1G1YU3D65G56008792016 CHEVROLET CorvettePremium 2LZ w/Z06

Experiencing sudden loss of power steering while driving - unsafe condition. Experiencing sudden loss of electric power steering assist while driving. Loss of power steering persists until ignition recycling (stop, put car in park, turn ignition off, turn ignition back on), which seems to clear it. Problem re-occurs intermittently on subsequent drives. Issue has been experienced at multiple MPH (0 to 65 MPH) across more than a month of time. I believe my vehicle is experiencing the recall noted earlier this year (N182182760 in 2025) for power steering unit failures in Corvettes manufactured in my car's timeframe. The recall is still expanding the list of cars associated due to its nascent nature, and I believe mine is one of them. My car was manufactured in 2016 and the manufacturing defect in the power steering unit circuitry was not corrected until 2017. The recall investigation only occurred a few months ago, earlier this year in 2025. Request my vehicle be added to recall N182182760 to correct this unsafe condition. Thank you. REFERENCES: 1) https://www.roadandtrack.com/news/a64272254/chevrolet-camaro-corvette-recall-steering-failure/ 2) chrome-extension://efaidnbmnnnibpcajpcglclefindmkaj/https://static.nhtsa.gov/odi/rcl/2019/RCSB-19V086-8145.pdf

Experiencing sudden loss of power steering while driving - unsafe condition. Experiencing sudden loss of electric power steering assist while driving. Loss of power steering persists until ignition recycling (stop, put car in park, turn ignition off, turn ignition back on), which seems to clear it. Problem re-occurs intermittently on subsequent drives. Issue has been experienced at multiple MPH (0 to 65 MPH) across more than a month of time. I believe my vehicle is experiencing the recall noted earlier this year for power steering unit failures in Corvettes manufactured in my car's timeframe (safety recall N252497020 in 2025, expanding on N182182760 from 2019). The recall is still expanding the list of cars associated due to its nascent nature, and I believe mine is one of them. My car was manufactured in 2016 and the manufacturing defect in the power steering unit circuitry was not corrected until 2017. The recall investigation only occurred a few months ago, earlier this year in 2025. Request my vehicle be added to recall N252497020 / N182182760 to correct this unsafe condition. Thank you. REFERENCES: 1 – My request to Chevrolet through the dealership for a “good will extension” of the 2025 recall (N252497020 – Loss of Power Steering Assist) to this VIN. Includes a detailed description of the issue. 2 – Safety Recall N252497020 – Loss of Power Steering Assist 3 – Safety Recall N182182760 – Loss of Power Steering Assist 4 – Photo of my vehicle DIC with associated power steering failure error message. 5 – Article from 2025 detailing the nascent power steering failure recall, noting the defective part manufacturing timeline affects my VIN. 6 – Additional article from 2025 acknowledging the recall issue.

I would be driving and get a notification in the panel that says power steering is out and to drive with care. It is extremely difficult to drive my vehicle, with no power steering. I would just be driving, and I would get the notification that power steering is out. The problem has been recently confirmed by a dealership. The mechanic at the dealership confirmed it was the same issue reported for the 2017 Chevrolet Corvette (N182182760). The first appearance of the issue was at 3800 miles on my 2016 Chevrolet Corvette. I was sitting at a red light, and the notification came on and said I didn't have power steering. The second time I was driving down the interstate at 70mph and it went out, not good. I was able to get it safely back to my sister's home and did not move it again until I took it straight to the dealership today, in which time it went out again. All this with 4085 total miles on my car at this time. I believe this should be covered under the same recall as the 2017 Chevrolet Corvette. My vehicle is available for inspection if someone would like to come out.

The contact owns a 2016 Chevrolet Corvette. The contact stated that while depressing the accelerator pedal, the vehicle hesitated while shifting from second gear to third gear. The transmission was skipping a gear. The contact believed that the vehicle was not working properly. The vehicle was not responding as needed. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed with torque converter failure. The dealer contacted the surveyor for the protection plan approval. The vehicle was not repaired. The manufacturer was not contacted. The contact called the attorney general and was referred to the NHTSA Hotline. The approximate failure mileage was 33,025.

My vehicle is covered by GM Special Warranty 17469 which relates to cracks and fuel leaks at the primary fuel pump module flange. It caught fire while driving at a high performance driver’s education event at Barber Motorsports Park and was denied coverage due to it having modifications. GM case number 9-15085163081. There were no warning messages displayed at any time during the incident. GM had the vehicle inspected by a “neutral” third party which turned out to be a retired GM service center instructor. None of the modifications on the vehicle affect the fuel pump module flange. This is in violation of the Magnuson Moss Warranty Act. The basic facts regarding the incident are as follows: the fire was a fuel fire, the vehicle had normal fuel pressure until I shut the engine off 2 minutes into the incident, the fuel line fittings are melted in the normal seated position, the fuel tank flange is cracked and fire damaged, the most significant fire damage is at the top of the driver’s side fuel tank (the location of the warrantied and currently cracked flange), the fire was not from any of the pressurized fuel lines. I have video from the vehicle of the incident prior to engine shutdown, pictures during and after the incident of all affected areas and components, and data logs of all vehicle parameters up to engine shutdown. These facts point strongly to the initial source of the fuel fire coming from the affected flange at the top of the driver’s side fuel tank. It is completely unacceptable that GM issued an extended warranty (and then denies coverage) for this known fire hazard vs issuing a recall. This is extremely unsafe and will lead to a loss of life if not corrected.

I left my car at Vandergriff Chevrolet in Arlington, TX for diagnosis and repair of a transmission sensor failure. They took nearly 6 weeks to fix the issue. When I went to pick up the car, there was a new noise in the engine so I left the vehicle for diagnosis. Now, they are telling me it's a known issue that is considered 'crucial' to repair but is not a recall and they are so far unwilling to cover the repair since it seems to have happened while they had the vehicle. I've attached their service bulletin indicating the known issue and repair.

Overview: Beginning sometime in 2020, the coating of the rearview inside mirror began to degrade and lose its reflective capability. By [XXX] visibility through the mirror was so bad that I had to have it replaced by the local Chevy dealership. Because it was out of warranty, I had to pay $453.93 out of pocket. The vehicle was unsafe to drive due to the mirror's degraded condition. 1. What component or system failed or malfunctioned, and is it available for inspection upon request? Rearview interior mirror 2. How was your safety or the safety of others put at risk? I could not see clearly in the rearview mirror. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? Many other drivers have reported the same issue with this model on the Corvette forum (see [XXX] ) Also, Sunrise Chevrolet in Collierville, TN confirmed the mirror was defective and replaced it at my expense. 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Overview - November 2022, my 2016 Covette Stingray vibrated badly at highway speeds, that I took it into the Sunrise Chevrolet Buick GMC dealership in Collierville, TN to investigate the cause. They made videos showing 3 of the 4 wheels (not tires) were warped. This is my second car (rarely driven), so I was quite surprised. Chevy was out of stock and the vehicle was out of warranty, so I had to replace all 4 wheels using after-market parts that had to be shipped to the dealership at total cost of $3,400.58. A few weeks after the wheels were replaced, I noticed the vibration was still occurring at highway speeds, so I returned it to the same dealership on Jan 3rd, 2023. The dealership said that the transmission fluid had to be replaced with a "new design" to prevent the shaking at my expense for a total of $1,066.10. The problem is so well-known, that it's called the "Chevy Shake" on the Corvette forum. I feel that Chevrolet has put my safety at risk twice in 2022 with a faulty mirror (I files a separate complaint for that), the faulty tires, and the faulty transmission fluid.

Transmission is very erratic to shift, especially when cold. Sometime, when pressing the accelerator, the car hesitates before moving forward. This can be dangerous at intersections with oncoming traffic. The transmission was inspected by a Chevy dealer right after the car was purchased (09/2017) and parts replaced. The symptoms still happen. It was inspected again 01/2023 by a Chevy dealer and the transmission fluid flushed. The symptoms still happen regularly. GM is aware of this dangerous issue, yet nothing has been done to correct the problem.

The contact owns a 2016 Chevrolet Corvette. The contact stated while the vehicle was parked, the contact noticed that the structure of the dashboard had started to detach from the vehicle. The vehicle was taken to the dealer where it was determined that the dashboard needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 50,027.

Normal driving - about 69,000 miles. Rear wheel rim developed cracks in inner bead lip causing complete loss of inflation.

Rear rims have cracks. Which is causing the car to lose air and it also lose traction.

The transmission has a shudder issue at speeds between 60 and 80 mph. Gives the feeling of driving over rumble strips. Vehicle milage is 6200 miles. The dealership verified the issue associated with the transmission and indicated that a repair bulletin was issued by GM to correct the issue

The contact owns a 2016 Chevrolet Corvette. The contact stated that while driving from a stop, after engaging the clutch, the vehicle started to shudder and vibrate and nearly stalled. The contact pulled over into a parking lot. No warning lights were illuminated. The vehicle was towed to an independent mechanic, who determined that the valve spring had fractured in half within cylinder #5. Further diagnostic test determined that the failure had caused damage to the engine, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 12,000.

