1FMCU9GN4PUA345312023 FORD EscapeActive

My 2023 Ford Escape is equipped with a factory-installed rearview backup camera system and SYNC infotainment system. Beginning on or around February 2026. I began experiencing a series of recurring, intermittent, and worsening failures with the rearview camera and the Accessory Protocol Interface Module (APIM) that controls it. These failures render the backup camera system unreliable or completely non-functional during vehicle operation. Specific Symptoms Observed •BLUE / BLANK SCREEN: When the vehicle is placed in reverse, the rearview camera display shows a solid blue screen or goes completely blank rather than displaying the rear camera image. This failure occurs with no warning and leaves me unable to see what is behind the vehicle while backing up. •INVERTED / UPSIDE-DOWN IMAGE: The rearview camera image displays upside-down and/or mirrored, rendering the image confusing and unsafe. Guidelines, directional aids, and proximity warnings displayed on screen are also inverted, making them unusable. •DISTORTED / CORRUPTED IMAGE: The camera feed displays visual distortion, artifacts, freezing, flickering, or corruption that makes it impossible to accurately interpret what is behind the vehicle. •APIM FAILURE: The Accessory Protocol Interface Module (APIM) — the core software module controlling the SYNC 3 display and camera feed — has failed or malfunctioned. Dealership diagnosis has identified the APIM as requiring repair or replacement. This module failure is the root cause of the camera display issues described above. The failures occur intermittently and unpredictably. The camera may function correctly for a period, then fail on the next use. In some cases, the failure is persistent across multiple ignition cycles. There is no consistent triggering condition — the defect occurs in varied weather conditions, temperatures, and after varying periods of use. Turning the vehicle off and back on sometimes temporarily restores the camera, but the defect returns.

2023 Ford Escape with approximately 80,000 miles. While traveling home, vehicle started shifting violently making loud bang. Lost acceleration while traveling on a two-way roadway with no shoulder. Vehicle would shift violently and allow acceleration momentarily and then would again lose acceleration. Just prior to reaching a pull off area in a safe place, the vehicle shifted violently one last time and would no longer accelerate. The service engine now warning light then came on advising of a powertrain malfunction. Vehicle was towed to Ford dealership and the technition reported that the planetary gears were locked up and a full transmission replacement would need to be done. This posed a serious safety issue on the road way due to the initial sudden speed changes becuase of the loss of acceleration and then the complete loss of ability to accelerate causing the vehilce to have to drift slowely to the shoulder while impeding traffic.

Stopped at a Light and took off thru the intersection and car made a loud bang noise then no power and kept bogging out, pulled into parking lot and stopped then car wouldn’t move. Shut car off then restarted it and put into reverse and car drive forward, put in neutral and car still drove forward, couldn’t get it to go into reverse, now the motor is tilting back to fire wall like motor mounts are broke and it’s make a grinding noise when idling.

[Recurring No-Start Issue with Multiple Warning Alerts – Safety Concern] I am reporting a recurring vehicle issue involving failure to start, which I believe may pose a safety risk. The issue has occurred five times: August 11, 2023 April 12, 2025 June 13, 2025 December 12, 2025 April 1, 2026 During these incidents, the vehicle failed to start and displayed multiple warning messages on the dashboard. On some occasions, the vehicle only started after several hours. The vehicle becomes completely inoperable when this issue occurs. After the third occurrence, I brought the vehicle to an authorized service center. However, the issue was not resolved and has continued to occur. This repeated failure raises serious concerns about vehicle reliability and safety, as the vehicle may become inoperable without warning. I have attached documentation, including repair records and photos of the dashboard warnings. I am submitting this report so that this issue can be properly investigated.

1.engine failed and my infotainment system turned off 2.i feel like I was scared because I didnt know if I was going to come back on 3. No 4. No

The contact owns a 2023 Ford Escape. The contact stated that while driving at an undisclosed speed, the message "Battery Issue, Pull Over" displayed, and the battery, check engine, and master warning lights illuminated. The contact pulled over and contacted the dealer, who instructed him to turn off and restart the vehicle. After following the dealer's instructions, the failure was resolved. The contact later received notification of NHTSA Campaign Number: 26V091000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the recall but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 28,000.

While pulling into a residential parking space at low speed, the vehicle (2023 Ford Escape) suddenly accelerated unexpectedly without additional throttle input. The acceleration was abrupt and forceful, and I was unable to stop the vehicle before it struck the structure in front of the parking space. The incident occurred at very low speed and under normal driving conditions. The driver was applying the brake at the time of the unintended acceleration. Airbags deployed upon impact. There were no prior warning lights or indications of a mechanical issue before the incident. The vehicle sustained significant front-end damage.

The contact owns a 2023 Ford Escape. The contact stated that while attempting to start the vehicle, the radio displayed a blank screen. A dealer was contacted. No warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic to be diagnosed. The contact stated that the failure had occurred on several occasions. The manufacturer was not notified of the failure. The approximate failure mileage was 34,756.

The left rear liftgate hinge cover flew off in the car wash during the drying cycle. The same thing has happened to my 2020 Escape and that vehicle is covered under a recall but this 2023 Escape is not. I feel it should be because it has the same issue for the same part.

