Chrysler Concorde Recalls — All NHTSA Recall Campaigns

SUSPENSION:FRONT:CONTROL ARM:LOWER ARM

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE LOWER CONTROL ARM ATTACHING BRACKETS CAN CRACK DUE TO FATIGUE AND SEPARATE FROM THE ENGINE CRADLE.

Risk: IF THIS OCCURS, THE TRANSMISSION HALF-SHAFT COULD PULL OUT OF THE TRANSAXLE AND RESULT IN LOSS OF POWER.

Remedy: DEALERS WILL REINFORCE THE ENGINE CRADLE AT THE POINT WHERE THE LOWER CONTROL ARM ATTACHES TO IT.

FUEL SYSTEM, GASOLINE:DELIVERY

VEHICLE DESCRIPTION: PASSENGER VEHICLES BUILT WITH 3.3L ENGINES. THE 'O-RINGS' USED TO SEAL THE INTERFACE OF THE FUEL INJECTOR RAIL SUPPLY, RETURN AND CROSS OVER TUBES ARE NOT AS ROBUST AS THOSE USED IN LATER MODEL YEARS. DETERIORATION OF THE 'O-RINGS' CAN CAUSE FUEL LEAKAGE.

Risk: IN THE PRESENCE OF AN IGNITION SOURCE, FUEL LEAKAGE IN THE ENGINE COMPARTMENT COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REPLACE THE ENGINE FUEL RAIL.

POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:FLOOR SHIFT

ON CERTAIN PASSENGER VEHICLES, THE FLOOR SHIFTER IGNITION-PARK INTERLOCK MAY FAIL AND ALLOW THE SHIFTER TO BE MOVED OUT OF THE PARK POSITION WITH THE KEY REMOVED. AN INOPERATIVE INTERLOCK MAY ALSO ALLOW THE KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE PARK POSITION.

Risk: EITHER CIRCUMSTANCE MAY RESULT IN THE VEHICLE ROLLING AWAY WITHOUT WARNING.

Remedy: DEALERS WILL INSTALL A NEW LOAD-LIMITING PUSH ROD INTO THE FLOOR SHIFTER LEVER OF THE AFFECTED VEHICLES. OWNER NOTIFICATION BEGAN ON JUNE 14, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853…

EXTERIOR LIGHTING

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES…

Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

LATCHES/LOCKS/LINKAGES:HOOD:LATCH

ON CERTAIN PASSENGER VEHICLES, AN INTERNAL HOOD LATCH COMPONENT MAY HAVE BEEN MANUFACTURED WITH A CRACK, WHICH COULD PROPAGATE AND BREAK, ALLOWING THE PRIMARY/SECONDARY LATCH SPRING TO DISENGAGE.

Risk: THIS COULD RESULT IN LOSS OF BOTH PRIMARY AND SECONDARY HOOD LATCH FUNCTION, ALLOWING THE HOOD TO OPEN WITHOUT WARNING. THIS COULD INCREASE THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE LATCH ASSEMBLY. OWNER NOTIFICATION BEGAN ON SEPTEMBER 22, 2003. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.

SEATS:FRONT ASSEMBLY:RECLINER

ON CERTAIN PASSENGER VEHICLES, SEAT BACK RECLINER BOLT BREAKAGE CAN OCCUR RESULTING IN THE SEAT BACK RECLINING UNEXPECTEDLY.

Risk: IF THE SEAT BACK UNEXPECTEDLY RECLINES WHILE THE CAR IS BEING DRIVEN, IT COULD RESULT IN LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE RECLINER BOLTS. OWNER NOTIFICATION BEGAN ON APRIL 23, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE…

SEAT BELTS:FRONT:RETRACTOR

VEHICLE DESCRIPTION: CERTAIN VAN, WAGON, PICKUP TRUCKS, PASSENGER AND SPORT UTILITY VEHICLES, FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE FRONT SEAT BELT RETRACTOR MAY NOT COMPLY WITH THE REQUIREMENTS OF THE STANDARD.

Risk: IF THE RETRACTOR DOES NOT WORK PROPERLY, IT WILL NOT ADEQUATELY PROTECT OCCUPANTS IN THE EVENT OF A CRASH.

Remedy: DEALERS WILL REPLACE THE SEAT BELT RETRACTOR. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE…

STRUCTURE:FRAME AND MEMBERS

VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES (NON-SUNROOF ONLY) FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT."

Risk: IN THE EVENT OF A CRASH, THERE IS A POTENTIAL FOR INJURY IF THE OCCUPANT'S HEAD WERE TO CONTACT THE B-PILLAR.

