1FM5K8DHXKGA538912019 FORD ExplorerXLT

Passenger side exterior B pillar trim came off while driving on highway on July 3, 2026. Trim was on vehicle when it left home. It was not on it when it arrived at destination. Possible danger to other drivers from flying trim component. No inspection or any symptoms of the problem prior to failure. Same problem as recall on 2016-2017 models.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the exterior A-pillar trim had detached from the vehicle. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 44,000.

Component/System: Aluminum hood panel (front edge seam). The hood is available for inspection upon request. The front edge of the aluminum hood on my 2019 Ford Explorer has developed bubbling, lifting paint, and corrosion originating from inside the folded seam. The defect has progressively worsened over time and continues to spread outward. Safety Risk: The corrosion is occurring at the front hood seam, which is part of the structure that supports the hood latch area. Progressive corrosion in this region may weaken the hood panel over time, potentially affecting hood retention at highway speeds. Paint loss and metal degradation also reduce visibility of the defect until it becomes severe. Reproduction/Confirmation: The problem is visible and reproducible at any time. The bubbling and corrosion are present continuously and worsen with normal vehicle use. Inspection History: The issue has been visually inspected by me. The vehicle has not yet been inspected by the manufacturer, dealer, police, or insurance representatives. Warning Lamps or Messages: No warning lamps or messages appeared. There were no electronic symptoms prior to the failure. The first visible symptom was small paint bubbles along the front hood edge, which appeared approximately when the corrosion began. Assessment: Based on widespread reports for this model year and Ford’s own Technical Service Bulletins for aluminum panel corrosion, the cause appears to be corrosion originating inside the aluminum hood seam, likely due to manufacturing contamination.

The contact owns a 2019 Ford Explorer. The contact stated that the leather on the dashboard was peeling and had detached. No warning lights were illuminated. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 100,000.

The contact owns a 2019 Ford Explorer. The contact stated that while driving 80 MPH, the steering wheel was abnormally loose, and the vehicle became uncontrollable. The contact stated that the brake pedal was depressed; however, the vehicle failed to stop as intended. The vehicle was driven to the shoulder of the road, and the brake pedal was depressed to the floorboard. The brake pedal was depressed several times, and the vehicle stopped. No warning lights were illuminated. A driver nearby assisted with stopping traffic to allow the contact to drive the vehicle off to the shoulder of the roadway. The vehicle was inspected, and the other driver became aware that the rear tires were completely bald. The vehicle was taken to Discount Tires, and the contact was informed that the failure was because of the rear suspension. The contact was advised to take the vehicle to the dealer. The vehicle was taken to the dealer and was informed that the vehicle was previously repaired under NHTSA Campaign Number: 26V101000 (Suspension) in March 24, 2026. In addition, the contact was informed that an alignment was not performed because the alignment machine was unavailable. The contact had not been informed that the recall repair was completed. The dealer informed the contact that an alignment had been completed. The vehicle was repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 147,419.

Fuel pump and module failure. Driving on the highway at 70 miles an hour and the fuel pump failed. Causing me to have zero acceleration. Thus losing speed rapidly in the center lane. No warning lights were present before or after. One previous symptom of a crank no start. Dealership was able to replicate the crank no start situation. Resulting in the problem being a fuel pump failure and module needing replaced, at 83,000 miles on the vehicle. Though I know normal wear and tear can and does happen, there was no warning. And losing engine power at high speeds on a highway is unsafe.

This recall has been unresolved for approximately two years. Recently, while traveling at highway speeds, the A-pillar trim detached from my vehicle and flew off, striking a vehicle behind me. Fortunately, no accident occurred, but the situation was extremely dangerous and could have resulted in serious injuries or property damage. This is precisely the type of incident the recall was intended to prevent. I have reached out to my local dealership numerous times and am told that Ford has no parts available. This is not acceptable and Ford is not handling this recall in a timely fashion.

The contact owns a 2019 Ford Explorer. The contact stated that while driving, Panel on the driver side door, keyless pad became completely detached. The vehicle was taken to a dealer where it was diagnosed as not being fully secured and was replaced. The panel blew the fuses and affected the liftgate on the vehicle and additional repairs, latch replacement on the liftgate had to be completed. The manufacturer was notified of the issue. The approximate failure mileage 47,000.

While my granddaughter was driving our 2019 Ford Explorer, the steering effort suddenly increased without warning, as if the electric power steering assist stopped functioning. She was traveling at approximately 45 mph on a public road and was unable to steer normally. The sudden loss of assist caused her to nearly leave her lane and almost resulted in a collision. This vehicle uses an electric‑assist rack‑and‑pinion steering system. There were no warning lights or messages before or during the event. Road conditions were dry. After the incident, steering remained abnormally heavy/intermittent. It isn't as though it mimics an old school vehicle without power steering, where it simply requires a good deal of strength. With this situation, if you work hard to make a correction, the car suddenly pulls further quickly in that direction, or in the opposite direction in a very jerky manner. The failure occurred without any prior symptoms and created an immediate loss‑of‑control hazard, especially for younger or smaller drivers who cannot overcome the sudden increase in steering force. It basically feels like it is locked up. I am reporting this because the failure was sudden, unannounced, and nearly caused an accident. This appears to be a malfunction of the electric power steering assist system, and it presents an unreasonable safety risk. On a related note, I am the Director of Quality for a manufacturing facility and have conducted hundreds of formal risk assessments during product design. A sudden, unannounced loss of steering assist represents a high‑severity, low‑tolerance safety hazard. In my professional opinion, this failure mode warrants an accelerated investigation.

I had my transmission replaced in California on Feb 2025. Had failure issues and took it to ford, they found an issue with the torque converter and replaced 7 months after the new transmission, it was cleaned out for debris and contamination. Early this May took it in again for the vehicle violently shaking, the ford Mechanic before inspecting immediately knew what transmission I had and knew what issue was, said all the 6F35 transmissions are failing. Took it to my local ford dealership who confirmed that the whole transmissions needs to be replaced again. Less than 20k miles on it. Of course this transmission had a law suit filed which was dismissed. Frustrating because it is clearly a known issue. I am currently #10 on the national waitlist for a new transmission. I am expected to be without a vehicle for months.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the windshield exterior A-pillar trims had become loose. The local dealer was contacted. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 75,000.

While driving at highway speeds on the interstate, the B-pillar exterior trim suddenly detached from the vehicle. The trim remained tethered only by the keypad wiring, causing it to flail in the wind and create an immediate road hazard. Simultaneously, the vehicle’s instrument cluster triggered a "Liftgate Open" warning, despite the liftgate being secure. I was forced to make an emergency pull-over onto the shoulder of the interstate—a dangerous situation—to prevent the trim from completely detaching and striking other vehicles. Upon reaching my destination, the vehicle suffered a significant electrical short. The interior lights remained on indefinitely due to the false "liftgate open" sensor reading, and the door keypad became completely inoperable. To prevent a total battery drain and potential fire risk from the short, I had to manually disconnect the battery. The dealership confirmed the failure but stated that current B-pillar recalls (such as Recall 25S53) currently only apply to 2016–2017 models, despite my 2019 model using the same defective clips and adhesive. This failure is identical in nature to Recall 24S02 (A-pillar detachment). The detachment of this trim is a documented projectile hazard. Furthermore, the resulting electrical short in the door harness has compromised the integrity of the vehicle’s sensor system. I am requesting that NHTSA investigate the expansion of the B-pillar recall to include the 2019 model year to prevent further highway incidents.

See attached document for complaint.

Brakes, rotors, tires and now steering column and starting gear is needing replaced after recall of rear toe link in 2019 ford explorer

The massage seat on the driver and passenger front seats malfunctioned. The drivers seat massage pillows stayed inflated on the seat and backrest. Driving to work this morning the massage pillow on the drivers seat popped. This was a very loud almost gunshot type of sound which caused me to swerve my vehicle and almost create an accident. This is due to the massage seat malfunctioning. Ford Motor corp is aware of the issue with the seats and have issued a Technical Service Bulletin but no recall. This is a serious safety issue as this could have caused a major accident while operating the vehicle. Ford Motor Corp refuses to fix the issue with my vehicle as it is no longer covered by my warranty.

I brought my vehicle to Ford Motor Place in Webster Massachusetts to do two recalls, my car was driving normally before the recall service. Immediately after recall work, it does not run properly. The dealer claims transmission failure without prior symptoms. The vehicle only has 70,000 miles.

The contact owns a 2019 Ford Explorer. The vehicle was taken to the local dealer to be repaired under NHTSA Campaign Number: 26V101000 (Suspension). While retrieving the vehicle, the vehicle failed to start. The contact heard the mechanic revving the engine of the vehicle. The dealer determined that the fuel pump and fuel pump module needed to be replaced, and that the failure was not related to the recall repair. The vehicle was not repaired. The manufacturer was contacted and determined that the failure was not related to the recall. The failure mileage was approximately 50,000.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the driver's side windshield exterior A-Pillar trim had started to detach while driving. The dealer was notified of the failure, but the vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 150,000.

Ford had a recall on a Explorer's roof rack covers...In 2021 the dealer glued down the covers. Over time the glue has gone bad and both roof racks are loose causing concern. I recently found out that there was a fix for this. It was installing Christmas tree push clips into cover to secure them. I recently went to the dealer (Sayville Ford, [XXX] ) and inquired about this and adviser stated not recall on file since it was done in 2021. Both roof rack covers are defective. Structure: Body Recall date 2021-05-04 Recall no. 21V316000 Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The retention pins could loosen and allow the roof rail covers to detach from the vehicle. Hide details Recall consequence A detached roof rail cover can create a road hazard, increasing the risk of a crash. Recall action Dealers will install push-pins and replace any damaged rail clips and roof rail covers, as necessary, free of charge. The interim owner notification letter was mailed on June 22, 2021. Owner notification letters (remedy available) were mailed on October 1, 2021. Owners may contact Ford customer service at [XXX] . Ford's number for this recall is 21S22. My vehicle never had push pins inserted according to this recall. Please advise on any help in this matter. I wait your response. Thank You [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Vehicle was stolen, sold, and relisted for sale. Open Recalls on vehicle.

The B post on the driver side flew off while driving. This is has been an ongoing issue. Ford has fixed them before and they keep causing issues on both the driver and passenger side. The exterior panel does not stay connected to the truck. It flew off at highway speeds, causing the air and rear tailgate to malfunction after it pulled a wire out. This is a huge safety issue ford refuses to acknowledge.

The a-pillar applique trim, which borders the left and right side of the front windshield of my 2019 Ford Explorer has been under recall since January 2024. I've taken it to Bill Utter Ford in Denton, Texas, on four separate occasions to ask for it to be repaired. Generally stated, every six months since the recall. They tell me its too bad, there are np arts to repair it. Question, how can you all allow 2 years to pass and not force them to do something? On March 29, 2026, the drivers side piece came flying off at 30 miles per hour. Luckily no one was behind me. Now my windshield has no protection trim. Further, I cut my right hand trying to force the broken pieces back in.

My ford dealer will not check 4 wheel alignment at no charge to me. I have two articles that it is mandatory to do a 4 wheel alignment after replacing the rear toe arms on my 2019 ford explorer.

The contact called on behalf of the owner of a 2019 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 24V031000 (STRUCTURE) and 26V101000 (SUSPENSION). The contact stated that after the vehicle was stopped at a traffic light, the vehicle stalled. The battery warning light was illuminated. The contact was able to restart the vehicle. The contact stated that the failure was occurring every other day. The vehicle was taken to an independent mechanic. The independent mechanic replaced the Manifold Absolute Pressure (MAP) sensor and an unknown sensor; however, the failure persisted. The contact stated that on a separate occasion, while the vehicle was idling, the vehicle stalled. The vehicle was restarted. The contact stated that while the temperature gauge was midway, the vehicle stalled. The battery warning light was illuminated. The contact stated that whenever the temperature gauge was midway, the vehicle would stall. The vehicle was taken to another independent mechanic who replaced a fractured spark plug and the timing chain. The vehicle was repaired; however, two months after the last repair, the failure reoccurred. The manufacturer was not made aware of the failure. The failure mileage was approximately 130,000.

Similar to NHTSA Recall Number 24V031, driver's "B-pillar" trim (top edge) has detached and loose, and is only secured in-place by remaining anchors/attachments. In inspecting underlying substrate, it appears that a mechanical anchor is missing AND adhesive exhibits cohesive failure (remainder adhesive on both supporting/underlying substrate and backside of trim.

Torque converter failed and had to be replaced within 60000 miles. Know issue to ford but they continue to charge $4,000 to have it repaired. Rear main seal leaks oil within 80,000 miles. Know issue to ford and they continue to charge $3,800 to have it repaired.

I am writing to formally report an issue regarding Safety Recall 24S02 on my 2019 Ford Explorer, which is incorrectly shown as completed by Cornerstone Ford in Elk River, Minnesota. This recall involves the exterior A‑pillar trim on 2011–2019 Ford Explorer vehicles and is a documented Ford safety campaign (24S02 / 24V031). According to Ford’s records and Cornerstone Ford’s reporting, Recall 24S02 is flagged as completed on my vehicle on Jun 2025; however, the actual recall repair has never been performed. It appears only on an estimate repair invoice from July 2025, and I have text message correspondence from the dealer dated December 19, 2025, stating that the part had arrived, yet no recall work was scheduled or completed. Notice on Invoice (attached): [Primary]: S100 - RECALL RECALL RECALL - C/S: NO REMEDY AVAILABLE YET-24S02 EXTERIOR A PILLAR APPLIQUE INSPECTION I am unable to take it to a different dealership because it has been flagged as completed. I contacted Ford's Customer service, and they are taking the dealership's word.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure). The local dealer was contacted and confirmed that the part for the recall repair was not yet available. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the issue. The contact had not experienced a failure.

B-pillar panels (both driver side and passenger, driver side has keyless entry). Panel could be come completely detached if not properly secured and cause a driving hazard in the roadway. No, the dealership stated I would have to pay out pocket to repair (estimate of $1900). Yes, it was inspected while at the dealership for a separate recall. No, the adhesive or clips that keep the panels on the door have either completely broken or non-existent.