The contact owns a 2023 Ford Escape. The contact received notification of NHTSA Campaign Number: 25V789000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

I am reporting a recurring safety issue involving sudden loss of power while driving in my 2023 Ford Escape. The vehicle has experienced multiple incidents where, while accelerating or pulling into traffic, it suddenly loses power, hesitates, or fails to respond to the accelerator. In some cases, the RPM drops unexpectedly, and the vehicle will not move or respond for several seconds. After this delay, the vehicle may jerk or surge forward suddenly. This creates a dangerous situation, especially when entering busy roads or intersections, as it puts me at risk of being struck by oncoming traffic. This issue has occurred multiple times and has been brought to the dealership on several occasions. The vehicle has undergone multiple repair attempts, including major engine-related repairs such as cylinder head and cooling system work, as well as a fuel system component replacement. Despite these efforts, the problem persists. On multiple visits, the dealership has stated they were unable to duplicate the issue, even though the condition continues to occur during normal driving. The vehicle has been out of service for an extended number of days due to these ongoing issues. This defect is intermittent but poses a serious safety hazard due to the unpredictable loss of power and delayed acceleration. I am concerned about the risk of an accident or injury if this issue is not properly identified and corrected. I am requesting that this issue be investigated, as it appears to be a recurring defect that may affect other vehicles of the same make and model

Vehicles coolant emptied out causing vehicle to overheat and smoke from under engine.

Reporting Long term safety defect and manufacturer behavior. There was no single incident. This is an ongoing safety defect related to multiple battery recalls that now limit my vehicle to 80% charging (in the past, no plug in charging), now going on nearly three years. My Ford Escape PHEV has been subject to limited charging due to these multiple recalls, and I am concerned Ford may close the recall with a software‑only fix that cannot truly validate battery safety, especially if modeled on limited and not real world charging. I have complied with all of Ford's requests which came at my expense and caused increased fuel usage and a diminished efficiency of my car. Now I need assurance that when a "fix" is determined that it will indeed be a permanent fix that is safe at 100% charge. This is a potentially crucial safety issue and thermal consequences with my grand daughters sitting above the battery is of the greatest concern.

My vehicle has stalled several times in the last couple of months. I go to accelerate and the vehicle suddenly stops out of no where. This has almost caused me to get into an accident. I see there have been several recalls on ford escapes and this issue should be looked into for my 2023 escape.

My 2023 Ford Escape acts like it is about to stall out once I hit the gas from a stop. It has happened multiple times. After idling for 10 minutes when I go to take off it will shift so hard that it pushes you forward in your seat. It has not been taken to a dealership yet since no light comes on and it doesn’t happen all the time. It has put my safety at risk since I was turning on the highway and it took 10-15 seconds to get up to speed.

The engine shut off and immediately turned on

Symptoms appeared in January 2026. Check engine light is on-HAD P0301 & P0316. Ran misfire monitor & Relative compression and cylinder 1 is the issue with 70 PSI. Performed cylinder head leak down test- exhaust valve leaking replace cylinder head assembly. Problem confirmed and diagnosed by Ford dealership. The safety issue associated with the car are: sudden jerking or hesitation, loss of acceleration when merging or crossing traffic, unpredictable throttle response, sudden loss of power. Symptoms appeared in September 2025. In October 2025, the car required a turbo repair, which cost a total of $1,600. The safety issue associated with the car are: air-fuel balance, engine misfires, complete stall, loss of power. This was diagnosed by certified repair show. Similar recalls have been made to other Ford Escape cars and I believe my VIN number should be included.

I have had many issues with this vehicle. Most concerning is that the other night while driving down the road at night, my car blacked out and I had no lights inside or headlights outside while driving in the dark. My back hatch button only works when it wants to. My screen freezes every once in awhile and also makes horrible noises very frequently. I’ve had one case of my screen freezing on a longer drive with my seat warmer on and the seats getting too hot and burning me. My safety features shut off all the time. My cruise control wouldn’t work at all on a 4 hour drive last month. When I get my oil changed they tell me under my hood is way louder than it should be for a vehicle this old. The dealership did a factory reset hoping it would help but I’ve already had issues with the hatch door not working appropriately, the sound coming from my screen, and notifications that my safety features have been shut off.

My ford escape has an ongoing safety issue where the instrument cluster shuts off while driving and the dealership has not been able to fix it.

I drive a 2023 Ford escape active, 8F35 transmission, with 111,114 miles on it. I purchased my car in July 2025 from truauto of Ladson SC with 93,000 miles on it. Had a transmission complete failure in December 2025 (5 months after buying). Ford dealership in Valdosta Georgia (where I lived) was no help in trying to get it fixed and it sat on there lot for a months or so, because it was undriveable. I got it towed back to SC to get it fixed by a local transmission shop and it is being halted due to a current planetary lawsuit with these cars for parts. I have now been without a car for 2-3 months and have forked over $6,000+ to get this car fixed. I was not told about any known transmission issues when I bought this car (verbally or written) from Truauto, nor was I contacted about any recall from Ford and I was denied a Remanufactured transmission at the dealership that I went to to get the car fixed. I am out of warranty but that still doesn’t explain a transmission failure in a close to brand new car regardless of miles. I have already paid the $5400 or so for the repair at the local shop and it has yet to be fixed due to lack of availability of parts.

The contact owns a 2023 Ford Escape. The contact stated that on several occasions, while stopped, while the accelerator was depressed, the vehicle hesitated while accelerating. The contact was almost rear-ended several times when the failure occurred. The contact stated that whenever the vehicle idled for longer than five minutes, the vehicle also hesitated while accelerating. The vehicle was taken to a dealer; however, the failure could not be duplicated. The manufacturer was not notified of the failure. The failure mileage was approximately 3,000.

The transmission failed at 70,000 miles. The research the transmission shop did indicated the main bearing fails in these because they are made of cheap metal. The transmission just stopped pulling with little warning. It started with a jerking and then quit pulling. Within a few feet. There was not any slipping of the transmission before hand.