Fuel smells after filling up seems like there is a leak, received a letters from manufacturer but miss placed it, when we found it it was over the mileage limit. Now they will not fix the safety issue.

Wheels are defective and cracked at approx 22k miles normal use. Inside of driver wheel cracked and does not hold air.

Attempted to start my Corvette. My Corvette was in the my garage Battery was dead. Called for a jump start. When mechanic arrived, I got into the driver's seat. When he applied electric power to the car battery, interior lights flickered, radio came on, tach needle and other needles cycled and my electric power adjustable seat went full forward and the electric power adjustable steering wheel went full down. This happened in seconds. The engine was not running. I thought I was going to be crushed by the steering wheel. I have a small frame. If I were a bigger person, I would have sustained a crushing chest injury or death. With the seat full forward and the steering wheel full down with great difficult I wiggled my way out of my Corvette. My Corvette is scheduled for diagnostic / repair on 11 Apr 23 at Criswell Chevrolet in Thurmont, MD. I have notified GM customer support and provided this narrative to them on 6 Apr 23.

The contact owns a 2016 Chevrolet Corvette. The contact stated that the wheels were cracking from the inside. The contact stated that the TPMS warning light was illuminated. The vehicle was taken to the local dealer where it was diagnosed and determined that the wheels needed to be replaced. The vehicle was repaired; however, the failure persisted. The manufacturer was not contacted. The failure mileage was approximately 20,000.

Started loosing tire pressure on L/R tire, local tire shop informed and showed me that my left rear rim has a crack which causes loos of air. This is a known issue that GM wants to blame on drivers but issue stems from GM using cheaper cast aluminum materials instead of forged materials which are better suited due to the amount of torque that the ZO6 models generated. *Note* GM used forged material on their ZR1 models!!

Since the vehicle was new, it has exhibited a transmission shake or shudder that is especially noticeable when the Active Fuel Management is active. The vehicle was serviced by Chevrolet under warranty on Dec. 5, 2017, for a transmission shake and/or shudder repair using the flush methods described in Bulletin No. 18-NA-355, but it has continued to exhibit a transmission shake or shudder. My local Chevrolet dealership has now diagnosed the vehicle as having a torque converter with excessive slippage and recommended a replacement torque converter at a cost of $3,450 including parts and labor, or a total transmission replacement at a cost of $8,100. My vehicle currently has 24,473 miles on the odometer. A major transmission component should not fail in less than 25,000 miles on a modern flagship vehicle used for light, non-everyday driving from a leading U.S. auto manufacturer.

Transmission shudder a low acceleration. Requires Triple Transmission flush. Vehicle is 2016 Model with 10500 miles GM refused any responsibility. GM was aware they had an issue with the transmission fluid. It has gone through two reformulations to correct the issue.

Vehicle has less than 8k miles and right rear wheel has a stress fracture on inside of wheel. Zero signs of damage to the tire or anything indicating cause of fracture was from a road hazard. Fracture causes a slow air leak. Hundreds if not 1000s of corvette owners 2015-2019 have had this issue.

Rear rims (20 by 12, cast aluminum) have both cracked with no trauma to the rim other than simply driving the car on the street. Right rear has been repaired multiple times and has now cracked right beside the repaired cracks. The left rear has cracked on the inside by the bead and with two wheels cracked and leaking air, I have ended up ordering two new rims from GM. I put some tire sealant in the left rear and that slowed down the slow leak while the new rims were being delivered. I have talked about this many times with the dealer and with GM, and they say I must have caused the cracks by my driving, which doesn't make sense to me. They say sue me and point out that you, the NTHSA, haven't ordered the rims recalled. These are now the seventh and eighth cracks that have developed on my rear rims, three different rims. One original lasted 27,000 miles before the first crack. The replacement original for that first rim lasted about 7,000 miles before the first crack. The last original rim of the same size on the back lasted 37,500 miles before the first crack appeared. I bought a 1978 Corvette new with forged aluminum rims and drove it some 150,000 miles with no rim cracking problems and I drove a 2001 Corvette Z06 that I bought used for over 100,000 miles over the same roads I've now driving my 2016 Corvette on and had not a single rim cracking problem (again, forged aluminum rims on that). I have had no cracking problems with the front 19 by 10 cast aluminum rims, so it sure appears to be the rear rim cracks are because of defects in the casting process. GM make the choice to go with cast aluminum rims instead of the stronger forged aluminum, and I don't take exception to their design choice as long as the rims hold up to everyday driving stresses. The rim cracks historically expand over time and ignoring them could, in the dealer's estimation, result in catastrophic rim failure resulting in a serious accident and potential driver fatality.

Rear rim (20 inch by 12 inch, cast aluminum) cracked in two places. These are the fifth and sixth cracks I've had in two rear rims. Reported it to the dealer and they effectively said "sue GM", won't help me. When the rim cracks, the tire looses air pressure and the car's sensors tell me the air pressure is low. These cracks appear on the inside of the rear wheels without any trauma to the rim. I do have the rim available for inspection upon request. Obviously a cracked rim could result in the rim coming apart while I'm driving resulting in an uncontrollable car and an accident that could be life threatening. Mileage at the moment is 37,201. Pictures of the original cracking were sent to a metalurgy professor who opined the rim was obviously defective. GM refuses to acknowledge the cracking issue with these Z06 rims and now won't even find me a replacement rim.

All 4 rims were all bent when tires were replaced a few months ago and Americas tire found that there were several cracks in the rims with only 25,000 miles on the car. Looking through the corvette forum, thousands of people have had the same problem. This is a huge safety concern with this fast of a car.

The top drivers side of the windshield has a 2" hairline crack that you cannot feel from the outside of the vehicle. Numerous Corvette Forum Sites have discussions regarding this to be a manufacturer assembly flaw. Apparently there is some left over welding material near the corner of the windshield pillar. This material creates pressure against the inside of the glass causing it to crack on the inside layer of glass. I have contacted the local Chevrolet dealer and the GM Customer Care Center. Both have declined to even look at the crack stating it is not GM's fault. There are numerous posts on the Corvette Forums showing pictures of cracks just like mine. GM's answer was to have my insurance company replace the glass. I do not feel this is right given this is a quality control issue. Some of the windshields in the forum posts have continued to crack across the whole top of the windshield. See below for forum sites and discussions! https://www.stingrayforums.com/threads/cracked-windshield-just-cracked-itself.39937/ https://www.stingrayforums.com/threads/cracked-windshield-already.6414/ https://www.corvette7.com/forums/showthread.php?p=9165900 My car only has 11,000 miles on it, has never been driven in the rain and is always covered in my garage when not in use. It also has never been in an accident.

Have now experienced, for the FOURTH time, a crack in one of my rear cast aluminum rims on my 2016 limited edition C7R Corvette. Once the rim cracks, it leaks air, slowly to start with but then faster and faster as the crack grows over time. This latest crack is on a rim that I bought for over $1,000 from my local GM/Chevy dealer when they wouldn't do anything for me over a previously cracked rim. Every one of the four cracks have been on the inside of the rear rim with no trauma evidence to be seen as a don't hit curbs or potholes with my car. I drive carefully as evidenced by my getting 19.7 miles per gallon for the life of my car and as much as 27 miles per gallon for a 50 mile stretch. I don't take it racing or abuse it as this was my dream car, one of 500 made for the US market. The local dealer folks admit the rims are defective but say they can't do anything about it because GM says the rims are not defective. The first cracked rim was also examined by a metals professor at Sacramento State who confirmed the rim was defective but said destructive testing would be required to prove that with absolute certainty. I have not agreed to destructive testing and am in possession of the latest cracked rim. Once a rim cracks, I have to get it replaced or fixed as the car is not really usable with a flat tire.

Right rim is cracked. Mechanic informed me the tire leak is due to cracked rim. Appears like others have the same issue. What’s not known is if the crack is propagating therefore becoming a true safety hazard while driving the vehicle at highway speeds.

The left rear rim on the vehicle cracked resulting in air loss. GM covered only a 40% of the cost to replace. This fracture places all four of the wheels in question. Rims should not CRACK and fail.

Right rear rim cracked for the third time on my car. I noticed a slow leak after driving for about an hour earlier in the day. I get back in my car after a round of golf and notice that the right rear tire is low on air pressure. This is the third time I've had a cracked rim. I don't abuse my car, as this is a limited edition C7R, one of 500 made for the US market. My dealer admits that the rims are defective but says they can't do anything about it because GM says the rims aren't defective. Even though my car is only five years old with less than 36,000 miles on it, GM no longer makes these rims and none are available nationwide, so I'm forced to go to a aluminum wheel repair shop to get my rim fixed as there is no alternative. The original rim cracked, the $1,000 OEM replacement rim cracked (in the same place), and now the original rim repaired has cracked (again in the same area just next to where it was repaired).

