1986 Jeep Cherokee — Problems, Recalls & Complaints

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Remedy: DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Remedy: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

VEHICLE DESCRIPTION: MULTIPURPOSE PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS. THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH FEDERAL REGULATION 573. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. DRIVERS CAN MISTAKENLY STEP ON THE ACCELERATOR PEDAL WHEN THEY INTEND TO STEP ON THE BRAKE PEDAL.

Remedy: DEALERS WILL INSTALL A SHIFT INTERLOCK ON THE AUTOMATIC TRANSMISSION OF THESE VEHICLES.

JEEPS MAY HAVE AN IMPROPERLY CONNECTED FUEL LINE FITTING WHICH COULD BECOME DISCONNECTED AND CAUSE GASOLINE TO BE SPILLED. CONSEQUENCE OF DEFECT: IF THE FUEL LINE BECOMES DISCONNECTED, SPILLS GASOLINE AND AN IGNITION SOURCE IS PRESENT, A FIRE OR EXPLOSION MAY OCCUR.

Remedy: RECONNECT FUEL LINE FITTING, AS REQUIRED.

BRAKE BOOSTER VACUUM RESERVOIR CANISTERS MAY DEVELOP LEAKS DUE TO BUMPER IMPACT.

Remedy: REPLACE BRAKE BOOSTER VACUUM CANNISTERS WITH NEW TYPE CANNISTERS; ALSO, INSTALL A RESTRICTION ORIFICE TO ENSURE SUFFICIENT VACUUM IN EVENT CANNISTER LEAKAGE OCCURS.

STEERING LINKAGE COUPLERS REMAINED IN ACID ETCHING BATH TOO LONG. CONSEQUENCE OF DEFECT: COUPLERS COULD BE OUT OF TOLERANCE RESULTING IN STEERING WHEEL MISALIGNMENT WITH EVENTUAL LOSS OF VEHICLE CONTROL.

Remedy: REPLACE OUT OF TOLERANCE STEERING LINKAGE COUPLERS.

ACCELERATOR CABLE BUSHING COULD DISCONNECT FROM THE ACCELERATOR LEVER ASSEMBLY. CONSEQUENCE OF DEFECT: THIS COULD RESULT IN LOSS OF ENGINE CONTROL WITH ENGINE RETURNING TO IDLE.

Remedy: REPLACE ACCELERATOR PEDAL BRACKET AND LEVER ASSEMBLIES.