Purchased brand new 11/2023, immediately started with electrical problems 01/2024, also would put car in reverse and car would cut off, was dropped off at service but never given a reason for the issue or a repair. 01/2025 car had acceleration issues, dropped off at service and was given a rental and given car back with no explanation. 6/2025 car went into limp mode and was towed to service where they found shards of metal throughout motor, replaced motor and then started having problems with cab filling with exhaust, was told they had no rental available and could continue to drive the car with my baby in it, then told was just a gasket needed to be replaced, car had same issue immediately, returned back to service where the turbo then needed to be replaced as well as catalytic converter gasket, after repair, called numerous times complaining that car would shift very hard and wouldn’t accelerate while driving or pulling out on an intersection or from a stop light, was told valve body needed to be replaced, then check engine light came on immediately after pickup, returned car and purge valve needed to be replaced, after pickup issue of car not accelerating continued, was told no issue found, car acceleration issues has became worse and now have been told soonest available appointment and rental is 02/12/2026.

Rearview Camera Has turned dark....

i found the brake pedal too high.i was involved in a very low speed crash. i found my right foot caught between the accelerator and break peddle .unable to stop in time. am checking for a video and police report at this time

I was driving on a very flat highway (no other cars around me) and it sounded like an explosion and glass rained down the back of the car. When I get to my destination, I looked at my roof and the sun roof glass had exploded.

The contact owned a 2023 Ford Escape. The contact stated that the infotainment center would display a black screen, and while doing so, the radio would continue to play. The contact stated that while driving at different speeds, the trunk would suddenly open, causing the contact to have to pull over and close the trunk in order to continue to drive. The failure occurred 3 times while the vehicle was parked at home. There would be a burning odor emitting from the vehicle intermittently; however, there would be no smoke or indication of where the smell was coming from. While parked at home and unoccupied, the rear window suddenly shattered, and the vehicle caught on fire. The fire department was called and extinguished the fire. The fire department and the insurance company had determined the vehicle would be totaled; however, an official determination had not been provided. A police report was filed. The dealer was informed of the failure. There were no injuries or medical attention needed. There was no damage done to the property. The manufacturer was informed of the failure. The failure mileage was approximately 37,000.

HI, Vehicle is under a second recall for the High Voltage Battery potential fire hazard. The first recall lasted 7 months before a potential fix. The second recall was issued in November with no fix available yet. Received second recall identical to first recall indicating a fire risk with no apparent fix. I have requested Ford buyback the vehicle, but it fell outside the 18 month NYS Lemon Law. They have refused. They have no fix and will not provide a loaner until it is fixed. The original vehicle electric range was between 38 and 40 with a window sticker range of 37. It is now down to around a range of 20 on full charge with an actual driveable of about 16. I have asked both Ford and delivering dealership to replace the High Voltage Battery pack as it has seriously deteriorated. Ford refuses to allow dealer to replace the Battery Pack. The vehicle is basically unusable for it's original intended purpose as a partial electric vehicle. I asked Ford, what am I supposed to do if I am transporting my two grandchildren in the vehicle and it starts on fire. How do I choose which child to get first? No response. These vehicles should be removed from use by Ford and loaner vehicles provided or a full buy back should take place. I only have 11,000 miles on this vehicle and it has been in the shop for more than 30 days for various warranty repairs and multiple recalls. These vehicles are not safe. See pictures attached for factual information from vehicle. I have plenty of detail if you need it. Please help. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Accessory protocol interface module went out screen went dark. No recall on my vin but should be. Problem appeared 12/26/2025 and has been inspected by Peach State Ford.

The transmission had an internal failure that caused metal fragments to end up in the transmission fluid and caused failure. The vehicle will not drive and required the transmission to be rebuilt

My 2023 Ford Escape Plug-In Hybrid has experienced repeated high-voltage battery safety issues and prolonged loss of intended function. In February 2025, Ford notified me under recall 24S79 that I must immediately stop charging the vehicle due to the risk of internal battery cell short, potential battery thermal venting, and fire. That “do not charge” instruction lasted approximately six months, eliminating the core plug-in hybrid functionality of the vehicle. Ford originally stated the remedy would be available in Q2 2025, but the repair was not completed until late August 2025. The recall documentation stated that an internal battery cell short could cause the “Stop Safely Now” warning and sudden loss of motive power, which presents a serious safety risk while driving, especially when transporting my family. During the “do not charge” period the vehicle’s plug-in hybrid capability was unusable, and Ford acknowledged the risk of fire and loss of power. In November 2025, I received a new high-voltage battery recall 25SC4 (NHTSA 25V789) for the same general hazard category (internal short, potential fire, loss of motive power). The new recall states that no remedy is available at this time. This means the vehicle is again subject to a serious unresolved safety defect involving the same critical system. The repeated battery failures and the absence of a current fix create an ongoing safety concern, and the vehicle cannot be reliably used or sold during this open recall with no remedy. I am requesting NHTSA review the repeated HV battery defects, extended loss of plug-in hybrid functionality, delayed first recall remedy, and the current “no remedy available” condition, and assess whether further investigation or corrective action is needed for these vehicles.

Purchased the vehicle approximately 45 days ago. Has driven fine with no problems. Randomly had a hard down shift and when I went to leave my destination put the vehicle in reverse and it would not go. The vehicle would not move in drive and when put in neutral it was still not even able to be pushed. Had it towed to the nearest ford dealership, they diagnosed that there were metal shavings in the transmission, stated the vehicle was no longer drive able and recommend a transmission replacement or rebuild. Vehicle only has 80,000 miles.

The contact owns a 2023 Ford Escape. The contact stated that the 12-Volt battery had become inoperable. The contact stated that the vehicle lost motive power while attempting to start the vehicle. There was no warning light illuminated. The contact had to charge the battery several times to start the vehicle. The vehicle was taken to the dealer, but was not diagnosed or repaired. The contact was informed that the issue was battery-related and was advised to drive the vehicle differently and to obtain a trickle charger for the battery. The manufacturer was not made aware of the failure. The approximate failure mileage was 8,000.