Vehicle fails to start intermittently. After having this happen on several occasions and waiting for 1-2 hours it would start. However, the last time, while traveling it would not start after taking brief stop. Had to leave the vehicle overnight and return the next day to haul it back home 300 hundred miles. That was Feb. 23, 2026 and still will not start. Vehicle has 70,000 miles.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

Remedy not available in timely manner. This came out in 2024. Issue should be fixed and parts available. I am experiencing the wind noice due to this. Manufacturer Recall Number 24S02 NHTSA Recall Number 24V031 Recall Status Recall Incomplete, remedy r yet available

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE). The contact stated that the passenger's side A-pillar was loose. The vehicle was taken to the dealer, and the contact was informed that the part to do the recall repair was not yet available. The vehicle was not repaired. Most recently, the contact noticed that the driver's side A-pillar trim was loose. The vehicle was not repaired after the most recent failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 40,000. The VIN was not available.

Accelerator stuck wide open while entering freeway. I also have a safety recall notice 24S02/NHTSA recall 24V031

The contact owns a 2019 Ford Explorer. The contact stated that while driving at various speeds, there was an abnormal rattling sound coming from the windshield. The vehicle was taken to a dealer, and the contact was informed that the exterior A-pillar trim retention clips were loose and needed to be replaced, and the contact was provided an estimate for the repair. The contact then received notification of NHTSA Campaign Number: 24V031000 (Structure); however, parts for the recall were not yet available. The dealer was notified of the failure, and the contact was informed that parts were not yet available. The manufacturer was made aware of the failur,e and the contact was provided the same information from the dealer. The vehicle was not repaired. The failure mileage was 64,000.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

The contact owns a 2019 Ford Explorer. The contact stated that while driving at an undisclosed speed, the driver's side door exterior B-Pillar trim clip attachment detached. The vehicle was taken to the dealer to be repaired under NHTSA Campaign Number: 24V031000 (Structure); however, the dealer informed the contact that the driver's side door exterior B-Pillar trim failure was not listed in the recall. The contact was informed that the B- Pillar Trim needed to be replaced at the owner's expense. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 125,000.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000(Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the windshield exterior A-pillar trims were loose, and there was a noticeable windy sound coming from the windshield while driving. The vehicle was taken to the dealer, where the contact was informed that the parts to do the recall repair were ordered. The vehicle was not yet repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 50,000.

The contact owns a 2019 Ford Explorer. The contact stated that while driving at an undisclosed speed, the contact noticed an abnormal buzzing sound coming from the windshield. The dealer was made aware of the failure. The contact stated that a technician arrived at the residence and inspected the vehicle, and placed duct tape around the front windshield. In addition, the contact was informed that the vehicle would fail an inspection with duct tape around the front windshield. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, parts were not yet available. The vehicle was taken to the dealer several times; however, the contact was informed that parts were not yet available. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was unknown.

Blown engine due to ecoboost fuel issues. Vehicle quit and shut off on highway. Multiple issues with 2019 ford explorer that does not get resolved.

The contact owns a 2019 Ford Explorer. The vehicle was serviced under NHTSA Campaign Number: 24V031000 (STRUCTURE), but the failure persisted. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the windshield. The local dealer was contacted; however, the vehicle was not inspected or diagnosed. The manufacturer was not made aware of the issue. The failure mileage was unknown.

The catalytic converters for the Ford Explorer Utility Police Interceptor fail prematurely, degrading the emissions from the vehicle and causing the vehicle to fail emissions testing. Although Ford has implemented a Customer Satisfaction Campaign 22M06, they do not inform owners of the campaign or potential problem. My car was inspected by two Ford dealerships who simply cleared the error code (P0430) and made no mention of Campaign 22M06. The error code persisted as I replaced numerous other components (spark plugs, purge valve, oxygen sensors, Mass air flow sensor) trying to alleviate the problem over the last year. Only if you mention the campaign specifically will they inspect the vehicle for the purpose of replacing the the catalytic converters under warranty. Replacing these failing catalytic converters should be a recall because failure creates substandard emissions for thousands of vehicles.

The contact owns a 2019 Ford Explorer. The contact stated that after a visual inspection of the exterior of the vehicle, the driver’s side roof rack rail had detached. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 21V316000 (Structure). The VIN was included, but the vehicle was repaired in October 2025. The manufacturer was not notified of the failure. The failure mileage was 90,000.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

Suspension issue causing premature inside tire wear which can be fatal, if not deadly. Multiple cases have been recorded and found among other owners for this same make and model yr. Even after parts replacement and 4 wheel alignment was completed.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that upon further inspection, the front driver’s and passenger’s side A-pillar trim seals had started to deteriorate. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 93,000.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure). The contact stated that while driving approximately 65 MPH, the driver’s side exterior A-pillar trim detached and flew off the vehicle. The vehicle was taken to a dealer, where it was determined that the part was under recall and that parts were not yet available for the recall repair. The manufacturer was not notified of the failure. The failure mileage was unknown.

The A pillars are coming off. Other years make and model were recalled . The A pillars on the sides should be recalled just as the front b pillars.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had experienced the failure listed in the recall. The failure mileage was 75,000.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The dealer was contacted. The dealer confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

Rear camera stopper working.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was not yet available. The contact stated there was an abnormal sound coming from the windshield while driving. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was not available.

It has been a year and a half since Ford recalled a part and they have yet to replace that part. It’s a year overdue from the timeline they claimed to be ready by.

The contact owns a 2019 Ford Explorer. The contact stated while driving approximately 75 MPH with the cruise control activated, the vehicle suddenly started sputtering and decelerated unintendedly. The vehicle was driven to the shoulder of the roadway, and the vehicle stalled. The vehicle failed to restart and was towed to the local dealer. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 52,000.

I have attempted multiple times to report Sync 3 screen issues with this vehicle. Began as intermittent issues. Screen would go off, get hung in reverse, unable to use touch screen, etc. Now, it is completely useless. Not able to use touch screen, not able to connect phone thru Bluetooth (making phone unusable), basically not unusable. I have no access to maps, any controls on screen. There's recalls on Explorers for this exact issue in 2020, etc models, so I am positive this same issue relates to mine. This is a very costly part to repair (we were quoted over $1200.00 by local Ford Dealership My car was barely out of warranty when this issue occured.

The contact owns a 2019 Ford Explorer. The contact stated that upon noticing that the roof rail cover was missing, the vehicle was taken to the local dealer, where it was repaired under NHTSA Campaign Number: 21V316000(Structure); however, the failure recurred. The contact stated that while driving at 30 MPH, the roof rail cover detached from the vehicle. The driver was able to retrieve the roof rail cover. The contact called the local dealer, but there was no response. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 63,000.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Subject: Urgent Complaint – Recall Repair Delayed Due to Unavailable Parts (2019 Explorer) To Whom It May Concern, I am writing to formally file a complaint regarding a safety-related recall/service campaign for my 2019 Ford Explorer (VIN: [XXX] ), specifically concerning the roof rack trim detachment issue (Customer Satisfaction Program / Recall #20N11 or 21S22). I visited an authorized Ford dealership to schedule the required repair, but was told that the necessary parts are currently unavailable, and no estimated delivery date could be provided. It has been an extended delay, and I am concerned about the continued safety risk this issue may present. As this is a known issue affecting many vehicles, I respectfully request: •A clear explanation of when the required parts will become available •An expedited resolution or alternative dealership that can complete the repair •A formal record of this delay for safety and warranty documentation purposes Please treat this matter as urgent. I would appreciate a prompt response with a timeline and any appropriate next steps. Sincerely, [XXX] Phone: [XXX] Email: [XXX] Location: Manhattan, New York VIN: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The bottom part that holds the windshield down is coming off. My windshield sounds like it is going to fly off when I drive. It makes a constant loud noise when driving. This has been an ongoing issue for almost 2 years. Ford told me they couldn’t do anything about it.

The contact owns a 2019 Ford Explorer. The contact stated that upon acceleration from a stop, the vehicle experienced a loss of automotive power. There were no warning lights illuminated. The vehicle was towed to a local dealer where it was diagnosed, and the contact was informed that the fuel pump and the fuel injectors were faulty and needed to be replaced. The vehicle was repaired; however, the failure persisted. The contact stated that on another occasion while driving 63 MPH, the vehicle lost automotive power. There were no warning lights illuminated. The vehicle was towed to a local dealer where it was diagnosed, and the contact was informed that the fuel pump and fuel injectors were faulty and needed to be replaced. The vehicle was repaired; however, the failure reoccurred while driving 72 MPH, and the vehicle lost automotive power. There was no warning light illuminated. The vehicle came to a complete stop and the contact called the Police for traffic control and the vehicle was towed to a local dealer to be diagnosed. The contact was informed that the fuel pump and the fuel injectors were faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 60,000.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was not yet available. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that the front driver’s side A-pillar trim had been ejected from the vehicle, and the passenger’s side A-pillar trim was cracked and not fully secured to the vehicle. The failure mileage was 104,000. VIN tool confirms parts not available.

Car would not start at certain times without warning. Sometimes putting us in an unsafe location. Finally vehicle was in a public parking and would not start and had to be towed to Ford dealer. The fuel pump and some other issues failed. Repair shop said it would happen with low gas, but we had over a half a tank. Total cost of bill without tow was $2132.02. Vehicle had 45,015 miles.

On 3 separate occasions my car has stalled when driving. All three were after driving for several hours in hot weather. 2 of the times I had a quarter of a tank of gas and pressed on the gas to pass someone and my car stalled out immediately after. Both very dangerous scenarios. 3 time just this week. Driving for over 5 hours in hot weather conditions, but 3 quarters of a tank of gas and stuck in traffic and the car just completely stalled. Again a dangerous scenario on the highway. All three times after waiting for about 45 minutes the car will start again. Sluggish at first and then drives normal. It’s giving indications that it could be a defect in the low pressure fuel pump that has been a recall in other 2019 ford explorers, but my vin #is not listed as one of them.

The contact owns a 2019 Ford Explorer. The contact stated while washing the vehicle in the driveway, the contact became aware that the A-pillar trim on the front passenger’s side had started to detach. The vehicle was not diagnosed by the dealer; however, a technician from the dealer went to the residence to inspect the vehicle. The vehicle was not repaired. The manufacturer was not notified of the failure. The contact related the failure to NHTSA Campaign Number: 24V031000 (STRUCTURE); and the VIN was included. The failure mileage was 73,441. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact stated while driving approximately 65 MPH, the keypad cover on the driver’s side door detached. The vehicle was taken to the dealer, who confirmed that the trim that had detached was not under recall. The vehicle was not repaired. The manufacturer was informed of the failure. The manufacturer opened a case regarding the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 68,000. The VIN was unavailable.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The A-PILLAR TRIM has flew off on the freeway on 4 separate occasions. 3 different times I paid out of pocket to have it repaired, not knowing this was a manufacture defect. Ford keeps saying that they do not have the parts to repair it.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

[XXX] � [XXX] [XXX] ⸻ To Whom It May Concern, My name [XXX], and I am writing to file a formal complaint against Ford Motor Company and multiple associated dealerships for gross negligence, financial harm, and discriminatory practices related to a recall repair that began in 2023 and has yet to be properly resolved. I own a 2019 Ford Explorer, VIN [XXX]. In 2023, I brought my vehicle to Wayne Akers Ford in West Palm Beach due to a torque converter recall. Before the issue was fixed, their transmission technician was fired, and I was redirected to Mullinax Ford. That began a two-year ordeal of being passed around between dealerships, misdiagnosed, and ignored while the original issue persisted. Alpaca Ford on 10th Avenue witnessed the malfunction twice but refused to repair it. I was told by Lenny, the Service Manager, and the Advisor Manager to “monitor the mileage” and report back — a delay tactic that eventually allowed them to deny my repair once the issue persisted at under 30 miles. When I returned with proof, they claimed the warranty had expired. This was caused entirely by their inaction and misguidance. To make matters worse: •I was forced to pay $1,300 for motor mounts that didn’t resolve the issue, despite telling them repeatedly it was unrelated. Ford covered a portion, but I was left to pay $897 out of pocket. •Tim Olsen at Wayne Akers Ford has refused to provide my refund and is now ignoring all calls and communication. •Ford’s corporate customer service has been involved from the beginning and failed to intervene effectively — despite acknowledging the situation. •I recently left a Google review describing my experience at Mullinax Ford, including my repeated denial of loaner vehicles while white customers were offered them freely. After posting the review, I was retaliated against — they refused to continue working on my car and told me to “come pick it up” without completing r INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

In February I was driving to an appt. when the side panel on driver's door broke & started flying around & hitting car. (It has the numbers to enter the car without a key.) So I had to roll down window 1/2 way, grab the broken part & drive 18 miles to town, holding the part so it wouldn't fly off (in 30 degree weather!) So I drove by the Ford Dealership where I got my car. They thought there was a recall on that item so I've been waiting. I just saw on the NHTSA site there was a recall for that item on 2016-17? Explorers, but mine is 2019!!! Would you please add the 2019 model to that recall? Also, I'm STILL WAITING (1 1/2 years later) for the recalled trim pieces around the front windshield.

The contact owns a 2019 Ford Explorer. The contact stated that upon start-up there was an abnormally loud rattling sound coming from the engine compartment, with the check engine warning light illuminated. The cause of the failure has not yet been determined. The manufacturer and local dealer were notified of the failure, but no assistance was provided. The failure mileage was 97,000.

The contact owns a 2019 Ford Explorer. The contact stated while driving at an undisclosed speed, the brake pedal became inoperable. There was no warning light illuminated. The contact stated that the brake pedal failed to function properly, and the contact had to depress the brake pedal with added force to stop the vehicle. The contact also stated there was an abnormal sound while depressing the brake pedal. The vehicle was towed to the dealer, where it was diagnosed and determined that the rear brake pads and rotors had failed, and the braking system needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was opened. The contact was also referred to the NHTSA Hotline for additional assistance. The approximate failure mileage was 36,000.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was not contacted. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the driver's side windshield exterior A-pillar trim had detached. The vehicle was taken to the dealer, who inspected the vehicle and advised the contact to apply tape on the windshield trim. The contact stated that the trim was taped; however, while driving 65 MPH, the driver's side windshield exterior A-pillar trim separated from the vehicle. Additionally, the contact stated that the weather stripping around the windshield was detaching. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure and informed the contact that the part was available at the dealer. The failure mileage was approximately 40,000. VIN tool confirms parts not available.

