1FM5K8AB6MGA200652021 FORD ExplorerPolice

While I drive my vehicle down the road the car all of a sudden sounds like you throw it in park, it screeches and grinds in the front and will not let you push the gas pedal down even when on the highway. This causes sever risk to the people around me as well as my children who drive in this car… ford has an open recall for this which my vehicle falls under year and build wise. But does not correlate with my vin #

The contact 2021 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 25V455000 (Fuel System, Gasoline) and 26V117000 (Visibility); however, the parts to do the recall repairs were not yet available. The contact stated that while driving approximately 40 MPH in inclement weather, the windshield wipers were activated, and the driver’s side windshield was not cleared, causing limited visibility. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The failure mileage was approximately 45,000.

The contact owns a 2021 Ford Explorer. The contact stated that while driving on several occasions at various speeds, the master warning, brake, battery, ABS, and brake system warning lights illuminated. Additionally, the message "STOP Safely Now" was displayed. The vehicle then went into LIMP Mode each time, but the vehicle failed to respond while the contact was attempting to turn off the vehicle or accelerate. The contact stated that while the vehicle was in neutral(N), it failed to respond as intended. The vehicle was taken to a dealer, where it was diagnosed that there were 11 undisclosed modules that needed to be updated, and the hybrid system was inoperable. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 54,230.

Passenger low-beam headlight failure. Dealer replaced headlight module but did not resolve. Next suggestion is replacing headlight for more than 2,000. Quite common issue on the Platinum model.

Interior panoramic roof shade roller broke and is not retracting the liner anymore

Sunshade has fallen off the tracks and the fabric is falling. This is a known issue amongst Ford Explorers with a sunroof; rear visibility is completely blocked. Ford requesting $1800 just to repair shade.

Car turns on but the engine will not turn over due to the electrical. And locks the car and not able to check or fix anything. If I was driving in the busy roads it would have been very dangerous as it stopped suddenly after starting the last time.

I am reporting a persistent and escalating electrical safety defect in a 2021 Ford Explorer. On February 28, 2022 (at approximately 10,542 miles), I formally reported a strong burning metal smell and the engine would be loud and idle high, there was abnormal noises and unusual electrical changes to the dealership (West Herr Ford). The dealer service advisor documented no problem found and told me not to worry about it. Over time, this unresolved electrical short and metal smell has resulted in a total system failure. In February 2026, the vehicle suddenly suffered a complete ‘black screen’ (APIM/infortainment failure) and a no-start condition. Most dangerously, the battery suddenly drains within days, which can lead to total loss of vehicle power while in motion, disabling power steering, braking assists and you can’t even put the car in neutral when this happens. I am gravely concerned that this unaddressed metal burning smoking/ electrical short issue poses a significant potential fire risk to myself, my passengers and other drivers. The same dealership has now had this car in there possession for 32 days and admits that what has happened is what happens while they have it and that they cannot find the root cause. Yet the previous service advisor from 2022, and the current service advisors ( gave the car back on 2/21/2026 and 3/6/2026 saying their was no problem) allowed the vehicle to remain on the public roads despite documented fire hazard symptoms.

my son is rear facing and puts his arm in the forward facing belt path then can not get his arm back out. he starts screaming and crying and i have to pull the car over to the side of the road to help him get his arm out and even i struggle getting his arm free. no sooner than i start driving again, he puts his arm back through and it’s the same cycle. i have contacted britax and have unfortunately not gotten any solution for this issue.

Everyday I get alerts saying the power train system, then I can’t use my cruise control, and many other alerts pop up

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 26V117000 (VISIBILITY); however, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed in the rain, the windshield wiper motor failed to function as intended and prevented the windshield wipers from operating properly. The local dealer was not contacted. The manufacturer was not made aware of the issue. The failure mileage was approximately 90,000.

Repeated failures of the rear axle bolt recall remedy on my 2021 Ford Explorer Hybrid. The vehicle has undergone multiple repairs including replacement of the rear axle bolt, axle seals, and transmission alignment. Despite these repairs the vehicle continues to exhibit driveline instability, seal leakage and symptoms similar to transmission slip.

SUNROOF SHADE SAGS WHEN OPENING IT, IMPEEDING REARVIEW VISABILITY

vehicle stalls when diving . After pulling over ina coast and turning off with start stop button then turning it back on with start stop button vehicle runs fine until it happens again intermediately cold be days could be months apart. about the 6th time over 2 years that it has occurred

When driving to our local store I noticed my down shift to be rough, so I turned into the back roads, I heard lots of noise coming from the back of the vehicle and then I heard a loud pop and it was my rear axe differential bolt that snapped causing me to lose power.

For full details please refer to complaint 11715221. Since the initial complaint, repairs have been completed and I will attach a list of parts that were replaced. The repair confirmed the rear axle bolt sheared and there were significant metal shavings in the rear differential. When the bolt broke, numerous other components were damaged as detailed in the repair documentation. Ford has refused to accept any responsibility for this repair even though the safety implications for this type of incident are alarming.

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 25V393000 (SEATS); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

Transmission clutch failure. As a result my 2021 ford explorer needs a new transmission.

The parking collision sensors started to act up. Its been replaced 3 or 4 times in the last year over the same problem and no one has tried to tell me how to fix the issue besides keep getting it replaced. People are at risk of getting hit or hitting a object that could be in the way of me reversing.

Recently purchased a vehicle that had just previously got a recall 23S55 3 weeks prior. Upon receiving the vehicle there was a slight clicking noise when going into gear. i took the vehicle to a ford dealer and they investigated the recall remedy was installed improper from the dealership and the vehicle was unsafe to drive the rear subframe of the car moves and has free play which made is very unsafe to drive . . While calling the dealership back that did the recall work they refused to take responsibility . i then put in a repair order through ford and they denied repairs for the recall mishap . I am being stuck with a $3500 bill for a recall that was installed improper.

Tiny specks in the windshield between laminate decreases visibility when in sunlight

The sunroof shade cover has become unattached to the rollers on the sunroof track. This causes sagging of the sunroof sunshade, and limits visibility while driving.

The vehicle has an ongoing oil leak originating from the engine/drivetrain area. The affected components include the intermediate shaft and related seals, which are subject to Ford technical service bulletins, and potentially the plastic engine oil pan and its sealing surfaces. The vehicle is currently operable and remains available for inspection upon request. he vehicle is actively leaking engine oil at approximately one drop per day. Oil leakage presents a safety risk due to the potential for oil contacting hot engine or exhaust components, reduced lubrication if the condition worsens, and the possibility of oil dripping onto road surfaces, which could reduce traction for other motorists. The condition has not caused an accident to date, but it presents an ongoing safety concern. Yes. A Ford dealership identified and documented oil leakage during a scheduled service visit in November. In addition, the dealership acknowledged known issues with the affected components and confirmed that the vehicle continues to exhibit oil leakage. The manufacturer has declined repair outside of warranty. The vehicle has been inspected by an authorized Ford dealership on multiple occasions. Ford Motor Company executive customer care reviewed the case and documented a decision to decline repair based on warranty status. The vehicle has not been inspected by police or insurance representatives. No warning lamps or messages were present prior to the discovery of the oil leak. The condition was first identified visually during a scheduled service visit in November when oil leakage was observed. The vehicle currently exhibits ongoing oil leakage without warning lamps or messages. I am also concerned that this model has had several recalls regarding the engin and our falls just outside the range of Ford recall it was build in January of 21 and the recall starts in May of 21. I would like to have that expanded to my vwhicle as well.

On [XXX], we sent a 2021 Ford Interceptor to J.C. Lewis Ford located at 309 W. Oglethorpe Hwy, Hinesville, Georgia 31313 for a recall under 23S55. The recall is a safety issue related to a rear axle bolt and the possibility the bolt can fracture. We had the recall done and returned the vehicle to service. On or about [XXX], our fleet manager was called to the Liberty County Jail because this vehicle was making a loud noise from the rear end. Our fleet manager had the vehicle towed to the county shop where it was inspected. They concluded the vehicle would need to be towed to Ford for repair since the rear axle bolt fractured, the exact issue that was addressed under the recall. A few days later, we were notified that the dealer was refusing to pay for the repair since they had already done the recall. I contacted Ford Customer Service, case number [XXX], to try and resolve the issue. After going back and forth, I received notification on February 3, 2026, that financial assistance has been denied and that this concern is caused by how the vehicle was / is used over and form of manufacturer defect or previously completed recall. The vehicle is a police interceptor purchased for use as a patrol vehicle for the Liberty County Sheriff's Office located in Hinesville, Georgia. The vehicle is assigned to our civil division and the operator serves evictions and civil documents. The vehicle is not used for patrol but even if it had been, that's the intended purpose of the vehicle when purchased. I have photos of the bolt which show it fractured and also shows the head of the bolt appears to have some damage, possibly from the manner in which it was installed. This failure has been identified as a safety issue related to the 2021 Ford Interceptor and is not a new issue. The recall referenced an axle bolt that can fracture, and that did happen but Ford doesn't want to take responsibility. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2021 Ford Explorer. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The contact's husband, who was an independent mechanic, used a diagnostic machine to diagnose the vehicle and discovered a failure with the emissions system. The contact stated that the failure was like the failure listed in NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The manufacturer was not made aware of the failure. The failure mileage was approximately 80,000.

