Buick Park Avenue Recalls — All NHTSA Recall Campaigns

POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES

VEHICLE DESCRIPTION: PASSENGER VEHICLES MANUFACTURED FROM AUGUST 1991 THROUGH JULY 1995. THE TRANSMISSION OIL COOLER LINE CAN SEPARATE WHEN THE VEHICLE IS OPERATED IN LOW TEMPERATURES IN COMBINATION WITH HIGH TRANSMISSION LOADS.

Risk: VEHICLE FIRES CAN OCCUR DUE TO THE SPILLAGE OF TRANSMISSION FLUID.

Remedy: DEALERS WILL REPLACE THE TRANSMISSION OIL COOLER LINES.

SEATS:MID/REAR ASSEMBLY

THESE VEHICLES WERE ASSEMBLED WITH CENTER REAR SEAT BELT ANCHOR BOLTS NOT PROPERLY INSTALLED. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES."

Risk: IN THE EVENT OF A VEHICLE CRASH, THE SEAT BELT SYSTEM WOULD NOT WITHSTAND THE REQUIRED LOAD AND INJURY TO THE SEAT OCCUPANT COULD OCCUR.

Remedy: DEALERS WILL TIGHTEN THE CENTER REAR SEAT BELT ANCHOR BOLTS TO SPECIFICATION.

SEAT BELTS:FRONT:BUCKLE ASSEMBLY

THESE VEHICLES WERE ASSEMBLED WITH ONE OR MORE INCORRECT SAFETY BELT AND/OR SAFETY BELT BUCKLE ENDS. THIS DOES NOT CONFORM WITH THE REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES."

Risk: CONSEQUENCE OF NON-COMPLIANCE: IF AN INCORRECT PART IS USED, THE BELT MAY NOT LATCH PROPERLY, INCREASING THE RISK OF INJURY TO THE OCCUPANT SHOULD A VEHICLE CRASH OCCUR.

Remedy: DEALERS WILL INSPECT ALL FRONT AND REAR SAFETY BELT LATCH ENDS AND SAFETY BELT BUCKLES FOR CORRECT PARTS AND REPLACE ANY INCORRECT PARTS.

FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM

A BACKFIRE DURING ENGINE STARTING CAN CAUSE BREAKAGE OF THE UPPER INTAKE MANIFOLD.

Risk: THIS CONDITION CAN CAUSE A NO-START CONDITION AND POSSIBLY AN ENGINE COMPARTMENT FIRE.

Remedy: DEALERS WILL UPDATE THE POWERTRAIN CONTROL MODULE PROGRAMMING. UNTIL THE CAMPAIGN REPAIR IS MADE, THE VEHICLE HOOD SHOULD BE SHUT WHENEVER STARTING THE VEHICLE TO REDUCE THE CHANCE OF PERSONAL INJURY.

EXTERIOR LIGHTING:HEADLIGHTS

THE DRIVER SIDE HEADLAMP LENS HAS AN INCORRECT AIM PAD NUMBER ON THE LENS. THIS DOES NOT COMPLY WITH FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Risk: CONSEQUENCE OF NON-COMPLIANCE: IF THESE HEAD LAMPS ARE RE-AIMED USING A MECHANICAL AIMING DEVICE THAT UTILIZES THE AIMING PAD NUMERS, THE RESULTANT AIM WOULD BE OUT OF THE SPECIFIED RANGE. THIS MAY …

Remedy: DEALERS WILL REPLACE THE DRIVER SIDE HEADLAMP ON VEHICLES WITH THE CORRECT OUTBOARD LOWER PAD NUMBER.

ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

THESE VEHICLES WERE ASSEMBLED WITH A MALFUNCTION ALARM, LIGHTING AND LOCKING (MALL) MODULE THAT CAN CONTAIN A DAMAGED CAPACITOR. IF THE CAPACITOR IS DAMAGED, THE "KEY IN THE IGNITION" WARNING CHIME AND THE DRIVER SEAT BELT UNBUCKLED WARNING CHIME AND INDICATOR LAMP MAY NOT WORK. THIS DOES NOT MEET T…

Risk: CONSEQUENCE OF NON-COMPLIANCE; THE DRIVER MAY NOT BE AWARE THAT THE KEY WAS LEFT IN THE IGNITION OR THAT THE SAFETY BELT WAS NOT BUCKLED.

Remedy: DEALERS WILL INSPECT AND, IF REQUIRED, REPLACE THE MALL MODULE.

SEAT BELTS:FRONT:WEBBING

VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES HAVE FRONT SEAT SHOULDER BELTS THAT MAY TWIST, ALLOWING THE WEBBING TO BECOME JAMMED IN THE RETRACTOR.

Risk: WHEN THE SHOULDER BELT WEBBING BECOMES JAMMED IN THE RETRACTOR, THE BELT MAY BE UNUSABLE.

Remedy: DEALERS WILL INSPECT FOR THE PRESENCE OF UPDATED FRONT SHOULDER BELT BEZELS AND WHERE NECESSARY, INSTALL NEW FRONT SEAT SHOULDER BELT OPENING BEZEL KITS.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

THE ELECTRONIC BRAKE CONTROL MODULE OR THE ELECTRONIC BRAKE AND TRACTION CONTROL MODULE CAN CAUSE THE ANTILOCK BRAKE SYSTEM (ABS) TO CYCLE DURING A NON-ABS BRAKE APPLICATION.

