Hyundai Tiburon Recalls — All NHTSA Recall Campaigns

SEAT BELTS:FRONT:WEBBING

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE DRIVER AND FRONT PASSENGER SEAT BELTS MAY NOT EXTEND AND RETRACT SMOOTHLY THROUGH THE D-RING GUIDES MOUNTED ON THE BODY PILLARS AFT OF THE DOORS. IF THE SEAT BELTS DO NOT EXTEND AND RETRACT SMOOTHLY, THEY MAY TWIST IN THE D-RING GUIDES AND MAKE IT INCO…

Risk: IF THE SEAT BELTS ARE INCONVENIENT TO USE, THE SEAT OCCUPANT MAY NOT BE INCLINED TO WEAR THE SEAT BELTS PROPERLY, INCREASING THE RISK OF INJURY IN THE EVENT OF A CRASH.

Remedy: DEALERS WILL INSTALL A STOPPER OVER EACH FRONT SEAT BELT D-RING GUIDE TO ASSIST THE SEAT BELT TO SMOOTHLY EXTEND AND RETRACT. OWNER NOTIFICATION BEGAN DECEMBER 10, 2001. OWNERS WHO TAKE THEIR VEHICL…

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE EVAPORATIVE EMISSION CONTROL SYSTEMS CAN APPLY EXCESSIVE VACUUM TO THE FUEL TANKS DURING THE CANISTER PURGE CYCLE. IF EXCESSIVE VACUUM IS APPLIED, MINOR FUEL TANK DISTORTION CAN RESULT. A SMALL CRACK COULD DEVELOP ON THE UPPER FUEL TANK SURFACE. THE …

Risk: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy: DEALERS WILL PRESSURE CHECK THE VEHICLE'S FUEL TANK TO DETERMINE IF IT HAS CRACKED. IF THE FUEL TANK HAS CRACKED, IT WILL BE REPLACED.

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE EVAPORATIVE EMISSION CONTROL SYSTEMS CAN APPLY EXCESSIVE VACUUM TO THE FUEL TANKS DURING THE CANISTER PURGE CYCLE. IF EXCESSIVE VACUUM IS APPLIED, MINOR FUEL TANK DISTORTION CAN RESULT. A SMALL CRACK COULD DEVELOP ON THE UPPER FUEL TANK SURFACE. THE …

Risk: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy: DEALERS WILL PRESSURE CHECK THE VEHICLE'S FUEL TANK TO DETERMINE IF IT HAS CRACKED. IF THE FUEL TANK HAS CRACKED, IT WILL BE REPLACED.

VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR

THE WINDSHIELD WIPER MOTOR CIRCUIT BREAKER ELECTRICAL CONTACTS WERE CONTAMINATED DURING ASSEMBLY.

Risk: THIS CONTAMINATION INTERFERES WITH THE ELECTRICAL CIRCUIT CONTINUITY AND PREVENTS THE WINDSHIELD WIPER MOTOR FROM OPERATING. INOPERATIVE WINDSHIELD WIPERS CAN CONTRIBUTE TO REDUCED VISIBILITY DURING …

Remedy: DEALERS WILL REMOVE THE CONTAMINANTS FROM THE WINDSHIELD WIPER MOTOR CIRCUIT BREAKER CONTACTS.

EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH

Hyundai Motor Company (Hyundai) is recalling certain model year 2006-2009 Accent, model year 2007-2011 Azera, Sonata and Sante Fe,2006-2011 Tucson, 2009-2011 Elantra Touring, 2007-2010 Elantra, 2008-2011 Veracruz, 2009-2011 Genesis, 2010-2011 Genesis Coupe, 2007-2008 Entourage, and 2006-2008 Tiburo…

Risk: Failure to illuminate the stop lamps during braking or inability to disengage the cruise control could increase the risk of a crash. Additionally, when the ignition is in the 'ON' position, the trans…

Remedy: Hyundai will notify owners, and dealers will replace the stop lamp switch, free of charge. The safety recall began on April 22, 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall …

POWER TRAIN:AUTOMATIC TRANSMISSION

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS. THE AUTOMATIC TRANSMISSION PRESSURE CONTROL SOLENOID VALVE SEALS DO NOT REMAIN SUFFICIENTLY ELASTIC, RESULTING IN TRANSMISSION FLUID LEAKAGE. THIS LEAKAGE CAN RESULT IN REDUCED PRESSURE APPLICATION TO THE CLUTCHES, B…

Risk: SUCH SLIPPAGE CAN CAUSE PREMATURE DETERIORATION OF THE FRICTION ELEMENT SURFACES AND COULD CAUSE THE VEHICLE NOT TO ACCELERATE, OR NOT ACCELERATE AS EXPECTED, WHEN THE DRIVER PRESSES THE ACCELERATOR P…

Remedy: DEALERS WILL REPLACE THE PRESSURE CONTROL SOLENOID VALVE.