During braking the car experienced what seemed to be a glitch and lost all breaking power. Foot went to the floor and had to press and release multiple times for break power assist to come back. This happened three times within 100 mile drive.

my 2023 ford edge caused burns to the back of my legs. i was unaware until my grandma informed me that something was wrong with my legs. i noticed when i got the car 2 months ago level 3 of the seat warmer was way to hot like i felt it burning. so i only used on setting 1 or 2 and did not feel the burning sensation like when used on 3 but somehow my legs are burned

Sunroof molding roof drip rail. Ford part #LJ6Z5450036A. This part is held on with double stick tape. When it comes loose, it can interfere with the proper operation of the sunroof sunshade or fall into the passenger compartment. Mine has been replaced several times under warranty. Even though it was nearly detached, it did not fall. However, if it had, it has the potential of either damaging the sunshade or creating a driver distraction while driving.

Campaign 23B56 Description Inspect front door check-arm reinforcement spot welds Next Steps Contact your dealer for next steps. ---------------------------------------------------------------------------------------------------------------- Recall Action Soon Issue Since 03-14-2025 Drivers side seat buckle replacement For More Information Telematics Generated Issue Recall Action Soon Issue Since 11-08-2024 Inspect front door check-arm reinforcement spot welds For More Information

Recall Action Soon Issue Since 03-14-2025 Drivers side seat buckle replacement For More Information Telematics Generated Issue Recall Action Soon Issue Since 11-08-2024 Inspect front door check-arm reinforcement spot welds For More Information

The contact owns a 2023 Ford Escape. The contact stated while driving at various speeds with the Adaptive Cruise Control Mode engaged, the vehicle failed to respond as needed after another vehicle pulled in front of the vehicle. The contact stated that the vehicle jerked and decelerated, and then revved up and accelerated unintendedly until the vehicle was within proximity of the other vehicle. Additionally, the contact stated that the Lane Keep Assist failed to keep the vehicle within the intended lane while driving, and the vehicle veered to the left unintendedly while the Lane Keep Assist was engaged. The vehicle was taken to the dealer to be diagnosed, but the cause of the failure could not be determined. Additionally, the dealer informed the contact that the vehicle was previously repaired under NHTSA Campaign Number: 24V440000 (Forward Collision Avoidance), which the contact related to the failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 98,000.

For the last 2 weeks After accelerating my engine coolant overheat warning light goes off and i can't accelerate any further until light goes off. Also ford mechanic states there is metal shavings in the coolant that might be causing engine to overheat on top of the sensor issue.

The contact owns a 2023 Ford Escape. The contact stated that while her husband was driving at an undisclosed speed, the vehicle experienced a loss of automotive power, and the steering wheel became difficult to turn in either direction. The contact stated that the messages "Electrical Power Saver Active" and "Service Charging System Warning" were displayed on the instrument panel. In addition, the contact's husband stated that the vehicle failed to come to a complete stop as intended, and the brake pedal felt firm while being depressed. The vehicle was towed to a local dealer and remained for further investigation. The manufacturer was not made aware of the failure. The failure mileage was approximately 35,338.

Sunshade retracted all the way and center roof molding holding it was with double stick tape. Rolled all the back and cannot get it to go back.

The contact owns a 2023 Ford Escape. The contact state while reversing, the back over prevention camera failed to function as intended. The contact stated that the back over prevention camera failed to display images of pedestrians or vehicles. The contact stated that due to the failure, the contact almost struck a pedestrian. The vehicle was taken to the dealer; however, the failure was not duplicated. The vehicle was then taken to another dealer where a software update was performed. The manufacturer was made aware of the failure. The contact was offered a buyback. The failure mileage was approximately 55,000.

12v battery system failure to keep 12v battery that boots operating system of car charged. This leads to a vehicle that cannot be started or moved unless jump started. This has happened daily, and sometimes multiple times a day, requiring a jump pack to get the car to turn on. This issue has been reproduced and confirmed via multiple revised manufacturer TSBs. This has likely been inspected by the ford dealership that sold the used vehicle to me. Multiple safety warnings appear when the vehicle determines the 12v battery is not sufficiently charged.

The contact owns a 2023 Ford Escape. The contact stated while driving 60 MPH, the Adaptive Cruise Control altered the speed after detecting the number on the Minnesota county road sign ending in the number 5. The Adaptive Cruise Control was changed without warning. The vehicle gradually accelerated after the failure. While driving at slow speeds, the speeds spontaneously increased from 30 MPH to 50 MPH. There were no warning lights illuminated. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was contacted, who referred the contact to the NHTSA Hotline. The failure mileage was approximately 19,280.

The contact owns a 2023 Ford Escape. The contact received notification of NHTSA Campaign Number: 24V954000 (Electrical System); however, the part to do the recall repair was unavailable. The dealer was contacted. The dealer confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and informed the contact that a second notice would be mailed whenever parts were available. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2023 Ford Escape. The contact stated while the vehicle was parked, the check engine warning light illuminated. The contact took the vehicle to the dealer where the vehicle was diagnosed, and it was determined that rodents had damaged the coil wiring. The vehicle was repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 23,106.

The contact owns a 2023 Ford Escape. The contact stated while driving at various speeds and depressing the accelerator pedal, the vehicle failed to respond as needed. The contact stated that the RPM was not increasing on the gauge on the instrument cluster. There was no warning illuminated. The contact stated that the failure was intermittent but became a recurring failure. Additionally, the contact reported several electrical failures. The contact stated that the instrument cluster was blank, and the windows failed to respond while attempting to raise or lower the windows. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the transmission software needed to be re-flashed, and the 12-Volt battery needed to be replaced. The vehicle was repaired. The contact stated that the failure reoccurred, and the vehicle was taken back to the same dealer. The dealer replaced the 12-Volt battery; however, the failure recurred. The manufacturer was informed of the failure. The failure mileage was approximately 15,500.