Difficulty getting the vehicle repaired in a reasonable time or without charge. Initial recall indicated parts would be available in the latter half of 2024. It is now mid 2025. Ford dealership indicates parts are not available for recall, BUT parts ARE available if I'd like to pay out of pocket for repairs. That seems fraudulent and the A-pillar trim on my vehicle is obviously defective and coming off the vehicle. This is hazardous and Ford should not be able to charge for repairs and not comply with the recall repairs.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the front driver's side windshield exterior A-pillar trim had detached. The vehicle was taken to the dealer, where it was inspected. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 95,000. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The windshield lower molding is deteriorating. The molding has cracked and fallen off in several places. This has been happening over the last 6 months but has gotten much worse. It also makes a buzzing vibration over 50mph. I'm afraid that if it gets any worse the windshield may pop out in an accident. Unknown Unknown No warning

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The A-pillar trim on the driver's side around windshield is coming off, and poses a risk to other drivers if it flys off while driving down the road. A recall on Ford Explorers of the same year is already issued, does not include the Police utility of same year.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated that while driving approximately 25 MPH, the driver's side A-pillar blew off the vehicle. The contact was unable to stop to recover the trim. The failure mileage was 25,000. VIN tool confirms parts not available.

Water is entering the rear liftgate which fills up during a rain event. This can potentially create problems with the electrical components mounted inside of the liftgate. i.e. Power door release, Rear defog, third bake light, window wiper, rear tail lights. These could short out or maybe cause a fire. It is already causing premature corrosion at the lowest end seam of the panel as the paint it now bubbling and beginning to seperate from the surface. This could also create a structural integrity issue with the liftgate. The rear glass is stationary. Not designed to open. Maybe this is a similar adhesion issue that the 2016 Transit connect had with the windshield which was recentlyn recalled for improper adhesion process/defect aloowing water to enter into the cabin.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted. The dealer confirmed that parts were not yet available. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact's wife owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact was unaware if a failure had been experienced. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact stated while driving 70 MPH, the driver’s side exterior A-pillar trim detached. The contact stated the front passenger’s side A-pillar trim was also starting to detach. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure; however, the manufacturer was unable to confirm when parts would be available. The failure mileage was unknown. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact stated that while driving at an undisclosed speed, the front windshield passenger's side A-pillar trim detached and flew off the vehicle. The dealer was made aware of the failure; however, the contact was informed that parts were not yet available to repair the vehicle. The contact engaged the parking brake and stopped the vehicle. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was unknown. VIN tool confirms parts not available.

Water pump went out that's for some reason located inside the engine causing the water to leak into my engine and lose all power functions to the car it completely shut down on the highway. It's 10,000 repair on a 5 year old car due to faulty water pumps ridiculous

The contact owns a 2019 Ford Explorer. The contact stated that while his wife was driving at an undisclosed speed, the passenger's side A-Pillar trim detached. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 24V031000 (Structure), but the VIN was not included. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 71,000.

I have been waiting on parts for the A-Pillar trim recall for a couple years. I've checked with 3 different local Ford dealers and have been told these parts are still back-ordered. This is a safety issue as the trim can detach while driving at higher speeds on the interstate.

The transmission was violently jerking when accelerating to get on the interstate. Our Explorer is available for inspection upon request. It was dangerous in that we couldn't have a consistent speed when joining oncoming traffic on the road. The local Ford dealer did confirm the transmission needed replacement. Ford did an inspection on the original transmission and confirmed it was damaged. It was a sudden failure of the transmission and it included a wrench light on the dashboard. We had a rebuilt transmission installed by the local Ford dealer which cost us over $9,400. This is known issue by Ford, especially for the Explorers, but they are not standing behind their powertrains. I contacted Corporate Ford to see about any goodwill, but they were not interested in providing any assistance.

The contact owns a 2019 Ford Explorer. The contact stated that after shifting to the drive position the vehicle would shake and vibrate. The failure continued while driving at various speeds. The vehicle was taken to the local dealer who replaced the torque convert and reprogrammed the PCM but approximately one year later the failure reoccurred. The vehicle was taken back to the dealer who diagnosed that the torque converter needed to be replaced a second time. The vehicle was not yet repaired. The manufacturer was notified of the failure but no assistance was offered. The failure mileage was 83,000.

The contact owns a 2019 Ford Explorer. The contact stated that the windshield cowl panel had partially separated from the vehicle. Additionally, the contact stated that the failure had caused the vehicle to make abnormally loud air pressure sounds while driving. The vehicle was taken to the dealer, where it was determined that the windshield cowl panel needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 54,271.

The contact owns a 2019 Ford Explorer. The contact stated that while accelerating, the engine made a winding noise and hesitated before accelerating. The contact noticed white smoke coming from the rear end of the vehicle. The smoke was coming out of the exhaust pipe. The vehicle was taken to an independent mechanic who diagnosed that the right and left superchargers had failed, causing oil to get into the exhaust, causing the smoke. The vehicle had not been repaired. The mechanic referred the contact to the dealer for assistance. The contact became aware of NHTSA Campaign Number: 24V635000 (Engine and Engine Cooling). The dealer was contacted, and an appointment was scheduled. The manufacturer was made aware of the failure and opened a case. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 56,000.

The contact owns a 2019 Ford Explorer. The contact stated while driving 45 MPH, while depressing the accelerator pedal the vehicle failed to respond as needed. No warning lights were illuminated. The contact stated that the vehicle was shielded by a bystander so that the contact would not be rear-ended. The vehicle was towed back to the residence. The vehicle was taken not to the dealer to be diagnosed. The contact stated that cylinder #2 had been replaced three times and the spark plugs were replaced; however, the vehicle was not fixed. The manufacturer was notified of the failure but offered no assistance. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 99,000.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed, the front driver’s and passenger’s side A-pillar trims detached. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,000. VIN tool confirms parts not available.

The molding around my windshield is no longer there due to a recall from 1/19/24. I am no worried that either my windshield could fall out or that I might get water damage in my vehicle from the missing molding that goes around the windshield. The recall is for the A-Pillar trim and that is what I am referring to.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated while driving 70 MPH, the driver’s side A-pillar trim separated from the vehicle. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact then received a call from the same dealer and was informed that parts were available, and an appointment was scheduled. The contact arrived to the appointment and waited for 2 hours before being notified that the part was not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue but offered no assistance. The failure mileage was approximately 52,000. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact received a notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that upon inspection, he noticed the sealant on both the front driver side and front passenger side A-pillar trims had started to deteriorate. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made not aware of the failure. VIN tool confirms parts not available.

The contact owns a 2019 Ford Escape. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

At two different times and locations, the side piece on the front windshield have become disconnected and flown off while traveling down the highway. The recall has been in effect for over a year and still no dealerships around me have the parts to fix the recall.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The contact stated while driving on the highway at 70 MPH, the A-pillar trim detached from the vehicle. There were no warning lights illuminated. The vehicle was taken to the dealer to be diagnosed; however, the part to do the recall was unavailable. The manufacturer was not made aware of the issue. The failure mileage was approximately 149,937. VIN tool confirms parts not available.

When i go to drive my car in the mornings when it first starts up I have to let it sit or it won't accelerate and if I just try to drive it the powertrane warning light comes on but it will be gone when I let it sit off for a bit. The ford dealership stated it was the torque converter and have replaced it twice in less than two years.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated while driving approximately 70 MPH on two occasions, the driver's side and passenger's side windshield exterior A-Pillar trims separated and flew off the vehicle. An unknown local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 32,000. VIN tool confirms parts not available.

Nov of 2023, overheated but no leak from engine was found and no antifreeze in radiator. TOOK to Mckie Ford they replaced the valve and noted thst there was antifreeze in the valve chamber and stated we needed a new engine. We purchased a new engine had it installed in Jan 2024 we paid for new engine. When we should not have as we did research on the engine and it was faulty but no recalls were in place at that time so we joined a claims action suit to help recover costs..

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that twice while the vehicle was being washed, water leaked into the cabin through the top front passenger’s side window. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 86,000. VIN tool confirms parts not available.

I hand washed the vehicle on 1/10/2025 and noted no defects. On [XXX] traveling northbound on [XXX] in the vicinity of Ontario, California at approximately [XXX], I heard a "clunk," but did not observe any road hazard. Upon arriving at Ridgecrest, California I discovered that the passenger pillar applique was missing. I reported event to service at Jim Charlon Ford and was informed that currently no fix available. On 1/14/2025, I had Jim Charlon Ford remove the driver side pillar applique remove for purposes safety. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2019 Ford Explorer. While the contact's husband was driving at various speeds, the transmission was slipping. The contact stated that the failure mostly occurred while driving and depressing the accelerator pedal with the transmission shifting between second and third gear. There was no warning light illuminated. The vehicle was taken to the dealer and was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced; however, the vehicle was not repaired due to the cost. The vehicle was then taken to Pioneer Transmission Services, where the transmission was replaced. The contact stated that the transmission warning light illuminated while driving at an undisclosed speed. The vehicle was taken back to Pioneer Transmission Services, where the torque converter was replaced. The vehicle was repaired. The manufacturer was notified of the failure and informed the contact that the VIN was not included in an unstated related recall. The failure mileage was approximately 84,000.

The contact owns a 2019 Ford Explorer. The contact stated while the vehicle was parked, the contact noticed a burning odor. The contact stated that later when the vehicle was started, the back over prevention camera display was black. In addition, several unknown warning lights were illuminated. The vehicle was taken to the dealer where it was diagnosed with a wiring harness failure. The contact was informed that the rear wiring harness needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 75,000.

In October of 2022 a the top part of exterior trim beside my windshield pulled away from the vehicle. I took it to our local auto shop and they cleaned the adhesive off the lower piece of molding and installed a new top molding. I paid $166.15 for this repair. Then in March of 2023 I was driving on the freeway when this same piece of trim suddenly flew off the vehicle just missing the car behind me, I took it to our local auto shop and they replaced the piece at a cost of $344.10. Then in June of 2023 the same piece flew off again while I was driving on the freeway, again just missing the car behind me. This time I paid $374.16 to have the piece replaced again, In February of 2024 I received a Safety Recall Notice from Ford and NHTSA saying the there is a defect with my vehicle and the A pillar applique trim clip attachments are not properly engaged due to improper assembly or repair. I took the vehicle to a Ford dealership after receiving this notice and was told there was not yet a remedy and I would be notified when there was one. I have checked the NHTSA website several times since then since then and it indicated that a remedy should be available by the end of 2024. However, it is now mid-January 2025 and still no remedy and I have paid more than $800 to temporarily repair this issue.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated while driving at various speeds, the driver's side and passenger's side windshield exterior A-pillar trims were shaking. The vehicle was taken to the dealer, where it was inspected, and the dealer confirmed that the trims needed to be replaced. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 60,000. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE) however, the part to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Vehicle shutters during acceleration due to torque converter failure. Vehicle shutters while traveling due to torque converter failure. Vehicle jerks when transmission is shifting due to torque converter failure. The vehicle was brought to the Ford dealer without the check engine light or mechanical light on. The Ford dealer was able to verify the above listed issues and deemed the torque converter failed. The ford dealer quoted me $4,000.00 for repairs. The torque converter failures in these vehicles is a common issue that Ford has failed to fix that can cause accidents and harm to persons involved due to bad design of the torque converter and transmission.

My engine is having to be replaced. It's at 100k miles. Costing me $5k for a replacement that is a used engine with 77k miles and 1 year warranty. I want to file a complaint. Car is still in the shop and I had to get a rental. I am a single mom with two kids. I had to pay all of this out of pocket.

It has been more than a year later, Ford has not resolved the issue with the exterior A-Pillar. The response at the dealership has been, A) we do not have the parts or B) If you pay for them out of pocket, we can fix the issue. Which tells me they can fix the issue but chose to not do so because they are banking on owners paying for this recall. What recourse do I have?

The contact owns a 2019 Ford Explorer. The contact stated while driving at an undisclosed speed, the A-pillar trim on the driver’s side of the windshield started to detach. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The vehicle was taken to the dealer where it was diagnosed that the A-pillar trim retention clips failed and needed to be replaced. The vehicle was not repaired. The contact was informed that the remedy was not available for the failure of the vehicle. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The approximate failure mileage was 59,000. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact stated while driving at an undisclosed speed, the A-pillar trim on both sides of the windshield started to detach. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted, and the dealer stated that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The approximate failure mileage was 98,000. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the driver's side and passenger's side windshield exterior A-pillar trims had detached and were making an abnormal sound while driving. The local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 39,000. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact stated on several occasions while the vehicle was parked or while driving at various speeds, the side mirrors failed to tilt left or right but tilted up and down. The contact manually moved the mirrors for proper visibility. The vehicle was taken to a dealer where it was determined that the switch on the driver’s door was inoperable and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 43,000.

The contact owns a 2019 Ford Explorer. The contact stated while driving approximately 65 MPH, the passenger’s side B-pillar trims blew off the vehicle by the slip stream. The contact stated that the vehicle was taken to a local dealer who replaced the trim. The contact stated that the trim on the driver's side B-pillar was now loosened. The contact called the dealer and was informed that the B-pillar trim was not included in NHTSA Campaign Number: 24V031000 (Structure); and would be an out-of-pocket expense for the repair. The contact was concerned that the B-pillar trims should also be recalled due to the failure. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 76,000.

