Saturn SC Recalls — All NHTSA Recall Campaigns

SEATS

VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME FRONT SEAT BACK RECLINER GEAR TEETH MAY WEAR EXCESSIVELY THROUGH REPEATED USE, AND COULD CAUSE THE SEAT BACK TO SLIP PARTIALLY REARWARD WHEN FORCE IS APPLIED.

Risk: IF THIS HAPPENS WHILE THE VEHICLE IS BEING DRIVEN, IT COULD CAUSE A LOSS OF CONTROL, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE FRONT SEAT RECLINER MECHANISMS.

POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)

THE AUTOMATIC TRANSAXLE PARK LOCK CABLE ASSEMBLY WAS IMPROPERLY ADJUSTED MAKING IT POSSIBLE TO SHIFT FROM THE "PARK" POSITION WITH THE IGNITION KEY REMOVED, OR REMOVE THE IGNITION KEY WITH THE SHIFT LEVER IN A POSITION OTHER THAN "PARK." THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS 114, "THEFT PROTE…

Risk: CONSEQUENCE OF NON-COMPLIANCE: UNINTENDED VEHICLE MOVEMENT CAN OCCUR WHICH COULD RESULT IN AN ACCIDENT.

Remedy: CONSUMERS ARE BEING ASKED TO INSPECT THE PARK LOCK CABLE. IF IT DOES NOT PERFORM CORRECTLY, DEALERS WILL MAKE THE NECESSARY ADJUSTMENTS.

ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR

THE GENERATOR ELECTRICAL WIRING IS NOT PROTECTED AGAINST EXCESSIVE CURRENT FLOW WHICH MAY BE CAUSED BY AN ELECTRICAL SHORT CIRCUIT IN THE GENERATOR.

Risk: SHOULD AN ELECTRICAL SHORT CIRCUIT OCCUR IN THEGENERATOR, THE GENERATOR WIRING HARNESS WOULD EXPERIENCE EXCESSIVE CURRENT FLOW.UNDER CERTAIN CONDITIONS, ENOUGH HEAT COULD BE GENERATED TO IGNITE SURROU…

Remedy: THE GENERATOR WIRING HARNESS WILL BE REPLACED WITH ONE THAT WILL OPEN AS A FUSE WOULD UNDER CERTAIN EXCESSIVE CURRENT FLOW CONDITIONS.

POWER TRAIN

THE TRANSAXLE VALVE ASSEMBLIES WERE IMPROPERLY MACHINED. VEHICLES MAY NOT PROPERLY ENGAGE IN NEUTRAL OR PARK, EVEN THOUGH THE GEAR SELECTOR INDICATES THE VEHICLE IS IN NEUTRAL OR PARK.

Risk: IF THE GEAR SELECTOR INDICATES THE VEHICLE IS IN PARK ORNEUTRAL, IT COULD BE IN REVERSE OR DRIVE. IF THIS HAPPENS, THE CAR COULD STARTIN REVERSE OR DRIVE, OR MIGHT MOVE UNEXPECTEDLY, WHICH MAY RESULT …

Remedy: REPLACE THE DEFECTIVE VALVE BODIES.

EXTERIOR LIGHTING:HEADLIGHTS

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SECTION OF THE OWNER'S HANDBOOK TITLED "HORIZONTAL AIM" DOES NOT SPECIFICALLY INSTRUCT AN OWNER HOW TO ADJUST THE HEADLAMP HORIZONTAL AIM. THIS DOES NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Risk: A VEHICLE'S HEADLAMP WOULD NOT BE PROPERLY ADJUSTED CAUSING VISIBILITY PROBLEMS TO ONCOMING VEHICLES.

Remedy: OWNERS ARE BEING PROVIDED WITH A LABEL WITH THE CORRECT INFORMATION ON HEADLAMP HORIZONTAL AIM TO BE PLACED OVER THE EXISTING TEXT IN THE OWNER'S HANDBOOK. IF AN OWNER DESIRES, THEIR DEALER CAN PLACE…

SEAT BELTS:FRONT:RETRACTOR

VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE DRIVER OR FRONT PASSENGER SAFETY BELT IS PULLED OUT MUCH FASTER THAN NORMAL, A NUMBER OF TIME, THE LOCK-UP FEATURE OF THE RETRACTOR WILL NOT WORK PROPERLY.

Risk: IN A RAPID DECELERATION OR VEHICLE CRASH, THE OCCUPANT WOULD NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.

Remedy: DEALERS WILL REPLACE THE DRIVER AND FRONT PASSENGER SAFETY BELT RETRACTOR.

SEATS

THE FRONT PASSENGER SEATS HAVE LESS LOCK PAWL ENGAGEMENT ON THE INBOARD FORE/AFT ADJUSTER THAN SPECIFIED. THIS DOES NOT COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207, "SEATING SYSTEMS."

Risk: THIS CONDITION COULD RESULT IN SEAT MOVEMENT WITH A BELTED OCCUPANT DURING A MODERATE TO SEVERE FRONTAL IMPACT.

Remedy: DEALERS WILL INSPECT AND REPLACE THE PASSENGER SEAT INBOARD FORE/AFT ADJUSTER.

SEAT BELTS:FRONT:ANCHORAGE

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." SOME OF THE VEHICLES WERE PRODUCED WITH SEAT BELT SHOULDER GUIDE ANCHOR BOLTS THAT WERE NOT ADEQUATELY TIGHTENED AT THE CENTER PILLAR AND COULD FALL OUT, MAKI…

Risk: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED.