The drivers side door latch mechanism malfunctions and causes the door to unlatch or does not allow the door to latch. This is a safety hazard. I know two other ford owners with vehicles after 2021 that is having this same issue. This calls for a recall!

Sun roof fabric/covering came off tracks and is now sagging. Many forums on this issue. When driving if windows are down, the fabric flaps in the wind and sounds like it will fly off. I no longer drive with the windows down. If it continues to sag, could obstruct rear view.

I was informed by the dealership that the engine issue with my 2021 Ford Explorer is the same issue for which a recall was issued. However, because my vehicle’s VIN was not included in the recall, I was required to pay for the engine replacement. I attempted to work with the dealership to have them coordinate with the manufacturer, but they declined to do so. I then contacted the manufacturer directly to file a complaint and request a review of the issue. I was advised that there was nothing they could do because my VIN is not listed under the recall. I am requesting that the manufacturer investigate this matter further and reimburse me for the repair costs if it is determined that the issue is applicable to my vehicle.

LED low beam headlight failures. Our 1st headlight failure occurred in January 2025 at 51,248 miles (Passengers Side), our 2nd failure occurred in December 2025 at 64,356 miles (Drivers Side). My claim is Ford decided to embrace LED technology with out properly performance testing it. LED headlights are new on the explorer platform since 2020, the platinum & ST trims are the only ones that utilizes LED's to my knowledge. The design intent was life of car which clearly is not occurring. Ford should have completed more testing and/or designed a serviceable headlight for all internal components. The cost of these lights is astronomical ($1600 a pop w/o labor or diagnosis fee). As reference we also own a 2006 Audi S4 & a 2012 F150 XLT. The Audi has ~170K miles on it and the F150 has ~130k miles on it. Both have the original headlights and bulbs within them. Both older technology and both still working as intended. The headlights in the 2021 car BOTH failed in terms of the low Beam LED components failing in under 4 years. Seems to be a common issue in over 50% of 6th Generation Platinum trim level explores on the market. Numerous others have experience similar issues. Asking for a recall for these. Again only on Platinum & ST trims so not nearly as many at the average XLT level trims.

While applying brakes coming to a stop light, the vehicle gave a message stating service brakes. The brakes still felt normal. Then after a few minutes, the brakes felt like they suddenly stopped working and then the rear tires started locking up and releasing. The frong brakes felt like they were not working at all. Stopping distance approximately tripled and not really any way to adjust braking pressure. Releasing the pedal would give a 2ish second delay before the brakes would reapply upon hitting the pedal again, and withing 1 second would lock up the rear brakes again, starting the cycle over again. Took approximately 3 applications to fully stop in a safe manner. Luckily I was already driving slow due to the warning and was able stop before hitting the car in front. Was driving approximately 30 mph when this happened. Under normal circumstances and driving distances this would have not been possible. The car was taken to the Ford. They determined there was internal failure in the Electronic Brake Booster. The fix was to replace the full assembly (EBB, ABS, etc), and flush the brake fluid. Along with diagnostics of the issue, the cost was $4,100.87 to fix. Since replacing the EBB assembly, the problem has gone away. There were no other indictions of an issue before this happened. I know other Explorer years, and other models that use this same component have been recalled for similar issues as well, and think there is a issue with this module as well.

2024 - 19k miles. Both rear shocks were leaking. Dealer replaced both at no charge. 2025 - 30k rear shock shows signs of leaking. Dealer states no leak. 2025 - 32k Tire shop says shock is leaking. I told them the dealer said it was not. they took pictures. 2025 - Arrive at dealer (2nd time same issue) Dealer states no warranty because I did not pay for replacements. They stated had I payed for replacements I would have a 2 year warranty. Since it's been over a year I have to pay for it. Left dealer called Ford and filed a complaint. Case # XXX-XXX or XXX? Under 40k miles and going on 3 sets of shocks. Online forums readily show this is a known problem that Ford will not acknowledge. Furthermore their warranty of 1 year vs 2 based on payment or warranty replacement should be illegal! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Police car started to run rough at low speed. Stalled in middle of road. Scanned codes and code for Catalytic converter showed up along with misfires from numerous cylinders. Brought to dealer and was told needed plugs and a wire. Vehicle was returned and the same issue occurred. Fixed again. Picked up and once again the same issue started. Turned around and brought it back to dealer. The mechanic stated he never checked the catalytic converter as he was never told it had a code for the converter being bad. Two weeks later I am informed that Cylinder 5 is bad. No compression. Two issues. Ford upped the warranty on the catalytic converters because of this common problem. The tech sheet shows that a bad cat will cause misfires, but never checked. Second issue is the recall 24s55 was for fords with a 3.o liter engine, built in Chicago, between the dates of 7/21 and 10/21. My vehicle was built in Chicago on 9/21 and has a 3.0 liter engine. I also received the post card regarding the recall and we had brought it t o the dealer. 24s55 states the valve could cause engine failure. Well now I have a bad engine. Ford says no recall even though prior Chief brought to dealer after receiving postcard for recall.

Rear differential/axle bolt broke, destroying other parts and making vehicle unsafe at the moment and then inoperable. Vehicle had previously had the recall work done for this exact issue prior to any issues/damage. Dealership is repairing the vehicle under warranty, but made sure to tell us that this is a known issue and the only true way to “fix” the issue is to install an aftermarket brace (at our cost).

When given gas to move from a complete stop, vehicle lost all power. After vehicle lost all power to rear wheels, warning lights flashed on cluster. Manually moved vehicle to side of road and checked under SUV to see rear axle was at a unusual angle and later discovered rear axle bolt on road. Vehicle was towed to dealership, which originally completed recall repair in July of this year, for this known issue. Repairs have been completed after 2 weeks, and was informed by dealership it was roughly 6 thousand in damages.

The fabric from the moonroof has come loose on the sides and blocks rear visibility if open. This is apparently an issue with many vehicles.

The contact owns a 2021 Ford Explorer. The contact stated that the vehicle was repaired under NHTSA Campaign Number: 23V675000 (Power Train); however, the repair failed to prevent a failure shortly after the vehicle was serviced. The contact stated that after shifting from reverse(R) to drive(D), there was an abnormal grinding sound coming from the vehicle before the vehicle lost automotive power. The vehicle was towed back to another local dealer, Sutton Ford (21315 Central Ave, Matteson, IL 60443); where it was diagnosed with a fractured rear axle bolt. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 77,000.

Adaptive Headlamps keep going out causing a safety issue.

The sliding roof mechanism for the sunroof failed and droops into the backseat impairing vision. This can be triggered accidentally while driving causing zero rear visibility. This is part of the sun roof that is the shade keeping the sun out of the car. With extremely little use on my 2021 ford explorer this mechanism has failed causing this dangerous malfunction. I found may posts in Facebook describing this same issue. [XXX] There’s just one example of many people having this issue. There’s component was taken to the Ford dealership where I was provided a verbal quote of more than $4,000 to fix, which is not feasible. There were no warning signs. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2021 Ford Explorer. The contact stated that the VIN was included in NHTSA Campaign Number: 24V598000 (Engine). The local dealer was contacted and declined to complete the recall repair. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The contact had not experienced a failure.

The sunroof shade is sagging. It broke from one day to the next, and it’s blocking my rear view.

Sunshade is sagging. For the 2nd time.

Panaromic sunroof blind became lose and is sagging, causing an unsafe driving experience, making it difficult to see out rear view mirrors.

My explorer is only 4 years old and it suddenly suffered catastrophic engine failure due to low engine oil. The engine started knokcing and clattering BEFORE any warning lights came on the dash. This could also be due to premature bearing failure which is common in the 3.0 ecboost engines.