Code P0301 can’t pin point issue

The contact owns a 2019 Ford Explorer. The contact stated while driving at an undisclosed speed, the A-pillar trim on the driver side of the windshield started to detach. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The vehicle was taken to the dealer but was not diagnosed or repaired. The dealer informed the contact that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The approximate failure mileage was 60,292. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

2019 Ford Explorer XLT with FWD Transaxle transmission and 46,107 miles on odometer, purchased in November 2018 and now 5 years old this month. Way too early for a transmission failure to occur. Normally drive the posted speed limit unless changes in the traffic patterns slower or a little faster.8 Heard a noise from left front wheel area when accelerating and slowing/re-accelerating in traffic. Extended service plan expired (5 year, 60,000 miles, Nov 2018-Nov 2023). Took car to local garage, did a test drive and checked by mechanic. It was determined that problem came from transmission. There have been NO warning lamps, messages, etc. prior to me noticing the problem and nothing since mechanic checked the vehicle. Sounded like the right front wheel area made a noise when turning around in a parking lot this morning. Mechanic estimated cost to repair with parts, labor, etc., will be $6,245.90 out of pocket.

The contact owns a 2019 Ford Explorer. The contact stated while driving 45 MPH, there was a rattling sound coming from the roof of the vehicle. The vehicle was stopped and inspected, and the contact observed the right and left roof rails, had separated in several areas. The vehicle was taken to a dealer where it was determined that the roof rails needed to be secured in place. The vehicle was repaired but the failure reoccurred. The vehicle was then taken to the same dealer where it was determined that the roof rails needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 79,000.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000(Structure); however, the part to do the recall repair was not yet available. The contact stated that both the driver's side and the passenger's side windshield exterior A-Pillar trims had separated from the vehicle. The local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 99,000. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact stated while driving at an undisclosed speed, the driver's side windshield trim detached and flew off. In addition, the contact stated that the passenger's side windshield trim had detached and was held in place with tape. The dealer was made aware of the failure; however, the contact was informed that the parts were not yet available. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was 89,000. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000(Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and confirmed that the parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact stated while driving at approximately 55 MPH, there was an abnormal sound coming from the roof. The contact stated that it sounded like an object bouncing on the roof of the vehicle. The contact stated that the sound ceased after several minutes. The contact arrived at the destination, checked the roof, and became aware that the passenger’s side roof rail had detached from the vehicle. The vehicle was not taken to a dealer or independent mechanic to be diagnosed or repaired. The contact researched online and related the failure to NHTSA Campaign Number: 21V316000 (Structure); however, the VIN was not included. The manufacturer was informed of the failure. The failure mileage was approximately 54,000.

The contact owns a 2019 Ford Explorer. The contact stated that while driving approximately 65 MPH, there was an abnormal anti-freeze odor inside the cabin of the vehicle. The contact stated that the "overheat" and "temperature" gauge illuminated. The contact drove the vehicle back to the residence, parked the vehicle, and observed that anti-freeze was leaking onto the driveway. The contact had the vehicle towed to an independent mechanic and was informed that the water pump had failed and needed to be replaced. The contact was referred to a dealer for assistance. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 70,000.

The contact owns a 2019 Ford Explorer. The contact stated while driving 25 MPH, the exterior A-pillar trim detached from the vehicle. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure; however, was unable to confirm when the part would become available. The failure mileage was 85,000. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000(Structure); however, the part to do the recall repair was not yet available. The contact stated that the upper part of the driver's side windshield exterior A-Pillar trim was fractured, causing the trim to detach. An unknown local dealer was notified of the failure. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 120,000. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact stated that while driving at 40 MPH, the trim piece detached from the vehicle. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE) however, the part to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure however was unable to confirm when the part was to become available. The failure mileage was unknown. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact stated while the vehicle was at the dealer for a routine oil change, it was discovered that the roof rack was loose and advised the contact to bring the vehicle to the dealer the following day to have it inspected. The vehicle was taken back to the same dealer the following day as instructed and it was advised that the roof rack needed to be replaced. The vehicle was previously serviced under NHTSA Campaign Number: 21V316000 (STRUCTURE) however it failed to prevent the risk. The vehicle was not repaired due to it being out of warranty. The manufacturer was notified of the failure. The approximate failure mileage was 32,000.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

For months, almost a year, my transmission could not properly accelorate. The car would not allow for the pick up in speed to happen. Each time I took it to the shop that cares for my car, Mike's More Miles, the problem would not duplicate. My special needs son, his service dog and I were all of the expressway traveling, the car slowed down on its own, I had not applied the brakes, the speed dropped from 65 to less than 35 in seconds. I pulled over and tried to regain speed after putting the car into park. No luck. the car would not go faster then 20-30 miles an hour, with me putting into neutral when coasting downhill, then back into drive manually to get it to the repair shop. This almost caused a terrible accident. This scared my son, who has brain disease. Our 85 lb. service dog was jolted from the back of the car slamming into the seat. I was also very scared and shaken. My son began to yell and scream what is happening, it was a scary and tense, literally jaw dropping experience. I drove to Enterprise Rental, called Austin the owner of the shop that has tried to duplicate the problem on a dozen tried and told him what occurred. I left my car at Enterprise, where Austin picked it up. The problem did duplicate. FINALLY a code came up to diagnose the problem. The transmission fluid was also black, with metal shavings in it as well. Please refer to all technical service bulletins that note this is a known problem by Ford. I have paid $7582.70 for a new transmission. The shop owner, Austin, told me the torque converter overheated, the transmission had failed. I also paid for the rental car an estimate of $490.00.

The contact owns a 2019 Ford Explorer. The contact stated while driving at an undisclosed speed, the Forward Collision Avoidance camera failed to function as intended. The contact stated that the Forward Collision Avoidance camera displayed a very blurry image. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The dealer was made aware of the failure. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 68,500.

Vehicle lost acceleration while driving down highway and shuttered severally when depressing gas pedal. I had to cut across lanes of highway traffic with no power and nearly caused an accident. Engine revs up be vehicle wont accelerate, just shakes badly. I am waiting on a mechanic to verify the problem but appears to be a transmission failure. The vehicle has had hard shifting in recent months leading up to this failure. A 2019 model year with 105000 miles.

Rear left toe link failed while entering a curved freeway on ramp. Failure caused the vehicle to lose traction in the rear causing the vehicle to fish tail. Advanced drivers training prevented a collision but the vehicle swayed back forth due to the forward momentum. By a miracle there was no collision because it was a narrow two lane road, with no shoulder and was between concrete wall and guardrail.

See attached document for complaint.

I am writing to formally file a complaint regarding my 2019 Ford Explorer, which is currently subject to the 2011–2019 Ford Explorer — A-Pillar Trim Detachment Recall (Recall Reference Number: 24S02). The exterior A-pillar trim on my 2019 Ford Explorer, covered under the aforementioned recall, has caused severe issues including vibrations and a loud whistling noise around the windshield area, particularly at highway speeds. These problems are not only a nuisance but also pose a potential safety hazard, as the vibrations could lead to more severe structural damage or detachment of the trim while driving. I have contacted several Ford dealerships in my area, as well as Ford headquarters, seeking a resolution under recall 24S02. Unfortunately, I was consistently informed that the necessary parts to correct the issue are not available. I was told that Ford had provided the parts, but they were only available for a two-week period and are no longer in stock. The person I spoke with at the dealership advised me to call back at a later time to check if the parts are available. Additionally, when I reached out to Ford’s headquarters customer relations department for further assistance, I was simply transferred to my local dealership without any other form of help or guidance. This lack of support from the manufacturer is deeply frustrating and concerning. Furthermore, one of the dealerships informed me that another customer with similar issues under the same recall has been waiting for over a month and has yet to receive the necessary parts. This delay, coupled with the lack of clear communication and guidance, is highly concerning, especially given the potential safety risks associated with the defect. Given the severity of the issue and the inadequate response from Ford, I am requesting that the NHTSA intervene to ensure that Ford takes the necessary steps to resolve this safety concern promptly. I am concerned that a serious incident can occur if not resolved.

The contact owns a 2019 Ford Explorer. The contact stated that while driving at an undisclosed speed, after a visual inspection of the exterior of the vehicle, the contact became aware that the shark fin antenna cover had detached, potentially becoming a dangerous road hazard. The vehicle was taken to the dealer, who was unable to determine the cause of the failure. The dealer determined that the shark fin antenna cover had detached independently. The vehicle was not repaired. The manufacturer was notified of the failure but did not assist. The failure mileage was 32,000.

The contact owns a 2019 Ford Explorer. The contact stated upon inspection, it was noticed that the B-pillar applique trim was peeling off. The vehicle was taken to a local dealer where it was diagnosed that the B-pillar applique trim needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 75,000. The VIN was not available.

The contact owns a 2019 Ford Explorer. The contact stated while driving approximately 70 MPH, the vehicle lost motive power, decelerated, and stalled. The vehicle was later towed to the local mechanic who diagnosed that the water pump was faulty and needed to be replaced. The water pump was replaced, and the vehicle was repaired. The manufacturer and local dealer were notified of the failure, but no assistance was provided. The failure mileage was unavailable.

The contact owns a 2019 Ford Explorer. The contact stated that while depressing the accelerator pedal, the vehicle shuddered and failed to properly accelerate. The contact stated that the failure also occurred on several occasions while driving up an incline. The vehicle was taken to the local dealer to be diagnosed and it was determined that the transmission was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 84,000.

The contact owns a 2019 Ford Explorer. The contact stated while driving at 75 MPH, the driver's side windshield exterior A-pillar trim separated and flew off. The contact stated that the failure caused the passenger's side of the windshield to become fractured. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. No further information was provided. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was 78,532. VIN tool confirms parts not available.

Vehicle suddenly began vibrating while in drive or reverse, and developed decreased acceleration, and overall sluggish performance. Mechanic checked and said it was the torque converter. This exact problem is addressed by a Customer Satisfaction Program 20N07, which seems like it should include my vehicle because it was manufactured in the covered location and dates. However, my VIN number does not appear to be covered.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Rough idle in drive and reverse, hard shifting or not shifting In to gear

The vehicle vibrates excessively when shifting into Drive or Reverse (rough idle). Additionally, the vehicle lacks acceleration/power when driving in slightly uphill roads, creating a hazard for nearby drivers. There were no check engine lights and the issue first appeared at approx. 84,000 miles. The vehicle was diagnosed at a Ford dealership and the issue was determined to be the torque converter. The Ford Service Dept cited TSB 22-2287 and recommended replacing the full transmission to fix the issue.

EXTERIOR A-PILLAR TRIM PART DETACHED, NOW CAUSED CRACKED WINDSHIELD WHERE TRIM WOULD HAVE BEEN. THE PART HAS BEEN DETACHED FOR MONTHS AND MY LOCAL FORD DEALERSHIP HAS NO TEMPORARY OR PERMANENT SOLUTION. MY WINDSHIELD NOW HAS A SPIDERING CRACK WHERE IT WOULD HAVE BEEN PROTECTED .

The contact owns a 2019 Ford Explorer. The contact stated that there was an orange wrench warning light was illuminated when the vehicle was shifted into reverse. The vehicle was towed to the dealer where it was diagnosed, and it was determined that the failure was with the torque converter. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The vehicle was towed to an independent mechanic where the same information was provided. The vehicle was not yet repaired. The manufacturer was notified of the failure and advised to contact NHSTA Hotline for assistance. The approximate failure mileage was 65,000.

I was putting my car in reverse and all of a sudden, it shifts really hard and makes this loud noise. I thought it was very strange, and put it in drive and went not even 2 minutes and my car had no power. I was pressing the gas pedals but it didn't want to go. I stopped it and called a Tow truck to come get my car and take it to the nearest Ford dealer. They called me in a few days advising that the transmission was gone. After researching online, I noticed a lot of Ford Explorers being recalled for this exact issue, including My sisters Ford Explorer. Hers was under the recall, and Ford paid for hers. Ironic, the same thing happened to mine and mine has no recall. My car had been running fine, up until this day. I have maintained this car and no warning lights ever came on, until I put it in drive and the Orange Wrench cam e on. I knew something was wrong then. I am a single mother of a [XXX] and this could have put us in alot of danger INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2019 Ford Explorer. The contact stated while driving 65 MPH, the A-pillar trim on the passenger’s side windshield started to detach. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The local dealer was contacted, and the dealer stated that parts were not yet available. The contact was charged for the vehicle to be diagnosed. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and referred the contact to the NHSTA Hotline for assistance. The approximate failure mileage was 56,000. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving approximately 62 MPH, the front driver’s side door keypad detached and caused a short circuit in the battery causing the battery to fail. The battery was replaced, and the keypad was repaired but shortly afterward the keypad detached and flew off the vehicle on the highway and the battery failed again. The contact referenced the failure to TSB: 19-2150 (Factory Keyless Entry Keypad). The dealer was made aware of the failure. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 19,000. VIN tool confirms parts not available.

I took my vehicle last year to the dealership to report the safety concern I had with a loose piece under my hood causing a flapping sound while driving. They determined the exterior a pillar was warped, loose and missing pieces. I received the recall in the mail a few weeks later, although they will not set up an appointment for me to resolve this issue. Not only does it state this is a potential safety concern, it has already been established this piece is defective on my vehicle. I also drive fellow associates around to meetings in my vehicle and it is putting them in danger along with myself and is bringing concerns it has not yet been addressed. The recall was sent to me a few weeks later on 01/26/2024.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was not made aware of the issue. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Airbag light has come on, states second row passanger side airbag inflatable circuit (inflatable seatbelt). Just purchased vehicle two days ago.

The contact owns a 2019 Ford Explorer. The contact stated that the roof rail had detached. The local dealer where the vehicle was diagnosed determined that the roof rail needed to be replaced. The contact stated that the roof rail was temporarily fixed with tape. The vehicle was not repaired. The contact was made aware NHTSA Campaign Number: 21V316000 (Structure). The manufacturer was made aware of the failure. The failure mileage was approximately 21,000.

The contact owns a 2019 Ford Explorer. The contact stated while driving approximately 65 MPH, the passenger's side A-pillar trim detached and made a loud popping sound. The contact stated that the driver's side A-pillar trim was extremely loose. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The vehicle was taken to the dealer. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made of the failure. The failure mileage was approximately 63,250. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact stated that the exterior pillars on both sides of the window had detached. Additionally, the contact stated that while driving on several occasions over 30 MPH, she observed a loud buzzing noise and wind coming through the sides of the windshield. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 76,000.

