Volvo S80 Recalls — All NHTSA Recall Campaigns

EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.

Risk: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.

Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A N…

VEHICLE SPEED CONTROL

ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.

Risk: THIS RESULTED IN A HIGH NUMBER OF VEHICLES GOING INTO THE LIMP HOME MODE WITHOUT NEED.

Remedy: DEALERS WILL INSTALL THE CURRENT SOFTWARE UPGRADE ONTO THE INVOLVED VEHICLES. THE RECALL BEGAN ON DECEMBER 29, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAI…

Risk: LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy: CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.

SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT

VEHICLE DESCRIPTION: PASSENGER VEHICLES. OVER TIME, THE BALL JOINT BETWEEN THE FRONT WHEEL KING PIN AND THE SUSPENSION LINK ARM, CAN EXPERIENCE INCREASED LOOSENESS.

Risk: THIS CONDITION COULD AFFECT THE BALL JOINT'S DURABILITY AND PERFORMANCE.

Remedy: DEALERS WILL REPLACE BOTH FRONT BALL JOINTS.

ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, UNDER CERTAIN OPERATING CONDITIONS, SOME ELECTRIC COOLING FANS MAY OVERHEAT POTENTIALLY CAUSING HEAT DAMAGE AND, IN RARE INSTANCES, A FIRE IN THE ENGINE COMPARTMENT.

Risk: A FIRE IN THE ENGINE COMPARTMENT COULD OCCUR.

Remedy: DEALERS WILL REPLACE THE COOLING FAN. THE RECALL BEGAN ON NOVEMBER 29, 2004. CUSTOMERS SHOULD CONTACT VOLVO CARS AT 1-800-458-1552.

AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

Volvo Car USA, LLC (Volvo Car) is recalling certain 2001-2006 S80 and 2001-2009 S60 vehicles. The driver's air bag inflator may explode during deployment, due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy: Dealers will replace the driver's air bag, free of charge. Owner notification letters were mailed November 29, 2021. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo's number …

AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

Volvo Car USA LLC (Volvo Car) is recalling certain 2001-2003 S80 and S60 vehicles sold or ever registered in Alabama, Arkansas, Florida, Georgia, Hawaii, Louisiana, Mississippi, North Carolina, Oklahoma, South Carolina, Tennessee, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Island…

Risk: Metal fragments can strike vehicle occupants increasing the risk of serious injury or death.

Remedy: Volvo Car will notify owners, and dealers will replace the driver side air bag module, free of charge. The recall began April 20, 2021. Owners may contact Volvo Car customer service at 1-800-458-155…

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLIN…

Risk: IF THE CONDITION OCCURS VEHICLE OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT THE FUEL PUMP INSTALLED IN THE VEHICLE, AND IF NECESSARY REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL…

SEAT BELTS:FRONT:ANCHORAGE

VEHICLE DESCRIPTION: SEDANS AND WAGONS. THE REAR OUTBOARD SEAT BELT ANCHORAGE BOLTS MAY HAVE BEEN INCORRECTLY TIGHTENED.

Risk: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF INJURY.

Remedy: DEALERS WILL INSPECT THE ANCHORAGE BOLTS AND TIGHTEN TO THE CORRECT TORQUE LEVEL. OWNER NOTIFICATION BEGAN MAY 7, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERV…

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

VOLVO IS RECALLING CERTAIN MODEL YEAR 2011-2013 S80 VEHICLES. A SOFTWARE ERROR MAY PREVENT THE TRANSMISSION FROM DOWNSHIFTING SUCH AS SHIFTING FROM FIFTH TO FOURTH GEAR WHEN COASTING.

Risk: THIS MAY RESULT IN DECREASED ENGINE RPMS AND POSSIBLE ENGINE STALL, INCREASING THE RISK OF A CRASH.

Remedy: VOLVO WILL NOTIFY OWNERS, AND DEALERS WILL UPGRADE THE SOFTWARE TO THE TRANSMISSION CONTROL MODULE, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 10, 2012. OWNERS MAY CONTACT VOLVO CARS AT 1-800…

ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

VOLVO IS RECALLING 17,614 MY 2008-2009 S80, V70, AND XC70 VEHICLES. THE ENGINE COOLING FAN MAY STOP WORKING DUE TO A SOFTWARE PROGRAMMING ERROR IN THE FAN CONTROL MODULE (FCM). DEPENDING ON DRIVING CONDITIONS, THE CUSTOMER MAY EXPERIENCE REDUCED AIR CONDITIONING PERFORMANCE, AND/OR RAPID INCREASE …

Risk: THIS SITUATION MAY RESULT IN LOSS OF COOLING SYSTEM FUNCTION AND ENGINE FAILURE. THE DRIVER MAY NOT HAVE SUFFICIENT TIME TO REACT TO THE WARNING LIGHT(S) OR THE TEXT MESSAGE IN THE INSTRUMENT PANEL, I…

Remedy: DEALERS WILL REPLACE THE FAN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2009. OWNERS MAY CONTACT VOLVO CUSTOMER CARE CENTER AT 1-800-458-1552.

