself. Vehicle has only been inspected by our fleet manager, our in house mechanic, and the dealership. No prior warning(s) before the failures.

seat collapse. Available to be inspected. Unable to see over wheel or reach the acceleration and break pedals. Airbag light comes on due to the collapsed seat either cutting the airbag electrical cable, or puncturing the airbag itself. Vehicle has only been inspected by our fleet manager, our in house mechanic, and the dealership. No prior warning(s) before the failures.

seat collapse. Available to be inspected. Unable to see over wheel or reach the acceleration and break pedals. Airbag light comes on due to the collapsed seat either cutting the airbag electrical cable, or puncturing the airbag itself. Vehicle has only been inspected by our fleet manager, our in house mechanic, and the dealership. No prior warning(s) before the failures.

Front drivers seat cushion sagging no good for almost 1 and a half years. I bought replacement cushions for over $200 each. This is due to a broken seat suspension mat and the only way to fix it is to buy the seat track for $600 plus dollars. I found this Manufacture communications number TSB 21-2353. I have a total of 6 2020 Transits and they all the same problem. 1FTBW3U8XLKA17017 1FTBW3U83LKA17022 1FTBW3U80LKB05414 1FTBW3U8XLKB05419 1FTBW3U80LKA65495

Seat collapse. Available to be inspection. Unable to see over wheel or reach acceleration or brake petals. Air bag light comes on due to seat cutting it or disconnecting it when collapses. Dealership. No.

The bottle jack catastrophically failed while replacing a spare tire, and it is available for inspection upon request. The safety of my partner was put at risk while they were changing the tire and the van fell. Luckily the van fell on the new tire that was not quite in place yet but did hold up the van. We have used the bottle jack several times now, but it could seriously hurt somebody if it failed catastrophically like it did for us. The cupped mounting point on the jack was bent from a prior tire change; however, we were about 1 hour from town and had little choice but to use it anyways when it failed catastrophically. We got a proper heavy-duty hydraulic jack from the store to finish the tire change. The problem has not been reproduced or confirmed by anybody. The vehicle and component were not inspected by anybody.

Rear camera (back up camera) will stop working. Also, rear (right-side) and side sliding door "door open alert" false indicates, beeps horn while driving but is sporadic.

Left the van running in my driveway next thing I know it was on fire

The contact owns a 2020 Ford Transit. The contact stated while driving 60 MPH, the check engine warning light illuminated. Additionally, the vehicle would not shift out of gear. The vehicle was taken to the local dealer where it was diagnosed that the transmission needed to be replaced. The vehicle was then taken to an independent mechanic. The vehicle was repaired. The manufacturer was notified of the failure and referred the contact to NHTSA. The failure mileage was approximately 150,000.

The contact owns a 2020 Ford Transit. The contact stated that while driving at an undisclosed speed, the vehicle shuddered and made an abnormal sound. Upon inspection, the contact noticed that the rear driver's and passenger's exhaust manifold bolts were fractured and leaking. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. Prior to the failure, the vehicle had a cylinder # 2 misfire with code P0302 and the spark plugs were replaced. The manufacturer was not made aware of the failure. The failure mileage was approximately 39,000.

1. 10 SPEED ELECTRIC TRANSMISSION - When traveling at a lower speed when approaching a turn (10, 15, 20, 25mph); when you release the accelerator to make the turn, and then begin to apply pressure to the accelerator to move forward, the transmission has not selected a gear and no acceleration occurs. This leaves the transmission between gears (neutral momentarily) and the vehicle has no power to move forward. It has happened on several occasions and I believe it places the driver in a dangerous position to not maintain power to the drive train. 2. FRONT SEAT ADJUSTMENT RAILS - The two rails on each seat are irregular shaped heavy metal rails which the seat assembly slides back and forth on. When getting into the truck (stepping up and moving your legs around the outside corner of the seat), the sharp metal end (painted) scrapes, scratches, or lacerates your calf, as you get in. This has happened on several occasions to me as the driver, and more than several occasions to my wife; who has the seat adjusted further back, thus exposing more of the metal rail to contact with her leg. In my owner's manual, diagrams show an plastic end cap on the front portion of the rails. They are not installed on the 2020 (actually 2021) model. I spoke to the Ford parts department. They are available for earlier model vans (2017, 2018 as an example) but, they are not available for the 2020 model. The price for me to purchase the "plastic" injection molded end caps to prevent future injury are $96.00 FOR EACH END CAP! Plus tax, over $414. If they were installed on previous models, why not the 2020 model? Injuries are minor but, they are injuries because of a part deletion/omission by Ford Motor Company.

