Volvo XC70 Recalls — All NHTSA Recall Campaigns

AIR BAGS:FRONTAL

Volvo Cars USA, LLC (Volvo Car) is recalling certain 2001-2007 V70 and XC70 vehicles. The driver's air bag inflator may explode during deployment, due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy: Dealers will replace the driver's air bag, free of charge. Owner notification letters were mailed December 14, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's num…

EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.

Risk: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.

Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A N…

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLIN…

Risk: IF THE CONDITION OCCURS VEHICLE OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT THE FUEL PUMP INSTALLED IN THE VEHICLE, AND IF NECESSARY REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL…

VEHICLE SPEED CONTROL

ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.

Risk: THIS RESULTED IN A HIGH NUMBER OF VEHICLES GOING INTO THE LIMP HOME MODE WITHOUT NEED.

Remedy: DEALERS WILL INSTALL THE CURRENT SOFTWARE UPGRADE ONTO THE INVOLVED VEHICLES. THE RECALL BEGAN ON DECEMBER 29, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.

EQUIPMENT:OTHER:LABELS

CERTAIN PASSENGER CARS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE SECOND ISOFIX GUIDE WAS NOT INSTALLED IN THESE VEHICLES AND, IN CERTAIN CASES, THE OWNER'S MANUAL ISOFIX INFORMATION IS INCORRECT.

Risk: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.

Remedy: OWNERS WILL RECEIVE A LETTER/PACKAGE CONSISTING OF THE SECOND ISOFIX GUIDE WITH INSTALLATION INSTRUCTIONS, AND IN CERTAIN CASES, THE CORRECTED OWNER'S MANUAL MAY BE PROVIDED. IF THE OWNER WANTS TO TA…

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAI…

Risk: LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy: CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.

SEAT BELTS:FRONT

Volvo Cars of N.A., LLC (Volvo) is recalling certain 2008-2016 V70 and XC70, 2007-2016 S80, 2011-2018 S60 and V60, 2016-2018 S60 Cross Country, 2014-2020 S60L, 2009-2015 S80L, 2009-2016 XC60 and 2015-2018 V60 Cross Country vehicles. The flexible steel cable that connects the seat belt to the front …

Risk: An unsecured occupant has an increased risk of injury in the event of a crash.

Remedy: Volvo will notify owners, and dealers will replace the seat belt anchor cable for both front seats. The recall began December 10, 2020. Owners may contact Volvo customer service at 1-800-458-1552. …

EQUIPMENT:OTHER:LABELS

CERTAIN VEHICLES EQUIPPED WITH REAR INTEGRATED BOOSTER SEATS FAIL TO COMPLY WITH THE LABELING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 213, "CHILD RESTRAINT SYSTEMS." LABELS ON THE AFFECTED VEHICLES ARE MISSING WARNING INFORMATION INDICATING THAT 'DEATH OR SERIOUS INJURY CAN OCCUR'…

Risk: THIS STANDARD SPECIFIES REQUIREMENTS FOR CHILD RESTRAINT SYSTEMS USED IN MOTOR VEHICLES AND AIRCRAFT FOR THE PURPOSE OF REDUCING THE NUMBER OF CHILDREN KILLED OR INJURED IN MOTOR VEHICLE CRASHES AND I…

Remedy: DEALERS WILL INSTALL A NEW LABEL WITH THE CORRECT WARNING INFORMATION. THE RECALL BEGAN ON FEBRUARY 20, 2008. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.

ELECTRICAL SYSTEM:SOFTWARE

VOLVO IS RECALLING 12,303 MY 2007-2008 S80 AND V70 VEHICLES. THE DIAGNOSTIC SOFTWARE IN THE CENTRAL ELECTRONIC MODULE (CEM) MAY CAUSE A MALFUNCTION OF THE WINDSHIELD WIPER FUNCTIONALITY. IF THIS CONDITION OCCURS, THE WINDSHIELD WIPERS MAY NOT OPERATE WHEN ACTIVATED; OR IN CERTAIN CASES THE WINDSHIE…

Risk: OPERATING A MOTOR VEHICLE DURING INCLEMENT WEATHER CONDITIONS WITHOUT FUNCTIONING WINDSHIELD WIPERS CAN INCREASE THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT THE CEM AND UPGRADE THE SOFTWARE FREE OF CHARGE. THE RECALL BEGAN ON MAY 15, 2009. OWNERS MAY CONTACT VOLVO CUSTOMER CARE CENTER AT 1-800-458-1552, OR CUSTOMERCARE@VOLVOFORLIFE.…

ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

VOLVO IS RECALLING 17,614 MY 2008-2009 S80, V70, AND XC70 VEHICLES. THE ENGINE COOLING FAN MAY STOP WORKING DUE TO A SOFTWARE PROGRAMMING ERROR IN THE FAN CONTROL MODULE (FCM). DEPENDING ON DRIVING CONDITIONS, THE CUSTOMER MAY EXPERIENCE REDUCED AIR CONDITIONING PERFORMANCE, AND/OR RAPID INCREASE …

Risk: THIS SITUATION MAY RESULT IN LOSS OF COOLING SYSTEM FUNCTION AND ENGINE FAILURE. THE DRIVER MAY NOT HAVE SUFFICIENT TIME TO REACT TO THE WARNING LIGHT(S) OR THE TEXT MESSAGE IN THE INSTRUMENT PANEL, I…

Remedy: DEALERS WILL REPLACE THE FAN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2009. OWNERS MAY CONTACT VOLVO CUSTOMER CARE CENTER AT 1-800-458-1552.

EQUIPMENT:OTHER:LABELS

CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THE WHEEL INFORMATION LABEL LOCATED ON THE REAR DRIVER'S SIDE DOOR PILLAR WAS PRINTED MISSING THE WHEEL SIZE (…

Risk: THE PURPOSE OF THIS STANDARD IS TO PROVIDE SAFE OPERATIONAL PERFORMANCE BY ENSURING THAT VEHICLES TO WHICH IT APPLIES ARE EQUIPPED WITH TIRES OF ADEQUATE SIZE AND LOAD RATING AND WITH RIMS OF APPROPRI…

Remedy: OWNERS WILL BE PROVIDED WITH A CORRECT CERTIFICATION LABEL AND INSTALLATION INSTRUCTIONS. IF THE OWNER PREFERS, A DEALER CAN INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON JANUARY 31, 2008. OWNERS…

AIR BAGS:FRONTAL

IN CERTAIN VEHICLES, TWO SOFTWARE ERRORS HAVE BEEN FOUND IN THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) CONTROL UNIT SOFTWARE. THIS MAY RESULT IN A LATE DEPLOYMENT OF THE INFLATABLE CURTAIN (IC) AND SIDE IMPACT PROTECTION SYSTEM (SIPS) AIR BAGS IN CERTAIN SIDE IMPACT CRASH SITUATIONS. IN ADDITION, THI…

Risk: LATE DEPLOYMENTOF THE IC AND SIPS AIR BAGS IN CERTAIN SIDE IMPACT CRASH SITUATIONS COULD INCREASE THE RISK OF INJURY TO THE VEHICLE OCCUPANT.

Remedy: DEALERS WILL PERFORM A SOFTWARE UPGRADE OF THE SRS CONTROL UNIT. THE RECALL BEGAN ON OCTOBER 31, 2007. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.

EQUIPMENT:OTHER:LABELS

VOLVO IS RECALLING CERTAIN MODEL YEAR 2010 XC70 VEHICLES MANUFACTURED FROM DECEMBER 5, 2006 THROUGH OCTOBER 1, 2009 FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE FMVSS LABEL, TIRE AND LOADING INFORMATION LABEL AND A PAGE…

Risk: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.

Remedy: THE CORRECTIVE ACTION IS TO UPDATE THE VEHICLES WITH A NEW FMVSS LABEL, TIRE AND LOADING INFORMATION LABEL AND TPMS SOFTWARE. VOLVO RETAILERS WILL ALSO APPLY A LABEL WITH CORRECT MAXIMUM TIRE PRESSUR…

ELECTRICAL SYSTEM:SOFTWARE

VOLVO IS RECALLING MY 2008-2010 S80, MODEL YEAR 2009-2010 XC70 AND MODEL YEAR 2010 XC60 VEHICLES. UNDER CERTAIN CONDITIONS THE SOFTWARE WITHIN THE CENTRAL ELECTRONIC MODULE (CEM) MAY NOT SEND A SIGNAL TO THE FUEL PUMP ELECTRONIC MODULE (PEM). THIS MISSING SIGNAL TO THE PEM INHIBITS THE START OF THE…

Risk: IF THE VEHICLE STALLS IN CERTAIN CONDITIONS, A CRASH COULD OCCUR.