The windshield cawl ( bottom piece that goes across windshield) has deteriorated. Making a whistling sound going down the road. I have already in December 2023 had to replace the A pillar trim and clips on driver side. Have talked to other explorer owners having the same issue. Thank you for your time

The contact owns a 2019 Ford Explorer. The contact stated while driving approximately 60 MPH, the vehicle began making abnormal noises from under the floorboards. The contact stated that the vehicle was losing forward momentum. The contact depressed the accelerator pedal and the vehicle only revved and was not gaining forward momentum. The contact stated numerous warning lights were illuminated. The contact stated that he was able to reach his destination, but was not able to exceed 30 MPH. The contact was able to drive the vehicle to a dealer; however, the vehicle was not diagnosed or repaired. The contact stated that the transmission had been replaced a year prior and felt that the failure was related to the transmission. The manufacturer was not informed of the failure. The failure mileage was approximately 52,000.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

I was traveling on the interstate (~75 mph) when the rear of my vehicle suddenly jerked to one side with enough force to cause a loss of control. There were no lights or warning sounds to indicate that there was anything wrong with the vehicle in that moment or leading up to it. I was fortunate enough that no contact was made with any other vehicles as my car crossed all three lanes; from the center lane to the far right and then back across all three lanes to the far left. The car skidded off the highway and slid onto a sloped embankment before it stopped. Obviously, I or someone else could have been seriously injured or even killed. I was able to drive the car back up on the shoulder of the highway. Everything was functioning properly EXCEPT the steering. I was able to drive at ~15 mph to the nearest exit. I was then towed to my mechanic's shop. The tow truck driver said it looked like my right rear tire was about to "fall off" and that I was very lucky. My mechanic took pictures of the damaged part (Right Rear Toe Arm) both on the vehicle and again once removed. He checked with Ford for a recall and found out that this part had been part of a recall on Explorers from 2012-2017, but not on the 2019. Assuming the part had been redesigned after 2017, he ordered a replacement for the right. (The Left Toe Arm was not damaged.) However, once the replacement part arrived, it was a completely new design from the 2019 Toe Arm. He recommended I replace the Left Toe Arm as well since the parts were so different. My right shock absorber was also damaged in the accident and had to be replaced.

The B-pillar trim piece has become detached from the vehicle due to broken clips and when driving it appears as if it will fall off. Ford will not address the issue, other then using two sided adhesive tape which needs to be replaced continuously. The clips that hold the trim in place are broken and this is common on many explorers. There are other body trim pieces which have been recalled for and this needs to be added as well. The A-pillar trim was recently a recall item and this is just as much a hazard.

The contact owns a 2019 Ford Explorer. The contact stated that there was rust on the aluminum hood, which had bubbles and rust. The vehicle was taken to the local dealer, who stated that the hood needed to be replaced. The vehicle was not repaired. The manufacturer was contacted, but no additional assistance was provided. The failure mileage was approximately 18,600.

The contact owns a 2019 Ford Explorer. The contact stated that there was an abnormal sound coming from the vehicle. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The approximate failure mileage was 38,000. VIN tool confirms parts not available.

My wrench light came on in my 2019 Ford Explorer with 2.3L engine last week. It caused my vehicle to have lack of acceleration during launch and shudder while driving. When my son and I took off from a stop, it was very slow when crossing traffic. Made appointment with Ford dealership to have it looked at the next morning. After car was parked and restarted, wrench light went off. Kept appointment and told them a mechanic friend said it sounded like the torque converter (which my mother who has a 2019 Ford Edge just had replaced the week before!). Explained this to the dealership, they said it didn't sound like that was it. 4 wheel drive module was corrupt so they updated it and told me I may need a new transmission in the near future. Today, my light came on again while taking my son to school and caused lack of acceleration while pulling onto the highway and I took it to the dealership while it was lit up. Codes P0767 and P2704 showed and they told me it was I needed a new transmission due to my torque converter failing. I checked into it and Customer Satisfaction Program 20N07 does not include my car even though it is doing the exact same thing and was assembled in Chicago in January 2019 (timeframe of the program and location). I just don't understand how my car doesn't fall under that program when it is DOING THE EXACT SAME THING with only 67,200 miles on it. This is a serious safety concern. So thankful that there was not heavy traffic when I pulled onto the highway.

The contact owns a 2019 Ford Explorer. The contact stated that the horn was inoperable. There was no warning light illuminated. The dealer was notified of the failure and an appointment was scheduled to perform a diagnostic test. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 74,000.

The contact owns a 2019 Ford Explorer. The contact stated that while driving at an undisclosed speed, the exterior B-Pillar trim detached. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 24V031000 (Structure). The manufacturer was notified of the failure but provided no assistance because the recall did not include the B-Pillar. The failure mileage was 96,000.

Drivers door will not lock. It will only lock if you push it down but doesn’t lock when taking off like it’s supposed to for safety.

Needs a full transmission replacement and only have 80,000 miles on it. Bought new from dealership in 2019.

The A-pillar passenger side flank flew off while driving.

Operator law enforcement was idling for an extended time in this vehicle. He was found unconscious in the vehicle and diagnosed with acute carbon monoxide poisoning. He was hospitalised for 4 days, and suffers continuing neurological deficits. Post-incident testing by engineer instructed by operator indicated two improper or incomplete welds on exhaust system, allowing exhaust to pool under vehicle and enter passenger compartment through HVAC fresh air intake. Post-incident testing recreated rising CO levels in passenger compartment. Vehicle has also been inspected by manufacturer. There were no warning lamps or messages.

VEHICLE SHIFTS ROUGH. I WAS TOLD BY FORD THAT I NEED TO REPLACE MY BATTERY EXCEPT I DO NOT HAVE ANY BATTERY ISSUES AT ALL. ALSO WHEN I PUT MY VEHICLE IN PARK IT ROLLS FORWARD A LITTLE.

The contact owns a 2019 Ford Explorer. The contact stated that the front windshield was slightly detached from the vehicle. While driving at various speeds there was a whistling sound coming from the windshield. The vehicle was taken to an auto body shop where it was diagnosed that there was mold along the sides of the windshield panel causing the windshield to detach. The vehicle was not repaired. The manufacturer was made aware of the failure, and it was confirmed that there was no recall on the VIN for the failure. The contact was referred to the NHTSA Hotline for assistance. The approximate failure mileage was 50,000.

My 2019 Ford Explore XLT wouldn’t shift right, kinda hesitated to lock. My RPM were jumping like crazy. My mechanic replaced my torque converter and throttle body. Now my vehicle drives fine but when you stop at a stop light it shakes you to death. Then it sputters when trying to accelerate. So back to the shop it went because that can cause an accident. Not to mention if it stalks while driving. My mechanic says my torque converter is [XXX] again. After paying $4000 to have my transmission basically rebuilt a year later I’m back in the same boat. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The trim that is on either side of the front windshield has come loose. The one on the driver side came loose while I was on the interstate and struck the vehicle behind me. It caused the driver to lose control and spin out. Fortunately, it did not cause a collision, but it could have caused a loss of life, we were travelling at highway speeds. The trim on the passenger side was still on the vehicle, but it had popped loose and was sticking up at an odd angle. I removed it to prevent the same thing from happening.

I purchased a Ford certified 2019 Ford Explorer recently. It is my 20th Ford. I could barely hear the horn and thought there was a problem with one of the horns. I researched it and found that the 2019 model year only came with one horn. The horn is at the front of the hood and when I checked there was a bracket for 2 horns but there was only one. You almost can not hear it when inside of the car and it makes me think that others may not hear it if there is an emergency. I have owned close to 70 cars and I have never had a car with one horn. A moped has a louder horn. In my opinion Ford should not have tried to save $5 that could cause an accident. I had to order Ford part number GB5Z-13832-A which are the dual horns found on the other model years. My safety and the safety of other 2019 Ford Explorer owners is at risk because of this.

coolant leaking into engine 2.3l eco boost

Dec 2022- Windshield trim on passenger side ripped off while driving on the interstate. Sept 2023- noticed noise while driving. Checked driver side trim and noticed seal was gone. Trim was cracked along its entirety. Replaced before it also flew off

Doing 70 mph and trim along passenger windshield broke in half and flew off

OEM Ford Gen 4 SYNC 3 Nav APIM suddenly started sporadically functioning. Contacted Ford after viewing multiple recalls from previous years Ford vehicles with exact issue. After being told there was no recall on my 2019 Explorer, was given a quote of $170.00 to diagnose issue, $900 + for APIM module, plus installation and programming. We purchased a re-programmed APIM module and installed. Problem is now corrected. Recall needs entered on this unit. Attaching photos of front & back of bad unit: WY1W748K GR26A KB5T-14G370-DCA SERIAL NO. 205831 MFG - JANUARY 2019 ASSY NO. MAJ0673GX PANASONIC AUTOMOTIVE SYSTEMS MODEL FA-170-BCAR-HS IFT# RCPPAFA16-2032 FCC ID: ACJ-FA-170-BCARHS IC ID: 216B-FA170BCARHS ANATEL ID: 05008-16-09014 CMIIT ID: 2016AJ4795

The driver's side exterior windshield moulding detached from the vehicle traveling at interstate speed (75 mph) and struck the driver's door above the window. The apparent cause of detachment was failure of the retaining clips and adhesive that holds the external piece to the internal rubber moulding.

Driver side pillar molding next to the windshield flew off unexpectedly while driving on the highway.

The contact owns a 2019 Ford Explorer. The contact stated while driving at an undisclosed speed, the vehicle shuddered while shifting gears. The vehicle was taken to the dealer, who informed the contact that the power transfer unit (PTU) needed to be replaced. The vehicle was repaired. The contact related the failure to the Customer Satisfaction Program: 20B27. The manufacturer was not made aware of the failure. The failure mileage was approximately 90,000.

Rear toe link and bushing issues. I have the same car as my sister. She has a 2016 with the same rear toe link as my 2019 and her car is covered under the recall and mine isn't.

Windshield trim falling off and deteriorating - windshield rattling - took to dealer to replace windshield trim - paid 642.00 to replace deteriorated trim - want a recall on this as it is very dangerous/ I also want reimbursement of 642.00 for repair

When the vehicle is in outside in the direct sunlight, the extreme heat causes the fuel pump driver module to fail. When this module fails, it cause the vehicles fuel pump to stop sending fuel to the motor which causes the vehicle to turn off or run extremely rough, while driving and or stationary. The moduel has been replaced by world ford Pensacola once, and twice by an ASE Certified Master Mechanic, on 3 separate occasions.

The rear camera failed and it was discovered a corroded connector and cable. This is causing rear camera to fail. Ford helped with the repair cost however, the entire cable was replaced. Waited 5 months. This is a common problem and FORD should cover the refund and recall. The cameras are on a recall but not the cables that are causing the camera to fail. The repair costs like $2000. Ford did help. This is a manufacturer defect and the problem is common. Please see pictures and the video link. https://youtu.be/ewz_OeFO_6M

The contact owns a 2019 Ford Explorer equipped with Hankook Tires, Tire Line: Ventus S1 Noble 2, Tire Size: 255/50/R20, DOT Number: (Unavailable). The contact stated that the tread on all four tires were extremely low. The vehicle was taken to a tire shop where the tread depth was measured. The manufacturer was notified of the failure and the contact was informed that the VIN was not included in TSB: SSM46905 and advised the contact to call the NHTSA Hotline for assistance. The failure mileage was approximately 19,700.

Passenger's side A pillar trim piece broke and flew off at highway speed. This seems to be a previously identified manufacturer's defect not yet recalled.

Windshield trim piece (passenger side) detached from vehicle while travelling at 40 mph.

I bought Ford Explorer 2019 brand new. I think first week of January 2023 My wife mention 3 times the car lost power and powertrain light on. She was afraid this happens in the freeway so I took to Ford dealer and they took around 3 month to repair.

Windshield and door trim is coming unglued and flaps while driving normal highway speeds.

Passenger side window trim blew off at highway speed without warning. Have not had it to the dealer yet as this appears to be a problem for the Explorer. I am not sure where the piece ended up. There was not a vehicle immediately behind the car so I don’t believe it struck anyone.

When the temperature outside is higher than an estimated 80 degrees the Battery indicator appears on the dash and the Ford Pass app tells me that there is a Charge System Fault. "The Battery light indicates that your vehicle has a concern with the 12-volt charging system." I have had a Ford Dealer check into this when I was under lease and they said they were unable to duplicate the warning. I also had an independent service center look into this and we decided to replace the battery and the battery terminals. However the alert still appears in the higher temperatures after making the change. I have seen this alert more than a dozen times having leased the vehicle from Ford from April 2019-April 2022 then purchasing the lease in April 2022. The date below indicates the last date the alert occur (5/12/23)

We were traveling on I90 west of Sioux Falls, SD. 06-01-2023. There is a 14 mile stretch that is under construction and the traffic is head to head in that stretch. We met a semi that created a gust of wind that blew the front window trim off the passenger side of the vehicle. I do not know where the trim went once it exited the vehicle. It was in an area where construction workers were working along side of the road and there was a line of cars behind us.

The contact owns a 2019 Ford Explorer. The contact stated that while driving at an undisclosed speed, the vehicle shuddered. The contact stated that while coming to a stop the vehicle shuddered and hesitated to resume driving. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who informed the contact that the torque converter needed to be replaced. The vehicle was not repaired. The contact related the failure to TSB Number: 20N07 (2.3L Engine and 6F35 Transmission). The manufacturer was not made aware of the failure. The approximate failure mileage was 82,000.

While driving on highway I-20 at 80 miles per hour, the trim panel around the windshield detached. The panel detached on the drive side but the passenger side is already detaching from the bottom part.

The contact owns a 2019 Ford Explorer. The contact stated that while the vehicle was at a complete stop, the vehicle shuddered. Additionally, the vehicle hesitated to accelerate while driving. No warning light was illuminated. The vehicle was taken to the dealer, where it was diagnosed that the torque converter needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but confirmed that the VIN was not included in Customer Satisfaction Program: 20N07 (Transmission Extended Warranty Coverage) and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 80,000.