The sunroof sunshade snapped a clip off and now hangs down blocking the rear view. It is impossible to see out the back window. I have read on multiple sites that this is happening to many of these SUVs and it's an extremely expensive and difficult fix. It's very dangerous and I won't even let my girlfriend drive it anymore.

vehicle low beam headlights went out all of the sudden. Would not come back on after car was turned off and restarted. Drove home with high beams on. Next day, just the driver side low beam came back on. Took to dealer, they reprogrammed and headlights worked for three days, then went passenger low beam went out again. Took back to dealer and now they are telling me both headlamp control modules on both sides need replacing. The cost is very expensive and I am doubting this is the problem. This is a safety issue and I am reading blogs and the Platinum version of the Explorer seem to have issues. This could cause an accident and Ford could be liable. This issue needs to be looked at, as this should not be an issue for a car with 50K miles on it.

SUNROOF SHADE HAS FALLEN OFF TRACKS WHILE DRIVING

The contact owns a 2021 Ford Explorer. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate. In addition, the vehicle jerked aggressively, and the engine idled roughly. No warning lights were illuminated. The vehicle was towed to the contact's residence. The vehicle was taken to the dealer, where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The contact received notification of NHTSA Campaign Number: 23V675000 (Power Train). The contact inquired if the failure was the result of the recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 97,954.

Dashboard not attached to frame. Clips intended to attach dashboard to frame are defective (cracked in half). Air bags may be affected (either won't deploy or will deploy on their own). Service Dept. at Ford dealership says this is the first case they've seen and repairing it would cost $$$. This vehicle has been regularly maintained and has 0 history of accidents. It is unknown if this defect has existed from the date the car was purchase(or earlier).

My vehicle is experiencing exhaust fume issue where the exhaust fumes are entering into the cabin for Explorer and Aviator models (Any model with the 3.0L Ecoobost). Upon inspection by 3rd party mechanic, it can be determined that the problematic catalytic converters that are not the one piece cast was installed on my vehicle from the factory. Speaking to other ST and Interceptor owners, the problem seems widespread to every 2021 model that Ford installed the multipiece welded catalytic converters. Apparently the cast part fairs better and is not subject to cracks. The recall originally covered the left side catalytic converter but the flawed design also affects the right side catalytic converter where many owners are experiencing this issue. This has affected all 3.0L Ecoboost engine vehicles. [XXX] I believe the recall should have extended to cover all 2020 and 2021 model year vehicles. There are forum posts where owners outside the recall have experienced the issue in addition to owners having to repeatedly replace the catalytic converters post warrant as Ford continued to reinstall bad catalytic converters as part of the repair process. I have driven this vehicle for several thousand miles with the issue and did not realize exhaust was leaking until notices of headaches and health issues as CO is odorless, causing CO2 levels to reach 3000+ inside the cabin at stop lights and blows in through the vents if A/C is on. I believe NHTSA should investigate this issue further and require Ford to replace both catalytic converters as this issue poses a serious health hazard, especially given the location of the exhaust leak and the commonplace occurrence. I am happy to forward to forums and provide evidence of this occurring. Ford considers lifetime of the vehicle to be ~150K miles and these exhausts do not last close to that, resulting in a massive expense and danger to US consumers. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2021 Ford Explorer. The contact stated that while driving at approximately 25 MPH, the liner of the panoramic sunroof was opened and was sagging, which obstructed the view of the rearview mirror. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 38,800.

We received notification from Ford that there is a "rear axle bolt fracture" possible on our 2021 Ford Explorer and noted we were to contact our dealer to address. However when I reached out to the dealership (and then subsequently to Ford Customer Service) I was told that the issue was being treated on an "extended warranty" basis. We would recognize the issue when we noticed severe vibration and lost of mobility in the vehicle and that putting it in Park would not keep the vehicle from rolling. Based on those calls, my wife could be left on the side of the road, involved in a fatal accident (to her or others) etc., instead of addressing the issue as a preventive measure. In addition, nothing in our coversations or in their notice involved the cost to us for additional damage to the vehicle, towing or a rental car (as the dealership said they wouldn't even be able to order the bolts until the fracture occurred and they had the vehicle in their shop. The service code for this defect is 24N01. As of this date we have not experianced this issue but am trying to avoid it occurring since it is a known defect by Ford.

Roof window cover/headliner has come loose and is impeding full vision to the rear of the car while the headliner is retracted.

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 25V455000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was not yet available. The contact stated that after purchasing the vehicle, while driving at an undisclosed speed, the vehicle failed to accelerate as intended while depressing the accelerator pedal. No warning light was illuminated. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 60,000.

The shade that covers the moonroof has fallen off the tracks (or something) and it's sagging down from the headliner. There wasn't a snapping or breaking sound, I just went to open it and it sagged instead of sliding back under the headliner like it should. The car is only 4 years old, we bought it new, and we hardly ever use this feature, so it hasn't received a lot of use. With the shade sagging down (it won't go back into place) it blocks the view of the rear window, which makes it a safety hazard. Apparently it's not covered by my warranty, and will be around $1,800 to fix. My car is at the dealership right now and they just told me it's not covered. This is very dangerous because it also blocks the view of my children in the back seat, and most of the rear window. I just googled how to fix it, and it seems like this is a known issue that many others are having. There was no warning lights or messages about this failure. It first happened on October 11, 2025. Note: It's still at the dealership, and I need to pick it up after work, so I don't have a photo to include. I apologize.

The contact owns a 2021 Ford Explorer. The contact stated that while driving approximately 30 MPH, the check engine warning light illuminated, and there was a burning odor coming from the vehicle. The contact pulled over and parked and allowed the vehicle to cool down before driving back to the residence. The vehicle was towed to the dealer and was diagnosed with coolant intrusion into the engine and the oil main bearings, causing engine failure. The contact was informed that the engine needed to be replaced. The contact received a notification of NHTSA Campaign Number: 24V635000 (Engine and Engine Cooling); however, the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was unknown.

When operating the sunshade a plastic clip sprung from the assembly mechanism that retracts the shade towards my face. Now the shade is obstructing my vision of the road and I am concerned that I am going to run over someone and/or something.

LED LIGHT ISSUE. PASSENGER SIDE LOW BEAM. LIFETIME OF LED SHOULD BE 45,000 HOURS OR 12-15 YEARS. IT IS NOT WORKING. FORD NEEDS TO GENERATE A REPAIR ALSO CURRENT WARRANTEE WORK NEEDS TO BE COMPLETED INCLUDING THE REAR CAMERA.

I bought the car brand new in 2021. It handled great, no issues, not even on extremely icy roads. The temporary fix for Recall 22S27 was done in July 2023 which was just a computer flash to set the park brake each time the car was put into park. Each time I put it in gear the car would make a loud noise as the park brake released. I immediately felt a difference when driving, it felt like the front end was "floating" and the car wasn't holding to the road. On dry roads it would be unstable if the road wasn't perfectly smooth. Driving in the winter on icy roads was scary, no control, it would fish back and forth. They performed the actual fix recall 23S55 in May 2024. They did not remove the temporary fix that sets the park brake. In January 2025 I was in a flat parking lot, icy and raining, I had NO control. There were 5 mornings with those road conditions that I couldn't make it 1/8 of a mile. Absolutely no control, it pushed me all over the road and when I braked, it continued to push me all over the road. It never showed warning lights on my dash. My local dealership pulled codes, told me it was a park brake module code but they couldn't do anything until they could duplicate it. I have spent the last 9 months arguing with the dealership and winter is almost here with no help, they treat me like I'm crazy and told me that I'm the only person in the world with this problem. I just traded it off yesterday, lost a bunch of money, but I couldn't go through another winter with it. It's way too dangerous!

There was no lights on the dash but the transmission was shifting very hard when slowing down. I took it to the dealer for service, but the dealer says the transmission is full of debris and needs a full replacement. When slowing down it was causing the vehicle to buck forward very hard advancing it forward and causing me the driver to feel forward force from the harsh bucking of the transmission.

Approximately 6 weeks ago, while driving at 30 -35 mph in residential area, vehicle started lurching/jolting, took to local dealership, nothing found, reported to Customer Service, instructed to write to FMC Consumer Affairs and am waiting on reply.

Sunroof shade loose / sagging when retracting. Issue is caused by a worn sunshade spring. When retracted, the sunroof shade fabric sags to the degree that it blocks / obscures the driver's view of the back window and activity to the rear of and/or behind the vehicle. An internet search shows that this in a known / common issue with Explorers.

