Mitsubishi Montero Recalls — All NHTSA Recall Campaigns

EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

CERTAIN SPORT UTILITY AND PASSENGER VEHICLES FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE OWNER'S MANUAL DOES NOT CONTAIN A STEP-BY-STEP DESCRIPTION FOR HEADREST ADJUSTMENT WHEN INSTALLING A CHILD RESTRAINT SYSTEM (CRS) TETHER STRAP.

Risk: IF THE TETHER STRAP IS IMPROPERLY INSTALLED TO THE TETHER ANCHOR, THE CHILD SAFETY SEAT MAY NOT BE SUFFICIENT RESTRAINED. IN THE EVENT OF A CRASH, THE CHILD COULD BE INJURED.

Remedy: A LETTER OUTLINING THE PROBLEM WILL BE SENT TO OWNERS ALONG WITH A STICKER CONTAINING THE CORRECT INSTRUCTIONS AS WELL AS INSTRUCTIONS ON WHERE TO AFFIX THE STICKER IN THE OWNER'S MANUAL. THE RECALL …

FUEL SYSTEM, GASOLINE:STORAGE

ON CERTAIN SPORT UTILITY VEHICLES, WHEN THE FUEL TANK IS FULL AND THE VEHICLE IS PARKED FACING FORWARD ON AN UPWARD SLOPE, THE FUEL TANK LEVELING VALVE MAY NOT MAINTAIN PROPER SEALING IN THE EVENT THE FUEL EXPANDS FROM A RISE IN THE AMBIENT TEMPERATURE.

Risk: IF THE FUEL LEVELING VALVE DOES NOT SEAL PROPERLY, FUEL MAY LEAK ONTO THE GROUND. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.

Remedy: DEALERS WILL REPLACE THE LEVELING VALVE. THE RECALL BEGAN ON AUGUST 30, 2004. OWNERS SHOULD CONTACT MITSUBISHI AT 1-800-222-0037 OR MITSUBISHI CARIBBEAN AT 1-787-251-8715.

EQUIPMENT:OTHER:LABELS

CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.' THE BILINGUAL ENGLISH/SPANISH REMOVABLE AIR BAG WARNING LABELS AFFIXED TO THE DASH AND TO THE SUNVISOR DO NOT MEET THE SIZE REQUIREMENTS OF THE STANDARD.

Risk: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.

Remedy: MITSUBISHI CARIBBEAN WILL MAIL A CUSTOMER NOTIFICATION LETTER CONTAINING A WRITTEN DESCRIPTION AND A GRAPHIC OF THE BI-LINGUAL DASHBOARD AIR BAG WARNING LABEL. IN ADDITION, ALL CURRENT 2000-2004 NATI…

SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE ACCUMULATOR THAT IS INSTALLED ON THE HYDRAULIC BRAKE BOOSTER MAY HAVE BEEN IMPROPERLY MANUFACTURED. OVER A PERIOD OF TIME, THIS COULD RESULT IN LEAKAGE OF THE PRESSURIZED NITROGEN GAS FROM INSIDE THE ACCUMULATOR.

Risk: THE LOSS OF THIS GAS PRESSURE COULD RESULT IN AN ABNORMAL NOISE FROM THE LEFT SIDE OF THE DASH PANEL WHEN THE BRAKES ARE APPLIED, AND POSSIBLY A DELAYED FIRST TIME BRAKE BOOST ASSIST AFTER THE VEHICLE…

Remedy: DEALERS WILL INSTALL AN IMPROVED ACCUMULATOR. OWNER NOTIFICATION MAILING BEGAN OCTOBER 1, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEI…

VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR

VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES ARE EQUIPPED WITH OUTSIDE REARVIEW MIRRORS ON THE PASSENGER SIDE WHICH DO NOT COMPLY WITH THE REQUIREMENTS OF FMVSS 111, "REARVIEW MIRRORS."

Risk: THIS LIMITS THE DRIVER'S FIELD OF VISION ON THAT SIDE OF THE VEHICLE.

Remedy: DEALERS WILL REPLACE THE REARVIEW MIRROR.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE FRONT BRAKE LINES CAN DEVELOP PIN HOLES DUE TO CHAFFING AGAINST THE EDGE OF THE PASS-THROUGH HOLE IN THE INNER FENDER.

Risk: BRAKE FLUID CAN LEAK RESULTING IN DETERIORATED BRAKING PERFORMANCE AND ILLUMINATION OF THE BRAKE INDICATOR LAMP.

Remedy: DEALERS WILL INSPECT THE FRONT BRAKE LINES FOR SIGNS OF WEAR AND ROUTING. IF THE LINES ARE NOT CORRECTLY CENTERED IN THE PASS-THROUGH HOLE, THE LINES WILL BE REPOSITIONED BY BENDING SLIGHTLY TO CORRE…

UNKNOWN OR OTHER

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH ACCESSORY CARGO MATS IN THE THIRD-SEAT AND CARGO AREA. THIS CARGO MAT INTERFERES WITH THE LATCHING INTEGRITY OF THE FOLDING THIRD SEATS.

Risk: IN THE EVENT OF A CRASH, AN OCCUPANT OF THE THIRD SEAT MAY NOT BE PROPERLY RESTRAINED AND COULD BE EJECTED FROM THE VEHICLE.

Remedy: DEALERS WILL INSPECT THE THIRD-SEAT LATCH AND STRIKER. A RECTANGLE WILL BE REMOVED FROM THE CARGO MAT AROUND EACH STRIKER TO PROVIDE ADEQUATE STRIKER CLEARANCE AND PROPER LATCHING.

AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 1998-2000 Montero vehicles. These vehicles were equipped with Non-Azide Driver air bag Inflators (NADI) and do not contain phase stabilized ammonium nitrate (PSAN) propellant. Due to a manufacturing issue, the NADI inflators may abs…

Risk: In the event of a crash necessitating air bag deployment, an inflator rupture may result in metal fragments striking the driver or other occupants. An underinflated air bag may not properly protect t…

Remedy: MMNA will notify owners, and dealers will replace the air bag inflator, free of charge. The recall began February 25, 2021. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number …

EQUIPMENT:OTHER:LABELS

ON CERTAIN SPORT UTILITY VEHICLES, THE VEHICLE CAPACITY WEIGHTS AS STATED ON THE TIRE AND LOADING INFORMATION LABEL ARE IN ERROR.

Risk: THIS INFORMATION COULD POTENTIALLY RESULT IN CONSUMERS LOADING THEIR VEHICLES BEYOND THE GROSS VEHICLE WEIGHT RATING (GVWR).

Remedy: OWNERS WILL BE SENT REPLACEMENT LABELS WITH INSTRUCTIONS ON HOW TO INSTALL THEM. THE RECALL BEGAN ON APRIL 14, 2004. OWNERS SHOULD CONTACT MITSUBISHI AT 1-800-222-0037.