EQUIPMENT:OTHER:LABELS

CERTAIN PASSENGER CARS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE SECOND ISOFIX GUIDE WAS NOT INSTALLED IN THESE VEHICLES AND, IN CERTAIN CASES, THE OWNER'S MANUAL ISOFIX INFORMATION IS INCORRECT.

Risk: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.

Remedy: OWNERS WILL RECEIVE A LETTER/PACKAGE CONSISTING OF THE SECOND ISOFIX GUIDE WITH INSTALLATION INSTRUCTIONS, AND IN CERTAIN CASES, THE CORRECTED OWNER'S MANUAL MAY BE PROVIDED. IF THE OWNER WANTS TO TA…

STEERING:LINKAGES

ON CERTAIN PASSENGER VEHICLES, THE FRONT CONTROL ARMS MAY NOT HAVE BEEN MANUFACTURED CORRECTLY AND, AS A RESULT, THE STUD AND NUT THAT SECURE THE ARM TO THE SPINDLE MAY LOSE THEIR INITIAL AXIAL TENSION. UNDER CERTAIN DRIVING CONDITIONS, THE STEERING MAY BECOME LESS RESPONSIVE AND THE DRIVER MAY EXP…

Risk: THIS DRIVING CONDITION COULD EVENTUALLY LEAD TO SEPARATION BETWEEN THE FRONT CONTROL ARM AND THE SPINDLE, WHICH COULD RESULT IN A CRASH.

Remedy: DEALERS WILL INSTALL A NEW TYPE OF NUT. OWNER NOTIFICATION BEGAN ON FEBRUARY 16, 2004. OWNERS SHOULD CONTACT VOLVO CARS AT 1-800-458-1552.

ELECTRICAL SYSTEM:STARTER ASSEMBLY:SOLENOID

ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, DUE TO AN ERROR IN THE FACTORY ASSEMBLY INSTRUCTION, THE B+TERMINAL MAY BE IN CONFLICT WITH THE STARTER MOTOR SOLENOID. IF THIS OCCURS, THE CONFLICT BETWEEN THE B+TERMINAL AND THE STARTER MOTOR SOLENOID MAY DEVELOP INTO A SHORT CIRCUIT OF THE BATTER…

Risk: SMOKE MAY APPEAR FROM UNDER THE HOOD AND IT MAY BE IMPOSSIBLE TO START THE CAR. IF THE SHORT CIRCUIT HAPPENS DURING DRIVING, ELECTRICAL POWER COULD BE LOST RESULTING IN THE WARNING LAMPS BEING DEACTI…

Remedy: DEALERS WILL INSPECT AND INCREASE DISTANCE BETWEEN THE B+TERMINAL AND THE STARTER MOTOR SOLENOID BY ADJUSTING THE TERMINAL. THE RECALL BEGAN ON JANUARY 31, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-45…

EQUIPMENT:OTHER:LABELS

CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE LABEL DENOTING THE TIRE AND LOADING PRESSURE INFORMATION IS INCORRECT.

Risk: A MISPRINTED LABEL WOULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL MAIL THE CORRECT LABELS FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 18, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.

SEAT BELTS:FRONT

Volvo Cars of N.A., LLC (Volvo) is recalling certain 2008-2016 V70 and XC70, 2007-2016 S80, 2011-2018 S60 and V60, 2016-2018 S60 Cross Country, 2014-2020 S60L, 2009-2015 S80L, 2009-2016 XC60 and 2015-2018 V60 Cross Country vehicles. The flexible steel cable that connects the seat belt to the front …

Risk: An unsecured occupant has an increased risk of injury in the event of a crash.