I bought my 2021 ford explorer limited brand new. I have never used the sunroof for my personal pleasure. I have opened it less than a handful of times, only to appease my grandson. The other day, I had my grandaon and I closed the sunroof, for maybe like the 4th time ever, and the sunshade liner started to sag. If this falls while I am driving I am afraid it may blind my driving. Should FORD have to pay for this defect? I am seeing forums all over the internet where this is happening to a lot of owners. Thanks for your time and help.

Passenger second row (Captain's) seat is loose, shakes (sometimes violently) and rattles loudly when vehicle is moving (and seat is unoccupied).

The contact owns a 2021 Ford Explorer. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate as needed and then lost motive power. The engine made ticking sounds, and the vehicle was running rough. No warning light was illuminated. The contact coasted the vehicle into the driveway. The vehicle was towed to the dealer, who discovered that the timing chain, spark plugs, and intake valves were fractured. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 80,000.

The contact owns a 2021 Ford Explorer. The contact stated that while reversing, there was an abnormal clunking sound coming from the rear differential, with the vehicle vibrating. The vehicle was taken to the dealer and was diagnosed and determined that the drive axle, wheel hub assembly, and the hub splines needed to be replaced. The dealer informed the contact that the vehicle was previously included in NHTSA Campaign Number: 22V255000 (Power Train); and was repaired by Hutchinson Ford of Forsyth (288 Harold G. Clark Parkway, Forsyth, GA 31029). The vehicle was not yet repaired for the recent failure. The manufacturer was not informed of the failure. The failure mileage was approximately 113,000.

Sunroof shade won't open and bind down covering the rear mirror view

Hi, i am concerned about the safety of my vehicle. i brought it to the attention of ford motor company and an authorized dealer that i am getting a parking brake warning on my dashboard. the authorized dealer inspected it, and said that the braking system is contaminated due to liquid spilling from the damaged cupholders. i communicated to them, that 1. the cupholders are clearly not strong enough to be placed over a critical component of the vehicle such as a braking system. 2. i think that this is a design flaw as there are normally drips and spills from having liquid in your car, especially in the designated place for it (cupholders). I should not be held liable for the repair to the braking system. they insisted this should be for my account, and if i decided not to fix it, it could lead to the entire braking system malfunctioning while the car is in motion or at a stand still. I am noting this with the department of transportation for investigation hopefully prior to an incident/accident taking place and the risk of a fatality, i have communicated to the dealer but they feel they have no accountability for this. while this may seem to be a cosmetic issue "just a cupholder", it is directly over a critical system of the car, and based on research i have done, i am not the only one with a broken cupholder in my ford explorer.

The contact owns a 2021 Ford Explorer. The contact stated that there was a 15x3/4-inch strip on the B-pillar trim of the driver's side rear door that was detaching from the vehicle. The vehicle was taken to the dealer, who attempted to use adhesive to secure the trim piece; however, the temporary repair failed to fix the vehicle. The dealer determined that the entire B-pillar trim needed to be replaced. The vehicle was not repaired. Additionally, the contact became aware that the B-pillar trim on the passenger's side rear door had started to detach. The contact informed the manufacturer of the failure. The contact was informed that the VIN was not included in NHTSA Campaign Number: 25V347000 (Structure). The manufacturer advised the contact to report the failure to the NHTSA Hotline. The failure mileage was approximately 65,000.

FOR THE PAST YEAR AND A HALD I HAVE TAKEN MY VEHICLE TO FORD IN ONTARIO BECAUSE IT HAS HAD NUMEROUS INCIDENTS THAT I AM AT A LIGHT AND THE VEHICLE COMPLETY SHUTS OFF. WHEN I HAVE TAKEN IT IN THEY RETURN IT STATING THAT NOTHING ID WRONG WITH THE CAR. THIS MONTH ALONE IT HAS HAPPENNED ATLEATT 5 TIMES. LATEST ONE BEING THIS MORNING ON MY WAY TO WORK. IT SHUT OFF LUCKYLY I AM GETTING FASTER AT 1ST PRESSING ON MY HAZARDS AND THEN RESUMING THE ENGINE AND TAKING OFF THE PARKING BRAKE I AM IN FEAR OF BEING IN A COLLISION. I CALLED DEALER TODAY THEY SAID ALL THEY CAN DO IS KEEP THE CAR AGAIN FOR SEVERAL DAYS BUT IF NOTHING IS FOUND AGAIN I HAVE TO PAY FOR THE RENTAL CAR OUT OF POCKET. THIS IS CRAZY AS MY SELF AND MY FAMILY ARE AT RISK EVERY TIME THE CAR SHUTS OFF WE HAVE BEEN BLESSED NOT TO HAVE BEEN REAR ENDED. THERE ARE NO WARNING LAMPS THAT TURN ON.

The contact owns a 2021 Ford Explorer. The contact stated that while driving at an undisclosed speed, the front driver’s door window independently rolled down. In addition, the contact stated that the failure had previously occurred with the front passenger’s and rear driver’s side windows. The contact stated that during the first failure the vehicle was repaired by the dealer and covered under warranty. After the second failure, the vehicle was repaired by an independent mechanic and the contact paid out-of-pocket. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 68,188.

The contact owns a 2021 Ford Explorer. The contact stated that while the vehicle was parked, the rearview camera became inoperable. The contact stated that the rearview camera image was blank. The contact received notification of NHTSA Campaign Numbers: 25V159000 (Back Over Prevention) and 25V393000 (Seats). The vehicle was taken to the dealer but was not diagnosed or repaired. The dealer confirmed that parts were not yet available to repair the vehicle. The manufacturer was made aware of the failure. The approximate failure mileage was 90,000.

I was driving down the road and heard a loud pop and it sounded like a golf ball hit my door. I immediately looked in my rear view mirror and was unable to see anything. After merging to the shoulder of the road and stopping safely I turned around and noticed that the headliner from my sun roof had broken and fallen and was blocking all view from my mirror.

While driving, the panoramic sunroof shade on my vehicle failed to retract properly, sagging down into the rear visibility area. The shade hangs low enough to completely block the view through the rearview mirror, significantly impairing my ability to monitor traffic behind me. This is a serious safety hazard, particularly when changing lanes, merging, or reversing. The issue also impacts rear passengers, as the drooping shade hangs down into the back seat area. This obstruction makes it difficult to check on passengers—especially children—while driving. There were no warnings before this failure occurred, and research shows that this problem is common among other owners, as documented in multiple online forums and complaint records. The shade appears to have a design flaw where the guide sliders or attachment points fail, causing it to sag into the driver’s line of sight. This failure should not happen on a safety-critical component affecting visibility. Given the frequency of reports and the direct impact on driver awareness, a recall or mandatory repair campaign should be issued to address this defect in all affected vehicles.

The auto/stop start system is malfunctioning. When I stop at a stop sign, or to turn left, the vehicle stops, but then does not turn on again when I press the gas pedal. Instead, I have to place the car in park and manually restart the engine. This has happened four times over a 2-month period. Sometimes it takes me 30 seconds to turn the car back on. This is harrowing when I am suddenly stuck in the middle of the road. I took my vehicle to the Ford Dealership after it happened three times. They had my vehicle for 3 weeks but could not find anything wrong, and the incident did not happen again. I’ve had my vehicle back for 6 days, and it happened again today at a stop sign. Suddenly, there was a message on my screen to place my car in park and restart the engine. There were many other cars waiting for me to turn.

I was driving and pressed the button to open my sunroof (which has a powered sunshade) but the sunshade dropped down on top of the 2nd row seats, blocking my view through my rear view mirror and rear window completely. I made an appointment with my Ford dealer the next day. The dealer had my vehicle for over 30 days waiting for parts to fix the tensioner system that pulls the powered sunshade back in order for the sunroof to open. I've seen in multiple forums online that this has happened to a lot of other people that has this option on their Ford Explorers (2020-2024) models. This was definitely a safety hazard as I was unable to see anything behind me while I was moving and luckily I didn't panic. I pulled over slowly to the soft shoulder in order to try and get the sunshade to at least go back to it's "closed" state which it finally did after trying for a few minutes. I think Ford needs to make this a recall because of the safety issues of this blocking the view of the driver.

Automatic roll up sun shade for the sunroof sags and does not retract anymore, causing visibility issues as it droops down. Car is out of factory bumper to bumper warranty, currently 52k miles, and the aftermarket warranty does not cover the shade. Ford quoted over $2000 for fix, when this is a manufacturer's defect and many cars are affected.