The contact owns a 2019 Ford Explorer. The contact stated while driving 45 MPH, several messages indicating that the hill descent control system, the ABS system, and road stability control system had failed were displayed. The contact stated that the failure had been reoccurring while driving. Additionally, a message stating that the Forward Collision Avoidance warning system had detected a fault or obstruction, was displayed intermittently, causing the brakes to apply independently. The contact pulled to the side of the road. The contact stated upon turning off and restarting the vehicle, the vehicle operated as needed; however, the failure reoccurred while driving a long distance. The vehicle was taken to the dealer several times however, the dealer was unable to duplicate the failure. The vehicle was taken to a second dealer, Franklin’s Spring Creek Ford (220 W Main St, Colquitt, GA 39837), who received remote assistance from Ford engineers, but was unable to duplicate the failure. The vehicle was not diagnosed nor repaired. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 36,066.

I have a 2019 Ford Explorer. I have seen that serval people have reported the front windshield trimming flying off going down the road for no reason. I recently had to replace both of my window trimming because this happened to me. One flew completely off going down the interstate and the other one came off but lucky did not fly off with traffic around. This is very dangerous not only for the owner of the vehicle but other vehicles around when it flys off. I have contacted FORD and they do not want to reimburse me for the amount of money I have spent to get this fixed. This is not a default on the owners end, it is a FORD default. I feel as if Ford needs to reimburse. Again, this could be very dangerous for other drivers on the road when these prices fly off. Safety first.

The windshield piece flow off while we were traveling around 45mph. We did not know what happened until the next day when we saw it missing.

I saw an article about the a pillars coming off while driving and wanted to report my story/experience with this problem vehicle! I pay wayyyy too much for this vehicle to be a 2019 and still have low miles (46,700) for it to be such a safety hazard for my family, I definitely expected more for such a big first Ford purchase. Very very disappointed. I don’t have all the receipts together right now to take pictures at this time but they are at my house if needed. -the a pillars have flown off the vehicle while driving down the freeway even after being fixed, even most recent fixes will not completely stay down and could still come off again. This has led to the window trim being ripped off with them and it all causing wind issues and allows stuff to catch on the windows while driving or build up underneath for weather conditions. -there is something within the vehicles power train that will not take alignments and has a very bad shimmy/sway within the wheels while driving. This is very very unsafe at any speed but quite bad at highway speeds, especially with wind because of the a-pillars issue. The way it moves while driving it feels like you’re not in control of the vehicle. Multiple alignments have been attempted, tire swaps and brand new ones have been put on and it continues to get worse. Nobody can figure out what’s causing this. -there are some electrical and heating shortages within the vehicle and intermittently these futures will glitch out and won’t work. Sometimes the display screen won’t come on or shut off, sometimes all the wipers will stop mid swipe and not fully stay down, sometimes the mirrors won’t adjust, some sensors barely work, there are times the seat warmer doesn’t work or does partially, the floorboard heat will only put out cold air unless it’s on auto and high, some lighting functions glitch out, same with the radio, sometimes the auto start don’t work, sometimes the seat positions will stop in mid move and won’t reposition

Windshield trim panels flying off vehicle while driving down the road

The contact owns a 2019 Ford Explorer. The contact stated while driving 40 MPH, the side trim on the passenger’s side windshield detached from the vehicle. The dealer was contacted and made aware of the failure. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was 76,000.

The trim panel around the windshield detached. The panel detached on the drive home from the Ford dealership. This happened on a brand new vehicle. I returned the car to the Ford dealership and they replaced the trim panel. I also had to have the windshield replaced on this vehicle. The windshield replacement company requires you to purchase new trim panels surrounding the windshield when the windshield is replaced. I purchased new trim panels and 1 of the trim panels detacted from the vehicle while I was driving on the expressway. The windshield company replaced the panel. They indicated that this happens all the time with Explorers.

The front window side panel is in the process of coming off on both side it’s already detaching from the top of both side & im afraid it’s gonna hot someone if it flies off I started to notice this a little after I got the car & im noticing more & the dealer ship saw it when I got the car & said it’s not on recall

The contact owns a 2019 Ford Explorer. The contact stated that the rubber strip located between the windshield and the side mirrors on the driver’s and passenger’s side was fractured. The contact then stated that the piece on the driver's side was shaking while driving. The dealer was made aware of the issue. Upon investigation, the contact discovered NHTSA Campaign Number: 21V316000 (Structure) which she linked to the failure. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 35,000.

The horn/horns stopped working. There just was no more sound. No wreck or jolts. Just no sound. Pressed all angles and area of horn “button” but not even a hint of horn sound. Horn fuse and horn relay are both good.

Roof rack rails coming off car. Recall number 21S22. I took my 2019 Ford explorer to the local Ford dealer on 03/25/2022 and roof rails were repaired. Roof rails coming off again. I called Ford motor company again (CS-40164791). A lady named Fallon told me there is nothing Ford Motor Company can do. All recall attempts have been made. Roof rails did not look like this when car was new, plus the roof rails looked like new when local Ford dealer made first recall repair. Now coming off again. Roof rails may not have been repaired correctly or to recall recommendation. I have checked many Ford Explorer’s, in parking lot, between 2016 and 2019 none have roof rails sticking up 3/4 of an inch in rear of car like mine.

I have had the key pad replaced 2 times because it melts at top. It has melted again Should it be recalled

2nd row seat belt malfunctioned during when rear ended recently. Seat belt came unlatched on my niece throwing her towards the front passenger seat. Car has been totaled. Injury was to driver.

The torque converter on my 2019 Explorer is messing up. Causing a stutter while driving and an extremely rough idle when trying to stop at a stop light/sign. This stutter happens intermittently and unexpectedly weather driving at a high rate of speed or low. A light never came on and no codes were able to be read. The last day I was able to dive my car the idle suddenly dropped so low mid driving. Thankfully I was going at a low rate of speed and able to get my vehicle off the road. I took my vehicle back to the Ford dealership and asked that they re-evaluate as the problem had gotten worse. That’s when I was informed my torque converter had malfunctioned. Not only did the dealership provide me with that information, but they also informed me that this is a known issue and has affected so many Explorers in this way, Ford had issued multiple TSBs to their service departments notifying them of this issue. I have attached screenshots of TSB 20-2271 and 22-2287, showing Ford is aware of these issues being reported on the 2016-2019 model Explorers. In my research, I’ve also found that the NHTSA has had a previous case, 17S16, showing Fords directive to replace faulty Torque Converters back in June of 2018. It is clear that Ford has not taken this issue seriously and continues to produce and sell vehicles with this bad part. This stutter and sudden decrease in idle could cause a wreck. Thankfully it did not with me, but it is an ongoing issue that could in the future. Ford has acknowledged there’s a problem but has not yet issued a recall on this part, for my VIN or cars like mine. I urge the NHTSA to investigate and encourage Ford to make this right and improve the quality of the torque converters they’re producing and selling to consumers.

When I took a left hand turn coming from a stop-sign the control arm on my front right passenger side busted. I did not hit anything or cause the damange instead this was in part of failure of the product. I was traveling approximately 3 mph on a flat surface with no traffic exiting an industrial park. Because the control arm broke, it caused significant other damage to my vehicle due to the inability to steer my vehicle and the wheel to no longer be controlled by the steering wheel. There were no warning signs and nothing to signal to me that my car was in fact having issues. If I would have been traveling on the hwy during this incident chances are I would have been severally hurt or even killed. I had just dropped off my husband and child at an event where we were traveling on a hwy. Luckily I was traveling at a slow speed during this incident and nobody was injured. The vehicle has been inspected and based on the significant damage (fender, door, mechanical) there has been nothing but challenges getting the issues fixed. My car is still covered under warranty because it's new however between my car insurance and the warranty nobody wants to help cover the cost of the damage that was cause at no fault of my own. Finally, this is a known issue with Ford vehicles. Research shows many, many other complaints just like mine where faulty control arms are breaking at no fault of the driver. As a matter of fact, 3 days ago there was the same incident at a round-about where another Ford Explorer was sitting in the middle with it's control arm broken. Same issue, same scenario.

Transmission torque converter and transmission clutches malfunctioning. Yes it's available for inspection if needed. Safety is an issue because car shudders when driving. Yes, problem has been observed by a dealer. And has been inspected with an estimated cost of $5,100+ No warning lights come on to know to assess the issue.

The front pillar columns on either side of the windshield have flown off while driving on the interstate. This is a ongoing Ford issue that should be fixed and is so dangerous could crack someone’s windshield

The contact owns a 2019 Ford Explorer. The contact stated there was a loud rattle coming from the rear passenger side wheel of the vehicle. The noise progressed when on rough roads. The contact inspected the rear passenger side toe link which seemed as though it was loose and malfunctioning. The contact did not take the vehicle to the dealer. The vehicle had not been diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 46,172

2019 Ford Explorer shutdown at full speed on Florida Turnpike for the second time within 30 days. The first time it was thought that the battery was at end of life. A new battery was installed and thought to be fine however, later the vehicle was unable to start after highway use, requiring waiting to restart. Engine cranks but will not start. Vehicle started then shut down at full highway speed on the Florida Turnpike on July 5th. Car was in unsafe location on highway edge as no other area was reachable. Car cranked but would not start. Turnpike Road Ranger responded, I called for tow and Uber, car eventually started and I drove it to Lorenzo Ford of Homestead FL. Ford has no TSBs on this subject however the internet has multiple videos showing Ford customer’s experiencing the same issue of no start or shutdowns. Please review for similar complaints. I have a very nice unreliable and unsafe car at this point.

At 53,000 miles I was driving down the highway and my vehicle sputtered and died leaving me stranded on the side of the road. The vehicle would not start. I took the vehicle to a local repair shop and had to replace the Fuel Pump for the vehicle. That was very low mileage to have an issue with a major part like a fuel pump.

Clip on horn cover that secures the driver air bag was coming apart, if not repaired may have caused an accident by inflating the air bag by a bump in the road or any other sensing that causes the air bag to engage, including honking the horn. on the interstate could have been catastrophic. To the driver, the horn cover could have discharged to the face without notice. The vehicle was taken to Dick Smith Ford in Columbia SC and after a long consideration by Ford Motors the steering wheel and air bag was replace at cost to me of $156.53. The vehicle had 24,000 with very light driving miles and little to no honking. Had not a mechanic at a local tire store took note, this possible tragic failure would have done some irrevocable harm to driver, occupants of vehicle and other in proximity of vehicle safety failure.

There is a recall and no remedy has been done. Still waiting on a call or email.

The contact owns a 2019 Ford Explorer. The contact stated while driving approximately 75 MPH, he heard an abnormal noise coming from the roof rack. The contact stated no warning light was illuminated. The contact stated that after parking the vehicle, he noticed that the roof rack had detached. The contact called the local dealer and made them aware of the failure. The vehicle was not diagnosed or repaired. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 21V316000 (Structure) however, the VIN was not included. The manufacturer had been informed of the failure. The failure mileage was approximately 270,450.

While driving on I-95 on 5/4, the RH windshield moulding broke off suddenly and flew off behind the car, fortunately not hitting another vehicle, although that could easily have happened. I took the car to Mullinex Ford in New Smyrna Beach, FL on 5/9; they said the exterior moulding (which broke off) and the underlying RH A pillar moulding needed to be replaced (costing me $432, since it wasn't covered by my extended warranty). This same thing happened to my previous 2013 Explorer in 2017-2018 timeframe! Apparently it is a well-known problem with all Ford Explorers since at least 2013 , as many others have reported at https://www.carproblemzoo.com/ford/explorer/body-problems.php ). But Ford has never issued a recall on this problem, and refuse to cover it under extended warranties. This is a real safey issue, as parts should NOT be breaking off on a car and flying through the air to potentially hit other vehicles. At the website I specified, some vehicle owners reported incidents that DID hit other vehicles, including a motorcyclist.

The contact owns a 2019 Ford Explorer. The contact stated that while his daughter was driving at approximately 25 mph, the steering wheel seized causing the vehicle to crash into a concrete brick mailbox. The air bags deployed. The contact stated that the driver sustained chemical burning from the air bags and the front passenger sustained a high ankle sprain and broke right foot that needed medical attention. A police report was filed. The vehicle was destroyed and towed to a collision center. The dealer was not contacted. The manufacturer was notified of the failure and provided a case number. The approximate failure mileage was 56,000.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 21V316000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed, the roof rack trim detached. The vehicle was taken to the dealer. The dealer took pictures of the vehicle and forwarded them to the manufacturer. The manufacturer was made aware of the failure and a case was opened. The manufacturer transferred the contact to the NHTSA to file a complaint. The failure mileage was approximately 30,000.

The contact owns a 2019 Ford Explorer. The contact stated that while the vehicle was parked, the lock button was depressed and the contact became aware that the horn was not operating as needed. There were no warning lights illuminated. The vehicle was taken to the dealer but was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 46,000.

The contact owns a 2019 Ford Explorer. The contact stated that there was an abnormal ticking noise detected from the front end of the vehicle. The contact stated that while his wife was driving, the vehicle failed to accelerate and revved up. The contact noticed that the air intake manifold was disconnected. The contact stated that he noticed an oil leak in the driveway. The rear seat heater became inoperable and the tires were bald. The vehicle was taken to the local dealer and the contact was informed that the vehicle was working as designed. The vehicle was taken to the same dealer where it was diagnosed that the seal was broken. The vehicle was repaired however, the failure recurred. The manufacturer was notified of the failure however, no further assistance was provided. The approximate failure mileage was 20,000.

We continue to smell exhaust fumes in the cabin on the vehicle.

The contact owns a 2019 Ford Explorer. The contact stated that on several occasions, the rear passenger’s side roof rack became loosened while driving at highway speeds and while going through the car wash. The contact then received notification of NHTSA Campaign Number: 21V316000 (Structure) and had the vehicle was serviced at the dealer. Three months later the failure recurred. The contact took the vehicle back to the dealer and was informed that the recall was a one-time free repair. The manufacturer was notified of the failure and referred her to NHTSA for assistance. The vehicle was not repaired. The failure mileage was approximately 45,000.