EQUIPMENT:OTHER:LABELS

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TIRE PRESSURE PLACARD REQUIRED BY FMVSS NO. 110, "TIRE SELECTION AND RIMS," WAS MISPRINTED. IT INCORRECTLY CONTAINS THE TIRE SIZES, SEATING CAPACITY, AND LUGGAGE CAPACITY.

Risk: EXCESSIVE LOADING CAN CAUSE TIRE AND VEHICLE DAMAGE THAT COULD RESULT IN A CRASH.

Remedy: OWNERS WILL BE PROVIDED WITH A CORRECT TIRE PRESSURE PLACARD AND INSTALLATION INSTRUCTIONS.

FUEL SYSTEM, GASOLINE:STORAGE

CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY" A VALVE ON THE FUEL TANK ASSEMBLY MAY NOT CLOSE PROPERLY. IF A VEHICLE ROLLS OVER AND THE FUEL TANK ASSEMBLY VALVE IS NOT PROPERLY CLOSED, FUEL SPILLAGE MAY OCC…

Risk: FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.

Remedy: DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. THE RECALL BEGAN ON OCTOBER 5, 2004. OWNERS SHOULD CONTACT HYUNDAI DE PUERTO RICO AT 1-800-981-0188.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

ON CERTAIN PASSENGER VEHICLES, THE REAR BRAKE TUBES PASS BEHIND THE FRONT SUSPENSION CROSSMEMBER. TWO STEERING GEARBOX MOUNTING BRACKETS ARE WELDED TO THE CROSSMEMBER. ON VEHICLES EQUIPPED WITH AN ANTILOCK BRAKE SYSTEM (ABS), THE REAR BRAKE TUBES COULD CONTACT BOTH STEERING GEARBOX MOUNTING BRACKE…

Risk: FLUID LEAKAGE COULD RESULT IN REDUCED BRAKING CAPABILITY INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPOSITION THE REAR BRAKE TUBES SO THEY DO NOT CONTACT THE MOUNTING BRACKETS, INSTALL BRAKE TUBE CLIPS TO CONTROL THE LOCATION OF THE REAR BRAKE TUBES, AND APPLY ANTI-CORROSION MATERIAL T…

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

SOME PASSENGER VEHICLES CONTAIN A FUEL TANK ASSEMBLY VALVE THAT MAY NOT CLOSE PROPERLY. IF A VEHICLE WITH A FUEL TANK ASSEMBLY VALVE THAT IS NOT PROPERLY CLOSED WERE TO ROLL OVER, FUEL SPILLAGE MAY OCCUR.

Risk: FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.

Remedy: DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. OWNER NOTIFICATION BEGAN ON JUNE 30, 2004. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

ON CERTAIN PASSENGER VEHICLES, THE BRAKE TUBES FOR THE REAR BRAKES CAN CONTACT THE STEERING GEARBOX MOUNTING BRACKETS.

Risk: CONTACT BETWEEN THE REAR BRAKE TUBES AND THE STEERING GEARBOX MOUNTING BRACKETS MAY RESULT IN REAR BRAKE TUBE WEAR AND CORROSION, INCREASING THE RISK OF BRAKE FLUID LEAKAGE. BRAKE FLUID LEAKAGE COULD…

Remedy: DEALERS WILL REPOSITION THE REAR BRAKE TUBES, INSTALL BRAKE TUBE CLIPS, AND APPLY ANTI-CORROSION MATERIAL TO THE REAR BRAKE TUBES. OWNER NOTIFICATION BEGAN JANUARY 22, 2004. OWNERS SHOULD CONTACT H…

SUSPENSION:FRONT:CONTROL ARM

HYUNDAI IS RECALLING 160,904 MY 2001-2003 ELANTRA AND MY 2003 TIBURON VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYL…

Risk: THE FRACTURING OF THE CONTROL ARM COULD AN OWNER'S CONTROL OVER THEIR VEHICLE THAT MAY INCREASE THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT THE FRONT LOWER CONTROL ARMS FOR CORROSION DAMAGE. IF SPECIFIED LEVELS OF INTERNAL CORROSION DAMAGE ARE FOUND, THE FRONT LOWER CONTROL ARMS WILL BE REPLACED WITH NEW FRONT LOWER …

SEAT BELTS:FRONT:BUCKLE ASSEMBLY

ON CERTAIN SPORT UTILITY VEHICLES, THE DRIVER SEAT BELT BUCKLE WIRING COULD BE DAMAGED BY INTERFERENCE WITH THE DRIVER SEAT CUSHION HEIGHT ADJUSTER MECHANISM. DAMAGED DRIVER SEAT BELT BUCKLE WIRING COULD CAUSE THE SEAT BELT WARNING LAMP OR THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG WIRING LAMP…

Risk: NONDEPLOYMENT OF AN SRS AIR BAG IN A CRASH WHERE AIR BAG DEPLOYMENT IS WARRANTED COULD INCREASE THE RISK OR SEVERITY OF INJURY IN A CRASH.