The contact owns a 2021 Ford Explorer. The contact stated that while her husband was driving at an undisclosed speed, the brake pedal was sticking on three occasions. The contact stated that while driving at an undisclosed speed in a parking lot, the contact had to raise the brake pedal with her foot after the brake pedal was depressed. The contact stated that it felt like the parking brake was engaged. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed that the power brake booster was inoperable. The part: L1MZ2005K - Ford Power brake booster was on back order for a month. The vehicle was taken to an independent mechanic who repaired the brakes, and informed the contact that the required parts were on back order for three months. The contact called the manufacturer, who confirmed the status of the parts, and that there was no release date for the parts. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 85,000.

My vehicle is equipped with a panoramic sunroof, furthermore the panoramic sunroof has a sliding screen to block out the sun when the owner prefers to block the sun. The issue is with the panoramic sunroof screen, this particular screen also slides on rails below the glass window from the panoramic sunroof. The sliders from the screen part seem to break and cause the screen to sag downward blocking the view from the rear view mirror. In which case it’s a safety hazard for the passengers and public due to limited visibility. Furthermore, it also blocks the view of monitoring the rear passengers in which in this case they are toddlers.

Sunroof shade did not retract properly when opened and sagged down low enough to block visibility to the rear of the vehicle while driving. Not only was rear visibility entirely cut off, rear passengers are affected as the shade hangs down well into the back seat area. I will be taking this to the dealer, problem is reproduced as well as documented by many online. There were no warnings prior to failure. This is clearly an issue with the design and a recall should be issued to all affected.

Center console cup holder base failure causing items to fall through and into the interior of the console. My key fob fell through the bottom and required nearly an hour to be retrieved. The problem is persistent with anything placed into the cup holder. This issue is common and well documented on forums and social media.

The transmission failed. The electrical component also failed

Panoramic sunroof fail for 2nd time repair is close to 2000$ I’m not going to paid again this is a ford design issue not a owner fault Panoramic roof have some plastic click that hold the shade and they got brake or damage by itself causing the shade felt, ford rapair is close to 1.8k$ I paid one when I first bought the car now after the Texas freeze when I was closing the system I heard the clicks braking and then we have the same issue with the panoramic shade got weak and there is no way to fixed just the deal and the price is close to 2000$ for a internal design there is several people with this same issue this is a internal fault design not a owner fault

Recall Action Soon Issue Since 06-20-2025 Unrequested second-row seat movement For More Information Telematics Generated Issue

Recall Action Soon Issue Since 06-20-2025 Unrequested second-row seat movement Unrequested second-row seat movement Recall incomplete Recall service not available right now. We have a remedy but parts are not available right now. We will inform you when the service is available. Or, you can contact your dealer. Contact Dealer Issue Date 2025-06-13 Campaign 25S67/25V393 Description On your vehicle, it is possible that the easy entry seat fold switch on the second-row outboard seats may bind or stick if its surrounding trim bezel was installed incorrectly. If the button is stuck in the down position, the seat may unlatch, fold and or slide unexpectedly, potentially while driving. Safety Risk A seat that unexpectedly folds or slides while driving could increase the risk of injury, particularly in a crash. Remedy Ford Motor Company is working to provide parts for this repair. When the remedy becomes available, Ford Motor Company will notify you via mail to schedule a service appointment with your dealer for repairs to be completed free of charge.

The contact owns a 2021 Ford Explorer. The contact stated that while driving approximately 20-30 MPH, the vehicle stalled, with the check engine warning light illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the VIN was not included. The vehicle was towed to an independent mechanic. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 55,000.

Fabric for sunroof shade sags making the rearview mirror un usable due to the fabric sag obstruction.

The contact owns a 2021 Ford Explorer. The contact stated that while depressing the accelerator pedal, the vehicle hesitated while accelerating and decelerated unintendedly. The contact stated that the failure mostly occurred during the warmer weather months. The cause of the failure was not determined. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in NHTSA Campaign Number: 25V455000 (FUEL SYSTEM, GASOLINE). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 55,000.

my explorer has a 10 speed transmission, and its REALLY heavy on shifting like it is missing shifts or slipping, it will shoot up in rpms to the 7-8k mark and jerk forward, this will happen every few minutes when varying speed, driving through residential areas or normal trafficways not including the highway, however on the highway it has a tendency to feel as if it loses power and regains it, dropping rpms and shooting back up to 4-5k rpm, and dropping back down to around 2k. today i had the incident where the car jerked hard after a shift, gave me prompts on the dash about seeing the manual, and that drive modes are not available. this has happened in the past month before multiple times, however this time i lost all power to acceleration going down the road, ended up just coasting to a stop on a road that speed limit is 55 mph. this made me panic, because i could have possibly been rear ended, or in any other case could have been hit if my car would not have properly been able to accelerate. the car has had similar problems reported from previous owners and they have been taken into a dealership for repairs of which did not fix the problem or the problem is reoccurring. there are no warning lamps prior to the jerkiness of shifting and loss of acceleration because of it. it will jerk a handful of times and eventually give me the "see manual" prompt after the initial problem was noticed, i decided to look online for answers as to what was wrong and it seems like this is a reoccurring problem with vehicles similar to mine. Hopefully it hasnt caused and injuries, but it definitely has the possibility to from what i have experienced.

I was stoped at a red light with cars in front of me and behind me when with my foot on the break the car accelerated forward like my foot was on the gas pedal but my foot was not on pedal, the car surged forward and came close to hitting the car in front of me I pressed the break and got stopped didn’t happen again but sometimes I can feel the car wanting to keep surging forward when breaking. If there is a problem this could cause me to hit someone in the rear or even worse could hit a pedestrian in the crosswalk please check this out

The contact owns a 2021 Ford Explorer. The contact stated that while her fiancé was driving 76 MPH, the vehicle inadvertently lost motive power. The driver was able to pull over to the shoulder of the roadway, where the vehicle was able to be restarted. After restarting the vehicle, the vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the transmission. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 39,000.

2021 Ford Explorer •Problem: Blind Spot Detection / Sensor Malfunction •Description to copLeft-side blind spot sensor fails intermittently. It shows no warning when vehicles are in the blind spot, creating a risk during lane changes. I found Ford TSB 23-2048 confirms the issue. Dealer quoted $1,200 but this is a known factory problem and safety issue.

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 25V393000 (SEATS); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that while driving at various speeds, the rear passenger’s seat moved forward unintendedly. There was no warning light illuminated. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The approximate failure mileage was 80,000. VIN tool confirms parts not available.

Backup camera has failed again aftyer being programmed twice and replaced once under recall's. But now it's out completely. It has worked off and on since new.

The contact owns a 2021 Ford Explorer. The contact stated that upon inspecting the vehicle, the contact noticed that there was a gap between the body and the frame on the passenger's side of the vehicle. The vehicle was not diagnosed or repaired by a dealer or an independent mechanic. The manufacturer was notified of the failure, and a case was filed. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 74,000.

Transmission failed while driving leading to a sudden loss of power. Vehicle was hard to control after incident causing other vehicles to swerve around. Vehicle was taken to Ford dealership where it was recommended for a total transmission replacement due to internal transmission components that failed.

10 speed Transmission malfunction, needs replacing,

The passenger 3rd row seat if the fold button is hit it can lock and pin a passenger. It wont release itself unless you try and hit the reset holding the 2 buttons simultaneously. Currently for safety reasons I taped that seats button and won't let anyone out in the 3rd row

The airbag burnt a hole in a cotton shirt and then left 2nd and 3 degree burns on my side.

The contact owns a 2021 Ford Explorer. The contact stated that while his wife was driving at an undisclosed speed, the driver heard an abnormal sound coming from the rear of the vehicle. The contact stated that the failure recurred while the vehicle was idle. Additionally, the contact stated that the driver had noticed an abnormal exhaust odor coming from the outside of the vehicle. The vehicle was taken to the dealer, where it was diagnosed that the catalytic converter had fractured at the welds location and needed to be replaced. The vehicle was not repaired due to cost. The vehicle was then taken to an exhaust system center, where it was being diagnosed. The vehicle was not repaired. The contact related the failure to Ford Campaign Number: 21E11. The manufacturer was not made aware of the failure. The failure mileage was approximately 89,000.

While our 2021 Ford Explorer with 47,000 miles to work the vehicle warning light came on stating the vehicle was overheated and shut down. We allowed the vehicle to cool for 20 minutes as recommended by the owners manual and then restarted the vehicle which immediately overheated again. We had the vehicle towed to the local dealer who diagnosed the issue as coolant in the oil forcing a replacement of the engine and coolant systems.

