Saturn Vue Recalls — All NHTSA Recall Campaigns

ELECTRICAL SYSTEM:IGNITION

General Motors LLC (GM) is recalling certain model year 2002-2004 Saturn Vue vehicles manufactured September 11, 2001, to April 6, 2004. In the affected vehicles, it may be possible for the key to be removed from the ignition when the ignition is not in the "Off" position.

Risk: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" pos…

Remedy: GM will notify owners, and dealers will inspect the vehicle to see if the key can be pulled out when the ignition is off. If it can, dealers will replace the ignition cylinder and keys, free of charg…

SEAT BELTS:FRONT:ANCHORAGE

VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." SOME VEHICLES WERE PRODUCED WITH REAR OUTER SEAT BELT SHOULDER GUIDE ANCHOR BOLTS THAT WERE INCORRECTLY INSTALLED.

Risk: IF THESE BOLTS WERE INCORRECTLY INSTALLED, THEY WOULD NOT WITHSTAND THE LOAD REQUIREMENTS OF THE STANDARD. IF AN ANCHORAGE FAILED IN A CRASH, THE OCCUPANT WOULD NOT BE PROPERLY RESTRAINED AND COULD …

Remedy: DEALERS WILL REPLACE THE REAR SHOULDER GUIDE ANCHOR BOLTS. OWNER NOTIFICATION BEGAN DECEMBER 19, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NO…

EQUIPMENT:OTHER:LABELS

CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 3.5L V6 (L66) ENGINES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR VEHICLES OTHER THAN PASSENGER CARS." THE FRONT AND REAR WHEEL RIM SIZE SPECIFICATIONS ON THE TIRE/CERTIFICATION LABEL…

Risk: IF THE WHEEL RIM SIZE IS INCORRECTLY PRINTED ON A TIRE/CERTIFICATION LABEL, A SERVICE TECHNICIAN WHO SOLELY USES THE TIRE/CERTIFICATION LABEL FOR SERVICE INFORMATION MAY ATTEMPT TO REPLACE A DAMAGED W…

Remedy: OWNERS WILL BE PROVIDED WITH A CORRECTED LABEL AND INSTALLATION INSTRUCTIONS. OWNER NOTIFICATION BEGAN ON DECEMBER 15, 2003. OWNERS SHOULD CONTACT SATURN AT 1-800-553-6000.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

GM IS RECALLING 44,451 MY 2008 SATURN VUE VEHICLES WITH BODY COLOR OUTSIDE DOOR HANDLES. THE OUTSIDE DOOR HANDLES MAY STICK OR BIND. IF THIS WERE TO OCCUR, THE DOOR MAY NOT LATCH WHEN CLOSED.

Risk: DRIVING WITH AN UNLATCHED DOOR COULD RESULT IN AN UNBELTED OCCUPANT FALLING OUT OF THE VEHICLE, CAUSING INCREASED RISK OF INJURY.

Remedy: DEALERS WILL REPLACE THE OUTSIDE DOOR HANDLES WITH CHROME DOOR HANDLES FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE AUGUST 18, 2009. OWNER MAY CONTACT SATURN AT 1-800-972-8876 OR AT …

STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS

GM IS RECALLING 42,408 MY 2008-2009 SATURN VUE VEHICLES. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH THE NUT SECURING THE POWER STEERING LINE TO THE POWER STEERING PUMP MAY LOOSEN. IF THIS WERE TO OCCUR, THERE MAY BE A POWER STEERING FLUID LEAK.

Risk: THE FLUID COULD CONTACT HOT EXHAUST COMPONENTS RESULTING IN A POSSIBLE ENGINE COMPARTMENT FIRE.

Remedy: DEALERS WILL INSPECT THE NUT SECURING THE POWER STEERING LINE TO THE POWER STEERING PUMP. IF THERE ARE NO SIGNS OF A FLUID LEAK, DEALERS WILL TIGHTEN THE NUT. IF A FLUID LEAK IS PRESENT, DEALER WILL…

POWER TRAIN:AUTOMATIC TRANSMISSION

GM IS RECALLING 26 MY 2008 SATURN VUE VEHICLES EQUIPPED WITH A 6T70 6-SPEED AUTOMATIC TRANSMISSION. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH THE TRANSMISSION CASE SIDE BORE THAT HOLDS THE PARK PAWL PIVOT PIN MAY HAVE A CASTING POROSITY. THIS CONDITION, COUPLED WITH NORMAL OPERATING STRESSE…

Risk: IF THIS HAPPENS WHILE THE VEHICLE IS PARKED ON A NON-LEVEL SURFACE, THE VEHICLE COULD ROLL WITHOUT WARNING AND CAUSE INJURY TO PEOPLE IN ITS PATH.

Remedy: DEALERS WILL REPLACE THE TRANSMISSION FREE OF CHARGE. THE RECALL BEGAN ON MAY 5, 2008. OWNERS MAY CONTACT SATURN AT 1-800-972-8876, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>H…

STEERING:LINKAGES:KNUCKLE:SPINDLE:ARM

GM IS RECALLING 2,149 MY 2009 SATURN VUE VEHICLES. SOME OF THESE VEHICLES MAY HAVE BEEN BUILT WITH AN INCORRECT RIGHT AND/OR LEFT FRONT STEERING KNUCKLE. AS A RESULT OF THE INCORRECT KNUCKLE AND RESULTING INADEQUATE CLEARANCE, THE TIE ROD BALL STUD COULD PULL OUT OF, OR FRACTURE, THE TIE ROD HOUSI…

Risk: ALTHOUGH STEERING CONTROL OF THE VEHICLE COULD BE MAINTAINED AFTER A TIE ROD SEPARATION BY THE UNAFFECTED WHEEL ON SMOOTH ROADS OR DURING LIGHT BRAKING, WITH MORE SIGNIFICANT SUSPENSION OR BRAKING INP…

Remedy: DEALERS WILL INSPECT THE STEERING KNUCKLES AND, IF NECESSARY, REPLACE THE STEERING KNUCKLE(S) AND TIE ROD(S). THE RECALL BEGAN ON DECEMBER 8, 2008. OWNERS MAY CONTACT SATURN AT 1-800-972-8876 OR THR…