Hyundai Tucson Recalls — All NHTSA Recall Campaigns

POWER TRAIN:AUTOMATIC TRANSMISSION:FLUID/LUBRICANT:PUMP

Hyundai Motor America (Hyundai) is recalling certain 2023-2024 Palisade Tucson, 2023 Sonata, Elantra, and Kona vehicles. The electronic controller for the Idle Stop & Go oil pump assembly may contain damaged electrical components that can cause the pump controller to overheat.

Risk: An electric oil pump assembly that overheats increases the risk of a vehicle fire.

Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will inspect and replace the electric oil pump controller, as necessary, free of charge. Owne…

TRAILER HITCHES

Hyundai Motor America (Hyundai) is recalling certain 2022-2024 Tucson vehicles equipped with an optional Mobis tow hitch wiring harness. The wiring harness may have been installed incorrectly, allowing water into the control module. Moisture accumulation may cause the trailer lighting to fail or an …

Risk: Nonfunctioning trailer lights can increase the risk of a crash. A short circuit can increase the risk of a fire.

Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will remove the trailer wiring harness and install a dust cap over the wiring receptacle, free …

STEERING:ELECTRIC POWER ASSIST SYSTEM

Hyundai Motor America (Hyundai) is recalling certain 2024 Tucson and Santa Cruz vehicles. The circuit board in the motor-driven power steering assembly may short circuit, resulting in a loss of power steering assist.

Risk: A loss of power steering assist can increase the risk of a crash.

Remedy: Dealers will replace the motor-driven power steering electric power pack, free of charge. Owner notification letters were mailed July 11, 2024. Owners may contact Hyundai customer service at 1-855-3…

EQUIPMENT:OTHER:LABELS

Hyundai Motor America (Hyundai) is recalling certain 2024 Tucson vehicles. The tire and loading information label may incorrectly indicate information about a spare tire. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selecti…

Risk: A label that incorrectly states spare tire pressure when there is no spare tire on-board may cause confusion during an emergency tire replacement, increasing the risk of a crash or injury.

Remedy: Dealers will inspect and replace the tire and loading information label, as necessary, free of charge. Owner notification letters were mailed September 5, 2023. Owners may contact Hyundai customer s…

EQUIPMENT:OTHER:LABELS

Hyundai Motor America (Hyundai) is recalling certain 2025 Tucson vehicles. The glove box air bag warning label may be missing. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Risk: Without the glove box label, operators may be unaware of the increased risks that an air bag poses to an infant or child in the front seat, increasing the risk of injury to occupants.

Remedy: Hyundai will mail owners the warning labels, free of charge. Owner notification letters were mailed October 4, 2024. Owners may contact Hyundai Customer service at 1-855-371-9460. Hyundai's number …

ELECTRICAL SYSTEM:WIRING

Hyundai Motor America (Hyundai) is recalling certain 2025 Tucson and Santa Cruz vehicles. The console extension wiring assembly may be routed improperly, allowing the transmission to be shifted out of Park without applying the brake pedal.

Risk: A transmission that can shift out of Park without applying the brake pedal can result in a vehicle roll away, increasing the risk of a crash.

Remedy: Owners are advised to use the parking brake when parking the vehicle. Dealers will reroute the console extension wiring assembly, free of charge. Owner notification letters were mailed December 17, …

ENGINE AND ENGINE COOLING:CRITICAL FASTENERS

Hyundai Motor America (Hyundai) is recalling certain 2025-2026 Tucson and Santa Fe vehicles. The connecting rod bolts in the engine may have been improperly tightened, which can cause a loss of drive power and engine damage, possibly resulting in an oil leak.

Risk: A loss of drive power increases the risk of a crash. An oil leak in the presence of hot engine components can increase the risk of an engine compartment fire.

Remedy: Dealers will replace the engine, free of charge. Owner notification letters were mailed October 23, 2025. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recal…

AIR BAGS:SIDE/WINDOW:CURTAIN

Hyundai Motor America (Hyundai) is recalling certain 2025 Tucson, 2025-2026 Santa Cruz, Santa Fe, Santa Fe Hybrid, and 2026 Genesis GV70 vehicles. The side curtain air bags may not have been installed properly, which can cause the air bags not to deploy as intended.

Risk: Side curtain air bags that do not deploy as intended increase the risk of injury in a crash.

Remedy: Dealers will reinstall the side curtain air bags, free of charge. Owner notification letters were mailed beginning December 29, 2025. Owners may contact Hyundai customer service at 1-855-371-9460. Hyu…

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

Hyundai Motor America (Hyundai) is recalling certain 2025-2026 Santa Cruz, Tucson, Tucson Hybrid, and Tucson Plug-In Hybrid Electric (PHEV) vehicles. Software in the front cameras may cause the forward collision avoidance system to activate prematurely and unexpectedly apply the brakes.

Risk: Unexpected braking increases the risk of a crash.

Remedy: Dealers will update the front camera software, free of charge. Owner notification letters are expected to be mailed July 17, 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyunda…

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

Hyundai Motor America (Hyundai) is recalling certain 2025-2026 Tucson, Tucson Hybrid, Tucson Plug-In Hybrid Electric (PHEV) vehicles. Due to a software error, the instrument panel display may fail. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard …

Risk: An instrument panel display that fails to show critical safety information, such as the speedometer or warning lights, increases the risk of a crash.

Remedy: The instrument panel display software will be updated over-the-air (OTA) or by a dealer, free of charge. Owner notification letters are expected to be mailed August 22, 2026. Owners may contact Hyunda…

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

Hyundai Motor America (Hyundai) is recalling certain 2025-2026 Tucson Hybrid, Tucson Plug-In Hybrid Electric (PHEV), 2026 IONIQ 5, Santa Cruz, Kona, Palisade, Palisade Hybrid, Santa Fe, Santa Fe Hybrid, Sonata, Sonata Hybrid, and Tucson vehicles. Due to a software error, the instrument panel display…

Risk: An instrument panel display that fails to show critical safety information, such as the speedometer or warning lights, increases the risk of a crash.

Remedy: The instrument panel display software will be updated over-the-air (OTA) or by a dealer, free of charge. Owner notification letters were mailed March 24, 2026. Owners may contact Hyundai's customer se…

AIR BAGS:SENSOR:SIDE IMPACT

Hyundai Motor America (Hyundai) is recalling certain 2025 Elantra N, 2026 Tucson, Tucson Hybrid, Tucson Plug-In Hybrid Electric (PHEV), and Elantra vehicles. The B-pillar impact sensors may have been misassembled, which can delay air bag deployment.

Risk: Air bags that do not deploy as intended increase the risk of injury in a crash.

Remedy: Dealers will inspect and replace the impact sensor(s), as necessary, free of charge. Owner notification letters were mailed June 11, 2026. Owners may contact Hyundai's customer service at 855-371-9460…

SUSPENSION:FRONT:MACPHERSON STRUT

Hyundai Motor America (Hyundai) is recalling certain 2026 Tucson Hybrid and Elantra vehicles. The front strut assembly fasteners may not be tightened properly, which can result in a loss of vehicle steering control.

Risk: A loss of vehicle steering control increases the risk of a crash.

Remedy: Dealers will inspect and replace the front strut assembly fasteners and perform a wheel alignment, as necessary, free of charge. Owner notification letters are expected to be mailed December 19, 2026.…