The contact owns a 2016 Chevrolet Corvette. The contact stated while the vehicle was being serviced at a tire shop, he was notified that the rear driver and passenger side rims were cracked. The contact called the local dealer to inform them of the failure and ordered both rims to be replaced. The vehicle had not been repaired as of yet. The manufacturer had not been informed of the failure. The failure mileage was approximately 12,488.

I RETURNED TO MY CAR AFTER PLAYING A ROUND OF GOLF ON MONDAY AND THE CAR SAID THE RIGHT REAR TIRE WAS LOW. I DROVE TO THE TIRE STORE AND THEY FOUND THE RIM WAS CRACKED WITH NO SIGNS OF ANY TRAUMA TO THE RIM OR TIRE. I HAD THE SAME THING HAPPEN IN JANUARY 2020, AND ENDED UP BUYING A NEW ALUMINUM RIM FROM THE DEALER (OVER $1.000) BECAUSE GM SAYS THE RIM ISN'T DEFECTIVE. THE CAR THEN HAD 26,500 MILES ON IT. NOW 7,600 MILES AND A LITTLE OVER A YEAR LATER, THE NEW REPLACEMENT RIM CRACKS ON THE INSIDE OF THE RIM IN THE VERY SAME MANNER AS THE ORIGINAL RIM CRACKED. I'VE ATTACHED A PICTURE AND NOW HAVE TWO CRACKED (DEFECTIVE) RIMS IN HAND. I REPORTED THE FIRST CRACKED RIM TO NTHSA WHEN IT HAPPENED A YEAR AGO AND NOW AM REPORTING THE SECOND IDENTICAL DEFECT. DO I NEED TO DRIVE THE CAR AND HURT MYSELF VIA AN ACCIDENT TO GET YOU FOLKS TO TAKE MY CASE SERIOUSLY?

I HAVE A '16 CORVETTE Z-51 W/8-SPEED AUTO TRANS. ORDERED CAR BRAND NEW IN APRIL 2015 - TOOK POSSESSION IN SEPT. 2015. CAR TURNED 6,000 MILES IN APRIL 2021. ON A DRIVE RECENTLY, REAR END BEGAN TO EXPERIENCE A SHUDDER/ VIBRATION BETWEEN 50-65 MPH LIKE DRIVING OVER SMALL RUMBLE STRIPS. INTERNET RESEARCH RESULTED IN ME FINDING THE EXISTENCE OF SERVICE BULLETIN NO. 18-NA-355, DATED FEBRUARY 2019 AND AN UPDATED BULLETIN WITH SAME NUMBER DATED APRIL, 2020. PROBLEM IS A KNOWN PROBLEM FOR A HOST OF GM VEHICLES FROM 2015-19 WITH THE GM 8L45 AND 8L90 8-SPEED AUTOMATIC TRANSMISSIONS. APPARENTLY THE WRONG FLUID WAS INSTALLED IN THESE TRANSMISSIONS. REFERENCE ATTACHED BULLETIN 18-NA-355. TOOK CAR TO DEALER THE FOLLOWING MONDAY AND IT WAS DIAGNOSED AS HAVING THE STATED TRANSMISSION SHUDDER PROBLEM AS OUTLINED IN SERVICE BULLETIN. BECAUSE MY CAR IS OUT OF FACTORY WARRANTY BY 6-MONTHS AND GM EXTENDED WARRANTY WON'T COVER FOR THIS EXPENSE, I WAS LEFT TO PAY THE $650 TO CORRECT A KNOWN ISSUE. WHY MUST OWNERS PAY FOR GM'S ERROR? ATTACHED BULLETIN EXPLAINS THE STEPS TAKEN TO CORRECT THE PROBLEM, INVOLVING 3 FLUSHES AND INSTALLING NEW/ DIFFERENT TYPE OF TRANSMISSION FLUID - NEW PART NUMBER 19417577. TIME WILL TELL IF THIS SO-CALLED FIX WORKS. INTERNET AUTO FORUMS INDICATE SOME FOLKS HAVE HAD TO RETURN TO THE GM DEALER MORE THAN ONCE FOR THIS PROBLEM, AFTER THE FLUSH PROCEDURE. CONTACTED GM AND LOGGED FORMAL COMPLAINT -- WITH NO RESPONSE AND BASICALLY NOTHING BUT A RUN AROUND THUS FAR. AS A CONSUMER WHO PAID GOOD MONEY FOR A HIGH END PERFORMANCE VEHICLE WOULD IT NOT HAVE BEEN GOOD BUSINESS PRACTICE TO NOTIFY CUSTOMERS OF A PENDING PROBLEM RATHER THAN REMAIN SILENT ABOUT THE PROBLEM, LET VEHICLE WARRANTY RUN OUT, THEN TELL CUSTOMERS IT'S THEIR PROBLEM? POOR CUSTOMER SATISFACTION POLICY NO DOUBT! GM SHOULD BE FORCED TO OWN UP TO THIS PROBLEM AND PAY FOR THE REPAIR.

AT 627 MILES TOOK TO DEALER, TRANSMISSION WAS SLOW SHIFTING FROM 1ST TO 2ND GEAR. DEALER REPROGRAMMED TRANSMISSION. AT 2319 MILES TOOK TO DEALER. TRANSMISSION SHUDDERS AT STEADY SPEED ON HIGHWAY OR GOING UP SLIGHT INCLINE. DEALER FLUSHED AND CHANGED TRANSMISSION FLUID TO REMEDY PROBLEM. CUSTOMER CHARGED $576. CAR WAS MANUFACTURED WITH INCORRECT TRANSMISSION FLUID FOR THE 8 SPEED AUTOMATIC TRANSMISSION APPLICATION. TEMPORARY COMPLAINT #CLN19-56809

WHEELS DEVELOPED CRACKS AND ARE SUBJECT TO BECOMING OUT OF ROUND.

HAVE HAD THIS VEHICLE FOR LESS THAN A YEAR. TOOK IT IN TO BE SERVICED AND TO GET NEW TIRES. UPON TAKING THE RIMS OFF, THE DEALERSHIP SHOWED ME THAT 3 OF MY RIMS HAD CRACKS IN THEM. ONE OF THE THREE RIMS HAD 3 CRACKS IN IT ALL THE WAY AROUND THAT COULD HAVE BROKEN AND FOLDED AT ANYTIME CAUSE A SERIOUS ACCIDENT OR EVEN DEATH. AFTER DOING RESEARCH THIS SEEMS TO BE AN EXTENSIVE PROBLEM FOR NUMEROUS CORVETTE OWNERS FROM 2015 TO PRESENT. WORST PART IS I'M ACTIVE DUTY MARINE CORPS AND USED MY DEPLOYMENT MONEY TO BUY THIS VEHICLE THAT IS NO LONGER RELIABLE OR SAFE, AND IS NOW JUST SITTING IN MY DRIVEWAY, UNDRIVEABLE AS THE RIMS CONTINUE TO CRACK AND ARE NOT SAFE.

TL* THE CONTACT OWNS A 2016 CHEVROLET CORVETTE EQUIPPED WITH MICHELIN TIRES, TIRE LINE: PILOT SPORT A/S 3PLUS, TIRE SIZE: 335/25/ZR20, DOT NUMBER 4M2R00VX3418. THE CONTACT STATED THAT THE REAR PASSENGER'S SIDE RIM WAS CRACKED IN TWO PLACES. ADDITIONALLY, THE REAR DRIVER'S SIDE RIM WAS BENT SINCE HE PURCHASED THE VEHICLE. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER AUTONATION CHEVROLET PEMBROKE PINES (8600 PINES BLVD, PEMBROKE PINES, FL 33024, (954) 644-5038) WHERE THE REAR PASSENGER'S SIDE RIM WAS REPLACED. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 2,070.*DT

2016 CHEVROLET CORVETTE Z06. CONSTITUENT STATED THAT THE VEHICLE WAS SOLD TO THEM WITH A LIEN FROM PREVIOUS OWNER. THEY ALSO STATED THAT THE VEHICLE HAS ENGINE ISSUES. *LD *JS

I WAS DRIVING DOWN I-20 AND MY TIRE WARNING LIGHT CAME ON FOR THE RIGHT REAR TIRE. I TOOK THE CAR TO DISCOUNT TIRE AND THE TECHNICIAN PULLED THE TIRE AND SAID THAT THE RIM WAS CRACKED AND SHOWED ME THE CRACK. I BELIEVE IF I HAD DISREGARDED THE TIRE WARNING AND JUST ADDED AIR I COULD HAVE HAD AN ACCIDENT IF THE RIM DISINTEGRATED WHILE DRIVING.

TL* THE CONTACT OWNS A 2016 CHEVROLET CORVETTE. THE CONTACT STATED THAT AIR WAS LEAKING FROM THE PASSENGER'S SIDE REAR WHEEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DISCOVER FOUR CRACKS ON THE INTERIOR SECTION OF THE WHEEL CAUSING THE AIR TO LEAK FROM THE TIRE. THE WHEEL WAS REPLACED HOWEVER, THE SAME FAILURE OCCURRED ON THE REAR DRIVER'S SIDE WHEEL. THE CAUSE OF THE FAILURES WERE NOT DETERMINED. THE LOCAL DEALER COUGHLIN CHEVROLET OF PATASKALA (900 EAST BROAD ST, PATASKALA, OH 43062) WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 12,000.

