Subaru Ascent Recalls — All NHTSA Recall Campaigns

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

Subaru of America, Inc. (Subaru) is recalling certain 2019-2020 Ascent, 2020 Legacy and Outback vehicles. A programming error in the Transmission Control Unit (TCU) may allow the clutch to engage before the drive chain is completely clamped.

Risk: An improperly secured drive chain may slip and break, causing a loss of drive power and increasing the risk of a crash.

Remedy: Dealers will reprogram the TCU, inspect TCU data for chain slip, and visually inspect the chain guide. If evidence of chain slippage or damage is found, the transmission will be replaced. Repairs wi…

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

Subaru of America, Inc. (Subaru) is recalling certain 2019 Ascent vehicles. The transmission hydraulic sensor may inaccurately measure the hydraulic fluid pressure.

Risk: If the fluid pressure is measured higher than its actual value, the hydraulic pressure will be reduced. If this occurs, the transmission drive chain may not have the proper tension, resulting in a lo…

Remedy: Subaru will notify owners, and dealers will reprogram the transmission control unit. The hydraulic sensor harness will be replaced on vehicles with certain stored diagnostic trouble codes. In additi…

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Subaru of America, Inc. (Subaru) is recalling certain 2019-2020 Ascent, 2018 Forester, 2018-2020 Impreza, Legacy, Outback, 2018-2019 BRZ, WRX, and Toyota 86 vehicles. The low-pressure fuel pump inside the fuel tank may fail.

Risk: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.

Remedy: Dealers will replace the low-pressure fuel pump, free of charge. Owner notification letters were mailed September 24, 2021. Subaru and Toyota owners may call customer service at 1-844-373-6614. Sub…

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Subaru of America, Inc. (Subaru) is recalling certain 2019 Impreza, Outback, Legacy, and Ascent vehicles. The low pressure fuel pump may become inoperative.

Risk: If the low pressure fuel pump fails, the engine may stall without the ability to restart the vehicle, increasing the risk of a crash.

Remedy: Subaru will notify owners, and dealers will replace the low pressure fuel pump, free of charge. The recall began June 4, 2020. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's…

TIRES

Subaru of America, Inc. (Subaru) is recalling certain 2023 Ascent vehicles equipped with 20-inch wheels. The internal tire bead may have been damaged during the wheel mounting process.

Risk: A damaged tire may experience a sudden loss of air pressure, increasing the risk of a crash.

Remedy: Dealers will replace all four tires, free of charge. Owner notification letters are expected to be mailed June 6, 2023. Owners may contact Subaru's customer service at 1-844-373-6614. Subaru's numb…

SUSPENSION:FRONT:CONTROL ARM:LOWER ARM

Subaru of America, Inc. (Subaru) is recalling certain 2023 Ascent vehicles. The left or right front lower control arm may have an improperly tightened ball joint castle nut which can result in retention pin failure and separation of the ball joint from the lower control arm.

Risk: Ball joint separation while the vehicle is in motion can cause a loss of vehicle control, increasing the risk of a crash.

Remedy: Dealers will inspect and, if necessary, replace the lower control arm, free of charge. Owner notification letters are expected to be mailed June 30, 2023. Owners may contact Subaru's customer servic…

ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH

Subaru of America, Inc. (Subaru) is recalling certain 2019-2022 Ascent vehicles. The ground bolt that secures the ground terminal of the Positive Temperature Coefficient (PTC) heater may have been improperly fastened, which could result in melting of the ground terminal and surrounding components.

Risk: A melting ground terminal increases the risk of a fire.

Remedy: Owners are advised to park their vehicle away from structures and to avoid leaving the vehicle unattended while the engine is running. An owner who notices or smells smoke coming from the dash or dri…

STEERING:LINKAGES:TIE ROD ASSEMBLY

Subaru of America, Inc. (Subaru) is recalling certain 2020 Ascent vehicles. Due to an incorrect tapered hole in the housing, the front tie rod ends may not fit properly. The improper fit can result in the tie rods and housings being deformed during assembly and service replacement if excessive tor…

Risk: The tie rods may separate from the housing, causing a loss of steering control and increasing the risk of a crash.

Remedy: Dealers will replace the left and right front tie rod ends and housings, free of charge. Owner notification letters were mailed February 7, 2022. Owners may contact Subaru customer service at 1-844-…

POWER TRAIN:DRIVELINE:DRIVESHAFT

Subaru of America, Inc. (Subaru) is recalling certain 2019 Ascent vehicles. The center support bolts for the driveshaft may loosen, possibly resulting in the front portion of the driveshaft disconnecting.

Risk: If the front end of the driveshaft separates, it can increase the risk of a crash.

Remedy: Subaru will notify owners, and dealers will replace the driveshaft assembly, including the center support brace, free of charge. The recall began July 26, 2019. Owners may contact Subaru customer se…

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)

Subaru of America, Inc. (Subaru) is recalling certain 2019 Crosstrek, Forester, and Ascent vehicles. The aluminum Positive Crankcase Ventilation (PCV) valve can separate, allowing the separated components to enter the engine, resulting in a loss of power while driving.

Risk: An unexpected loss of power while driving can increase the risk of a crash.

Remedy: Subaru will notify owners, and dealers will inspect and replace the PCV valve, free of charge. If the PCV valve has separated and the components cannot be found, the short block engine will be replac…

STRUCTURE:BODY:ROOF AND PILLARS

Subaru of America, Inc. (Subaru) is recalling certain 2019 Subaru Ascent vehicles. These vehicles may be missing spot welds on, or around, the B-Pillar, compromising vehicle strength.

Risk: In the event of a crash, the missing spot welds may compromise the vehicle's strength, increasing the risk of injury.

Remedy: Subaru will notify owners, and dealers will inspect the vehicle to check for missing spot welds. If the welds are missing, the vehicle will be replaced, free of charge. The recall began July 31, 201…

POWER TRAIN:DRIVELINE:DRIVESHAFT

Subaru of America, Inc. (Subaru) is recalling certain 2023 Outback, Legacy, Ascent, and Impreza vehicles. The center support bolts for the driveshaft may loosen, resulting in the disconnection of the front end of the driveshaft.

Risk: Separation of the front end of the driveshaft increases the risk of a crash.

Remedy: Dealers will clean the bolt mounting surfaces of the center support brace and install new bolts, free of charge. Owner notification letters were mailed November 20, 2023. Owners may contact Subaru's…