1. The vehicle HORN unknowingly and unexpectedly stopped working, became unavailable, and subsequently failed to alert other of hazardous conditions, when approperiately initiated by the driver/operator. Without any indication or prior warning to the driver that the HORN was NOT FUNCTIONAL. This vehicle can be made available for NHTSA inspection upon request. For all intensive purposes, the only unique purpose for having a vehicle HORN is for SAFETY. 2. SAFETY was compromised and reslted in highly eleveted risks for the Driver, Passangers, Pedestrians, Traffic Officers, By Standers, Other Vehicles and Congestion, following a Night Time Egress of an NFL Football Game. 3. The problem is repeatable and the HORN is currently in a FAILED state. The HORN has not been diagnosed or repaired. It has not been confirmed, by the Dealer, nor Independent Service Center. WHY? For them to bill me some ungodly amount, just to tell me, my the HORN DOES NOT WORK.. ON a vehicle I financed/purchased 4 months ago? and that I paid $200 last month for a FAILED BATTERY last month. Good LORD, and on a vehicle with more automated driver assist sensors, than a MARTIAN LAND EXPLORER? and the HORN FAILS? For SAFETY, HORNS are intentionally "enabled" and maintained in fuctional state. Note: AUTO OWNER has reported this SAFETY DEFECT to NHTSA. Owner requests all costs of diagnosis, parts, replacement, labor, repairs, wiring, computer, software, and the transparent identification of flaws in automatic updates via internet and wireless, connectivity, software updates, digital processing of vehicle operating systems, and digital monitoring of driving conditions, location, and environment. 4. No. It has not been inspected by manufacturer, police, insurance reps, or others. Yet. 5. No warning lights, messages, or indicators prior to non-functioning and unexpected HORN failure. I would like to request independent NHTSA inspection Root Cause Analysis. Thank You

I have a 2019 Ford Explorer Limited. Since shortly after my lease began, I found it to emit a burnt hair like smell in the passenger cabin whenever I am applying heavy acceleration. I have had a similar issue with two previous Explorers I've owned (2015 XLT, 2017 XLT), and brought the vehicle to the dealer, requesting that they remediate the issue. The dealer's service center claims there are no fumes, and did not attempt to repair the vehicle. This was the second time I took it to that dealer for the issue. I have contacted Ford Customer Service, though have yet to get any repair or remediation of the issue. I am concerned as I have had repeated instances of drowsiness when operating the vehicle.

The contact owns a 2019 Ford Explorer. The contact stated that there was water leaking into the headliner and sunroof. Additionally, the battery was leaking battery acid. The battery failure caused the contact's baby to be diagnosed with Intrauterine Growth Restrictions (IUGR). The first failure occurred when the contact detected an odor and checked under the hood of the vehicle. The contact saw that the battery was swollen and had exploded. The vehicle was towed to the dealer on October 21, 2020, and the dealer informed the contact that it was a faulty battery and replaced it with a new battery that the contact had purchased from Walmart. The dealer informed the contact, who was pregnant at the time, that the vehicle was safe to drive. The failure recurred, and the vehicle was taken to Darling's Brunswick Ford (262 Bath Rd, Brunswick, ME 04011) on May 17, 2021. The dealer informed the contact that the battery was actively leaking and covered in battery acid. The vehicle was not repaired and remained at the dealer. The manufacturer was made aware of the failure and first informed the contact that there was no recall associated with the VIN. The manufacturer later informed the contact that they would be buying back the vehicle from the contact under Florida's Lemon Law. The failure mileage was approximately 42,000.

The contact owns a 2019 FORD Explorer. The contact stated that she initially received a recall notice for the roof rail covers under Manufacturer recall Number: 20N11. The contact took the vehicle to a dealer and had the recall serviced. Since the repair, the contact noticed that the roof rail cover had begun to detach from the vehicle despite the recall repair. The contact had taken the vehicle to the dealer where they acknowledged the failure and referred her to the manufacturer for assistance. The manufacturer was notified of the failure and referred her to NHTSA for assistance. Upon investigation, the contact discovered NHTSA Campaign Number: 21V316000 (Structure) however, the vehicle was not included in the recall. The vehicle was not repaired. The failure mileage was approximately 18,000.

The contact owns a 2019 Ford Explorer. The contact stated that the roof rail had detached. The contact received notification of NHTSA campaign number: 21V316000 (Structure) however, the part to do the recall repair was unavailable. The vehicle was taken to the local dealer where the roof rail was glued. The vehicle was repaired however, the failure recurred. The roof pins are unable to be attached. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified but, no further assistance was provided. The failure mileage was approximately 3,000. VIN tool confirms parts are not available.

The contact owns a 2019 Ford Explorer. The contact stated while driving 60 MPH, the driver’s side roof rail detached from the body of the vehicle. The vehicle was taken to a local dealer where it was diagnosed but not repaired. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 21V316000 (Structure) however, the VIN was not included. The manufacturer was informed of the failure and referred the contact to NHTSA. The failure mileage was approximately 55,000.

As per a recall on this vehicle, the roof rails become detached and have the potential to fly off the car at high speeds. I have brought this in to a Ford service center numerous times to be addressed and upon repair each time, the issue recurs. The latest conversation I have had with a Ford motor company representative is that the issue is known but there is no known fix for it at this time. Meanwhile, I, like so many others, are driving around with what can be a potential safety hazard for other drivers.

Driving 70 mph on interstate the driver side windshield trim came off. Startled the driver and caused car behind us to hit it on their windshield and lost control for a short time. In looking at trim clips they are plastic and 3 of them were broken. I drove to a ford dealer and was told this is a problem but they have not recall on it. Components should not be falling off a 60K car. No warning that this might occur.

NTHSA acknowledged there was an issue with 2019 Ford explorer roof rails being a danger and filed a warning which Ford supposedly issued a recall which never happened, had my SUV to Coggin Ford in Orange city Fl they made several repairs and the rails are still falling off SUV, Now the dealership is stating parts are on backorder, NTHSA filed wrong recall number with complaints, called FORD only to get a runaround for a week

The windshield weather stripping has Disintegrated . Half is missing. What’s left crumbles in your hand. I am get a picture, just not at this time. I will have it there is ever a follow up.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA campaign number: 21V316000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact attempted to reach out to local dealer several times for recall repair appointment but was informed that the part was not available. The manufacturer was not made aware of the issue. The contact had not experienced a failure. The VIN was not available.

Roof rail covers are falling off. Ford dealer where purchased has repaired this trouble three times and the covers are now detached worse than ever. Dealer where purchased refuses to work on the vehicle and told me to take the vehicle elsewhere. Needs to be corrected before the covers come off at highway speeds and possibly create a catastrophic situation for vehicles following.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA campaign number 21V316000 (Structure) however, the part to do the recall repair was not yet available. The local dealer was contacted and it was confirmed that the part was not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced the failure. Vin tool showed no open recall.

The contact owns a 2019 Ford Explorer. The contact stated that the front windshield gasket was crumbling. The contact was concerned that water might leak into the vehicle. The vehicle was taken to the dealer and inspected but the dealer informed the contact that there was no recall associated with the failure, although they had seen the failure on other vehicles. The vehicle was taken to an auto glass repair shop and repaired. The manufacturer was made aware of the failure and referred the contact to file a complaint with the NHTSA. The failure mileage was 40,000.

I am extremely frustrated. I use my car as a second source of income and with the recall I now can't rent out my car through Turo as the recall isn't fixed. I don't even have a roof rack! I understand there is an attempt here to fix the issue with the vehicle but the impact is costing me thousands.

TL* THE CONTACT OWNS A 2019 FORD EXPLORER. THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS, THE HORN FAILED TO WORK WHEN DEPRESSED. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A LOCAL DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSIS OR REPAIRS. THE MANUFACTURER HAD NOT BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 45,600.

LAST 2 TIMES I HAVE DRIVE THE VEHICLE MORE THAN SEVERAL HOURS, A BURNT ODD SMELL HAS COME FROM THE ENGINE HOWEVER THERE HAVE BEEN NO CHECK ENGINE LIGHTS, ONLY AN ODOR OR CHALKY BURNT SMELL. I HAVE 3 YOUNG KIDS AND THEY SMELLED IT AS WELL. IT HASNT HAPPEND ON SHORT TRIPS I NOTICED AFTER LONGER TRIPS OF DRIVING

VERY LOUD NOISE FROM THE ENGINE WAS TOLD IT WAS THE SUPERCHARGER BUT IT SOUNDS LIKE A CONSTANT CLICKING. WE TOOK IT BACK AND DEALERSHIP TOLD US IT WAS FIXED. STILL MAKES A LOUD CLICKING WHEN DRIVING , MORE SO WHEN ACCELERATING. CALLED DEALERSHIP, THEY SAID THEY FIXED IT. TO US ITS STILL DOESNT SOUND LIKE A 2019 VEHICLE SHOULD

ROOF RAIL COVERS ON LEFT AND RIGHT SIDES OF 2019 FORD EXPLORER COME LOOSE AFTER DEALERSHIP REPAIRED FORD TSB-20-2154, STILL COMING LOOSE, THEY CAN FLY OFF VEHICLE AND CAUSE AN ACCIDENT ELECTRICAL WIRES ARE CODED WITH SOY CAUSING SQUIRRELS / RODENTS ETC.TO EAT ENGINE WIRES AND TRYING TO BUILD A NEST IN ENGINE CAN CREAT A FIRE

2019 FORD EXPLORER. CONSUMER WRITES IN REGARDS TO HORN BEING MUFFLED. *LD THE CONSUMER STATED THE VEHICLE WAS NOT INSTALLED WITH A HIGH PITCHED HORN.*JS

MY SUV IS LEAKING EXHAUST INTO THE CABIN. THE PROBLEM BEGAN WHEN ACCELERATING QUICKLY, LIKE GETTING ON THE HIGHWAY OR PASSING A CAR. NOW THE PROBLEM IS OFTEN WHEN JUST DRIVING NORMALLY. YOU CAN SMELL THE EXHAUST INSIDE. IT SMELLS LIKE ROTTEN EGGS. I HAVE BROUGHT THE EXPLORER BACK 3 TIMES TO THE DEALER AND THE CANNOT FIX IT. IT HAS BEEN AT THE DEALERSHIP FOR OVER 8 WEEKS.

CARBON MONOXIDE SMELL IN THE CAR WHEN DRIVING, WE TOOK THE VEHICLE IN TO THE FORD DEALERSHIP WHERE WE BOUGHT THE CAR, ON SEVERAL OCCASIONS, AND THEY TELL US THEY CAN NOT FIND A SMELL, OF A PROBLEM, SO WE HAVE JUST HAD TO LIVE WITH THE HORRID SMELL, WITH A NEW BABY AND ANOTHER SMALL CHILD RIDING INSIDE. VERY UNSAFE IN MY OPINION. WE ALSO NOTED THAT THE HORN IS VERY QUIET. ONLY HORN WAS INSTALLED IN THE 2019 FORD EXPLORER, AS OPPOSED TO THE PREVIOUS YEAR VEHICLES, THEY HAD 2 HORNS INSTALLED.

FORD RECALL 19C07- { APPLIES TO VEHICLES EQUIPPED WITH ONE OR MORE MECHANICAL FRONT SEATS- POTENTIAL LACK OF SEAT RESTRAINT IN THE EVENT OF A CRASH}. I RECEIVED THIS NOTICE BY MAIL AND MADE AN APPOINTMENT FOR MY 2019 FORD EXPLORER AT 'GARY YEOMANS FORD PALM BAY' ZIP-32907. THEY DID NOT REPAIR THIS RECALL. I TOOK MY VEHICLE IN ON 07/27/20. MY REPAIR ORDER STATES THEIR TECH #5534 FOUND: "THIS VEHICLE DOES NOT HAVE ONE OR MORE MECHANICALLY ADJUSTABLE FRONT SEATS. BOTH SEATS IN THIS VEHICLE ARE ELECTRONICALLY CONTROLLED". THE VIN SAYS THEY BOTH ARE POWER-WHICH I QUESTIONED AT THE TIME OF PURCHASE-AT THIS SAME DEALERSHIP. I WAITED 3 FULL DAYS FOR MY VEHICLE TO BE REPAIRED WITHOUT A LOANER VEHICLE-WHILE THIS TECH WAS TOO LAZY TO WALK FROM THE DRIVER SEAT TO THE PASSENGER SEAT TO INSPECT THAT IT WASN'T A POWER SEAT. I ALSO REQUESTED THE 2ND ROW PASSENGER SEAT BE REPAIRED OR REPLACED. IT CONTINUES TO GET STUCK AND WON'T FOLD UP OR CLICK INTO PLACE IN THE UPRIGHT POSITION. TWICE IT HAS JOLTED FORWARD IN THE OPEN POSITION UPON BRAKING, WHILE DRIVING ON THE HIGHWAY, HITTING THE FRONT PASSENGER SEAT. ONE OF THESE TIMES MY GRANDDAUGHTER WAS SITTING IN THIS SEAT - I CAN ONLY THANK GOD SHE WASN'T A TODDLER. FOR THIS REASON MY PASSENGERS CANNOT SIT IT IN IT - IT VERY WELL COULD KILL THEM. THIS SAME TECHNICIAN STATES ON MY REPAIR ORDER: "VERIFIED THAT THE REAR SECOND ROW SEATS FOLD UP AND DOWN AND OPERATE PROPERLY". I HAVE BEEN GRILLED ABOUT GIVING A FIVE STAR REVIEW

FOR THIS MODEL YEAR FORD EQUIPPED THE EXPLORER WITH A SINGLE-TONE HORN. THE VOLUME IS VERY LOW AND SOUNDS LIKE A TOY HORN. I DO NOT HAVE ANY CONFIDENCE THAT THIS HORN WILL HELP ME IN A DANGEROUS SITUATION. *TR

I PURCHASED MY 2019 FORD EXPLORER IN MARCH 2019. I HAVE NOW REPLACED ALL 4 HANKOOK TIRES. THE TIRES HAVE HAD CRACKS, TEARS, HOLES, AND WERE SHREDDING. EACH TIRE FAULTED AT DIFFERENT TIMES. I HAD A BLOW OUT ON THE HIGHWAY. HANKOOK WAS CONTACTED BY THE DEALERSHIP AND MYSELF. HANKOOK BLAMED ME ON THE FIRST TIRE. I HAVE NOW FOUND A HOLE AND RIPS ALL OVER THE 4TH TIRE. THE DEALERSHIP CLAIMED IT MANUFACTURER FAULT. I CANNOT REVEAL MY AGE BUT I HAVE OWNED MANY CARS. I HAVE NEVER HAD ANY OTHER CAR DO THIS BUT MY 2016 FORD EXPLORER. THIS CAR HAD HANKOOK TIRES. I HAD TO REPLACE THE TIRES ON THIS VEHICLES AT 8 MONTHS DUE TO HOLES AND EXTREME SHREDDING. HANKOOK HAS COMPLAINTS ALL OVER THE INTERNET AND BBB. I HAD A BLOW OUT RIGHT AFTER CONTACTING THEM ON A DIFFERENT TIRE THAN I REPORTED TO THEM. I HAVE A YEAR OLD CAR WITH 4 TIRES THAT HAVE HOLES, YEARS, SHREDS. TODAY I HAD TO PUT A 4TH TIRE ON THE CAR. HANKOOK IS GOING TO HURT SOMEONE! I WAS DRIVING 85MPH WHEN THE TIRE BLEW OUT. *TR

ROOF RAILS COME LOOSE, TOTALLY UNSECURED TO VEHICLE. ONE HAS FALLEN OFF WHILE DRIVING, ONE WAS DESTROYED IN CAR WASH. THE RAILS SEEM TO POP LOOSE NO MATTER WHAT IS HAPPENING WITH THE VEHICLE (I.E. PARKED, DRIVING). THIS IS A WELL DOCUMENTED PROBLEM ONLINE BUT NOTHING HAS BEEN DONE TO RESOLVE IT. *TR

ROOF RACK ON TOP OF VEHICLE CAME OFF WHILE DRIVING. THE PLASTIC CLIPS AREN'T ENOUGH TO KEEP IT ON THE VEHICLE. VEHICLE HAD 12K MILES WHEN THIS HAPPENED. THIS IS VERY UNSAFE I SHOULDN'T HAVE TO WORRY ABOUT MY ROOF RACKS COMING OFF MY VEHICLE.