Risk: THIS CONDITION CAN RESULT IN AN INCREASE IN VEHICLE STOPPING DISTANCE INCREASING THE RISK OF A VEHICLE CRASH.

Remedy: DEALERS WILL REPLACE THE ELECTRONIC BRAKE CONTROL MODULE OR THE ELECTRONIC BRAKE AND TRACTION CONTROL MODULE.

FUEL SYSTEM, GASOLINE:DELIVERY

ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 3800 V6 (L36) ENGINES AND CERTAIN DELPHI FUEL PRESSURE REGULATORS, THE REGULATORS HAVE A MUCH HIGHER THAN USUAL RATE OF FUEL LEAKS. A LEAK CAN ALLOW FUEL TO ENTER THE INTAKE MANIFOLD THROUGH A VACUUM LINE. IF THE ENGINE DOES NOT START WHEN CRANKED, THE …

Risk: THE BACKFIRE CAN RUPTURE THE INTAKE MANIFOLD. THE RUPTURE OF THE INTAKE MANIFOLD CAN DISPLACE A FUEL LINE, PULLING AN INJECTOR OUT OF PLACE, AND CAUSING A FUEL LEAK AND POSSIBLE FIRE.

Remedy: DEALERS WILL INSTALL NEW FUEL PRESSURE REGULATORS WITH IMPROVED DIAPHRAGMS. THE RECALL WILL BE CONDUCTED IN PHASED MAILINGS. PHASE 1 BEGAN ON JUNE 30, 2004, AND PHASE 2 BEGAN ON SEPTEMBER 30, 2004. …

SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE BRAKE BOOSTER TO PEDAL ASSEMBLY ATTACHMENT NUTS MAY BE LOOSE.

Risk: IF THESE NUTS ARE LOOSE, THE BRAKE PEDAL MAY BE LOW, THE ASSEMBLY MAY BE LOOSE, THE BRAKES MAY NOT RELEASE, AND IF THE NUTS BACK COMPLETELY OFF, BRAKING MAY BE LOST. ALSO FUME AND WATER INTRUSION TO …

Remedy: DEALERS WILL REPLACE ANY MISSING BRAKE BOOSTER TO BRAKE PEDAL ASSEMBLY NUTS AND TIGHTEN ALL FOUR (4) NUTS TO SPECIFIED TORQUE.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES MAY HAVE BEEN BUILT WITH INCORRECT FRONT BRAKE ROTOR, BRAKE CALIPER ASSEMBLY, BRAKE PADS, AND CALIPER MOUNTING BRACKET ON EITHER THE LEFT OR RIGHT SIDE OF THE VEHICLE.

Risk: A VEHICLE WITH THIS CONDITION CAN PULL TO ONE SIDE DURING A BRAKING MANEUVER. IN ADDITION, VEHICLE STOPPING DISTANCE COULD BE INCREASED.

Remedy: DEALERS WILL INSPECT FOR CORRECT BRAKE PARTS AND REPLACE ANY INCORRECT ROTORS, CALIPER ASSEMBLIES, BRAKE PADS, AND CALIPER MOUNTING BRACKETS.

VISIBILITY:WINDSHIELD WIPER/WASHER

VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 104, "WINDSHIELD WIPING AND WASHING SYSTEMS." THESE VEHICLES HAVE A WIPER SYSTEM MICROPROCESSOR THAT IS SUSCEPTIBLE TO VOLTAGE TRANSIENTS, WHICH CAN CAUSE A "LATCH-UP" CONDITION IN THE S…

Risk: IF MICROPROCESSOR "LATCH-UP" OCCURS, THE CUSTOMER WILL NOT BE ABLE TO OPERATE THE SYSTEM IN BOTH THE LOWER AND HIGH-SPEED MODES REQUIRED BY THE STANDARD.

Remedy: DEALERS WILL REPLACE THE WINDSHIELD WIPER MOTOR COVER WHICH CONTAINS THE MICROPROCESSOR.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS

VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES HAVE INTERNAL FLUID LEAKS IN THE BRAKE HYDRAULIC CONTROL UNIT.

Risk: WHEN THE REAR BRAKE PROPORTIONING, ANTILOCK BRAKE, TRACTION CONTROL, OR STABILITY CONTROL FEATURE IS ACTIVATED IN SOME DRIVING SITUATIONS, THE FEATURE MAY NOT PERFORM AS DESIGNED.

Remedy: DEALERS WILL INSPECT THE ABS HYDRAULIC MODULATOR UNIT AND IF NECESSARY, REPLACE THE HYDRAULIC MODULATOR.

LATCHES/LOCKS/LINKAGES:TRUNK LID:LOCK

ON CERTAIN PASSENGER VEHICLES, THE EMERGENCY TRUNK RELEASE HANDLE MAY BE INSTALLED OR FORCED OUT OF THE PROPER POSITION.

Risk: IF THE CABLE IS OUT OF THE PROPER POSITION, IT COULD INCREASE THE FORCE REQUIRED TO ACTIVATE THE EMERGENCY TRUNK RELEASE HANDLE AND A PERSON TRAPPED IN THE TRUNK MAY NOT BE ABLE TO RELEASE THE TRUNK L…

Remedy: DEALERS WILL SECURE THE EMERGENCY TRUNK RELEASE CABLE TO ENSURE THAT THE EMERGENCY TRUNK RELEASE HANDLE OPERATES PROPERLY. OWNER NOTIFICATION BEGAN DECEMBER 19, 2002. OWNERS WHO TAKE THEIR VEHICLES …