Volvo C70 Recalls — All NHTSA Recall Campaigns

EXTERIOR LIGHTING:HEADLIGHTS:SWITCH

ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, OVER AN EXTENDED PERIOD OF TIME, THE HEADLIGHT SWITCH MAY CEASE TO FUNCTION.

Risk: THE HEAD LIGHTS MAY NOT OPERATE PROPERLY WHICH COULD RESULT IN INTERMITTENT OR NO HEADLIGHT FUNCTION. THIS COULD IMPAIR A DRIVER'S VISIBILITY, INCREASING THE RISK OF A CRASH.

Remedy: ON VEHICLES WITH AN ORIGINAL OEM SWITCH, DEALERS WILL REPLACE THE HEADLIGHT SWITCH. ALL OTHER VEHICLES WILL BE INSPECTED TO DETERMINE IF THE SWITCH HAS EEN DAMAGED AND REPLACE ONLY IF NECESSARY. TH…

AIR BAGS:FRONTAL

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FRONTAL PASSENGER AIR BAG MAY BE OVERLY SENSITIVE TO CERTAIN ELECTROSTATIC DISCHARGE.

Risk: THIS COULD POSSIBLY CAUSE AN INADVERTENT DEPLOYMENT.

Remedy: DEALERS WILL INSTALL AN ADDITIONAL GROUND WIRE IN THE PASSENGER SIDE TO ASSURE SUFFICIENT GROUNDING.

EXTERIOR LIGHTING:HEADLIGHTS:SWITCH

VEHICLE DESCRIPTION: PASSENGER VEHICLES. OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.

Risk: DRIVER'S COULD EXPERIENCE A LOSS OF VISIBILITY, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE HEADLIGHT SWITCH.

EXTERIOR LIGHTING:TURN SIGNAL

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THERE COULD BE INADEQUATE CONTACT BETWEEN THE BULB AND SOCKET WHICH COULD CAUSE THE FRONT TURN SIGNAL NOT TO FUNCTION AS DESIGNED.

Risk: THIS WOULD FAIL TO WARN AN APPROACHING DRIVER THAT THE VEHICLE IS TURNING AND COULD LEAD TO A CRASH.

Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT FRONT TURN SIGNAL BULB AND SOCKET.

VEHICLE SPEED CONTROL

ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.

Risk: THIS RESULTED IN A HIGH NUMBER OF VEHICLES GOING INTO THE LIMP HOME MODE WITHOUT NEED.

Remedy: DEALERS WILL INSTALL THE CURRENT SOFTWARE UPGRADE ONTO THE INVOLVED VEHICLES. THE RECALL BEGAN ON DECEMBER 29, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAI…

Risk: LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy: CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.

EQUIPMENT:OTHER:LABELS

VOLVO IS RECALLING CERTAIN MODEL YEAR 2006-2012 C70 VEHICLES MANUFACTURED FROM NOVEMBER 15, 2005, THROUGH JULY 31, 2011, AND MODEL YEAR 2011-2012 S60 VEHICLES MANUFACTURED FROM JULY 14, 2010, THROUGH APRIL 16, 2011, THAT WERE EQUIPPED WITH OPTIONAL ACCESSORY SPARE TIRE KIT. THESE VEHICLES FAIL TO C…

Risk: A MISPRINTED LABEL COULD LEAD TO IMPROPER TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.

Remedy: VOLVO WILL NOTIFY OWNERS AND DEALERS WILL INSPECT THE VEHICLE AND INSTALL THE LABEL AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 23, 2012. OWNERS MAY CONTACT VOLVO AT 1-201-768-…

EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.

Risk: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.

Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A N…

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

VOLVO IS RECALLING 1,114 MY 2007 C30, C70, S40, AND V50 PASSENGER VEHICLES. A SOFT ANODIZED LAYER IN THE MASTER CYLINDER MAY TRIGGER EARLY WEAR ON A RUBBER SEAL THAT CAN RESULT IN INTERNAL LEAKAGE OF BRAKE FLUID. IF AFFECTED, THE DRIVER MAY EXPERIENCE REDUCED BRAKE PERFORMANCE WHEN APPLYING AND MA…

Risk: THE CAPACITY TO BRAKE WILL GRADUALLY DETERIORATE FORCING THE DRIVER TO USE A HIGHER THAN EXPECTED FORCE ON THE BRAKE PEDAL WHEN COMPARED TO AN INTACT BRAKE SYSTEM. THE DETERIORATION CAN EVENTUALLY RE…

Remedy: DEALERS WILL INSPECT THE MASTER CYLINDER. THE BRAKE MASTER CYLINDER AND BRAKE FLUID RESERVOIR WILL BE REPLACED AND CERTAIN BRAKE LINES CLEANED FREE OF CHARGE. THE RECALL BEGAN ON MARCH 11, 2008. OW…

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

ON CERTAIN PASSENGER VEHICLES, AN INCORRECT TEMPORARY ASSEMBLY INSTRUCTION RESULTED IN AN INCORRECT ASSEMBLY OF THE LEFT DOOR HANDLE BOWDEN CABLE ATTACHMENT.

Risk: THIS INCORRECT ASSEMBLY MAY RESULT IN THE LEFT DOOR NOT MEETING CERTAIN LEGAL REQUIREMENTS AT A CERTAIN CRASH SCENARIO.

Remedy: DEALERS WILL ADJUST THE LEFT DOOR BOWDEN CABLE BY REMOVING AN EXISTING CABLE TIE AND PLACING THE BOWDEN CABLE IN ITS DESIGNATED POSITION FREE OF CHARGE. THE RECALL BEGAN ON JUNE 29, 2007. OWNERS MAY…

STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS

VOLVO IS RECALLING MY 2008-2009 VEHICLES. A SECTION OF THE POWER STEERING RETURN LINE HOSE WAS NOT PROPERLY VULCANIZED (CURED) AND DOES NOT MEET SPECIFICATIONS. IF THE POWER STEERING RETURN HOSE FAILS, A SUDDEN RUPTURE OF THE HOSE CAN OCCUR.

Risk: THIS CAN RESULT IN A RAPID DRAINAGE OF THE POWER STEERING FLUID IN THE SYSTEM AND A COMPLETE LOSS OF POWER ASSISTANCE, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT AND REPLACE THE STEERING RETURN LINE HOSE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 13, 2008. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.