Remedy: DEALERS WILL DOWNLOAD SOFTWARE TO THE VEHICLES' CEM FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 30, 2009. VEHICLES IN DEALER'S INVENTORY WILL BE REPAIRED PRIOR TO DELIVERY. OWNERS MAY CONTACT VOL…

AIR BAGS:FRONTAL

VOLVO IS RECALLING CERTAIN MODEL YEAR 2010-2011 S80, XC70, MODEL YEAR 2011 XC60 AND MODEL YEAR 2010 V70 VEHICLES. THERE MAY BE AN INTERMITTENT FAULT IN THE DRIVER'S AIRBAG CLOCKSPRING WIRING CONNECTOR FOR THE SUPPLEMENTAL RESTRAINT SYSTEM.

Risk: IN THE EVENT OF A CRASH, THE DRIVER'S FRONTAL AIRBAG MAY NOT DEPLOY AS INTENDED OR AT ALL, AND THEREFORE WILL NOT BE ABLE TO PROPERLY PROTECT THE DRIVER, INCREASING THE RISK OF INJURIES.

Remedy: DEALERS WILL INSTALL A METAL SHIM IN THE DRIVER'S AIR BAG CLOCKSPRING WIRING CONNECTOR. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 20, 2010. OWNERS MAY CONTAC…

ENGINE AND ENGINE COOLING

VOLVO IS RECALLING CERTAIN MODEL YEAR 2011, S80, S60, XC70 AND XC60 VEHICLES. THE SOFTWARE CALIBRATION FOR THE FUEL CUT-OFF FUNCTIONALITY IN THE ENGINE CONTROL MODULE (ECM) IS TOO SENSITIVE.

Risk: SUDDEN ENGINE STALL COULD OCCUR INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL UPDATE THE ECM AND TCM WITH NEW SOFTWARE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE DECEMBER 10, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552 OR AT CUSTOMER…

ELECTRICAL SYSTEM:WIRING

VOLVO IS RECALLING CERTAIN MODEL YEAR 2012 S60, XC60, S80 AND XC70 VEHICLES MANUFACTURED FROM MAY 16, 2011, THROUGH OCTOBER 6, 2011. IN THESE VEHICLES, THE WIRE HARNESS UNDER THE FRONT SEATS MAY HAVE NOT BEEN ATTACHED PROPERLY TO THE SEAT FRAME. AS A RESULT, WHEN THE SEATS ARE MOVED TO ADJUST THE …

Risk: IN THE EVENT OF CRASH, THE FRONT AND/OR SIDE IMPACT AIR BAGS MAY DEPLOY IMPROPERLY OR NOT AT ALL, INCREASING THE RISK OF INJURY. ALSO, THE LAP BELT PRETENSIONER MAY NOT DEPLOY.

Remedy: VOLVO WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND, IF NECESSARY, SECURE THE SEAT WIRE HARNESS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 12, 2012. OWNERS …

TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

Volvo is recalling certain model year 2013 S80 and XC70 vehicles. A software error within the Central Electronic Module (CEM) will result in the "TPMS Service Required" message appearing after approximately 15 minutes of accumulated driving over 25 mph. The error will prevent the Tire Pressure Mon…

Risk: A malfunctioning TPMS cannot warn a driver that a tire is underinflated. Underinflated tires can result in tire overloading and overheating, which could lead to a blowout and possible crash.

Remedy: Volvo will notify owners and dealers will reprogram the vehicle's TPMS. This service will be performed free of charge. The safety recall began on October 12, 2012. Owners may contact Volvo at 1-800…

ELECTRICAL SYSTEM

Volvo is recalling certain model year 2014 S60, S80, XC60 and XC70 vehicles equipped with keyless ignition. In the affected vehicles, the Central Electronic Module (CEM) will not perform as intended. As a result, the front windshield wipers might run continuously when the ignition is on. Also, th…

Risk: Malfunctioning head lamps and/or turn signals increase the risk of a crash.

Remedy: Volvo will notify owners, and dealers will upgrade the CEM software, free of charge. The recall began on October 3, 2013. Owners may contact Volvo at 1-800-458-1552.

ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS

Volvo Cars of North America, LLC. (Volvo) is recalling certain model year 2016 Volvo S60, V60, V60CC, XC60, XC70, and S80 vehicles manufactured April 8, 2015 to August 19, 2015. In certain driving conditions when using the automatic engine stop/start function, the starter motor fuse may blow, preve…

Risk: If the vehicle is unexpectedly unable to be started in the middle of traffic, such as when stopped at an intersection, there is an increased risk of a crash.

Remedy: Volvo will notify owners, and dealers will replace the existing starter motor fuse with a higher amperage fuse, free of charge. The recall began on October 26, 2015. Owners may contact Volvo custome…