Mazda 626 Recalls — All NHTSA Recall Campaigns

ELECTRICAL SYSTEM:IGNITION:SWITCH

Mazda North American Operations (Mazda) is recalling certain model year 1989-1998 MPV, 1990-1995 323, 1990-1998 Protege, 1992-1993 MX-3, 1993-1995 929, 1993-1997 MX-6, and 1993-1998 626 vehicles. In the affected vehicles, grease applied to the contact points inside the ignition switch may become co…

Risk: If the ignition switch overheats there would be an increased risk of a fire.

Remedy: Mazda will notify owners, and dealers will replace the ignition switch, free of charge. The recall began on December 17, 2015. Owners may contact Mazda Customer Experience Center at 1-800-222-5500, …

FUEL SYSTEM, GASOLINE

CERTAIN SPX FILTRAN FUEL FILTERS WITH A 45-DEGREE ANGLE INLET TUBE, MODEL 800F350-S1, SOLD AS REPLACEMENT FILTERS FOR 1993-1997 FORD PROBE,1993-2001 MAZDA 626 AND MX-6, AND 1983-1994 LOYAL, 3-DOOR COUPE, HATCHBACK, SEDAN, WAGON, BRAT, DL, GL, GL-10, RX, XT, AND XT6 PASSENGER VEHICLES WITH EFI OR TUR…

Risk: IN THE PRESENCE OF AN IGNITION SOURCE, A VEHICLE FIRE CAN OCCUR.

Remedy: SPX WILL NOTIFY ITS CUSTOMERS AND PROVIDE A FULL REFUND. THE RECALL BEGAN SEPTEMBER 27, 2005. OWNERS MAY CONTACT MR. CHRIS GREESON AT 704-869-3733 OR CONTACT THE WIX INFORMATION HOTLINE AT 800-949-6…

EXTERIOR LIGHTING:HEADLIGHTS:SWITCH

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE HEADLIGHT WIRE THAT RUNS THROUGH THE TURN SIGNAL LEVER CAN FAIL AT THE POINT WHERE IT IS SOLDERED TO THE HEADLIGHT SWITCH.

Risk: THE FAILURE OF THIS WIRE COULD CAUSE A LOSS OF HEADLIGHTS, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE HEADLIGHT SWITCH LEVER.

POWER TRAIN:MANUAL TRANSMISSION

THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SPEEDOMETER GEAR SET CAN FAIL. SYMPTOMS INCLUDE AN INOPERATIVE SPEEDOMETER, SEVERE LACK OF POWER, AND/OR A TRANSMISSI…

Risk: A DRIVER MAY NOT BE AWARE OF INCREASED SPEED DUE TO THE SPEEDOMETER NOT WORKING CORRECTLY.

Remedy: DEALERS WILL INSPECT THE SPEEDOMETER GEAR SET AND IF NECESSARY, WILL REPLACE THE SPEEDOMETER GEAR SET AT NO CHARGE. THIS EXTENDED WARRANTY COVERS NECESSARY REPAIRS DUE TO FAILURE OF THE VEHICLE'S SPE…

AIR BAGS:FRONTAL

THE PASSENGER SIDE AIR BAG HAS AN INFLATOR BODY THAT CRACKED DURING FORMING OF THE CURL THAT RETAINS THE IGNITER PLUG IN THE END OF THE INFLATOR. ALSO, THE IGNITER END CAP CAN SEPARATE FROM THE INFLATOR.

Risk: THE PASSENGER SIDE AIR BAG MAY NOT INFLATE PROPERLY RESULTING IN REDUCED OCCUPANT PROTECTION IN A VEHICLE ACCIDENT. IF THE IGNITER END CAP SEPARATES IN A FRONTAL COLLISION, HOT GASES CAN BE RELEASED A…

Remedy: DEALERS WILL REMOVE AND REPLACE THE PASSENGER SIDE AIR BAG MODULE.

EXTERIOR LIGHTING

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES…

Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

ENGINE AND ENGINE COOLING:ENGINE

VEHICLE DESCRIPTION: PASSENGER VEHICLES. AN EXTERNAL SPRING IN THE TIMING BELT TENSIONER COULD BREAK.

Risk: THE BROKEN SPRING MAY GET CAUGHT IN THE TIMING BELT, RESULTING POSSIBLE ENGINE STALLING.

Remedy: DEALERS WILL CHECK THE TENSIONER INSTALLED AND REPLACE IT IF THE VEHICLE IS EQUIPPED WITH THE AFFECTED TENSIONER.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

VEHICLE DESCRIPTION: PASSENGER VEHICLES. CERTAIN RESERVOIR TANK CAPS ON THE BRAKE MASTER CYLINDER WERE PRODUCED WITH A WORN OUT DIE AND LACK VENTILATION HOLES. AS A RESULT, THE PRESSURE IN THE RESERVOIR TANK CAN DROP GRADUALLY AS THE BRAKE PAD OR SHOE WEARS AND AMBIENT TEMPERATURE DROPS. ALSO,…

Risk: THIS CONDITION COULD CAUSE REDUCED BRAKE EFFICIENCY, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT THE RESERVOIR CAP AND REPLACE IT, IF NECESSARY.

AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH THE SAS SENSOR UNIT. THESE VEHICLES CAN EXPERIENCE AIR BAG DEPLOYMENTS IN MINOR UNDERCARRIAGE IMPACTS.

Risk: UNEXPECTED AIR BAG DEPLOYMENT CAN RESULT IN OCCUPANT INJURY.

Remedy: DEALERS WILL REPROGRAM THE SAS UNIT TO REDUCE THE PROBABILITY OF UNNECESSARY DEPLOYMENTS IN LOW SPEED UNDERCARRIAGE IMPACTS.

ENGINE AND ENGINE COOLING:ENGINE

VEHICLE DESCRIPTION: PASSENGER VEHICLES. AN EXTERNAL SPRING IN THE TIMING BELT TENSIONER CAN BREAK AND GET CAUGHT IN THE TIMING BELT.

Risk: THIS CONDITION CAN RESULT IN POSSIBLE ENGINE STALLING.

Remedy: DEALERS WILL INSPECT THE TENSIONER AND REPLACE IT IF NECESSARY.

FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM

VEHICLE DESCRIPTION: PASSENGER VEHICLES. DUE TO A PROGRAMMING ERROR, THE POWERTRAIN CONTROL MODULE (PCM) INSTALLED CAN, UNDER CERTAIN DRIVING CONDITIONS, TRIGGER A SHIFT IN AIR-FUEL RATIO TO AN OVERLEAN CONDITION.

Risk: THIS CONDITION CAN RESULT IN AN ENGINE STALL, WHICH COULD LEAD TO LOSS OF VEHICLE CONTROL AND/OR A VEHICLE CRASH.

Remedy: DEALERS WILL REPROGRAM THE PCM WITH THE CORRECT ENGINE CONTROL LOGIC.

EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

VEHICLE DESCRIPTION: IF THE VEHICLE IS OPERATED IN A HOT, HUMID ENVIRONMENT WITH THE WINDOW OPEN AND AIR CONDITIONER RUNNING, IT IS POSSIBLE FOR CONDENSATION TO ENTER THE AUDIO UNIT AND CAUSE A SHORT CIRCUIT.

Risk: IF THE SHORT CIRCUIT OCCURS AT ONE SPECIFIC SET OF TERMINALS, THE SPEAKER CAN OVERHEAT AND IN SOME CASES, CATCH FIRE.

Remedy: DEALERS WILL AFFIX ALUMINUM TAPE OVER THE AUDIO UNIT TO PREVENT WATER FROM ENTERING.