MULTIPLE STRESS CRACKS IN BOTH REAR WHEELS, NO DAMAGE OR INSULTS TO WHEEL! GENERAL MOTORS OR NASSANI BROTHERS CHEVROLET DEALERSHIP CULVER CITY, CA, WOULD ACKNOWLEDG THE PROBLEM. THIS WAS REPORTED TO THE DEALERSHIP AND GENERAL MOTORS NUMEROUS TIMES, WITH GM TELLING TO TAKE IT TO DEALERSHIP AND THE DEALERSHIP TELLING ME TO CONTACT GENERAL MOTORS, I CONTINUE TO HAVE PROBLEMS RESULTING IN BUYING 1 TIRE AND NEW WHEELS OUT OF POCKET.

BENT OR CRACKED WHEEL RIMS DESPITE LOW MILEAGE AND CAREFUL DRIVING. SOME HAVE COMPLAINED TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION, OTHERS TO THE BETTER BUSINESS BUREAU.

ON SEPTEMBER 20, 2020, I TOOK MY 2016 CORVETTE Z06 TO CLASSIC CHEVROLET IN SUGAR LAND, TEXAS BECASE I HAD A LEAK IN MY RIGHT REAR TIRE/WHEEL. I WAS TOLD LATER THAT DAY THAT I HAD A CRACKED WHEEL AND IT WOULD HAVE TO BE REPLACED AT A COST TO ME OF $900. I HAD NO CHOICE BUT TO REPLACE THE WHEEL. I HAVE NOT HIT ANYTHING THAT WOULD CAUSE THIS CRACK, AND FOUND THAT MANY PEOPLE WITH Z06'S HAVE HAD THE SAME PROBLEM; THAT IS, CRACKED WHEELS FOR NO APPARENT REASON. I QUESTIONED THE SERVICE TECHNICIAN ABOUT THIS COMPLAINT AS I HAVE READ ABOUT IT ON LINE. HE SAID GM KNOWS ABOUT THE PROBLEM BUT REFUSES TO DO ANYTHING ABOUT IT. THIS IS NOT ONLY POTENTIALLY DANGEROUS, BUT A HORRIBLE EXPENSE THAT SHOULD NOT BE BORNE BY Z06 OWNERS.

I WAS DRIVING AND I NOTICE A WHEEL IS LOW ON AIR. I GO TO A TIRE SHOP AND THEY TELL ME THAT THE WHEEL IS CRACKED AND NEEDS TO BE REPLACED. THIS HAS HAPPENED TWICE SO FAR. I DON'T REMEMBER HITTING A POT HOLE OR ANYTHING.

IT HAS A STRONG SMELL OF GAS AND IS LEAKING FROM THE TOP OF THE FUEL TANK. STRONG SMELL OF GAS WHEN PARKED IN GARAGE AND ALSO WHEN DRIVING AND STOPPED. THIS HAS BEEN HAPPENING FOR A WHILE BUT HAS GOTTEN WORSE.

ALL 4 RIMS WERE BENT WHEN I TOOK MY CHEVY CORVETTE IN FOR A TIRE CHANGE AT 15,000 MILES.

RIGHT REAR TIME CRACKED MULTIPLE TIMES AND SUPERCHARGER RATTLE AT LOWES SPEEDS

MY DRIVER'S SIDE REAR TIRE HAD A SLOW LEAK, AND I TOOK IT TO THE LOCAL TIRE SHOP FOR A QUICK REPAIR AND SIDE TO SIDE TIRE ROTATION. COME TO FIND OUT BOTH REAR WHEELS ARE CRACKED AND CANNOT BE REPAIRED. I SEARCHED THE GM CORVETTE OWNER'S FORUM, AND IT'S A COMMON PROBLEM. THIS ISN'T COVERED BY WARRANTY EITHER DESPITE THIS BEING THE SECOND SET OF WHEELS FOR MY VETTE. THE FIRST WERE BENT OUT OF ROUND. *TR

MY 2016 CHEVROLET CORVETTE Z06 CONVERTIBLE JUST PASSED 18000 MILES. I TOOK MY CAR INTO THE DEALERSHIP TO GET THE FAULTY BRAKE WEAR SENSORS REPLACED. I ALSO HAD A 4 WHEEL ALIGNMENT DONE AS THE INSIDE OF MY TIRES WERE WEARING. WHEN THEY GOT THE CAR UP THEY SHOWED ME CORDS ON MY RIGHT FRONT TIRE WERE SHOWING ON THE INSIDE WEAR AREA. SO I HAD TO REPLACE ALL 4 TIRES, DEALERSHIP SAID 18000 MILES FROM FACTORY TIRES WAS GREAT. I THINK THAT IS AN INDICATION OF HOW I DRIVE THE VEHICLE, MEANING I DON'T BEAT IT UP NOR TRACK IT. ON MY WAY HOME I NOTICED A VERY STRONG SHAKING/VIBRATION IN THE CAR. I TOOK THE CAR BACK AND THE DEALER SAID MY RIGHT FRONT RIM WAS DENTED. I'VE OWNED THE CAR SINCE 1825 MILES AND HAVE BEEN THE ONLY PERSON TO DRIVE IT. I HAVE NEVER HIT A POT HOLE OR ANYTHING TO CAUSE THIS. SO I WAS SHOCKED WHEN THEY SAID MY WHEEL WAS DENTED. THEY THEN SAID THAT THIS IS EXTREMELY COMMON ON THE C7 CORVETTE. THE DEALER SAID THEY'VE HAD CUSTOMERS THAT HAVE REPLACED 3-4 WHEELS. THEY RECOMMENDED BUYING AFTER MARKET FORGED WHEELS AS REPLACING THEM WITH NEW FACTORY WHEELS WON'T GUARANTEE THAT THEY WON'T BEND OR CRACK. A SET OF FORGED WHEELS RUNS $8000 OR BETTER FOR THE CAR. THIS IS A HUGE SAFETY ISSUE ON A VERY EXPENSIVE CAR THAT WAS DESIGNED TO RUN ON A RACE TRACK. THIS COULD EASILY CAUSE AN ACCIDENT IF THE WHEEL FAILS WHY DRIVING. ONLINE YOU CAN SEE THIS ISN'T JUST A MINOR PROBLEM, BUT ONE THAT SEEMS TO BE PLAGUING MAY OF THE C7 Z06 AND GRAND SPORT OWNERS. I'M NOT SURE ABOUT THE ZR1 OWNERS, MAYBE GM GOT THEIR WHEELS RIGHT. GM SHOULD BE REPLACING ALL Z06 AND GRAND SPORT OWNERS WHEELS AND NOT WITH THE CURRENT FACTORY WHEELS AS THEY ARE CLEARLY DEFECTIVE. ANYWAY I JUST WANTED TO POST MY COMPLAINT AS I THINK ITS IMPORTANT FOR YOUR AGENCY TO SEE HOW MANY PEOPLE ARE ACTUALLY AFFECTED. I'M SURE THERE ARE MANY THAT HAVEN'T THAT HAVE HAD THIS PROBLEM. *TR

Z06 MODEL, BLACK WHEELS WITH MACHINED GROOVE, 12K MILES,MARCH 2016 BUILD. HAIRLINE CRACK FOUND ON LEFT REAR WHEEL, ON THE INSIDE LIP. APPEARS IDENTICAL TO PROBLEMS REPORTED BY OTHERS HERE AND ON CORVETTE RELATED WEB SITES. FIRST NOTED AS SLOW LOSS OF AIR IN SEPTEMBER 2019. THE AIR LOSS WORSENED AND WAS BROUGHT IN FOR REPAIR IN JUNE 2020. THE LOCAL SHOP DISCOVERED THE CRACK AS THE CAUSE OF THE LEAK. THE WHEEL WAS FIXED (WELDED) AND IS BACK ON THE ROAD. I AM CONCERNED ABOUT THE RIMS SAFETY GIVEN THE (APPARENT) ORIGINAL MANUFACTURING DEFICIENCY, AND ALSO THAT ONE HAS NOW NEEDED TO BE WELDED. THE PROBLEM APPEARS TO HAVE HAPPENED ON ITS OWN. THERE ARE NO KNOWN CONTRIBUTING FACTORS SUCH AS ACCIDENTS, UNDERINFLATION, RACING, POTHOLES OR SUCH. *TR