As I am traveling on the freeway or expressway, when I have cruise control active and I am in the far right lane the vehicle suddenly changes to the speed of the frontage road dropping my speed from 65 or 70mph down to 40, even tho I am on the expressway. It almost caused me to be rear ended because of the sudden drop in speed.

Sun roof clips broke causing sunroof shade to sag

The electronic sunshade that covers the panoramic sunroof has malfunctioned and cannot be retracted fully. The sagging sun shade covers the rear window and blocks the view. I have taken it to the dealership for repair, but it is not covered under my extended warranty and is around $2000.00 to repair out of pocket. The dealership charged a $199.99 diagnostic fee to ascertain that it was the sunroof shade that had broken. There were no symptoms or warnings before this happened.

The contact owns a 2021 Ford Explorer. The contact stated that upon shifting into reverse, the rearview camera failed to display an image. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 25V315000 (Back Over Prevention); however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 36,000.

We bought this in 2022 from clek, and a few months before we were transferring our daughter from the infant seat to a convertible seat, our infant seat became stuck on the base. Absolutely impossible to get off and my husband and I both tried many times. I reached out to Clek because I was very concerned that in an emergency situation it would take much longer to unstrap and get baby out instead of just grabbing the seat and going. I mean in a car fire, if we went in any body of water- anything it’s extremely concerning to me that this could happen. I have bought cheaper car seats than this for our other children and never once had this issue. They ended up emailing me with a video showing me to break the base, pull a strap and remove the seat from the base - that’s great besides it still won’t detach and you could never do this in an emergency. They also said this happens often which clearly it does if they have a video showing how to remove it. The car seat has been inspected by the hospital and police prior to this and we have had other friends/ family who are in those professional fields who were very concerned. We actually were told by Albee baby to report clek because they said they should refund us. They aren’t even offering us a new seat and we are due in less than 2 months with baby number 3. We have no seat and to be truthful I don’t want one like this where it may get stuck again. They also told me in an email, police and ems could help save my child- sometimes you can’t wait for that- that’s a horrible excuse to me. I should be able to save my children myself and I will never rely on anyone else.

The rear axle bolt snapped. Causing the differential to fall out and rear wheel axles and driveshaft to break out of position.

The contact owned a 2021 Ford Explorer. The contact stated that the vehicle was parked in the driveway for over three hours before the vehicle caught on fire. The origin of the fire was unknown, however, the contact believes the fire originated from faulty electrical wiring. The vehicle was unoccupied during the fire. The location of the fire was the rear end of the vehicle. The fire department arrived to extinguish the fire. A fire department report was filed. A police report was not filed. The vehicle was destroyed. The local dealer was contacted, and the vehicle was not diagnosed as it was determined to be a complete loss. The manufacturer was notified of the failure. The approximate failure mileage was 75,000.

The vehicle has intermittent issues with bucking, running poorly, and not shifting properly. It results in several warning lights which will clear at random. The dealer has told us it needed a new alternator. The repair was made but the problem resurfaced again today. This is not a new issue as it has occurred many times before.

Moon roof cover is sagging and interfering with visibility with the rear view mirror. There have been many incidents of the sagging occurring online in for forums. There have been no warning notices for this issue

My vehicle is having the blue screen & message to contact my dealer when in reverse. I understand there is a recall for this. I contacted ford to see why I haven't received a notice & am being told that it only affects certain vehicles yet I'm having the exact issue. It is a safety hazard due to low visibility behind the vehicle when in reverse.

This vehicle has an electronic shifting transmission and when shifting from drive to reverse, the system lags significantly (1-3) seconds before engaging reverse. This has been an issue causing several close calls. In addition to not being able to back up efficiently and being left hanging in limbo while waiting for the transmission to engage, the vehicle also continues to roll forward causing near collisions. Happens while maneuvering the vehicle in situations where a three point turn is necessary or when trying to quickly go from drive to reverse in an attempt to avoid another traffic unit or on coming hazard. Has been brought to Ford for them to check and they advised after a test drive that the vehicle shifts smoothly. The smoothness of the shifting was not the concern. It was the lag between drive to reverse. I believe it needs a software reprogram for the transmission.

The chrome on the window switch on the passenger side is peeling and cut my finger while using it.

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V635000 (Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Sunroof headliner sagging. Can't see out back window

2021 Ford Exploer the RPM SHOOTS UP AND DOES NOT GO DOWN. I HAVE TO PULL OVER AND SHUT VEHICLE OFF TO RESET.. This has been replaced in 2023 and I am having problems with same issue. VEHICLE WILL NOT PICK UP SPEED UPON Accelerating and when it finally picks up the transmission with jerk really hard. This happens 2x a week. At times I have to pull over because there is no speed when pressing on the gas and need to shut off my car to reset it. When pressing on the gas pedal it Will sped up and take off with light Touch from gas pedal .

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V675000 (POWER TRAIN); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Sun shade sagging. Causing loss of visibility.

The contact owns a 2021 Ford Explorer. The contact stated while driving at an undisclosed speed, the transmission unexpectedly downshifted. There was no warning light illuminated. The vehicle was able to restart. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 72,000.

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V675000 (Power Train); however, the part to do the recall repair was not yet available. The contact stated that the check engine warning light was illuminated. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 27,000. Parts distribution disconnect.

We were driving the vehicle when we experienced a sudden loss of power and acceleration. We also noticed odors of gas. We took it to a Ford authorized dealership and they said it was due to antifreeze in the oil from what they said was a leaking water pump. They recommended a new engine due to the difficulty of changing the internal water pump and the fact it leaked antifreeze into the engine oil, possibly damaging the engine itself. This was the explanation for the fault codes, random gas odors, and loss of power. It was explained this was normal when the sensors detect something wrong with the oil in the engine. Estimated cost provided by the dealership was $11,000 to replace the engine.

the rear axle bolt fractured while driving causing damage to the differential, axles, and mounting bushing. the problem has been confirmed by Baytown Ford Dealership service dept. located at 4110 I-10, Baytown, TX 77521. it has been inspected by the Service Dept at Baytown Ford. located at 4110 I-10, Baytown, TX 77521 no prior symptoms or warnings.

Car has a delay when going into reverse & will move forward while in reverse then jerks into reverse. Also has a delay in going into drive from reverse. Not safe to back out into the road or doing a 3 point turn because of the delays. It happens all the time so the incident happens every day for me.

When vehicle is in reverse, the car still moves forward. Dealership said there is no fix. I was almost hit the other day because I couldn’t reverse quick enough.

The contact owns a 2021 Ford Explorer. The contact stated that while at a stop sign, the vehicle lost automotive power and failed to restart. No warning lights were illuminated. The vehicle was taken to a local dealer, where it was diagnosed; however, the cause of the failure was undetermined. The vehicle was not repaired. The contact stated that several unknown warning lights were illuminated. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 74,000.

Sunshade cover for sunroof malfunctioned and it hangs down causing a visibility issue as it obstructs the view from the rear view mirror. After doing a search on Reddit and the Ford forum, it seems to be a common issue. My vehicle only has 35,000 miles on it and this should not be happening.

I had complete engine failure on my 2021 115,000 mi Ford Explorer ST. The truck was only 3 years old. I heard a knocking noise and pulled over. Throughout the summer smoke had been coming out of the exhaust pipe every time I turned on the car before work. There was a cloud of smoke. A week before the engine failure I had the vehicle in the ford shop. They said everything was fine. I towed the vehicle to Currie Ford in Frankfort and they stated that there was catastrophic engine failure. Nothing could be done but I needed to put a new $12,000 engine in a $63,000 car. They said the warranty did not cover nor do I have any recourse. The safety of my family was placed at risk., I was travelling with my family, my wife, son, daughter, nephew who is [XXX] old and niece who is [XXX] . It left us stranded. There were no warnings. The dealership inspected the car a week before and said it was good to go. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I purchased my Explorer used last March. The window switches, on driver and passenger sides (front seats and rear seats) have the black metal pieces peeling off the switch. Metal pieces are sharp and I continue to cut my fingers on them. The dealer shows the recall did not affect my car, yet they are all in need of replacement. My vehicle has faulty window switches and I am asking Ford to replace them under recall or warranty.