The contact owns a 2023 Ford Escape. The contact stated that while driving approximately 30 MPH, the transmission overheated warning light illuminated. The contact stated that the vehicle went into LIMP Mode. The contact stopped and had the vehicle towed to the dealer. The dealer diagnosed the vehicle but could not duplicate the failure. The vehicle was not repaired. The contact stated that the failure reoccurred, and the vehicle was taken to another dealer who also was not able to duplicate the failure. The vehicle was not repaired. The contact stated that the transmission failed and was unable to shift into reverse(R) or park(P). The contact had the vehicle towed to an independent mechanic. The vehicle was diagnosed, and it was determined that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 150,000.

The contact owns a 2023 Ford Escape. The contact stated that while driving at various speeds, the transmission unexpectedly downshifted. There was no warning light illuminated. The dealer was notified of the failure, and the contact was instructed to bring the vehicle in for a diagnostic test. The vehicle was not diagnosed or repaired. The manufacturer had not been notified of the failure. The failure mileage was approximately 41,000.

Summary of Issues: 1. March 2024 – First Incident: •Warning lights appeared on the dashboard while driving (including ABS and power steering). •Vehicle was taken to Camelback Ford. •Dealership diagnosed a software update failure due to low voltage. •Battery was recharged, software updated, and codes cleared. ⸻ 2. April 6, 2024 – Battery Replacement: •Vehicle continued to experience electrical issues. •Battery was replaced by dealership under warranty. ⸻ 3. June 11, 2024 – Second Incident: •Dashboard warning lights returned. •Dealership again cleared codes, no new repair or replacement performed. •Explanation given was “modern cars have more computers” and that these issues were “normal.” ⸻ 4. July 12, 2024 – Third Incident: •While stopped at a red light, the entire dashboard shut off and restarted on its own. •Engine remained on, but the sudden blackout raised serious safety and reliability concerns. •Vehicle was not moved after the incident. •Dealership advised to return only if issue happens again. ⸻ Ongoing Concern: This vehicle has experienced repeated electrical system failures including instrument cluster blackout and communication errors, despite warranty repairs and a new battery. These intermittent issues pose a potential safety risk, especially if they occur while driving. The lack of a consistent fix raises concerns about the vehicle’s electrical integrity and reliability.

I purchased a Ford Escape 2023 in Green Bay, Wisconsin on [XXX] from Dorsch Ford Dealership. On October 7, 2023 I tried to start my vehicle and the battery was drained/dead. This continued through January of 2024, and I received a new battery. I thought the problem was fixed. Not so, and it has continued throughout the past two years. My vehicle will go into Deep Sleep Mode at different times of the day. I have to drive it to regenerate the battery. At times I do not even have lights when I start the Ford Escape. I have taken it to a Ford Dealership in Appleton. I am suppose to go again on March 25, 2025 and it will be my tenth time. The service person stated why should I even come because they can not find the problem. There is a parasitic draw and it needs to be found, or the battery is not operating properly, and needs to be replaced. I am a school teacher, and I thought I was buying a safe and reliable car. This is not the case. I have over 100 pages of documentation. I have filed complaints with Ford and with the State of Wisconsin Lemon Law to no avail. Also, I am close to warranty and then I will have to pay out of pocket. The Ford Motor Company is violating the consumer laws and not following their obligation to make repairs on my car. This is similar to the Bronco/Maverick battery issue. Something more electrical is happening under the hood. The service people I have dealt with even stated that I don't drive the car regularly. I have to now get up at 4am to get the battery charged. I can not access the added features such as remote start. I paid for something I didn't receive! Plus, what happens when I am driving and the vehicle decides to have a major malfunction? This is wrong on all levels. Please look into this matter immediately. I have had one recall concerning the door locks which were repaired last summer. I am worried and nervous to continue driving the Ford Escape 2023 because of its battery. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2023 Ford Escape. The contact stated while driving 40 MPH, the "Blind Spot Detection System Fault" message was displayed. The contact stated that several unknown warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the trailer tow wiring harness (Part Number: LX6Z-15A416-B). The contact was informed that the wiring harness was damaged by the heat shield. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The approximate failure mileage was 9,000.

The contact owns a 2023 Ford Escape. The contact stated while the vehicle was parked, the contact attempted to close the front driver’s side door; however, the door failed to close securely. No warning light was illuminated. The vehicle was taken back to the residence. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 30,000.

The contact owns a 2023 Ford Escape. The contact stated that the front driver's door window would not completely roll up and close. The vehicle was taken to the local dealer who replaced the front driver's side door window motor, and the vehicle was repaired but failure reoccurred. Additionally, while operating the vehicle, the message "Front Collision Camera Inoperable" was displayed. The vehicle was taken to the local dealer, but failure code could not be retrieved, and the cause of the failure was not yet determined. The manufacturer was notified of the failures, but no assistance was offered. The failure mileage was 13,000.

While driving on an interstate, the Instrument cluster / digital gauge cluster screen behind my steering wheel turned off. I was driving with my adaptive cruise control on when all of a sudden I see the screen go black and I was no longer able to see how fast the car was going, the engine temperature, or how much fuel I had, as well as all of the other metrics on that dashboard. The car never lost power, because the entertainment screen in the middle of my dash remained on and responsive during the short period of time that my instrument cluster screen was off, and I never lost power steering. Instinctively, I pressed on the break pedal and pulled off of the road onto the shoulder, so I’m not sure if the cruise control would have stayed on. After a few minutes on the shoulder, the instrument cluster screen turned back on, not quite like it does when you turn on the car, but it flashed a bunch of the warning lights and slowly came back to normal. I was able to drive my car safely and without another incident back home, however I am very concerned about this happening again. There were no warning lights, signals, or sounds before this happened. Driving on any road, weather it’s a highway or an interstate, it is very important to be able to see how fast you are traveling for the safety of yourself, your children, and the other drivers. There is a popular recall among this same vehicle type, however mine was not included in the previous recall even though it just repeated the same problem the other ford escapes were having. My local dealership is not taking this problem seriously, and I am very concerned.