Remedy: DEALERS WILL INSPECT THESE VEHICLES FOR PROPER INSTALLATION AND TORQUE OF THE SEAT BELT SHOULDER GUIDE ANCHOR BOLTS.

STRUCTURE:BODY:BUMPERS

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 581, "BUMPER STANDARD." THESE VEHICLES WERE PRODUCED WITH REAR BUMPER FASTENERS THAT MAY BE LOOSE OR MISSING.

Risk: IF THE FASTENERS ARE LOOSE OR MISSING, THE REAR BUMPER MAY NOT ABSORB ENERGY AS IT WAS DESIGNED TO DO IN THE EVENT OF A REAR END COLLISION.

Remedy: DEALERS WILL VERIFY THAT THE REAR BUMPER BEAM FASTENERS ARE PRESENT AND PROPERLY TIGHTENED AND, IF MISSING, INSTALL NEW FASTENERS.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 135, "PASSENGER CAR BRAKE SYSTEMS." THESE VEHICLES WERE PRODUCED WITH BRAKE PIPE ATTACHMENT NUTS THAT MAY NOT BE TIGHTENED TO SPECIFICATIONS.

Risk: IF THE BRAKE PIPE NUTS ARE NOT PROPERLY TIGHTENED, BRAKE FLUID LEAKAGE COULD OCCUR, INCREASING THE BRAKE'S STOPPING DISTANCE.

Remedy: DEALERS WILL INSPECT THE BRAKE PIPE NUTS FOR LEAKAGE, VERIFY THEY ARE TIGHTENED TO SPECIFICATIONS, AND REPLACE THE BRAKE PIPES IF NEEDED.

UNKNOWN OR OTHER

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." SOME OF THESE VEHICLES WERE MANUFACTURED WITH WELDS IN THE INSTRUMENT PANEL CARRIER ASSEMBLY THAT DO NOT MEET SATURN QUALITY STANDARDS.

Risk: A FRONT SEAT OCCUPANT, PARTICULARLY AN UNBELTED OCCUPANT, MAY HAVE AN INCREASED RISK OF INJURY IN A FRONTAL CRASH.

Remedy: DEALERS WILL REPAIR THE VEHICLE'S INSTRUMENT PANEL CARRIER ASSEMBLY.

POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH

VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, EQUIPPED WITH AUTOMATIC TRANSAXLES, FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 114, "THEFT PROTECTION." THESE VEHICLES WERE BUILT WITH AN IMPROPERLY ADJUSTED AUTOMATIC TRANSAXLE PARK LOCK CABLE ASSEMBLY. IF IMPROPERLY ADJUSTED, IT IS POSSIBL…

Risk: THIS CONDITION INCREASES THE RISK OF A CRASH RESULTING FROM THE UNINTENDED MOVEMENT OF PARKED VEHICLES.

Remedy: SATURN IS ASKING OWNERS AND RETAILERS TO PERFORM A FUNCTIONAL CHECK OF THE AUTOMATIC TRANSAXLE PARK LOCK CABLE ASSEMBLY OPERATION, AND IF NECESSARY, TO HAVE THE CABLE ADJUSTED. IF OWNERS ARE NOT COMF…

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." THESE VEHICLES WERE BUILT WITH AN INADEQUATE VENT VALVE WELD ON THE TOP PORTION OF THE FUEL TANK.

Risk: FUEL SPILLAGE COULD OCCUR DURING REFUELING OR IF THE VEHICLE WERE INVOLVED IN A ROLLOVER. IF AN IGNITION SOURCE WERE PRESENT, A FIRE COULD OCCUR.

Remedy: DEALERS WILL INSPECT THE VEHICLE TO ENSURE THE FUEL TANK VENT VALVE IS PROPERLY WELDED. IF NECESSARY, DEALERS WILL REPLACE THE FUEL TANK ASSEMBLY.

STRUCTURE:BODY

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A CONSOLE ARMREST FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACTS." THE ARMRESTS WERE PRODUCED WITH A LATCH THAT WILL NOT WITHSTAND THE VERTICAL FORCE REQUIREMENTS OF THE STANDARD.

Risk: IN THE EVENT OF A CRASH, THE LATCH MAY OPEN AND THE ARMREST OR THE CONTENTS OF THE CONSOLE COULD INJURE AN OCCUPANT.

Remedy: DEALERS WILL REPLACE THE CONSOLE ARMREST LATCH.

ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES

THE POSITIVE BATTERY CABLE TERMINAL AT THE STARTER SOLENOID MAY BE FORMED INCORRECTLY. INCORRECTLY FORMED TERMINALS CAN CONTACT THE STARTER SOLENOID HOUSING AND CAUSE AN ELECTRIC SHORT CIRCUIT.

Risk: AN ELECTRICAL SHORT CIRCUIT BETWEEN THE BATTERY CABLE ANDTHE STARTER HOUSING CAN RESULT IN AN UNDERHOOD FIRE.

Remedy: INSPECT AND, IF NECESSARY, ADJUST THE CLEARANCE BETWEEN THE POSITIVE BATTERY CABLE TERMINAL SO THAT IT DOES NOT CONTACT THE STARTER SOLENOID HOUSING.