I bought this vehicle in Sept 2020 and have had this issue since day one. The drivers seat creates a bulge about half-way up the seat back when the seat warms up either with the heated seat feature or sunlight and pushes me forward out of the safety of the side seat bolsters. The passenger seat does not have this issue and has a slight concave shape to it for proper support. The Ford dealer has replaced the lumbar support system and "wrapped" the lever inside the seat back to reduce any protrusions. I now can feel that padding which adds to the bulge that pushes me forward. The Ford rep says they have not been able to duplicate the concern. I have asked for someone to drive the vehicle for a period of time so they too can notice how the bulge gets bigger as the seat heats up. The rep says there is nothing more they can do since the problem can't be duplicated. So, I am asking for your help since I feel very unsafe when I have to drive this due to the bulge. This is from the Ford Rep- "[XXX], Good morning. I do apologize for not getting back with you as I said I would. Ford Pro has been experiencing unexpected high call volume for several weeks now. We are actively working to address that issue. I did speak with S/A [XXX] at Monaco & Sons Motor Sales just a few minutes ago. He advised the wheel repair shop has not yet returned the wheel as they said may be done as early as last Friday or Monday at the latest. I asked [XXX] about the driver seat, and he states they have not been able to reproduce the concern you reported, they have also compared it to other Transits at their dealership and find your seat to be similar. Until or unless they are able to verify a concern that is due to a factory defect in the seat or components, they will not be able to address this further. I will schedule my next follow up for Monday, 12/13/21. Barring any unforeseen issues, the wheel should be repaired and your vehicle should be back with you before then." INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Driving 30 MPH engine starting revving up to 4000rpm and very loud! Stalled out and wouldn't start, 3 times during a 5 minute drive.

While riding through a Walmart parking lot the power steering went out. I managed to manuever to a nearby Ford service station. While there awaiting service I read online that this make and model looses power steering. The Blog suggested turning off the vehicle and restarting it. I went back to my vehicle and started it and the power steering had returned. I was 5.5 hours away from home but when I got home I parked it until I could get it to the dealership. It has been at the dealership for 10 days and just last night the dealership told me that the vehicle has water and sand in it and that that is what is causing the problems with the vehicle. I have never been in water or sand in this vehicle.

VEHICLE INSTRUMENT CLUSTER INTERMITTENTLY LOSES POWER, BOTH WHILE VEHICLE IS IN MOTION OR WHILE STOPPED. INSTRUMENT CLUSTER CEASES TO DISPLAY VEHICLE SPEED, ENGINE RPM, ENGINE TEMP, AND FUEL LEVEL, AS WELL AS ALL OTHER INFO THAT IS TYPICALLY DISPLAYED. THIS CONDITION CAN LAST SECONDS OR SEVERAL MINUTES AT A TIME. IF CRUISE CONTROL IS ACTIVE WHILE THE ISSUE OCCURS, CRUISE CONTROL CEASES TO FUNCTION AND THE VEHICLE STARTS TO SLOW DOWN UNEXPECTEDLY. WHEN THE INSTRUMENT CLUSTER REGAINS POWER, IT SOMETIMES FLASHES VARIOUS WARNINGS, SUCH AS "BLIND SPOT ASSIST ERROR," "TRANSMISSION NOT IN PARK," "PRE-COLLISION ASSIST ERROR," "ADAPTIVE CRUISE NOT AVAILABLE," AND "PARK ASSIST ERROR." THIS PROBLEM OCCURS INTERMITTENTLY, BUT HAS OCCURRED COUNTLESS TIMES SINCE THE VEHICLE WAS PURCHASED NEW IN JANUARY OF 2021.