I PURCHASED A USED 2016 CHEVY CORVETTE ZO6 & AFTER DRIVING IT LESS THAN 3,000 MILES HAVE HAD 4 DIFFERENT CRACKS IN THE WHEELS THAT NEEDED REPAIR. THIS ISSUE TOTALLY BLINDSIDED ME & HAD I KNOWN THE EXTENT OF IT, I WOULD NEVER HAVE PURCHASED THIS VEHICLE. I NOW DO NOT FEEL SAFE DRIVING IT & WILL BE ATTEMPTING TO TRADE IN OR SELL. IT IS MIND BOGGLING TO ME HOW THIS ISSUE HAS BEEN ALLOWED TO GO UNRESOLVED WITH NO OWNERSHIP FROM GM. TO SAY I AM VERY DISAPPOINTED WOULD BE A GROSS UNDERSTATEMENT. *TR

I WANT TO KNOW WHY THIS GAS LEAKING AT THE FUEL PUMP IS NOT A MANDATORY RECALL?HTTPS://WWW.CORVETTEACTIONCENTER.COM/TECH/KNOWLEDGEBASE/FILE.PHP?ID=143

WHEEL, MADE OF ALUMINUM, DEVELOPED A CRACK ON THE INSIDE OF THE RIGHT REAR TIRE, WITHOUT MY NOTICING ANY REASON. ONE DAY I JUST NOTICED THAT THERE WAS A SLOW LEAD IN THE RIGHT REAR. AMERICA'S TIRE WOULDN'T REPAIR THE LEAK AND SAID I HAD TO BUY NEW TIRES. I DID AND THE NEXT DAY THE RIGHT REAR WAS FLAT AGAIN. I TOOK IT BACK TO AMERICA'S TIRE AND THEY FOUND THE CRACK IN THE RIM. THE CAR HAD LESS THAN 26,500 MILES ON IT AT THE TIME. THE CHEVY DEALER TOOK PICTURES TO VERIFY FOR GM THAT THERE WERE NO SIGNS OF THE CAR BEING RACED OR ABUSED, BUT GM DECLINED TO REPLACE THE RIM SAYING IT WASN'T DEFECTIVE. THE CHEVY DEALER ULTIMATELY SOLD ME A NEW RIM ($1,000 ON MY CAR) AND CHARGED ME $50 EXTRA FOR A CORE CHARGE AS I WANTED TO KEEP THE CRACKED RIM SO I CAN SHOW ANYONE WHO WANTS TO SEE IT THAT THERE ISN'T ANY IMPACT MARKS ON THE MEDAL IN THE AREA OF THE CRACK, I.E., THE RIM JUST CRACKED. MY CAR IS A VERY EXPENSIVE LIMITED EDITION CAR WITH VERY BIG RIMS. I AM ATTACHING PICTURES OF THE CRACK, ONE WITH THE TIRE MOUNTED AND LEAKING AIR AND TWO WITH VIEWS OF THE CRACK ONCE THE TIRE WAS REMOVED.

MY 2016 CORVETTE WITH 13000 + MILES HAS BEEN IN THE SHOP WITH THE ' SERVICE REAR AXLE LIGHT ' ON DESPITE SEVERAL ATTEMPTS TO FIX IT. AFTER SEVERAL TRIPS TO THE SERVICE DEPARTMENT THEY HAVE BEEN UNSUCCESSFUL. THIS PAST WEEK, I WAS NOTIFIED BY (SERVICE SUPERVISOR) THAT THEY HAVE EXHAUSTED ALL EFFORTS IN THE ATTEMPT TO FIX MY CAR. I NOW HAVE TO WAIT FOR AN ENGINEER TO BE DISPATCHED PHYSICALLY TO LOOK INTO THIS ISSUE . ACCORDING TO SERVICE SUPERVISOR , THIS CAN TAKE SEVERAL WEEKS. I HAVE LOOKED AT THE INTERNET AND HAVE FOUND SEVERAL CORVETTE OWNERS HAVING/ EXPERIENCING THE SAME PROBLEM. IS GM LOOKING INTO THIS ? DOES GM KNOW WHAT THE PROBLEM IS SO THEY CAN SHARE IT HERE LOCALLY ? WHY CANT MY LOCAL DEALERSHIP FIX MY PROBLEM DESPITE WORKING WITH GM ENGINEERS? WHAT ARE MY OPTIONS? THIS LIGHT SEEMS TO COME ON ON FIRST STARTS OR AFTER BEING OFF FOR HOURS.

I NOTICED A VIBRATION THAT WOULD START AT ABOUT 55 MPH. I TOOK THE CAR IN TO AMERICA'S TIRE TO HAVE THE WHEELS BALANCED AND FOUND OUT THAT ALL FOUR WHEELS WERE BENT. THE CAR HAS NEVER BEEN RACED AND HAS BEEN DRIVEN IN A NORMAL MATTER. I HAVE HIT SOME MINOR POTHOLES BUT NOTHING OF ANY CONSEQUENCE.

HAD LOW TIRE ON 11/22/2018. WENT TO TIRE SHOP. FIXED THE FLAT ON RIGHT REAR WHEEL. THEY INFORMED ME THE WHEEL WAS BENT BUT WOULD HOLD AIR. TOOK TO THE DEALER. GM WOULD NOT REPAIR UNDER WARRANTY. I HAD TO PAY FOR REPAIR. THE CAR NEVER HIT A POTHOLE, CURB, OR ANY ROAD DEBRIS. IT APPARENTLY OCCURRED WHILE CAR WAS IN MOTION ON CITY STREETS.

AS HAS BEEN CITED BY MANY OWNERS OF THE 7TH GENERATION CORVETTE, I EXPERIENCED 2 BENT WHEELS IN FEBRUARY OF 2018 WHEN CAR WAS NOTICED TO HAVE HARSH VIBRATION WHILE DRIVING. IN OCTOBER 2019 TIRE PRESSURE WOULD NOT HOLD AND WHEEL WAS FOUND TO BE CRACKED. THIS CAR IS DRIVEN OCCASIONALLY AND IS NOT AUTOCROSSED OR DRIVEN ON A TRACK. CAR HAS ONLY 15,600 MILES.

2 RIGHT SIDE BENT RIMS PER GM DEALER. UNKNOWN WHAT CAUSE

SERVICE AIRBAG WARNING LIGHT STAYS ON.

AT 26000 MILES, LEFT REAR TIRE WAS LOSING AIR. NO DAMAGE OR ANY IMPACTS AT ALL. FOUND INNER LIP OF WHEEL HAD A HAIRLINE FRACTURE. VERY CONCERNED ABOUT THE MATERIALS OR PROCESS USED TO MANUFACTURE THE WHEELS.

OVER ABOUT 3000 MILES THIS IM ON MY SECOND CRACKED RIM. DEALER KEEPS TELLING ME I HIT A POTHOLE. DEFINITELY DID NOT HIT ANY THING. I BABY THE CAR. GM NEEDS TO BE RESPONSIBLE FOR THIS AT $1000/RIM NOT TO MENTION THE SAFETY IMPLICATIONS.

RIGHT REAR TIRE BEGAN LOOSING AIR. UPON INSPECTION, FOUND THAT THE INSIDE OF THE WHEEL HAD A CRACK. REPLACED ALL FOUR WHEELS AT MY OWN EXPENSE. THE VEHICLE COULD NOT HOLD AIR FOR MORE THAN A FEW HOURS.

CORVETTE CRACKED WHEEL: ONE OF MY WHEELS ON MY 2016 CORVETTE Z06 CRACKED FOR NO APPARENT REASON.

INSIDE RIGHT REAR WHEEL CRACKED, CAUSING AIR LEAKAGE FROM TIRE. CAUSE UNKNOWN, NOT AWARE OF ANY ROAD HAZARD OR POT HOLE INCIDENT. NOTICED CRACK AFTER WHEEL DUMP IN WATER BATH TO LOCATE SLOW LEAK. HAVE GM EXTENDED WARRANTY, DEALER WOULD NOT HONOR.

VEH PURCHASED 9/2015 AND SO FAR I HAVE REPLACE FOUR REAR RIMS AND ONE FRONT. ALL HAVE HAIR LINE CRACKS ON THE INSIDE OF RIM CAUSING RADICAL AIR LOSS, VIBRATION AND TIRE WEAR. NAVIGATION SCREEN FLICKERS AND GOES ON AND OFF AT LEAST TWO TIMES A WEEK AND I HAVE TO OPEN AND CLOSE TO RESTART SCREEN. BLOWER MOTOR WENT OUT AT 37K MILES AND THE TRANSMISSION IS BUCKING, VIBRATING, SHUDDERING AND GOING INTO 5TH GEAR AT 31MPH AND FEELS LIKE IT IS HANGING UP IN 5TH GEAR THE CLUNKS DOWN TO FIRST AT 10MPH. WENT TO DEALER, THEY CLAIMED THEY DID A SOFTWARE UP DATE AND THINGS ARE FINE. LEFT THE DEALERSHIP AND CAME BACK 5 MIN LATER WITH SAME ISSUE. TOOK SERVICE MANAGER FOR A RIDE AND HE CONFIRMED THE HORRIBLE RIDE. HAVE TO TAKE BACK ON TUESDAY 5/28 AND IT FEELS LIKE THE DRIVE SHAFT OR REAR END WILL FALL OUT. THEY SAID IT WAS FINE. I HOPE NOTHING HAPPENS TO ME OR THE CAR.