Remedy: DEALERS WILL INSTALL A NEW DRIVER SEAT BELT BUCKLE, IF NECESSARY, AND WILL PLACE A PROTECTIVE COVER OVER THE DRIVER SEAT BELT BUCKLE WIRING TO PREVENT DAMAGE FROM OCCURRING. OWNER NOTIFICATION BEGAN …

AIR BAGS:FRONTAL

ON CERTAIN SPORT UTILITY VEHICLES, THE FRONT PASSENGER AIR BAG IS MOUNTED BENEATH THE RIGHT PORTION OF THE INSTRUMENT PANEL'S PADDED SURFACE. TEAR LINES ARE FORMED INTO THE UNDERSIDE OF THE INSTRUMENT PANEL'S PADDED SURFACE DURING THE PRODUCTION PROCESS OF THE INSTRUMENT PANEL TOP PAD. THESE TEAR …

Risk: IN THE EVENT OF A VEHICLE CRASH, THE AIR BAG MAY NOT DEPLOY PROPERLY, POSSIBLY RESULTING IN SERIOUS INJURY TO THE RIGHT FRONT PASSENGER.

Remedy: HYUNDAI WILL REPLACE THE INSTRUMENT PANEL. OWNER NOTIFICATION BEGAN ON OCTOBER 13, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE …

UNKNOWN OR OTHER

ON CERTAIN PASSENGER VEHICLES, THE LEFT LOWER INSTRUMENT PANEL BRACKET WAS NOT INSTALLED.

Risk: IF THIS BRACKET HAS NOT BEEN INSTALLED, THERE MAY BE AN INCREASED LIKELIHOOD OF INJURY OR INCREASED SEVERITY OF INJURY IN A FRONTAL CRASH.

Remedy: DEALERS WILL INSPECT THE VEHICLES TO DETERMINE IF THE BRACKET HAS BEEN INSTALLED. IF THE BRACKET HAS NOT BEEN INSTALLED, THE DEALER WILL INSTALL THE LEFT LOWER INSTRUMENT PANEL BRACKET. OWNER NOTIFI…

SEAT BELTS:FRONT:BUCKLE ASSEMBLY

ON CERTAIN PASSENGER VEHICLES, THE DRIVER SEAT BELT BUCKLE WIRING COULD BE DAMAGED BY INTERFERENCE WITH THE DRIVER SEAT CUSHION HEIGHT ADJUSTER MECHANISM.

Risk: DAMAGED DRIVER SEAT BELT BUCKLE WIRING COULD CAUSE THE SEAT BELT WARNING LAMP OR THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG WIRING LAMP TO ILLUMINATE. IT COULD ALSO CAUSE THE AIR BAG FUSE (CAVIT…

Remedy: DEALERS WILL INSTALL A NEW DRIVER SEAT BELT BUCKLE, IF NECESSARY, AND WILL PLACE A PROTECTIVE COVER OVER THE DRIVER SEAT BELT BUCKLE WIRING TO PREVENT DAMAGE FROM OCCURRING. OWNER NOTIFICATION BEGAN…

STEERING:LINKAGES:TIE ROD ASSEMBLY

CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH THREADED PORTIONS OF THE STEERING GEARBOX ASSEMBLY'S LEFT AND RIGHT INNER BALL JOINT ASSEMBLIES THAT CONTAIN INTERNAL CRACKS IN THE MATERIAL STRUCTURE.

Risk: IF THE INNER BALL JOINT ASSEMBLY WAS TO BREAK AS A RESULT OF THE INTERNAL CRACK, THE TIE ROD END ASSEMBLY WOULD NOT LONGER BE ATTACHED TO THE STEERING GEAR BOX. THIS WOULD PREVENT STEERING CONTROL OF…

Remedy: DEALERS WILL REPLACE THE STEERING GEARBOX ASSEMBLIES ON THESE VEHICLES FREE OF CHARGE. OWNERS WERE CONTACTED BY TELEPHONE BEGINNING ON APRIL 8, 2005, AND INSTRUCTED NOT TO DRIVE THEIR VEHICLES. HYUN…