Mitsubishi Endeavor Recalls — All NHTSA Recall Campaigns

TRAILER HITCHES

CERTAIN SPORT UTILITY VEHICLES MAY HAVE BEEN EQUIPPED WITH DEALER-INSTALLED TRAILER HITCH WIRING HARNESS AND CONTROL MODULE. THE ELECTRONIC CONTROL MODULE CAN OVERHEAT.

Risk: OVERHEATING OF THE TRAILER HITCH WIRING HARNESS MODULE COULD RESULT IN A FIRE.

Remedy: OWNERS ARE BEING REQUESTED TO STOP USING THE HARNESS UNTIL A NEWLY DESIGNED REPLACEMENT IS PROVIDED AND CAN BE INSTALLED BY THE DEALER. THE RECALL BEGAN ON MAY 28, 2004. OWNERS SHOULD CONTACT MITSUB…

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

MITSUBISHI IS RECALLING 45,988 MY 2005-2007 ENDEAVOR, GALANT, ECLIPSE COUPE, AND MY 2007 ECLIPSE SPYDER VEHICLES. THE BRACKET THAT IS THE ATTACHMENT POINT FOR THE LEFT REAR FUEL TANK MOUNTING STRAP MAY HAVE BEEN IMPROPERLY FORMED DURING A METAL STAMPING PROCESS. THE PROCESS MAY HAVE CAUSED THE MET…

Risk: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT TO SEE IF THE LEFT REAR FUEL TANK STRAP MOUNTING BRACKET HAS SPLITTING BEYOND A SPECIFIC LIMIT. VEHICLES WITH MODERATE TO SEVERE SPLITTING WILL BE REPAIRED USING A REINFORCEMENT…

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER

ON CERTAIN SPORT UTILITY VEHICLES, THE MATERIAL USED TO MANUFACTURE THE FRONT DISC BRAKE CALIPERS MAY BE BRITTLE DUE TO IMPROPER METALLURGY.

Risk: THIS COULD CAUSE FRACTURE OF THE BRAKE CALIPER AND SUBSEQUENT UNEXPECTED PARTIAL LOSS OF BRAKING FORCE, WHICH COULD RESULT IN A VEHICLE CRASH.

Remedy: DEALERS WILL INSPECT AND REPLACE THE FRONT BRAKE CALIPER IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON APRIL 10, 2006. OWNERS MAY CONTACT MITSUBISHI AT 1-800-222-0037.

PARKING BRAKE

ON CERTAIN SPORT UTILITY VEHICLES, THE PARKING BRAKE PEDAL CABLE LOCK NUT MAY NOT HAVE BEEN TIGHTENED TO THE PROPER TORQUE SPECIFICATION. THE LOCK NUT MAY LOOSEN AND COME OFF, WHICH WILL REDUCE THE EFFECTIVENESS OF THE PARKING BRAKE.

Risk: THIS CONDITION COULD ALLOW THE VEHICLE TO ROLL IF THE TRANSMISSION IS NOT PLACED INTO THE "PARK" POSITION AND THE VEHICLE IS PARKED ON A SLOPE, THUS RAISING THE POSSIBILITY OF A CRASH.

Remedy: DEALERS WILL INSPECT AND TIGHTEN THE PARKING BRAKE CABLE LOCK NUT, IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN FEBRUARY 24, 2005. OWNERS MAY CONTACT MITSUBISHI AT 1-800-222-5500.

SEATS

ON CERTAIN VEHICLES, THE FOOT OF THE DRIVER'S SIDE SEAT RISER MAY DEVELOP A CRACK, RESULTING IN REDUCED STRENGTH OF THE SEAT ANCHORAGE.

Risk: IN THE EVENT OF A CRASH, THE SEAT COULD BECOME DETACHED, INCREASING THE RISK OF OCCUPANT INJURY.

Remedy: DEALERS WILL INSPECT THE DRIVER'S SEAT BRACKET TO DETERMINE WHETHER IT REQUIRES REPLACEMENT. IF SO, THE DEALER WILL REPLACE IT WITH A NEW, IMPROVED PART. THE RECALL BEGAN ON JULY 26, 2004. OWNERS S…

EQUIPMENT:OTHER:LABELS

CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.' THE BILINGUAL ENGLISH/SPANISH REMOVABLE AIR BAG WARNING LABELS AFFIXED TO THE DASH AND TO THE SUNVISOR DO NOT MEET THE SIZE REQUIREMENTS OF THE STANDARD.

Risk: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.

Remedy: MITSUBISHI CARIBBEAN WILL MAIL A CUSTOMER NOTIFICATION LETTER CONTAINING A WRITTEN DESCRIPTION AND A GRAPHIC OF THE BI-LINGUAL DASHBOARD AIR BAG WARNING LABEL. IN ADDITION, ALL CURRENT 2000-2004 NATI…

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP

MITSUBISHI IS RECALLING CERTAIN MODEL YEAR 2004-2010 ENDEAVOR VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNS…

Risk: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REPLACE THE FUEL FILLER PIPE WITH A NEW IMPROVED PART FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JULY 5, 2010. OWNERS MAY CONTACT MITSUBISHI AT 1-800-222-0037.