The contact owns a 2023 Ford Escape. The contact stated that while driving at undisclosed speeds, the back-over prevention camera screen went to a blue screen. The contact stated that while driving, the camera turned on and the image was shown. The camera was unavailable, and a message to contact the dealer was displayed. The vehicle was taken to the local dealer, where it was diagnosed and determined that the camera needed to be reset and the software updated. The vehicle was test-driven. The vehicle was repaired, but the failure recurred. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 10,668.

The contact owns a 2023 Ford Escape. The contact stated that upon starting the vehicle, the center console display remained off. The contact was able to continue driving the vehicle however, the center console and the display was independently turning on and off. No warning lights were illuminated. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 8,000.

The contact owns a 2023 Ford Escape. The contact stated while driving at various speeds, there was an abnormal sound coming from the engine and the front driver’s side tire. In addition, the instrument panel was occasionally turned off independently. Additionally, during rainy weather driving the brakes were making abnormal sounds. The contact stated that several unknown warning lights were occasionally illuminated. The vehicle was taken to a local dealer on several occasions and was diagnosed; however, the failure could not be replicated. The vehicle was taken to another local dealer, Mullinax Ford of Kissimmee (1810 E Irlo Bronson Memorial Hwy, Kissimmee, FL 34744); for a second opinion; however, the failure could not be replicated. The vehicle was also taken to a third local dealer, Tropical Ford (9900 S Orange Blossom Trl, Orlando, FL 32837); but the cause of the failure could not be determined. The vehicle was taken to a local independent mechanic where it was diagnosed and determined that an unknown material might have intruded into the engine. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 5,000.

The contact owns a 2023 Ford Escape. The contact stated while driving 70 MPH, the vehicle suddenly decelerated after the engine overheated and shifted into "LIMP Mode". The contact stated that during the failure, the message "Engine Overheated" was displayed. The vehicle was taken to the local dealer who diagnosed that the engine was faulty and needed to be replaced. No further information was available. The vehicle was not yet repaired. The manufacturer was not contacted regarding the failure. The failure mileage was 4,200.

At any random time, all sensors fail. Blind spot systems, parking sensors, pre-collision assist, front camera fault, cross traffic system, cruise control, lane assist, auto headlights. Returned to the dealership multiple times, with no resolution. All sensors continue to fail, with no immediate fix available, according to Ford, until the fourth quarter. So, I am left with an unrepairable vehicle to drive in the already dangerous central Texas traffic. The problem has been confirmed at Leif Johnson Ford, 501 E. Koenig, Austin, Tx 78751. Main #512-454-3711, Service #512-454-3767, and reported to Ford Care at 800-392-3673

I was driving home to Aspen, CO from Denver. I was about 44 miles from my home, on the other side of an 11,000 ft mountain pass. As I was passing another vehicle, the car died. The dashboard light said "engine coolant over temperature". The car died as I was pulling back into the right lane. The person behind me swerved around me. I had to have the car towed to a dealer that is 2 1/2 hours from my home. It's been sitting at the Ford Dealership in Salida, CO for 9 days. They keep telling me they will get it in to diagnose the problem but every day it's the same story and they do nothing. After doing online research, that make, model and year vehicle engine issue has been reported by many owners. There was no warning about this issue. It simply died while driving on the highway.

I've had this thing less than 6 months, I've already had the engine rebuilt with 34 parts a month and a half in and the drivers side rear door handle replaced during this time because it would not open from the outside and only the inside despite being unlocked. All of this occurred at the beginning of May 2024 and it sat for 3 months due to the engine being basically rebuilt with most parts being on backorder. Today the same door is having the same issue, only this time the same exact door won't open neither from the inside or outside, which is a huge safety hazard in my eyes if I got into an accident and had passengers in the backseat. I do have video proof of this too.

The contact owns a 2023 Ford Escape. The contact stated on several occasions while driving, or while the vehicle was parked, all four doors locked inadvertently with the keys inside the vehicle. The contact stated the hatch failed to lock securely and there was no other way to get into the vehicle. The emergency brake light had illuminated. In addition, the contact stated that the cruise control was inoperable. The vehicle was taken to a local dealer where it was diagnosed but the vehicle could not be repaired on several occasions. The contact stated that a systems update was performed; however, the failure reoccurred. The manufacturer was made aware of the failure. The failure mileage was approximately 4,000.

a 2023 Ford Escape. while driving at approximately 76 MPH, I observed a warning chime dinging, the power train warning light illuminated, and the low engine coolant message was displayed. I received a notification via the Ford Pass APP stating that "There was a failure with the vehicle and to see the dealer'. I contacted the dealer, and they stated they did not see any warnings. Anytime I exceeded a certain rate of speed it still does this. The first time it happened, it had less than 800 miles on it.

HAD A CHECK ENGINE LIGHT COME ON 2 WEEKS AGO. TOOK IT TO THE DEALER AND THEY REPROGRAMMED THE PCM AND INSPECTED CYLINDER BORES. DEALER ALSO CHANGED THE OIL AT THAT TIME. SHORTLY AFTER THAT THE LIGHT CAME ON AGAIN, TOOK IT BACK TO THE DEALER THEY'VE HAD SINCE LAST FRIDAY AND NOW REPORT THE VEHICLE MAY NEED A REPLACEMENT ENGINE BLOCK. VEHICLE HAS 10,565 MILES AND IS JUST 13 MONTHS OLD. I HAVE RESEARCHED AND FOUND MANY OTHER SIMILAR INSTANCES ON THE INTERNET.