DRIVING VEHICLE ON THE ROAD AND EXPERIENCE TRANSMISSION SLIPPING, ABOUT AN HOUR LATER IT STARTED MAKING WHINING NOISE, THEN GEAR SHIFTED AND VEHICLE SKID. STARTED MAKING LIGHT GRINDING NOISE WHILE SHIFTING GEARS. AFTER COOLING, VAN WOULD SHIFT GEARS BUT NOT MOVE, INCLUDING REVERSE. TOOK TO DEALERSHIP AND THEY SAID VAN HAD A TRANSMISSION LEAK. VAN DID NOT HAVE ANY EVIDENCE OF LEAKAGE, FROM PUDDLES UNDER VEHICLE TO ANY TRAIL OF FLUID OR MESS WHEN INSPECTING UNDER VEHICLE. HAD THE VAN FOR LESS THAN 30 DAYS AND THEY SAY 10 QUARTS OF OIL LEAKED! THERE IS NO TRANSMISSION FLUID ON MY DRIVEWAY AT ALL!

TL* THE CONTACT OWNS A 2020 FORD TRANSIT. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V575000 (VISIBILITY). THE VEHICLE WAS TAKEN TO WAYNE AKERS FORD (2000 10TH AVE N, LAKE WORTH, FL 33461) FOR THE RECALL, HOWEVER THE DEALER DID NOT PERFORM THE REPAIR SINCE PARTS WERE ON BACKORDER. AFTER GETTING THE VEHICLE BACK FROM THE DEALER, THE CONTACT STATED THAT WHILE REVERSING, THE REAR VIEW CAMERA DISPLAYED A DISTORTED IMAGE, WHICH RESULTED IN HER REVERSING INTO AN ELECTRICAL POLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 8,000. PARTS DISTRIBUTION DISCONNECT.

PURCHASED NEW AWD AND NOTICED VEHICLE DOES NOT HAVE WHEEL WELL COVERS, I PURCHASED THE AWD BECAUSE I LIVE ON A DIRT ROAD AND WANT TO TAKE OUT ON UNPAVED ROADS, I'VE NOTICED THE AREA HAS COLLECTED LARGE AMOUNTS OF DIRT AND ROCKS. IF I'M DRIVING ON A HIGHWAY A BIG CHUCK COULD FLY OUT AND POSSIBLY DAMAGE CARS BEHIND ME, AND ALSO CASE CONTAINING SEVERAL WIRES IS LOCATED IN THIS SPOT. I'VE CLEANED THIS AREA AND DIRT AND ROCKS CONSTANTLY COLLECTS IN THIS SPOT, I SPENT WELL OVER $50,000 ON THIS VEHICLE, FEEL VEHICLE SHOULD BE INCLUDED ON AN ALL WHEEL DRIVE VEHICLE

WHEN STARTING THE CAR, I HEAR POPPING NOISES SOUNDING LIKE A SPARK PLUG AND OR A TAP/POP NOISE. I HEAR THE NOISE EVERY COUPLE OF DAYS DURING STARTUP, DRIVING, AND AT IDLE.

2020 FORD TRANSIT HIGH ROOF.UPON STARTING VAN 'STEERING ASSIST FAULT SERVICE REQUIRED'MESSAGE CAME UP.STEERING WAS VERY DIFFICULT.WAITING ABOUT 5 MINUTES MESSAGE WAS GONE.VEHICLE WITH ONLY 11K MILES

WHILE DRIVING ABOUT 45 MPH IN NO TRAFFIC, WARNING LIGHT CAME ON THE CRASH BREAKING NOT AVAILABLE. APPROXIMATELY 3 MINUTES LATER THE VEHICLE STALLED. WE HAD TO COAST TO THE SIDE OF THE ROAD. WE WERE ABLE TO RESTART IT THERE. THE DEALER SAID THERE WAS A BUG ON THE SENSOR. THE VEHICLE WAS BROUGHT BACK TO US AND NOW IT IS DEAD AGAIN AND WON'T START. THE VEHICLE IS BRAND NEW AND THE STALL OCCURRED ON OUR FIRST OUTING. IT WAS TOWED BACK TO THE DEALER.