I HAVE HAD THE CAR IN TO THE DEALER TWICE NOW FOR CARBON MONOXIDE ENTERING THE PASSENGER COMPARTMENT. I HAVE HAD A CARBON MONOXIDE DETECTOR THAT I PURCHASED FROM A RETAILER THAT SHOWS ELEVATED LEVELS ABOVE 60 PARTS PER MILLION WITHIN THE PASSENGER COMPARTMENT MY FAMILY HAS BEEN EXPERIENCING NEUROLOGICAL SYMPTOMS RELATED TO THE CO EXPOSURE

NOTICED SEVERE EXHAUST SMELL WHEN DEFROST IS ON WHILE DRIVING, AND MORE MODERATELY WHEN THE RECIRCULATED AIR IS ON. LOOKED UP THE ISSUE ONLINE AND FOUND THAT OUR 2019 FORD EXPLORER IS EXPERIENCING THE SAME ISSUES THAT CAUSED A SOFT RECALL FROM FORD FOR THEIR 2011-2017 MODELS. TOOK IT TO LOCAL FORD SERVICE CENTER, BUT THEY COULD NOT REPLICATE THE ISSUE. HOWEVER, THE TECH AT FORD SERVICE CALLED THEIR HOTLINE, WHO STATED "REAR AIR VENTS WERE LOOSE CAUSING THIS CONCERN". FOLLOWING THIS CALL, FORD SERVICE CENTER DID THE FOLLOWING (ALL QUOTES ARE FROM SERVICE INVOICE): "REMOVED REAR BUMPER COVER AND INSPECT[ED] AIR EXTRACTORS. INSPECTION FOUND BOTH EXTRACTORS WERE NOT CONNECTED ON THE LEFT REAR CORNER OF BOTH SIDES, LIKE THEY ARE BROKEN WILL NOT PROPERLY SEAT. INSPECTION ALSO FOUND LIFTGATE DRAIN VALVE WAS MISSING AND LR TAILLAMP GROMET WAS NOT SEATED TO THE BODY. REPLACED BOTH EXTRACTORS AND DRAIN VALVE, RESEATED LR TAILLAMP BODY PLUG, REINSTALLED REAR BUMPER AND TEST DROVE." WE HAVE NOT NOTICED THE EXHAUST SMELL SINCE THE FIX ONE WEEK AGO. I AM REPORTING THIS SO THAT NHTSA AND ANYONE READING THIS KNOWS THAT THE FORD EXHAUST ISSUES THAT CAUSED SO MANY PROBLEMS ARE STILL ONGOING THROUGH THE 2019 MODEL, AND ALSO SO THAT CONSUMERS WHO HAVE THIS MODEL KNOW EXACTLY WHAT TO TELL THEIR LOCAL FORD SERVICE CENTERS TO DO TO FIX IT.

BACK UP CAMERA DOESN'T WORK ESPECIALLY NOT IN COLD. I CAN JUST START THE VEHICLE AND THE CAMERA WON'T WORK ONCE BUT IT HAS NOW BECOME AN ALL DAY THING

THIS CAR WILL NOT START AFTER BEING TURNED OFF AND LEFT FOR CERTAIN TIME. THE CAR CRANKS BUT WILL NOT START. THE BATTERY HAS BEEN CHECKED AND IS FUNCTIONING. THE CAR WAS TAKEN TO FORD DEALER AND FOUND THE GAS MODULE BAD. AFTER 4 MONTHS THE ISSUE HAS OCCURRED AND THE CAR WILL NOT START.

JUST RECENTLY PURCHASED A 2019 FORD EXPLORER LIMITED. WHILE DRIVING ON THE FREEWAY AND ALMOST NEARLY BEING SIDE SWIPED BY A BIG RIG WHO APPARENTLY DID NOT SEE ME OR HEAR MY HORN. I THEN PULLED OVER NEAREST EXIT AND PRESSED MY HORN TO HEAR THAT IT WAS LOW SOUNDING. I THOUGHT MAYBE IT WAS DEFECTIVE OR A RECALL ON HORNS. I SEARCHED ONLINE TO FIND OUT THAT FORD HAS ONLY INSTALLED 1 HORN FOR THIS YEAR MODEL. NOT SURE IF ITS TO BE CHEAP OR BY MISTAKE, BUT I HAVE READ MANY REVIEWS THAT THERE'S ONLY 1 HORN INSTALLED WHEN ALL PREVIOUS YEARS HAVE 2 HORNS INSTALLED. THERE ALSO HAS BEEN VIDEOS MADE ON YOUTUBE REGARDING CONCERNS OF THESE 2019 FORD EXPLORERS. I TRULY BELIEVE THIS IS A BIG SAFETY ISSUE.

REAR HATCH ELECTRIC OPENING/CLOSING MECHANISM FAILED - HATCH CAME DOWN A STRUCK THE HEAD OF A PERSON CAUSING AN INJURY. ALSO BECAUSE THE HATCH WOULDN'T CLOSE PROPERLY EXHAUST ENTERED THE VEHICLE WHEN BEING DRIVEN.

TL* THE CONTACT OWNS A 2019 FORD EXPLORER EQUIPPED WITH HANKOOK VENTUS 105H TIRES, SIZE: 255/50/R20. THE CONTACT STATED THAT THE ORIGINAL FRONT PASSENGER SIDE TIRE HAD TO BE REPLACED BECAUSE THE TIRE PRESSURE WAS CONSISTENTLY DUE TO A THREE INCH CUT APPROXIMATELY TWO INCHES FROM THE RIM. SUNSET FORD (11700 GRAVOIS RD, ST. LOUIS, MO 63127, (314) 843-4431) TRIED TO SELL THE CONTACT A NEW TIRE AFTER INFORMING HIM THAT THE TIRE WAS NOT COVERED BY THE WARRANTY. THE CONTACT WENT TO A TIRE SHOP FOR A SECOND OPINION AND WAS INFORMED THAT THERE WAS A DEFECT WITH THE TIRE. THE TIRE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE FAILURE MILEAGE WAS 2,000. THE TIRE FAILURE MILEAGE WAS UNKNOWN.

THE BRAKE PEDAL IS NOT READILY ACCESSIBLE DUE TO CLEARANCE UNDER THE DASH. MY SIZE 12 FEET WILL NOT REACH THE PEDAL QUICKLY ENOUGH IN AN EMERGENCY.

2019 FORD EXPLORER. CONSUMER WRITES IN REGARDS TO HORN NOT BEING LOUD ENOUGH TO BE HEARD AT ANY SAFE DISTANCE. *LD *JS

VEHICLE WAS BEING DRIVEN STRAIGHT ON RESIDENTIAL 2 LANE STREET. HEARD A LOUD BREAK/ LOSS OF DRIVING CONTROL OF VEHICLE WHICH PULLED FORCEFULLY TO THE RIGHT. VEHICLE SCRAPED OFF CURB THEN BACK INTO ONCOMING TRAFFIC AND COMING TO STOPPED. HAD LOST ALL POWER TO STEERING AND OPERABILITY OF VEHICLE. PUT HAZARDS ON TO AVOID ACCIDENT EXAMINED DAMAGE TO RIGHT FRONT PASS SIDE TIRE. APPEARED THAT STABILIZER ARM, SNAPPED, BALL JOINT DISCONNECTED. RIM WAS NOT BENT OR DAMAGED OTHER THAN SCRAPE TO CURB AND TIRE WAS FULLY INFLATED. PRIOR TO MALFUNCTION DRIVER DID NOT HIT ANY OBSTRUCTION, DEBRIS OR POTHOLES ON ROAD. NO DAMAGE TO BODY OF VEHICLE.

BURNING SMELL (PRESUMABLY EXHAUST FUMES) ARE LEAKING INTO CABIN WHILE DRIVING. HAPPENS MORE OFTEN UPON HARD ACCELERATION AND WITH AIR CONDITIONING ON IN AIR RECYCLE MODE.

THE 2019 FORD EXPLORER IS DELIVERED NEW WITH ONE INADEQUATE HORN. ALL OTHER MODEL YEARS HAVE TWO HORNS AND ARE WHAT YOU EXPECT FROM A HORN. THIS IS A DANGEROUS SITUATION, THE HORN IS SO LOW I COULD NOT SCARE A SQUIRREL. FORD MOTOR COMPANY SAID THEY CANNOT UPGRADE. THE FORD DEALER SAID THEY CANNOT UPGRADE WITHOUT EFFECTING THE WARRANTY.

WHILE DRIVING FROM VIRGINIA TO FLORIDA, TOWING SMALL U-HAUL TRAILER, WHEEL LUGS SHEARED OFF, CAUSING WHEEL TO COME OFF BELT ROLLING THE VEHICLE. VEHICLE IS BRAND NEW, I AM THE ONE AND ONLY OWNER FROM THE DEALERSHIP AND NEVER BEEN WORKED ON.

TL* THE CONTACT OWNS A 2019 FORD EXPLORER. WHILE DRIVING 70 MPH, THE CONTACT SMELLED FUMES COMING FROM THE IGNITION. THE VEHICLE WAS TAKEN TO LEE FORD LINCOLN (LOCATED AT 4170-C RALEIGH RD PKWY W, WILSON, NC 27896, (252) 291-6000) TO BE DIAGNOSED, BUT THE FAILURE COULD NOT BE DUPLICATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 1,100. *TT SINCE THE INITIAL FAILURE REPORT TO NHTSA ON JUNE 6, 2019, THE VEHICLE HAS BEEN TAKEN TO THE DEALER IN THREE SEPARATE OCCASIONS TO DATE, BUT THE FAILURE COULD NOT BE DUPLICATED. TO THIS DATE, THE VEHICLE HAS NOT BEEN REPAIRED AND THE PROBLEM PERSISTS. EXCESSIVE FUMES IN THE CABIN, MAINLY WHILE ACCELERATING AND/OR DRIVING LONG DISTANCES; THE SMELL IS SO STRONG THAT WE KEEP THE SUNROOF TILT OPEN TO ENSURE GOOD AIR FLOW & REMOVE FUMES FROM CABIN.*JB

ON MARCH 2ND 2019 FORD EXPLORER SPORT WITH 1,800 MILES WAS TOWED TO THOMASSEN FORD IN CHARLES TOWN WV LEAVING OWNER STRANDED. COMPLAINED OF STRONG FUEL/GASOLINE ODOR INSIDE THE VEHICLE. FUEL/GASOLINE WAS LEAKING BADLY OUT OF THE VEHICLE ONTO THE EXHAUST PIPE. ON MARCH 4TH NOTIFICATION WAS PROVIDED FROM SERVICE WRITER THAT NONE OF THE FUEL LINES OR CLAMPS WERE ATTACHED PROPERLY FROM THE FACTORY. VEHICLE SAT AT THOMASSEN FORD UNTIL MARCH 27TH WHEN REPAIRS WERE COMPLETE. APRIL 9TH 2019 SOME FORM OF FLUID LEAKED OUT OF THE PARKED VEHICLE FOR 8 HOURS AFTER A 7 MINUTE DRIVE. VEHICLE WAS TAKEN TO JERRY'S FORD IN LEESBURG VA "UNABLE TO DUPLICATE" THEREFORE NO ACTION WAS TAKEN. THERE ARE PHOTOS OF THIS ISSUE. APRIL 18TH 2019 A STRANGE NOISE COMING FROM THE STEERING COLUMN WHEN DRIVING. VEHICLE WAS TAKEN BACK TO JERRY'S FORD IN LEESBURG VA "UNABLE TO DUPLICATE" THEREFORE AGAIN NO ACTION WAS TAKEN. TO THIS DAY THE VEHICLE STILL MAKES THE NOISE WHICH HAS GOTTEN PROGRESSIVELY WORSE. THERE IS VIDEO OF THIS ISSUE

TL* THE CONTACT OWNS A 2019 FORD EXPLORER. WHILE DRIVING THE VEHICLE, THE CONTACT SMELLED EXHAUST FUMES AND FUEL INSIDE THE VEHICLE. THE VEHICLE WAS TAKEN TO ADVANTAGE FORD (4000 SE FEDERAL HWY, STUART, FL 34997, (772) 287-0955) TO BE DIAGNOSED, BUT THE TEST WAS NOT YET COMPLETED. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 4,500.