The system/component that failed is the panoramic moon roof retractable shade. This is an electronic retractable fabric shade on the inside of the car that covers the moon roof glass. The tracks that hold the shade taught and in place have failed, this is a major safety concern due to the sagging fabric blocking the view of the rearview mirror and side windows. This impairs visual awareness of surrounding vehicles, obstructions, and approaching emergency vehicles from behind. This is a known common issue with this make and model vehicles as read about on multiple forums and social media sites. There were/are no sort of warning lamps as this is a mechanical track with no sensors. Ford has not issued any sort of safety recall thus far.

The contact owns a 2021 Ford Explorer. The contact stated that while driving approximately 40 MPH, the vehicle lost automotive power. The contact stated that there was an abnormal shaking and vibrating coming from the engine compartment. The vehicle was taken to a nearby mechanic to be diagnosed. The contact was informed that cylinders #3 and #4 had lost compression, and the engine needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in NHTSA Campaign Number: 24V598000 (ENGINE). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 105,000.

I was backing out of my driveway and a whoosh of water came pouring into my trunk from my roof of my car. When I took it to the Ford dealership they took the headliner down and found that the drains for my sunroof were clogged and caused the leak. They found that the headliner had mold growing on it. This is currently not a recall issue yet but I believe it should be or should be considered a default from Ford, (my warranty expired a couple months earlier). After speaking with the maintenance manager at Ford, I have been informed that it is not uncommon that the sunroof drains get clogged and this is something that should be checked or cleaned out periodically. With that being said- my 3 year old vehicle has only been maintained at a Ford dealership during its life. I go every 3-4 months and this has never been checked or cleaned out. My vehicle has been at the dealership for 3 months now because the parts are on back order. When I spoke with the dealership on 12/18 I was told there were 16 headliners on order, but when I checked back in January (a month later) there were 437 on order. This seems to be an issue with more and more of these vehicles. This is a dangerous situation because I do not know how long the mold has been growing in my vehicle and could cause health issues with me or my kids.

The contact owns a 2021 Ford Explorer. The contact stated that while driving 80 MPH, the power train warning light illuminated, and the vehicle stalled. The contact was able to exit the highway and the contact was able to pull over to the side of the road. The contact stated that upon turning off and restarting the vehicle, the vehicle operated as needed. The contact stated that the failure had been recurring while driving. The vehicle was taken to Express Care Automotive, where it was diagnosed that a valve in the engine had failed. The mechanic informed the contact that the engine needed to be taken apart for additional diagnostic testing. The mechanic informed the contact that the failure could be related to Ford Campaign Number: 24S55. The vehicle was not repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 80,000.

Fuel Sloshing When vehicle accelerates, brakes, or turns, the fuel moves within the tank, creating waves and sloshing. This can be heard as well when you come to a stop and road noise is less. You can also feel the sloshing on your foot under the driver's side. Excessive fuel sloshing can lead to instability, affecting the vehicle's center of gravity and causing handling issues, especially in extreme maneuvers. I've reported to dealership and Ford manufacturer but they say this is normal operation of vehicle.

Hard shifting

Queja por reparación defectuosa de recall en mi Ford Explorer Estimados Señores: Por medio de la presente, me dirijo a ustedes para expresar mi profunda insatisfacción con el servicio recibido en su concesionario relacionado con un problema de recall en mi Ford Explorer [indicar modelo y año del vehículo], cuya reparación, realizada bajo su supervisión, no ha sido adecuada. En los primeros meses de 2024, llevé mi vehículo a sus instalaciones debido a un recall emitido por Ford, relacionado con un sonido de media frecuencia resonante (de tono profundo) que se manifiesta al conducir a baja velocidad sobre superficies irregulares. Según se me informó, este problema fue causado por un defecto en una pieza, la cual supuestamente fue reemplazada en su momento. Sin embargo, después de meses de lidiar con el inconveniente inicial y tras un extenso tiempo de espera, el problema parecía haberse solucionado temporalmente. Desafortunadamente, en noviembre de 2024, el problema ha reaparecido exactamente con las mismas características, lo que me lleva a sospechar que no se realizó un reemplazo adecuado de la pieza defectuosa, sino únicamente un ajuste superficial. Al comunicarme nuevamente con su concesionario, se me ha informado que no pueden hacer nada más porque el supuesto reemplazo ya se realizó. Este tipo de respuesta es inaceptable, considerando que: 1.El problema persiste y claramente no fue solucionado de manera definitiva. 2.El recall original fue emitido para garantizar la seguridad y funcionalidad del vehículo, lo cual no se está cumpliendo. 3.Como cliente, esperaba un servicio honesto y de calidad, especialmente tratándose de un problema cubierto por un recall oficial. Solicito formalmente que este caso sea reabierto y revisado nuevamente, ya que mi confianza en la calidad de los servicios proporcionados se ha visto seriamente afectada. Espero que Ford y su concesionario asuman la responsabilidad correspondiente y brinden una solución definitiva al problema

The contact owns a 2021 Ford Explorer. The contact stated that while driving 55 MPH, the contact heard an abnormal sound, and the tempered stationary sunroof glass shattered without impact. The local dealer was contacted; however, the vehicle was not diagnosed or repaired due to the cost. The manufacturer was not made aware of the failure. The failure mileage was approximately 38,000.

When driving or on neutral the vehicle shakes between 1000rpm-1500rpm. During driving or stationary you can feel the vehicle vibrating when in that rpm range. Under load the car does feel a bit hesitant and tampers acceleration. They're is a TSB 22-2377 which may be related to this issue as well.

Recently brought my 2021 Ford Explorer with 100,000 miles in for what I thought was a wheel bearing issue. The mechanic reports the entire rear end is gone and needs to be replaced. I’ve owned at least 4 Explorers all driven well over 170,000 without ever having this issue. This car also spent the first 3/4 months I owned it at the Ford garage getting the electrical replaced and “brains”. The crash alert system malfunctioned as did the locking system.

The class three hitch receiver is well above an acceptable tolerance causing the hitch to move within the receiver and cause damage to the receiver. This abundance of "play" in the receiver was duplicated with a brand new hitch as well. My safety as well as others was put at risk through the risk of excessive torque being applied to the hitch/receiver through it's overly large size potentially causing it to break. This problem has not been reproduced or confirmed by a dealer nor been inspected. The part has not failed, but is likely to fail through continued use. ***Plastic deformation has occurred within the hitch receiver because of its excessive size.

While driving on the freeway, the customer experienced a power train failure, which resulted in the vehicle stopping. Though the vehicle was able to continue driving, it would unpredictably jump gears and eventually became immobile. The "service engine" wrench light first appeared on [XXX], signaling the issue. The vehicle was inspected by Curt Service in Oak Park, Michigan, and no additional codes were identified beyond the service engine wrench light. The power train system is available for inspection upon request. This situation posed a safety risk to the driver and others on the road, as the vehicle's sudden stop and gear issues could have led to an accident. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2021 Ford Explorer. The contact stated that while his wife was driving and was at a traffic light, the light turned green and the accelerator pedal was depressed; however, the vehicle stalled. The contact stated that there was no warning light illuminated. The contact stated that the instrument cluster was dark, and the vehicle failed to restart. The contact stated that his wife waited for approximately 15 minutes in the middle of the road. The contact’s wife was able to restart the vehicle and drove a local dealer. The vehicle had experienced the failure in November 2024 and the same dealer replaced the battery and replaced all four tires. The contact stated that the vehicle was diagnosed, and the dealer determined that the 12-Volt battery needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 30,000.

The contact owns a 2021 Ford Explorer. The contact stated that after parking the vehicle, there was an abnormal fuel odor inside and outside the vehicle. The vehicle was taken to the local dealer who diagnosed that the fuel hoses had ruptured due to the hoses making contact and rubbing together. The contact was informed that the fuel hoses needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure but offered no assistance. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 19V859000 (FUEL SYSTEM, GASOLINE). The contact indicated that the vehicle had experienced the failure listed in the recall. The failure mileage was 44,000.

Difficulty shifting gears, delayed shifting, slipping between gears, jerking motions during acceleration, and stalling when you move from a stop. Also leaking oil under transmission pan and makes noises in the transmission.