KEYS ARE BREAKING OFF FROM THE ACTUAL REMOTE CAUSING THE DRIVER TO BE STUCK WITHOUT A WAY TO START THE VEHICLE. THIS HAS HAPPENED TO AT LEAST 5 OTHER VANS AS WELL AND OTHER VEHICLE OWNERS THAT DELIVER AMAZON PACKAGES. THERE ARE WELL OVER 20 TO 30 VANS THAT THIS IS ALSO HAPPENING TO.

SINCE PURCHASING THE VAN, THE STEERING WHEEL HAS OCCASIONALLY FELT SLUGGISH AND HEAVIER TO TURN AT CERTAIN TIMES THAN OTHERS. THE FINAL TIME IT WAS NEARLY IMPOSSIBLE TO TURN AND FELT ALMOST LOCKED, WHICH IS OBVIOUSLY A HUGE SAFETY ISSUE. THIS HAS OCCURRED WHILE STARTING THE ENGINE AT RANDOM TIMES AND IMPEDES DRIVING AND OVERALL SAFETY AS IT SEEMS TO COME AND GO AS AN ISSUE. THIS HAS OCCURRED BOTH WHILE STATIONARY AND WHILE IN MOTION.

THE PAINT AND BODY PANELS ARE DEFINITELY DEFECTIVE.

UPON STARTING THE VEHICLE IN THE DRIVEWAY A STEERING ASSIST WARNING SHOWED IN THE VEHICLE INFORMATION AREA. IT WAS STATIONARY. THE POWER STEERING DID NOT FUNCTION AND THE STEERING WHEEL WAS EXTREMELY DIFFICULT TO TURN. NEXT DAY STARTED VEHICLE WITHOUT STEERING ASSIST WARNING APPEARING AND THE POWER STEERING WAS APPARENTLY WORKING AGAIN. MOVED VEHICLE TO THE STREET SO IT CAN MORE EASILY BE DRIVEN TO THE MECHANIC IF PROBLEM RE-OCCURS. THE VEHICLE IS UNRELIABLE WITH THIS POTENTIAL PROBLEM AND HAS TO SIT IDLE AND UNTIL THIS PROBLEM IS RECTIFIED.

VAN WAS STATIONARY ON STREET AND FAILED TO START TWO TIMES, BATTERY WAS FULLY CHARGED.

AT 565 MILES I WAS DRIVING DOWN THE HIGHWAY AND ONE OF MY VALVE STEMS STARTED RAPIDLY LEAKING AIR. AT 11,400 MILES, ANOTHER VALVE STEM STARTED LEAKING RAPIDLY AFTER STOPPING FOR GAS ON A TRIP. ALUMINUM WHEELS, NEVER TOUCHED ANYTHING WITH THEM. WHEN WILL THE REMAINING ONES FAIL?

TL* THE CONTACT RENTED A 2020 FORD TRANSIT CARGO VAN EQUIPPED WITH CONTINENTAL TIRES, TIRE LINE: VANCONTACT A/S N/A, TIRE SIZE: 235/65/R16 N/A, DOT NUMBER: 16Y04DR83. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 70 MPH, A POPPING SOUND WAS HEARD BEFORE THE VAN BECAME UNSTABLE AND BEGAN TO SHAKE AND VIBRATE. AFTER STOPPING TO INSPECT THE VEHICLE, IT WAS DISCOVERED THAT THE PASSENGER'S SIDE REAR TIRE HAD SUSTAINED SEVERE SIDE WALL DAMAGE AND TREAD SEPARATION. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. ENTERPRISE TRUCK RENTAL LOCATED AT 249 FOREST PKWY, FOREST PARK, GA 30297 WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 400. THE VIN WAS NOT AVAILABLE.