The contact owns a 2023 Ford Escape. The contact stated while driving at approximately 50 MPH, he observed a warning chime dinging, the power train warning light illuminated, and the 'low engine coolant' message was displayed. The vehicle was taken to the residence. The contact's wife received a notification via the Ford Pass APP stating that “There was a failure with the vehicle and to see the dealer”. The vehicle was taken to a dealer where it was diagnosed that the engine and head gasket needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 3,900.

Quite often, the display screen for the back up camera does not turn on at all. It will also go blank during use at times.

See attached document for complaint

Upon reaching 60 mph my vehicle displayed overheating messages and cut power to the motor. Vehicle was towed into Ford service on 4/4/24 and remains in the shop. Been told it needs a new top end of the motor with no eta on parts. I was approximately one mile from my home when the incident occurred.

The contact rented a 2023 Ford Escape. The contact stated that while driving at about 20 MPH and driving over a railroad track, the hood of the vehicle opened abruptly and struck the windshield. The contact lost visibility and went through an intersection before coming to a complete stop. The contact made the rental company aware and was informed that they could not diagnose the issue. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was unknown.

The car warned of overheating and messaged to service immediately...

Within a block of my wife pulling out of our apartment complex onto a 55mph highway to travel to work in the morning, the vehicle had several lights on the cluster illuminate and indicated that it was overheating and went into limp mode. She was able to move to the shoulder and call me. The amount of traffic on this highway and the speed in which she lost power made this a very unsafe event. The check engine light had come on and the vehicle indicated maximum engine temperature, service engine soon light illuminated as well as powertrain fault. The vehicle was towed to the selling Ford Dealer and the condition was confirmed and the vehicle still indicated high temp even after sitting overnight. It was diagnosed from a service bulletin as having a faulty head that had manufacturing debris in it which was released into the coolant system and blocked the coolant temperature sensor. Warranty covered parts have been ordered with some being on Backorder. The vehicle is still in the shop awaiting parts and we have been provided a loaner. We have only owned the vehicle three months and 1500 miles when this occurred. Ford declined a buyback request on the vehicle and offered no remedy except warranty repair.

See attached document for complaint

The contact owns a 2023 Ford Escape. The contact stated while driving with the cruise control set to 45 MPH, the vehicle unintendedly accelerated to 65 MPH. No warning lights were illuminated. The vehicle was not taken to the dealer and was not diagnosed or repaired. The manufacturer was made aware of the issue and referred the contact to the NHTSA Hotline. The failure mileage was unknown.

On 1/29/24, I drove around town to run errands and on my second stop, I tried starting the car and it would not start, but it went into "accessory mode". I received SEVERAL warnings: Pedestrian Sounder, Memory Recall Failure, Front Collision Sensors, Tractions Control, Check Engine Light, etc. It also stated it would sound an alarm if we tried turning it on again. I sat there for 10 mins and tried turning it on after getting in and out of the car, looking underneath to see if oil or gas was leaking, which nothing was leaking. I kept trying to start the vehicle with no success, still getting the warnings. My spouse arrived after 15 mins and when she opened the hood and wiggled some cables around, we were able to start the car up and it was like it went through a factory reset as the memory for the driver seat went really close to the steering wheel. We called roadside assistance thinking we need to get this towed to a dealership but cancelled it after seeing it would start and my spouse driving it around the grocery parking lot carefully. When we got it to the dealership, it wasn't having those issues and they couldn't do much for it. On 2/10/24, the check engine light came on. We took it to the dealership on 2/12/24 and they told us the PCM malfunctioned. They did a software update on the PCM, which the dealership said has fixed the problem for now. Just worried this is going to happen again and will happen when I'm in a place where maybe my spouse can't come or we are traveling long distance. Prior to this incident, the dash (MPH, Gas level, Oil level, Engine Temp) of the vehicle, which is entirely digital, flickers like there is a short in the wiring somewhere. It doesn't happen every time we drive it, just sometimes (maybe 35% of the time). This was happening shortly after purchasing the vehicle in July 2023. I have a feeling that something relating to the electrical components, battery, chip/software/firmware in the Ford Escape needs to be replaced entirely.

Engine does not start or crank. It is available for inspection upon request. Pregnant wife and child were left stranded in the cold until I could pick them up. Problem has occurred on three separate occasions: 6/29/23 - No DTCs generated, Ford dealership did not do any work 9/22/23 - No DTCs again, but Ford dealership replaced a module and cleared other codes 1/29/24 - No DTCs. Dealership cleared other codes and informed of Ford SSM 52179 2023 Escape/Corsair - Intermittent No Crank/No Start Condition With Various Lost Communication DTCs Stored In Various Modules And Multiple Illuminated Warning Indicators Displayed In The IPC - Built On Or Before 07-Sep-2023. Dealership explained other customers have had complaints and Ford has no solution and is telling dealerships to return the vehicles to customers. Vehicle has not been inspected by any other party, including manufacturer, other than the dealership. There are messages for "Service AdvanceTrac" and "Park brake limited function, Service required" in the instrument panel each of the three occurrences.

Unknown

The navigation icon located on the instrument panel is a mirror image of the actual direction icon for roundabouts. If you are to take a right tune from a roundabout the indicator on the instrument panel shows you turning into oncoming traffic and taking a left. It appears to be a mirror image of the icon on the navigation screen. If not paying attention this could be VERY dangerous.

The contact owns a 2023 Ford Escape. The contact stated that while her husband was driving at 55 MPH he smelled a burning odor. The vehicle was pulled into a parking lot where the hood was lifted and the odor emanated strongly from the engine compartment. Additionally, he noticed sparking, and then flames erupted. The vehicle was towed to an unknown repair center. The fire department distinguished the fire. A police report was not filed. The manufacturer was not notified of the failure. The failure mileage was approximately 7,400.