ELECTRICAL SYSTEM:IGNITION

MITSUBISHI IS RECALLING 120,000 MY 2004-2006 ENDEAVOR PASSENGER VEHICLES. DURING VEHICLE USE, THE IGNITION KEY INTERLOCK CABLE (WHICH IS A COMPONENT OF THE INTERLOCK SYSTEM) MAY ALLOW THE INTERLOCKING CAM TO FALL FORWARD AND ALLOW THE IGNITION KEY TO BE REMOVED FROM THE IGNITION SWITCH WHEN THE GEA…

Risk: IF THE DRIVER DOES NOT SHIFT TO PARK BEFORE REMOVING THE KEY AND FAILS TO ENGAGE THE PARKING BRAKE, THE VEHICLE COULD ROLL AND A CRASH COULD OCCUR.

Remedy: DEALERS WILL INSPECT AND CORRECT THESE VEHICLES FOR THE REPORTED CONDITION. THE RECALL WILL BEGIN ON JULY 7, 2008. OWNERS MAY CONTACT MITSUBISHI AT 1-888-648-7820.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH ANTI-LOCK BRAKES, THE BRAKE MASTER CYLINDER, WHICH CONTROLS THE FLUID PRESSURE TO THE VEHICLE'S BRAKES, MAY ALLOW BRAKE FLUID TO BYPASS INTERNALLY DURING STOPPING.

Risk: THIS MAY RESULT IN A PARTIAL LOSS OF BRAKING, INCREASED STOPPING DISTANCES, AND COULD LEAD TO A VEHICLE CRASH.

Remedy: DEALERS WILL REPLACE THE BRAKE MASTER CYLINDER. THE RECALL BEGAN ON OCTOBER 3, 2005. OWNERS MAY CONTACT MITSUBISHI AT 1-800-222-0037.

SEAT BELTS:FRONT

ON CERTAIN PASSENGER VEHICLES, THE RIGHT SIDE LOWER SEAT BELT ANCHOR MAY SEPARATE DURING A SEVERE VEHICLE CRASH.

Risk: BREAKAGE OF THE MOUNTING BRACKET IN A SEVERE CRASH COULD ALLOW THE SEAT BELT TO NOT PROPERLY RESTRAIN THE PASSENGER AND POTENTIALLY RESULT IN INJURY OR DEATH.

Remedy: DEALERS WILL REPLACE THE FRONT PASSENGER SIDE SEAT BELT AND BRACKET ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 17, 2008. OWNERS MAY CONTACT MITSUBISHI AT 1-800-222-0037.

ELECTRICAL SYSTEM:SOFTWARE

MITSUBISHI IS RECALLING CERTAIN MODEL YEAR 2006-2008 ENDEAVOR WITH MANUAL AIR CONDITIONING. DUE TO AN INCORRECT HEATER (HVAC) CONTROLLER SIGNAL, THE AIR FLOW FROM THE AIR VENTS MAY RANDOMLY CHANGE DIRECTION AND/OR THE TEMPERATURE MAY BRIEFLY CYCLE BETWEEN HOT AND COLD.

Risk: THIS CONDITION COULD AFFECT DEFROSTER PERFORMANCE, RESULTING IN POOR WINDSHIELD VISIBILITY AND POTENTIALLY CAUSE A CRASH.

Remedy: DEALERS WILL INSPECT FOR DAMAGE AND IF NECESSARY REPAIR THE MODE DOOR SHAFT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 7, 2010. OWNERS MAY CONTACT MITSUBISHI AT 1-800-222-0037.

AIR BAGS

MITSUBISHI MOTORS NORTH AMERICA, INC. (MMNA) IS RECALLING CERTAIN MODEL YEAR 2010 ENDEAVOR MODEL VEHICLES MANUFACTURED BETWEEN MAY 26 AND JULY 28, 2009. THE RETAINER BRACKET USED FOR THE SEAT-MOUNTED SIDE AIRBAG FRAMES ON BOTH THE DRIVER AND FRONT PASSENGER SEATS MAY NOT HAVE BEEN PROPERLY WELDED.

Risk: IF THIS CONDITION EXISTS, THE FRONT SEAT-MOUNTED AIRBAGS MAY NOT DEPLOY CORRECTLY IN A SIDE IMPACT CRASH, POSSIBLY RESULTING IN INJURY TO THE SEAT OCCUPANT.

Remedy: MMNA WILL NOTIFY OWNERS AND DEALERS WILL INSPECT THE WELD CONDITION OF THE SIDE AIRBAG RETAINER BRACKET ON THE FRONT PASSENGER SEATS. IF THE WELD IS INSUFFICIENT, THE DEALER WILL REPLACE THE SEATBACK…