BOTH REAR WHEELS ON MY Z06 CRACKED ON THE INSIDE NO WARPING NO DINGS OR HITS HAPPENED TOOK TO DEALER TO REPLACE TIRES AND WAS SHOWED THAT BOTH WHEELS CRACKED AND NEED TO BE REPLACED TOO DANGEROUS TO USE HAVE PICTURES IN PHONE AND DEALERS REPORT AND I WILL HOLD ON TO THE WHEELS

RIGHT REAR WHEEL CRACKED. LESS THAN 17K MILES. GM SAYS NOT COVERED UNDER B2B WARRANTY. DISCOVERED WHEN TIRE LOSS AIR WHILE DRIVING. DID NOT HIT ANY POT HOLES WHEN EVENT OCCURRED/DISCOVERED. MODEL IS CORVETTE Z06, WHICH IS NOT A CHOICE ABOVE.

BENT WHEELS OR RIMS WITH CRACKS THAT HAVE TO BE REPLACED FOR SAFETY.

I OWN A 2016 CHEVROLET CORVETTE Z06. I NOTICED A WOBBLING SENSATION ON THE HIGHWAY ONLY TO FIND THAT MY REAR WHEELS ARE BENT AND CRACKED! THE CAR HAS LESS THAN 13K MILES ON IT AND IS NOW UNSAFE TO DRIVE UNLESS I SPEND THOUSANDS ON NEW WHEELS.

WHILE ATTEMPTING TO ACCELERATE OR DECELERATE MY CAR I FEEL A HESITATION, FOLLOWED BY A SIGNIFICANT SHUDDER WHEN THE VEHICLE'S AUTOMATIC TRANSMISSION CHANGES GEARS. THE SHUDDER, SHAKE AND HESITATION ALSO OCCURS WHILE MY VEHICLE ACCELERATES IN A SINGLE GEAR, AND NOT ACTIVELY SHIFTING GEARS. THE PROBLEM DOES NOT MERELY RESULT IN AN UNCOMFORTABLE DRIVING CONDITION. THE SHUDDERING AND HESITATION SEEM TO BE RELATED TO INTERNAL ISSUES WITHIN THE TRANSMISSION AND/OR TORQUE CONVERTER CAUSING FRICTION SURFACES, HYDRAULIC SYSTEMS, AND GEARS TO NOT FUNCTION PROPERLY. THERE IS POSSIBLY PERMANENT DAMAGE THAT WILL OCCUR TO THE TRANSMISSION AND/OR TORQUE CONVERTER OVER TIME. I FACE ESCALATING REPAIRS THAT CAN INCLUDE FLUSHING THE TRANSMISSION OF METAL SHAVINGS CAUSED BY THE DEFECTIVE TRANSMISSION OPERATION, AND WHICH EVENTUALLY NECESSITATE THE REPLACEMENT OF COMPONENTS SUCH AS THE TORQUE CONVERTER, VALVE BODY, OR THE ENTIRE TRANSMISSION. AS SUCH, THE TRANSMISSION DEFECT ENDANGERS THE DRIVERS AND PASSENGERS OF THE VEHICLES, AND DIMINISHES THE VALUE OF THE VEHICLES. GM'S DELIBERATE NON-DISCLOSURE OF THESE DEFECTS ARTIFICIALLY INFLATED THE PURCHASE AND LEASE PRICE FOR THESE VEHICLES. GM HAS KNOWN ABOUT THE TRANSMISSION DEFECT FOR YEARS, SINCE RIGHT AFTER INTRODUCTION OF THE TRANSMISSION. SINCE 2015, GM HAS ISSUED THIRTEEN VERSIONS OF A 'TECHNICAL SERVICE BULLETIN,' OR 'TSB,' RELATED TO THIS SHIFTING ISSUE ALONE. THE TSBS RELATED TO THE TRANSMISSION ISSUE HAVE ADVISED DEALERSHIPS TO, AMONG OTHER THINGS: COMPLETE THE 'CLUTCH DRIVE LEARN PROCEDURE,' REPLACE THE VALVE BODY, REPLACE THE ENTIRE TRANSMISSION, FLUSH THE COOLER LINES AND COOLER, REMOVE DEBRIS FROM AND CLEAN THE TRANSMISSION PAN, REPLACE THE TRANSMISSION FILTER, REPLACE THE TRANSMISSION FLUID, AND FLUSH THE TRANSMISSION. TO DATE, NONE OF GM RECOMMENDED SOLUTIONS HAS RESOLVED THE PROBLEM.

CORVETTE REAR WHEEL WAS LOSING AIR SO INSPECTED TIRES AND FOUND NO HOLES. WENT TO CORVETTE FORUM TO LEARN THIS IS A KNOWN PROBLEM ON Z06 AND GRAND SPORTS. SEEMS GM HAS A PROBLEM WITH CRACKING. MY CRACK IS EXACTLY WHAT THE FORUM MEMBERS HAVE. HAIRLINE CRACK IN THE RIM ON THE NON-HUB SIDE. THIS IS A SAFETY ISSUE AS THE RIM COULD COME APART AT SPEED AND CAUSE A SERIOUS ACCIDENT. I HAVE NO OTHER DAMAGE TO THE WHEEL AND HAVE NOT HAD ANY CURB DAMAGE. I BABY THIS CAR AND THE SAME CRACK THAT MANY OTHERS HAVE EXPERIENCED APPEAR.

FACTORY WHEELS CRACKED FROM NORMAL DRIVING ON THE INNER LIP, TIRE MECHANIC ADVISED HE'S SEEN MANY OF THESE ON THE Z06 WHEELS AND IT'S A KNOWN PROBLEM HOWEVER GM WON'T COVER THE DEFECTIVE WHEELS UNDER WARRANTY. THE CRACKED WHEEL CAUSES A SLOW LEAK END EVENTUALLY CAN BREAK IF GONE UNDETECTED RESULTING IN A LOSS OF CONTROL OF THE VEHICLE.

ON OR ABOUT SEPTEMBER 11, 2018 I NOTICED MY RIGHT FRONT TIRE WAS LOW ON AIR. I TOOK IT TO LES SCHWAB TIRE AND THEY REPAIRED A LEAK FROM A SCREW. A COUPLE OF DAYS LATER I NOTICED THE TIRE WAS STILL GOING LOW I TOOK IT BACK AND THEY INFORMED ME THAT IT HAD A CRACKED WHEEL. I PURCHASED A NEW WHEEL FROM CHEVROLET AND HAD LESS SCHWAB INSTALL IT FOR ME . I JUST RECENTLY 2/22/2019 PUT NEW TIRES ON THE CAR AND THE DEALERSHIP NOTED THE BRAND NEW WHEEL I PUT ON THE RIGHT REAR HAS CRACKS IN IT NOW AS WELL AS THE LEFT REAR WHEEL WHICH IS LOSING AIR. THESE WHEELS ARE EXPENSIVE I BELIEVE THEY RETAIL FOR $800 EACH AT THE DEALER AND ARE DEFECTIVE AND DANGEROUS. MOST OF OUR MILES ARE HIGHWAY MILES DRIVING BETWEEN SAN JOSE CALIFORNIA AND ELK GROVE CALIFORNIA BETWEEN MY OFFICES.

WE HAVE HAD TO REPAIR THEN REPLACE 2 REAR CRACKED RIMS IN THE 1.5 YEARS WE HAVE OWNED THIS VEHICLE. THE FIRST ONE WAS 3 MONTHS AFTER PURCHASING IT AND THE SECOND ONE WAS IN JANUARY 2019. AFTER NOTICING BOTH TIMES THAT FIRST THE LEFT TIRE WAS LOSING AIR A HAIRLINE CRACK WAS NOTICED ON THE INSIDE OF THE RIM. WE HAD IT REPAIRED AND IT DID NOT LAST SO FOR SAFETY REASONS WE NEEDED TO REPLACE IT. THE SAME THING HAPPENED WITH THE RIGHT SIDE IN LATE 2018. IT WAS AGAIN SUGGESTED WE REPAIR IT, THEN AGAIN THE REPAIR DID NOT HOLD AND WE NEEDED TO REPLACE.

FRONT LEFT AND REAR LEFT WHEELS CAUSING VIBRATION IN VEHICLE AT SPEEDS OVER 40 MPH. VEHICLE HAD LESS THAN 3000 MILES ON ODOMETER AND WHEELS WERE NOT DAMAGED BY STRIKING ANYTHING. VIBRATION BECOMES MORE PRONOUNCED AS SPEED INCREASES. DEALER CONFIRMED BOTH WHEELS OUT OF MANUFACTURERS SPEC.

CRACKED WHEEL AFTER DRIVING OVER SMALL POTHOLE ON THE INTERSTATE CAUSING CRACK IN RIM AND SLOW LOSS OF TIRE AIR PRESSURE. CRACK IN REAR WHEEL INBOARD FLANGE, WHEEL WAS NOT BENT OR WARPED.