New 2023 Ford Escape purchased Dec 15, 2023. While accelerating onto expressway- get an error flashing "Engine Coolant Over temperature - service vehicle soon"

After reviewing my owner’s manual on my newly purchased vehicle, I was shocked at how quickly and unexpectedly I was propelled from 75mph to 105mph because of a new-to-me feature on this model. I was surprised and moreover shocked that a system like this is mass-produced and sold worldwide. Seems like the manufacturer should provide proper training materials and not just the dealer telling me to Youtube it. I fear for my life every time I get behind the wheel. If someone unassumingly were to drive this vehicle without becoming accustomed to they ways it operates, I fear of what horrible accidents may result. I wish I could give the car back but the dealership won’t do anything for me. So I felt it necessary to make this report. Hopefully the features on this particular model of a major vehicle manufacturing brand are re-examined. Something just doesn’t seem right with this specific sub-model.

Shortly after purchasing this, my daughter was driving it and the check engine light came on and it said it was overheating. The dealer was contacted and it was taken in for repairs. We got it back and was told that it was a broken wire in the wiring harness and they ordered a new harness but had fixed the wire so it should be good to go. 2 weeks later it did the same thing and actually went into limp mode. This time they said it was the sensor in the cylinder head and they ordered a replacement. Fast forward 3 1/2 months and it's still at the dealers. They are now telling us the cylinder needs to be replaced and the parts are on backorder. While we have been waiting they gave us a 2023 Bronco Sport with the same 1.5 liter 3 cylinder and that hasn't given any issues. When the loaner hit 5000 miles we had to return it to the dealer for a different vehicle. They gave us a 2023 Escape with the same 1.5 liter 3 cylinder and only 800 miles in it. The 2nd day my daughter drove it, it did the same thing as the one she originally purchased did. We have now been told by the service department that they have several doing the same thing and they are replacing the heads on each one when they get them. Our Escape is now on the Lemon Law Buyback and the dealer won't even give us the time of day. The dealer told my daughter she needed to stop the Lemon Law Buyback process and then they would talk to her about trading it in for a different vehicle. The issue is, she is upside down on the loan and the only way she can finish the Lemon Law buyback is to come up with close to $5000 to get out from under the vehicle and the dealer says there is no way that they can/will roll that into a different loan. Upon looking at the Forums many of these vehicles are having the same issue. Ford really needs to step up and take care of this ASAP. It isn't safe being stranded along the road.

3 times, either merging on the highway or full throttle, vehicle screams overheat warning with wrench light for a couple of seconds and disappears. No limp mode or smoke at all. And coolant level is at MAX. No clue is this some sort of glitch or engine failure? Vehicles drives amazing and power is great. Maybe it’s a software glitch?

Vehicle has a 1.5L dragon 3 cylinder. When passing vehicles, on 3 occasions it throws codes that says that the engine has an engine overheated issue, service asap, and goes into a limp mode which does not give you any time to get to safety before your speed is dropped below 55 mph. It will not go out of limp mode until you completely shut off the vehicle and wait 5 or so minutes and turn it back on. Even after it stays in a limp mode capacity and does not easily get back up to highway speeds. The certified dealership service department has had my brand new vehicle 7 weeks with no resolution. Car was bought with 16 miles on the odometer, on August 25th, 2023, at 650 ish miles on September 6th it happened the 1st time. The 2nd time was on September 14th, 3rd time September 15th, 4th time was, September 29th. 3 times on a 4 lane highway, 1st time on a 2 lane country highway.

As I was driving home with about 5 minutes to go, in my brand new (2 week old)2023 Ford Escape, I smelled something burning. I pulled over and saw smoke so I turned off the car and got out. As I got out of the car I looked under and saw fire. I got away from the car and as I did, the fire kept growing and growing from under the hood. The fire went high enough to hit the trees on the side of the roasd. The police and fire department came and were able to put out the fire but not before the car was distroyed. There were no warning lights or any other symtoms of a problem prior to smelling burning. The Ford company has not responded to me from the day my wife spoke to a representative on Monday, October 2nd. The car fire was on Saturday, September 30th. It's been 3 days. My insurance company was going to do an inspection. Ford wants nothing to do with us. We have a police report and a fire report. This clearly was a engine or electrical problem with this car. I was lucy this happened on a small street and not on the highway where pulling over would have been difficult. Lucky I could smell it so I knew to stop. Lucky I didn't have one or both of my toddler grandchildren in the back seat in their car seats! I would never have been able to get them out in time!

engine light came on took it into dealership. they said it was evap system then fixed it. picked car up in a wednesday by the friday, light came on again. took back into dealership, they didn’t detect any leaks.. said they were going to put in a canister purge solenoid. found out about 23S27.. apparently my vehicle vin doesn’t fall under that recall.. but yet my vehicle has all the signs.

After the vehicle sits idle for about two contiguous days and you open the driver's door, there are not lights on inside or outside. Normally when you open the driver's door, the center dash and console light up as well as the ambient lighting in various areas of the interior. There is no mention of the 'battery deep sleep' anywhere in the online user manual for a non electric vehicle (ICE). Entering a dark interior in the middle of the night creates the potential for a slip and fall accident. Not to mention contact with kees and the dash or the door opening and the side of the head when trying to get situated behind the steering wheel.

At approximately 1,000 miles on 2 separate occasions while traveling on the interstate, roughly 10 minutes apart, an audible chime and visual alert within the speedometer cluster appeared “engine coolant over temperature” for approximately 10 seconds. The temperature gauge within the cluster indicated normal, midway within the span of the gauge. The following day prior to starting the vehicle, a cold start essentially, the coolant level was “full”. I ran a “check engine” check with no stored codes in temporary or permanent storage. My 2023 Ford Escape has the 1.5L EcoBoost engine. When the warnings appeared, there was no reduction in engine power(limp mode) and no signs of steam while looking in the rear view mirror.