Remedy: Volvo will notify owners, and dealers will replace the seat belt anchor cable for both front seats. The recall began December 10, 2020. Owners may contact Volvo customer service at 1-800-458-1552. …

STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS

VOLVO IS RECALLING CERTAIN MODEL YEAR 2007 S80 PASSENGER CARS MANUFACTURED FROM MARCH 8, 2006, THROUGH MAY 16, 2007. THE POWER STEERING RESERVOIR RETURN HOSE MAY HAVE BEEN INCORRECTLY ROUTED, WHICH CAN RESULT IN INCREASED PRESSURE IN THE POWER STEERING SYSTEM. THE POWER STEERING RETURN HOSE MAY BUR…

Risk: THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING, INCREASING THE RISK OF A CRASH.

Remedy: VOLVO DEALERS WILL INSPECT THE ROUTING OF THE POWER STEERING RESERVOIR RETURN HOSE AND MAKE REPAIRS AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING AUGUST 2011. OWNERS MA…

ELECTRICAL SYSTEM:SOFTWARE

VOLVO IS RECALLING 12,303 MY 2007-2008 S80 AND V70 VEHICLES. THE DIAGNOSTIC SOFTWARE IN THE CENTRAL ELECTRONIC MODULE (CEM) MAY CAUSE A MALFUNCTION OF THE WINDSHIELD WIPER FUNCTIONALITY. IF THIS CONDITION OCCURS, THE WINDSHIELD WIPERS MAY NOT OPERATE WHEN ACTIVATED; OR IN CERTAIN CASES THE WINDSHIE…

Risk: OPERATING A MOTOR VEHICLE DURING INCLEMENT WEATHER CONDITIONS WITHOUT FUNCTIONING WINDSHIELD WIPERS CAN INCREASE THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT THE CEM AND UPGRADE THE SOFTWARE FREE OF CHARGE. THE RECALL BEGAN ON MAY 15, 2009. OWNERS MAY CONTACT VOLVO CUSTOMER CARE CENTER AT 1-800-458-1552, OR CUSTOMERCARE@VOLVOFORLIFE.…

TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

VOLVO IS RECALLING CERTAIN MODEL YEAR 2007-2010 S80 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE AND LOADING INFORMATION LABEL AND A PAGE IN THE OWNER'S MANUAL CONTAIN INCORRECT MAXIMUM PERMISSIBLE INFLATI…

Risk: THESE VEHICLES DO NOT MEET THE REQUIRED SAFETY STANDARDS.

Remedy: DEALERS WILL UPDATE THE VEHICLES WITH A NEW TIRE AND LOADING INFORMATION LABEL, OWNER'S MANUAL LABEL AND TPMS SOFTWARE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED T…

ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS

Volvo Cars of North America, LLC. (Volvo) is recalling certain model year 2016 Volvo S60, V60, V60CC, XC60, XC70, and S80 vehicles manufactured April 8, 2015 to August 19, 2015. In certain driving conditions when using the automatic engine stop/start function, the starter motor fuse may blow, preve…

Risk: If the vehicle is unexpectedly unable to be started in the middle of traffic, such as when stopped at an intersection, there is an increased risk of a crash.

Remedy: Volvo will notify owners, and dealers will replace the existing starter motor fuse with a higher amperage fuse, free of charge. The recall began on October 26, 2015. Owners may contact Volvo custome…

ELECTRICAL SYSTEM:SOFTWARE

VOLVO IS RECALLING MY 2008-2010 S80, MODEL YEAR 2009-2010 XC70 AND MODEL YEAR 2010 XC60 VEHICLES. UNDER CERTAIN CONDITIONS THE SOFTWARE WITHIN THE CENTRAL ELECTRONIC MODULE (CEM) MAY NOT SEND A SIGNAL TO THE FUEL PUMP ELECTRONIC MODULE (PEM). THIS MISSING SIGNAL TO THE PEM INHIBITS THE START OF THE…

Risk: IF THE VEHICLE STALLS IN CERTAIN CONDITIONS, A CRASH COULD OCCUR.

Remedy: DEALERS WILL DOWNLOAD SOFTWARE TO THE VEHICLES' CEM FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 30, 2009. VEHICLES IN DEALER'S INVENTORY WILL BE REPAIRED PRIOR TO DELIVERY. OWNERS MAY CONTACT VOL…

ENGINE AND ENGINE COOLING:ENGINE

VOLVO IS RECALLING 102 MY 2008 XC90 AND S80 VEHICLES EQUIPPED WITH V8 ENGINES. THESE VEHICLES MAY HAVE BEEN BUILT WITH INCORRECT BOLTS TO THE ENGINE MOUNT.