Remedy: OWNERS WILL BE SENT A STORAGE BIN ACCESSORY UNIT THAT CAN BE ATTACHED TO THE B-PILLAR ALONG WITH INSTALLATION INSTRUCTIONS. HOWEVER, IF AN OWNER WISHES, THE DEALER CAN PERFORM THE INSTALLATION. OWNE…

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

VEHICLE DESCRIPTION: NON-ABS EQUIPPED PASSENGER VEHICLES. THE BRAKE MASTER CYLINDER PISTON RETAINER SNAP RING MAY HAVE BEEN BENT INWARD DURING THE ASSEMBLY PROCESS. THE MASTER CYLINDER PISTON MAY BE IN A "BRAKE APPLIED" POSITION DUE TO THE DAMAGED PISTON RETAINER SNAP RING. WHEN THE PISTON IS …

Risk: IF THE BRAKE OVERHEAT, BRAKE FADING COULD LEAD TO AN INCREASE IN NEEDED STOPPING DISTANCE. SHOULD A DRIVER NOT ANTICIPATE THE EXTRA STOPPING DISTANCE, THIS CONDITION COULD CAUSE A CRASH.

Remedy: DEALERS WILL REPLACE THE BRAKE MASTER CYLINDER.

CHILD SEAT

VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." SOME OF THE OWNER'S MANUALS FOR THESE VEHICLES ARE MISSING INSTRUCTIONS THAT PROVIDE A STEP-BY-STEP PROCEDURE, INCLU…

Risk: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.

Remedy: OWNERS WILL BE PROVIDED WITH AN ADDENDUM TO THE OWNER'S MANUALS.

SEAT BELTS

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SEAT BELT SHOULDER HEIGHT ADJUSTABLE TURNING LOOP (ATL) TOP MOUNTING BOLT WAS INADEQUATELY MANUFACTURED.

Risk: THE AFFECTED MOUNTING BOLTS MAY NOT WITHSTAND SUFFICIENT FORCE TO FUNCTION PROPERLY IN CERTAIN IMPACT SITUATIONS, INCREASING THE RISK OF INJURY TO A BELTED OCCUPANT.

Remedy: DEALERS WILL REPLACE THE SHOULDER BELT HEIGHT ADJUSTER MOUNTING BOLTS.

SEAT BELTS:FRONT:RETRACTOR

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE MOLDING FLASH ON THE PRIMARY LEVER MAY PREVENT THE OPERATION OF THE G-LOCK AND TILT LOCK FUNCTIONS ON SOME OF THE DRIVER'S SIDE RETRACTORS.

Risk: IF THIS OCCURS IN A FRONTAL CRASH SITUATION, DRIVER PROTECTION FROM THE SEAT BELT MAY BE REDUCED, INCREASING THE RISK OF INJURY.

Remedy: DEALERS WILL REPLACE THE LEFT FRONT RETRACTOR ASSEMBLIES.

AIR BAGS:FRONTAL

VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES. THE PASSENGER AIR BAG INFLATOR ASSEMBLY CONTAINS AN INCORRECT INFLATOR CHARGE AMOUNT.

Risk: THIS CONDITION COULD INCREASE THE RISK OF A PASSENGER OCCUPANT INJURY UNDER CERTAIN ACCIDENT CONDITIONS.

Remedy: DEALERS WILL REPLACE THE AIR BAG MODULE WITH A CORRECT MODULE.

FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM

VEHICLE DESCRIPTION: PASSENGER VEHICLES BUILT WITH 3.5L ENGINES. THE FUEL INJECTION DELIVERY SYSTEM CAN LEAK FUEL FROM SOME OF THE SEALING O-RINGS OR FROM HAIR LINE CRACKS IN THE THERMOSET FUEL INJECTION RAIL.

Risk: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.

Remedy: DEALERS WILL REPLACE THE FUEL RAIL O-RINGS AND REINFORCE THE OUTLET (PASSENGER) SIDE FUEL RAIL. VEHICLES SHOWING FUEL LEAKAGE ON THE OUTLET FUEL RAIL MUST HAVE THE OUTLET RAIL REPLACED WHICH INCLUDES…

ELECTRICAL SYSTEM:WIRING

THE RIGHT STEERING TIE ROD CAN RUB THROUGH THE AUTOMATIC TRANSMISSION WIRING HARNESS CAUSING A SHORT CIRCUIT WHICH RESULTS IN ELECTRICAL SYSTEM MALFUNCTIONS INCLUDING ENGINE STALLING AND AN INOPERATIVE PARK/STARTER INTERLOCK SYSTEM.

Risk: ELECTRICAL SYSTEM MALFUNCTION CAUSING STALLING WHILE IN MOTION OR AN INOPERATIVE PARK/STARTER INTERLOCK SYSTEM, WHICH ALLOWS ENGINE START WHILE THE TRANSMISSION IS NOT IN THE PARK POSITION, MAY RESULT…

Remedy: INSTALL A REVISED WIRING HARNESS BRACKET AND A PLASTIC CONVOLUTED SLEEVE TO PROTECT THE TRANSMISSION WIRING HARNESS.