I HAD A SLOW LEAK IN A REAR TIRE ON A Z06 WHEEL. THE TIRE SHOP FIXED THE LEAK AND INFORMED ME THE WHEEL WAS BENT. THE CAR WAS BOUGHT NEW AND HAS ONLY 2000 MILES ON THE ODO. I CANNOT RECALL HITTING A LARGE POTHOLE OR RUNNING OVER ANYTHING

FOUR REAR WHEELS HAVE CRACKED LEAKING AIR AND HAVE NO EXTERNAL DAMAGE FROM ROAD HAZARDS. TWO WERE REPLACED UNDER THE NEW CAR WARRANTY AND TWO WERE REPLACED UNDER GM'S PURCHASED EXTENDED WARRANTY. THE FIRST ONE, RIGHT REAR, CRACKED ON 11/19/16 WITH 18,843 MILES ON THE CAR. THE SECOND ONE,LEFT REAR, CRACKED ON 8/23/17 WITH 24,332 MILES ON THE CAR. THE THIRD ONE,LEFT REAR, CRACKED ON 8/14/18 WITH 34,854 MILES ON THE CAR. THE FOURTH ONE, RIGHT REAR, CRACKED ON 10/17/18 WITH 39,501 MILES ON THE CAR. CALLING THE GM HOT LINE I WAS TOLD TO CONTACT MY GM SERVICE DEPARTMENT IN REGARDS TO THIS ISSUE. THEY TOLD ME THE THE WHEEL WAS DESIGNED TO CRACK TO PROTECT THE REAR SUSPENSION !!! THIS IS A HUGE SAFETY ISSUE. WHAT WOULD HAPPEN IF THAT CRACK LEAD TO A WHEEL FAILURE AT SPEED? I HAVE ALL MY GM SERVICE STATEMENTS TO BACK THESE FACTS UP. GM NEEDS TO CORRECT THE PROBLEM!

AUTOMATIC LOCKING FUEL DOOR MADE HEAVY WHIRRING NOISES. FUEL DOOR/CAP IS LOCKED AND NO REFUELING IS POSSIBLE. VEHICLE IS PARKED. NO DRIVING PROBLEM UNTIL FUEL IS EXHAUSTED THEN A USELESS VEHICLE.

TL* THE CONTACT OWNS A 2016 CHEVROLET CORVETTE. THE CONTACT STATED THAT THERE WAS A FAILURE CONCERNING THE REAR OEM FACTORY RIMS. THE CONTACT STATED THAT THE METAL WAS NOT STRUCTURALLY SOUND AND THERE WERE CRACKS IN THE REAR PASSENGER SIDE WHEEL. THE FAILURE LED TO LOW TIRE PRESSURE. THE DEALER (GEORGE MATICK CHEVROLET, 14001 TELEGRAPH RD, REDFORD CHARTER TWP, MI 48239, (313) 531-7100) REPLACED THE OEM FACTORY RIM. THE DEALER ALSO MENTIONED THAT THEY RECEIVED SEVERAL COMPLAINTS FOR THE SAME MODEL, BUT VARIOUS YEARS, CONCERNING THE OEM REAR RIMS CRACKING AND THE LOW TIRE PRESSURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE. *TT *TR

KNOWN ISSUES WITH A SUB STANDARD TORGUE COVERTER CAUSING A SHUDDER AND JERKY MOTION THE CAR STARTS DEMONSTRATING ACCOMPANIED BY FLUCTUATING ENGINE RPMS. THIS CORVETTE IS EQUIPPED WITH A 8I90 8 SPEED AUTOMATIC TRANSMISSION. ITS ESPECIALLY NOTICEABLE WHEN CRUISING AT HIGHWAY SPEED WITH THE CRUISE CONTROL ENGAGED, HOWEVER IT DISPLAYS THIS PROBLEM WHETHER THE CRUISE CONTROL IS ENGAGED OR NOT. THIS ISSUE SEEMS TO HAVE AFFECTED ABOUT 20,000 CORVETTES UNTIL ABOUT THE END OF OCTOBER 2016 PRODUCTION DATES. INTERNET RESEARCH SHOWS THA THIS IS A WIDE SPREAD PROBLEM AND THERE SHOULD BE A RECALL ON THESE VEHICLES THAT REQUIRES GM TO REPLACES THE TRANSMISSION AND TORQUE CONVERTER

CRACKED REAR WHEEL. I PURCHASED THE CAR USED AND THIS WAS DISCOVERED DURING AN INSPECTION.

TL* THE CONTACT OWNS A 2016 CHEVROLET CORVETTE. WHILE DRIVING APPROXIMATELY 45 MPH, THE STEERING WHEEL LOST POWER AND THE "POWER STEERING NEEDS SERVICE" MESSAGE ILLUMINATED. THE CONTACT CALLED AND SCHEDULED AN APPOINTMENT FOR DIAGNOSTIC TESTING WITH GRABIAK CHEVROLET (8282 US-22, NEW ALEXANDRIA, PA 15670, 724-668-2231). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND PROVIDED A CASE NUMBER. THE FAILURE MILEAGE WAS APPROXIMATELY 900. *TT

BOTH REAR WHEELS DEVELOPED CRACKS APPROXIMATELY TWO INCHES LONG FROM THE INSIDE EDGE TOWARD THE MIDDLE OF THE WHEEL. THE CRACKS IN BOTH WHEELS WERE SIMILAR IN SIZE AND LOCATION. MILEAGE WHEN NOTICED WAS 24,000. NUMEROUS REPORTS OF THE SAME ISSUE ARE BEING REPORTED ON CORVETTE RELATED WEB SITES.

RECEIVED A LETTER WITH THE FOLLOWING FROM GM. "THIS LETTER IS INTENDED TO MAKE YOU AWARE THAT SOME 2016 MODEL YEAR CHEVROLET CORVETTE VEHICLES MAY HAVE A CONDITION WHERE CRACKS ON THE TOP SURFACE OF THE LEFT FUEL TANK PUMP MODULE FLANGE, MAY CAUSE FUEL ODOR, OR A LOSS OF FUEL ON THE GROUND. A CHECK ENGINE LIGHT MAY ILLUMINATE IF THE FUEL TANK IS LESS THAN HALF FULL." GM RECALL 17469 . TO ME DUE TO POSSIBLE SAFETY ISSUES THIS SHOULD BE A MANDATORY RECALL. PLEASE ASSIST.

CAR OVERHEATING WHEN USED IN HIGH PERFORMANCE DRIVING, ALARM SOUNDS AND GOES INTO LIMP MODE. HAPPENS WITHIN 10 MILES OF 30 RAPID ACCELERATIONS.

THIS ISSUE IS VERY SERIOUS. FUEL LEAKS OUT THE TOP OF THE TANKS, AND WILL THEN DRIP DOWN THE BACK SIDE. IT HAPPENS WHETHER RUNNING OR NOT.

I PURCHASED AN OPTIONAL CHROME WHEEL UPGRADE WHICH WAS DELIVERED WITH NEW VEHICLE. RIGHT REAR WHEEL CRACKED AND LOST AIR PRESSURE AFTER 4,000 MILES, LEFT REAR WHEEL CRACKED AND LOST AIR PRESSURE AFTER 6,800 MILES.

TL* THE CONTACT OWNS A 2016 CHEVROLET CORVETTE. WHILE DRIVING 50 MPH, THE CLUTCH FAILED WITHOUT WARNING AND TRAVELED TO THE FLOORBOARD. THE PEDAL FAILED TO RISE BACK IN POSITION. THE VEHICLE WAS TAKEN TO NORFOLK GM AUTO CENTER (1123 S 20TH ST, NORFOLK, NE 68701) WHERE IT WAS DIAGNOSED THAT THE MASTER CYLINDER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE AND OPENED CASE NUMBER: 8-3631978340. NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 9,000.

GAS LEAK WHEN THE TANK IS FILLED.