UPDATE TO COMPLAINT NO 11302124 DATED 2/26/2020 SPOKE WITH FORD CUST SERVICE REP REGARDING THE ISSUES AND WAS TOLD TO MAKE AN APPOINTMENT WITH DEALER TO CHECK OUT THE SEAT AND ELECTRIC SYSTEM. THE SERVICE DEPT CHECKED THE ISSUES ON 2/12/2020. THE SERVICE TECH VERIFIED THAT THE WIRE BUNDLE IS BEING DAMAGED BY THE SEAT BEING MOVED. THE SERVICE TECH WRAPPED THE BUNDLE WITH TAPE AND RE-ROUTED THE BUNDLE. THE SEAT WAS TESTED FORWARD AND BACK BUT I DON'T BELIEVE THE SWIVEL WAS TESTED. IT APPEARS THAT THE WIRE BUNDLE AND DRIVER'S SWIVEL SEAT NEEDS FURTHER TESTING AND REPAIRS TO ASSURE THAT THE SWIVEL SEAT IS NOT DAMAGING THE WIRE BUNDLE. DAMAGE TO THE DRIVER'S SEAT WIRE BUNDLE MIGHT AFFECT SEAT AIR BAG OPERATION CAUSING EITHER FAILURE TO DEPLOY OR DEPLOYING WHEN NOT NEEDED. DAMAGE ALSO MIGHT AFFECT SEAT BELT AND SEAT WEIGHT/ORIENTATION SENSORS. FOLLOWING ARE THE FORD SERVICE TECH NOTES FROM THE SERVICE WORK ORDER: CUSTOMER STATES WIRING BUNDLE UNDER DRIVER SEAT THAT IS BEING DAMAGE FROM THE SEAT MOVING BACK AND FORTH PLEASE CHECK AND ADVISE CAUSE 612 DRIVERS SEAT HARNESS IS CHAFFING ON SEAT RIVETS VERIFIED DRIVERS SEAT HARNESS IS CHAFFING ON SEAT RIVETS. HAD SERVICE WRITER TAKE PICTURES OF DAMAGE. CHECKED OASIS NO TSB'S, SSM'S, OR GSB'S RELATED. WRAPPED HARNESS WITH HIGH TEMP CLOTH ELECTRICAL TAPE AND RE-ROUTED HARNESS TO CLEAR SEAT RIVETS. TESTED SEAT FORWARD AND BACK TO VERIFIED CHAFFING CONCERN IS NO LONGER PRESENT. THE SERVICE WRITER ALSO CHECKED WITH FORD REGARDING THE FUEL PUMP AND ENGINE SYSTEMS ACTIVATING WHEN THE DRIVER'S DOOR IS OPENED AND WHEN THE KEY IS INSERTED IN THE IGNITION. THE SERVICE WRITER TOLD ME THAT HE WAS TOLD THAT THIS IS NORMAL FOR THE 2020 TRANSIT AND CANNOT BE CHANGED. THIS SHOULD BE CONFIRMED SINCE THIS BEHAVIOR ADDS ADDITIONAL WEAR/TEAR TO THE ENGINE SYSTEMS AND COULD BE A POTENTIAL FIRE HAZARD.

NOTICED THAT A PUMP (FUEL???) WAS CYCLING ON WHEN DRIVER DOOR WAS OPENED AND WHEN KEY WAS INSERTED IN IGNITION. PARKING LIGHTS ALSO TURN ON WHEN DOOR IS OPENED. THE PUMP HAS ALSO CYCLED ON FOR NO APPARENT REASON AFTER ENGINE HAS BEEN TURNED OFF. CHECKED BATTERY WHICH IS LOCATED UNDER DRIVER SEAT AND FOUND THAT ELECTRICAL CABLES THAT LEAD TO SEAT HAVE BEEN DAMAGED BY RIVETS HOLDING SWIVEL SEAT WHEN THE SEAT IS MOVED FORWARD AND BACK. CAREFULLY MOVED THE SEAT BACK GUIDING THE CABLE BUNDLE UNDER THE RIVETS. THE PUMP NOW DOES NOT TURN ON WHEN THE DOOR IS OPENED BUT STILL CYCLES WHEN THE IGNITION KEY IS INSERTED. HAVE MOVED THE TRANSIT OUT OF THE GARAGE DUE TO POTENTIAL FIRE HAZARD. PHOTOS OF WIRE CABLE ARE INCLUDED. TRANSIT WAS JUST PURCHASED ON 1/20/2020 AND THE SWIVEL SEATS ARE NEW FOR THE 2020 MODEL.