Risk: THE ALUMINUM BRACKET FOR THE ENGINE MOUNT COULD BREAK DUE TO LACK OF ADEQUATE CLAMPING FORCE. THIS COULD CAUSE THE ENGINE TO COME IN CONTACT WITH THE SUB-FRAME, ULTIMATELY RESULTING IN A REDUCED ENGI…

Remedy: DEALERS WILL INSPECT THE ENGINE MOUNT BOLTS FOR SPECIFIC MARKINGS. IF ANY OF THE BOLTS CONTAIN THE INCORRECT MARKINGS, THE BRACKET AND BOLTS WILL BE REPLACED. ALL OWNERS HAVE BEEN CONTACTED AND ARRA…

AIR BAGS:FRONTAL

VOLVO IS RECALLING CERTAIN MODEL YEAR 2010-2011 S80, XC70, MODEL YEAR 2011 XC60 AND MODEL YEAR 2010 V70 VEHICLES. THERE MAY BE AN INTERMITTENT FAULT IN THE DRIVER'S AIRBAG CLOCKSPRING WIRING CONNECTOR FOR THE SUPPLEMENTAL RESTRAINT SYSTEM.

Risk: IN THE EVENT OF A CRASH, THE DRIVER'S FRONTAL AIRBAG MAY NOT DEPLOY AS INTENDED OR AT ALL, AND THEREFORE WILL NOT BE ABLE TO PROPERLY PROTECT THE DRIVER, INCREASING THE RISK OF INJURIES.

Remedy: DEALERS WILL INSTALL A METAL SHIM IN THE DRIVER'S AIR BAG CLOCKSPRING WIRING CONNECTOR. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 20, 2010. OWNERS MAY CONTAC…

ENGINE AND ENGINE COOLING

VOLVO IS RECALLING CERTAIN MODEL YEAR 2011, S80, S60, XC70 AND XC60 VEHICLES. THE SOFTWARE CALIBRATION FOR THE FUEL CUT-OFF FUNCTIONALITY IN THE ENGINE CONTROL MODULE (ECM) IS TOO SENSITIVE.

Risk: SUDDEN ENGINE STALL COULD OCCUR INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL UPDATE THE ECM AND TCM WITH NEW SOFTWARE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE DECEMBER 10, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552 OR AT CUSTOMER…

ELECTRICAL SYSTEM:WIRING

VOLVO IS RECALLING CERTAIN MODEL YEAR 2012 S60, XC60, S80 AND XC70 VEHICLES MANUFACTURED FROM MAY 16, 2011, THROUGH OCTOBER 6, 2011. IN THESE VEHICLES, THE WIRE HARNESS UNDER THE FRONT SEATS MAY HAVE NOT BEEN ATTACHED PROPERLY TO THE SEAT FRAME. AS A RESULT, WHEN THE SEATS ARE MOVED TO ADJUST THE …

Risk: IN THE EVENT OF CRASH, THE FRONT AND/OR SIDE IMPACT AIR BAGS MAY DEPLOY IMPROPERLY OR NOT AT ALL, INCREASING THE RISK OF INJURY. ALSO, THE LAP BELT PRETENSIONER MAY NOT DEPLOY.

Remedy: VOLVO WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND, IF NECESSARY, SECURE THE SEAT WIRE HARNESS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 12, 2012. OWNERS …

TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

Volvo is recalling certain model year 2013 S80 and XC70 vehicles. A software error within the Central Electronic Module (CEM) will result in the "TPMS Service Required" message appearing after approximately 15 minutes of accumulated driving over 25 mph. The error will prevent the Tire Pressure Mon…

Risk: A malfunctioning TPMS cannot warn a driver that a tire is underinflated. Underinflated tires can result in tire overloading and overheating, which could lead to a blowout and possible crash.

Remedy: Volvo will notify owners and dealers will reprogram the vehicle's TPMS. This service will be performed free of charge. The safety recall began on October 12, 2012. Owners may contact Volvo at 1-800…

ELECTRICAL SYSTEM

Volvo is recalling certain model year 2014 S60, S80, XC60 and XC70 vehicles equipped with keyless ignition. In the affected vehicles, the Central Electronic Module (CEM) will not perform as intended. As a result, the front windshield wipers might run continuously when the ignition is on. Also, th…

Risk: Malfunctioning head lamps and/or turn signals increase the risk of a crash.

Remedy: Volvo will notify owners, and dealers will upgrade the CEM software, free of charge. The recall began on October 3, 2013. Owners may contact Volvo at 1-800-458-1552.