TL* THE CONTACT OWNED A 2016 CHEVROLET CORVETTE. WHILE DRIVING 25 MPH, THE VEHICLE WAS INVOLVED IN A CRASH. THE CONTACT REAR ENDED ANOTHER VEHICLE THAT ABRUPTLY PULLED OUT IN FRONT OF THEM. THE DRIVER'S AIR BAG DEPLOYED. A POLICE REPORT WAS FILED. THE CONTACT WAS KNOCKED UNCONSCIOUS BY THE AIR BAG. THE CONTACT SUSTAINED DAMAGE TO THE LEFT EYE, WHICH REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS TOWED AND DESTROYED. A DEALER WAS NOT MADE AWARE OF THE CRASH. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS APPROXIMATELY 6,000. THE VIN WAS NOT AVAILABLE. *TT UPDATED 8/21/18*JB

MY 2016 CORVETTE STARTED HAVING HIGH FREQUENCY VIBRATIONS IN STEERING WHEEL AND INTERIOR PANELS WITH UNDER 7900 MILES OF SERVICE. I COMPLAINED TO THE DEALERSHIP SERVICE DEPARTMENT ABOUT THE PROBLEM AND FOUND FRONT WHEELS TO BE BENT AND COULD NOT BALANCE THE WHEELS PROPERLY. THE DEALERSHIP ADVISED ME TO TAKE MY CORVETTE TO ANOTHER DEALERSHIP THAT HAD BETTER EQUIPMENT THAN THEM. THE SECOND DEALERSHIP INSPECTED MY CORVETTE AND INFORMED ME THAT ALL FOUR WHEELS ARE BENT AND CANNOT BALANCE THEM PROPERLY. NEITHER DEALERSHIP WILL REPLACE THE WHEELS UNDER WARRANTY. THUS FAR, GM AS WELL, WILL NOT REPLACE WHEELS UNDER WARRANTY. I ATTEST THAT I HAVE NOT DRIVEN MY CORVETTE ABNORMALLY NOR HAVE HIT OBSTRUCTIONS OR POT HOLES. I HAVE NEVER DRIVEN MY CORVETTE ON ROUGH, GRAVEL OR DIRT ROADS. I DO BELIEVE THIS IS A VERY SERIOUS SAFETY PROBLEM THAT CHEVROLET AND GM SHOULD ADDRESS BEFORE SOMEONE HAS A TERRIBLE ACCIDENT BECAUSE OF THESE WHEELS!

BAD SMELL OF GAS IN GARARGE WHEN CAR IS PARKED IN THERE.

2ND GAS LEAK TO 2016 Z51 CORVETTE WITH 1800 MILES. DEALER REPLACE GAS TANK BECAUSE OF A GAS LEAK. THE ODOMETER REGISTERED ABOUT 1300 MILES. ABOUT 500 MILES LATER (1,800 MILES ON THE ODOMETER) THE CAR ONCE AGAIN EXPERIENCED A GAS LEAK AT THE TANK. THIS IS A DANGEROUS SITUATION SINCE THE GAS COULD LEAK UPON THE HOT TAILPIPE OR MUFFLER. REPLACING THE GAS TANK IS A MAJOR ENDEAVOR REQUIRING THE COMPLETE DISASSEMBLE OF THE REAR DRIVETRAIN.

SINCE 2014 C7 MODELS OF CORVETTE HAVE TORQUE TUBE FAILURES. ITS A COUPLING AT THE END OF THE DRIVESHAFT ATTACHING TO THE DIFFERENTIAL. CHEVY TRIED A FIX IN MODEL 2015 THAT FAILED. IT CONTINUES TO FAIL AND THERE ARE NO PARTS AVAILABLE TO DO THE REPAIR. MY 2016 JUST FAILED BUT THERE ARE CARS THAT FAIL MULTIPLE TIMES SINCE THE PART HAVE NOT BEEN REDESIGNED. PART FAILURE RESULTS IN DAMAGE TO THE DIFFERENTIAL, DRIVE SHAFT AND TRANSMISSION. REPAIR EXCEEDS $6000 AND CHEVY WILL NOT REPAIR IF OUT OF WARRANTY. PLEASE SEE GOOGLE AND OTHER CORVETTE FORUM COMPLAINTS. THIS IS ONGOING WITH NO RESOLUTION

WHILE OPERATING VEHICLE LOSES THE ABILITY TO ACCELERATE, WHICH HAS RESULTED IN 3 NEAR MISS COLLISIONS, (ONE HEAD ON INCIDENT AND TWO SIDE IMPACT COLLISIONS.) THE SIDE IMPACT NEAR MISS COLLISIONS WERE AFTER MAKING AN ATTEMPT AT A LEFT TURN WHERE THERE WAS PLENTY OF TIME INITIALLY TO COMPLETE THE MANEUVER, THE CAR COMPLETELY LOSES THE ABILITY TO ACCELERATE AND IS DEAD IN ITS TRACKS ON THE ROAD. THE HEAD ON NEAR MISS COLLISION OCCURRED DURING AN ATTEMPT TO PASS ANOTHER VEHICLE. AS THE CAR ACCELERATED IN THE PASSING ZONE, AND PULLED NEXT TO THE VEHICLE BEING PASSED, THE ABILITY TO ACCELERATE WAS LOST AND THANKFULLY THE OTHER DRIVER WAS ABLE TO AVOID THE COLLISION PRIOR TO THE ABILITY TO ACCELERATE RESUMING. WHEN THE ABILITY TO ACCELERATE VOIDS, PUSHING THE GAS PEDAL HAS NO IMPACT ON ACCELERATION. THESE 3 OCCURRENCES WERE THE MOST PRONOUNCED AND POTENTIALLY FATAL, HOWEVER, THERE HAVE BEEN A MYRIAD OF INSTANCES WHERE THE ABILITY TO ACCELERATE HAS STOPPED MOMENTARILY. I AM ALSO CONCERNED WITH THE OVERWHELMING CHEMICAL ODOR (PLASTIC SMELL) EMANATING THROUGHOUT THE CAR. AFTER A YEAR OF OWNERSHIP, AND LEAVING WINDOWS OPEN WHILE STORED, IT PERSISTS TO THE POINT THAT IT REMAINS OVERWHELMING WITH THE WINDOWS UP AND TOP ON. DUE TO FEARS FOR MY SAFETY AND WELLBEING I HAVE BEEN UNABLE TO TAKE PLEASURE IN THE VEHICLE I PURCHASED EXCLUSIVELY FOR ENJOYMENT.

TL* THE CONTACT OWNS A 2016 CHEVROLET CORVETTE. THE CONTACT STATED THAT THERE WAS LEAKAGE OF AIR ON THE FRONT PASSENGER SIDE. AFTER OPENING THE CONVERTIBLE TOP, THE FRONT DRIVER SIDE HAD A LEAKAGE OF AIR. THE VEHICLE WAS TAKEN TO THE DEALER MORE THAN FOUR TIMES, BUT THE VEHICLE COULD NOT BE REPAIRED. THE MANUFACTURER WAS NOTIFIED SEVERAL TIMES AND PROVIDED NO SOLUTION. THE APPROXIMATE FAILURE MILEAGE WAS 3,000. UPDATED 01/06/2017*CT CONSUMER STATED AIR LEAK FROM CONVERTIBLE TOP/WINDOWS OR DOORS. UPDATED 7/13/18*JB *TR

STRONG FUEL LEAK SMELL WHEN PARKED IN THE GARAGE

GAS SMELL AFTER FILLING TANK

I BOUGHT THE CAR ON 9/8/16. I SMELLED GAS AS IT SAT IDLING AT DEALERSHIP ( RICK HENDRICKS OF BUFORD GA. ) AND THOUGHT IT WAS JUST FUMES. I GOT HOME AND PARKED IT, 1/2 TANK. I DID NOT SMELL GAS THEN. I LEFT FOR WEEK LONG TRIP AND RETURNED ON 9/15/16. I FILLED THE CAR TO DRIVE AND WENT TO A MEETING THAT NIGHT. A FRIEND WAS CHECKING HIS CAR AFTER I PARKED NEXT TO HIM SAYING HE SMELLED GAS. I TOLD HIM I HAD AFTER I FILLED MINE. I HAS A PUDDLE UNDER ME CAR AS LARGE AS A SEMI TRUCK TIRE. THE NEXT DAY I TOOK IT TO GLENN SMITH CHEV IN OPELIKA AL. THEY STILL HAVE CAR AND HAVE ORDERED THE LEFT SIDE TANK TO REPLACE. CAR HAS AROUND 335 MILES ON IT. I AM WAITING TO GET MY CAR BACK.

THE REAR TAIL LIGHT BEZELS ON MY 2016 CHEVROLET CORVETTE STINGRAY ARE NOT BOLTED DOWN, THEY SNAP IN/OUT. THIS IS A PROBLEM BECAUSE SOMEONE STOLE MINE AND I'M SURE THEY WERE ALSO WANTING TO GET THE TAIL LIGHTS. ANYWAY, THE REAR TAIL LIGHT BEZELS ARE NOT BOLTED DOWN, THEY SNAP IN/OUT. SOMEONE CAN EASILY STEAL MY TAIL LIGHTS AFTER THE BEZELS ARE REMOVED MAKING MY CAR UNSAFE FOR TRAVEL. I HAVE A POLICE REPORT OF THE INCIDENT. THE VEHICLE WAS PARKED AT MY HOME UNDER A CAR PORT. THERE ARE LOTS OF ONLINE VIDEOS ON YOUTUBE THAT TEACH ANYONE HOW TO REMOVE THESE BEZELS WITH JUST A SMALL TOOL TO GRAB ONTO THE BEZEL.

FUEL LEAK IN THE AREA OF THE FUEL TANKS

SECOND 2016 CORVETTE, FIRST ONE GM TOOK BACK. NOW SECOND CORVETTE WITH SAME ISSUE. GAS LEAKING FROM UNDER CAR!