1982 Mercury Cougar — Problems, Recalls & Complaints

CERTAIN FEDERAL-MOGUL AFTERMARKET FUEL PUMPS SOLD UNDER THE BRAND NAMES OF CARTER, ACCUFLOW, NAPA, TRUFLOW, PARTS DEPO, AND PARTS MASTER, SHIPPED BETWEEN AUGUST 2006 AND JULY 2007 FOR USE ON THE VEHICLES LISTED ABOVE. THE FUEL PUMP DIAPHRAGM IN CERTAIN PRODUCTION RUNS MAY HAVE BEEN IMPROPERLY INSTALLED OR INADEQUATELY TESTED WHICH MAY CAUSE THE FUEL PUMP TO LEAK.

Remedy: FEDERAL-MOGUL WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 15, 2007. OWNERS CAN CONTACT FEDERAL-MOGUL AT 248-354-7700.

INCORRECT INFORMATION ON TIRE PLACARDS CONSTITUTES A FAILURE TO COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS". THE INFORMATION CONCERNING TIRE SIZES AND INFLATION PRESSURES IS APPLICABLE TO BOTH TWO AND FOUR DOOR SEDANS. THE STATEMENT COVERS FOUR DOOR BUT FAILS TO SPECIFY TWO DOOR SEDANS.

Remedy: REVISED PLACARDS WILL BE INSTALLED BY OWNERS, OR BY DEALERS WITHOUT CHARGE.

SOME OF THE SUSPECT VEHICLES MAY HAVE BEEN PRODUCED WITH IMPROPERLY TIGHTENED PROPANE FUEL SYSTEM FITTINGS IN THE ENGINE COMPARTMENT; FUEL LEAKAGE COULD OCCUR.

Remedy: DEALER WILL INSPECT, REPLACE, AND SEAL CERTAIN FUEL SYSTEM CONNECTIONS AT NO COST TO OWNER.

SOME OF THE INVOLVED VEHICLES MAY HAVE BEEN PRODUCED WITH IMPROPERLY WELDED FUEL TANK SUPPORT STRAPS. UNDER CERTAIN COLLISION CONDITIONS, THESE STRAPS MAY NOT BE ABLE TO SUPPORT THE FUEL TANK AND LEAKS COULD DEVELOP.

Remedy: DEALER WILL INSPECT THE FUEL TANK RETAINING STRAPS FOR TYPE OF WELDS AND, IF NECESSARY, REPLACE THEM AT NO CHARGE TO OWNER.