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V675000 (Power Train); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

I have had this problem ever since we Purchased this automobile on [XXX], When the car gets to a Quarter tank of gas or a little less the dash monitoring system says there's 87 miles left till empty and you park this car on a hill or incline with the front end facing down the car will not start and everything shuts down. The only way to restart it is to put more gas from a can in it or go through a long process to takes two people to do to get the car on a level area then it will restart. I call the Dealer abut it and they said there is no problem. The car had to be towed twice in the first few months we had it for this and as soon as they got it off the truck it would start and they do nothing about it. I call Fords Hot line and they said they know about the Problem but can't do anything about it , I was told that its a fuel pickup Problem. Today [XXX] my wife when to the store this morning and the fuel gage said it had a quarter tank of gas in it and when she came out of the store the car would not start for her. I had to go and get a 5 gal. can of gas and drive to where she was and put the gas in the car and after that the car started, she drove to the nearest gas station to fill it up. All I have been told to do by Ford and the Dealer is to keep the gas tank full and fill it when it gets to half a tank. There is definitely a problem with this car and it needs to be Addressed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2021 Ford Explorer. The contact's wife stated that while driving at an undisclosed speed, the vehicle lost motive power with a system shut-down message displayed. The contact also stated that the vehicle inadvertently shifted into park. The vehicle was able to restart after 30 minutes. The vehicle was taken to the dealer where it was diagnosed and determined that the tires had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 30,469.

The contact's son owns a 2021 Ford Explorer. The contact stated that while driving at 5 MPH down a hill and making a left turn, the hood was unintentionally released, swung open, and hit the front windshield causing it to shatter. There was an abnormal snapping or popping sound detected. The driver pulled over immediately since their view was obstructed. No warning lights were illuminated before the failure however after the hood shattered the windshield the "hood open sensor" light was displayed. The driver's pregnant fiancé was occupying the front passenger's side seat and sustained injuries and pain to her left side. There was glass in her lap, and medical attention was provided. The vehicle was towed to the local dealer but was not diagnosed or repaired. The manufacturer was notified of the failure and referred to the NHTSA Hotline. The approximate failure mileage was 55,401.

The contact owns a 2021 Ford Explorer. The contact stated while coming to a stop, the vehicle stalled with an engine misfire. The contact stated there was a knocking sound coming from the engine with the check engine warning light illuminated. The vehicle was restarted; however, the failure recurred. The vehicle was taken to the dealer where it was diagnosed that valve springs in the engine cylinder needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and confirmed that the VIN was not included in NHTSA Campaign Number: 24V635000 (Engine and Engine Cooling). The contact was referred to the NHSTA Hotline for assistance by the manufacturer. The approximate failure mileage was 74,000.

Steering is sticking

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V635000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated prior to the failure, the oil was changed 2-months prior at approximately 27,000. The contact stated that while driving at an undisclosed speed, there was an abnormal knocking sound coming from under the hood. No warning light was illuminated. The vehicle was towed to a local dealer where it remained for further diagnostic tests. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 31,000. VIN tool confirms parts not available.

My vehicle, a 2021 Ford Explorer ST, still hasn't had NHTSA Safety Recall 23V675 repaired. Even though the parts for the repair have been available to the Dealer for almost a year or more, they can't do the repair because they don't have the special tools required for the repair. The Ford Motor Corporation hasn't provided the Dealership with the tools. I've checked other Ford Dealerships in my area and they too say that they don't have the tools needed to do the repair and they can't get them from Ford Motors. I've called Ford Motors to complain and they tell me it's the Dealerships problem as the parts are available to the Dealerships. I've asked to speak to management but they won't let me. So, over a year has gone by and still no tools have been sent to my Dealership, Chuck Stevens Ford in Bay Minette, Alabama.

On [XXX], I was driving to my destination. I looked in the rear view mirror and saw a large amount of grayish smoke coming from both tailpipes. Less then 1 mile after that, the Explorer was unable to accelerate. The vehicle was towed to Don's Ford in Utica NY where on October 8th they diagnosed the problem as a blown turbo within the engine. There were no symptoms that illuminated in the vehicle, made any noises and/or other issues that would have prompted me that there was a problem. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2021 Ford Explorer. The contact stated that occasionally the front driver’s and front passenger’s side windows failed to respond while depressing the switch. The contact stated that the failure was recurring and was previously repaired by the dealer. The vehicle was taken back to the same local dealer and remained at the dealer for the repair. Additionally, the contact stated that the local dealer was unable to duplicate the failure. The manufacturer was made aware of the failure. The failure mileage was approximately 18,600.

Been dealing with this backup camera blue screen for the last year. I pay too much money for this not to be working. Someone came out yesterday to fix it but it’s still doing the same thing.

The contact owns a 2021 Ford Explorer. The contact stated that the power liftgate failed to close as needed. The contact was able to manually close the liftgate. Additionally, the roof was leaking near the sunroof and roof rails. There were no warning lights illuminated. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 58,000.

I am writing to provide an update on the status of the recall (23V675) repair for my vehicle. Over a year ago, I was notified of a safety recall that affects my vehicle, making it unsafe by the standards set by the NHTSA. This issue, if not addressed, could cause a loss of the vehicle's forward power and significantly increases the risk of a crash or injury. Since receiving the recall notice, I have made multiple attempts to schedule the repair with the local ford dealership. Despite my efforts, I am still waiting for the necessary parts to become available, and the dealerships have been unable to provide specific date for when the repair will completed. I am concerned about continuing to drive a vehicle that is currently considered unsafe and poses a heightened risk to myself and others on the road. I am seeking assistance or guidance you may be able to provide to expedite the repair process and ensure that this safety issue is resolved as soon as possible. Thank you for your attention to this matter. I look forward to your prompt response.

[XXX] after driving less than 10 min. warning signs flashed on screen. I immediately pulled off the road where the vehicle completely shut down and realized my 2021 Ford Explorer was on fire. Bystanders attempted to put the fire out with fire extinguishers but were unsuccessful. My passenger and I opened our doors, I exited and attempted to open trunk to remove wheelchair but could not (because door is electrical). My passenger flung himself onto the ground until bystanders came with a rolling office chair to remove him away from the burning vehicle. Had the bystanders not been there I do not know how I would have been able to move my passenger (25 year old, 200 lb male) away from the burning vehicle. Fire Marshall could not determine cause of fire because vehicle was completely melted/too damaged. Ford Motor Company reviewed photos I sent to them but claims they could not determine cause of fire. The vehicle was properly maintained with routine oil changes. There were no issues with the vehicle prior to this incident. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owned a 2021 Ford Explorer. The contact was stopped at an intersection traffic signal when she was crashed from behind by another vehicle. The contact's seat belt pretensioner failed to lock and was not able to restrain her. The contact's face hit the steering wheel. The contact had suffered a broken nose, and bruises on her arms. The contact was transported by ambulance to a hospital. The vehicle had extensive crush damage to the rear bumper, lift gate. The vehicle was towed to an impound lot and later declared a total loss by her insurance provider. The police were on scene and issued a report. The manufacturer was informed of the failure. The failure mileage was 36,606.

The contact's spouse owns a 2021 Ford Explorer. The contact stated that while driving at approximately 68 MPH, the L-trim retaining strip detached from the driver's side door. The vehicle was taken to the residence. The vehicle was then taken to a dealer where it was diagnosed that the L-trim molding and the retaining strip needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 33,000.

The contact owns a 2021 Ford Explorer. The contact stated while driving at an undisclosed speed, the rear axle bolt fractured. The contact stated that the failure occurred while driving on a busy highway. The vehicle was towed to the dealer; however, the vehicle was not diagnosed or repaired. The contact received notification of NHTSA Campaign Number: 23V675000 (Power Train) however, the part to do the recall repair was unavailable. The contact stated that the vehicle was scheduled for the recall repair; however, the recall repair was not completed. The contact was informed that the recall repair was not completed due to the tool not being available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was 40,093. Parts distribution disconnect.

Part 573 Safety Recall Report 23V-675 The recall that is has been applied causes safety issues with the car when driving forward or in reverse. When putting the car into park the parking break auto applies. Now that is great however.. When putting the car into reverse or drive it does not release until the accelerator is applied. Now the problem is that the electric parking brake is delayed vs the acceleration causing the car to jerk forward or in reverse when the accelerator is applied. It acts like your trying to do a burn out holding down the break and it releases. This is not safe. A worker at the dealer almost rear ended a power pole in the parking lot because of this. My suggestion is to have the electric parking brake disengaged automatically when the car is put into drive or reverse. This will keep the protection of the electronic parking break being applied while in park and allowing smooth transition back to drive and reverse. Why has this issue been brushed under the rug..

Air compressor fails while leaking Freon all over the engine creating an environmental hazard.

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V675000 (Power Train); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and offered to buy back the vehicle. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2021 Ford Explorer. The contact stated that the vehicle was hard to shift and there was a delay while shifting from first gear. The vehicle hesitated while shifting. While at a stop, the vehicle hesitated and was slow to shift into gear. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed, and the turbo charger was reset. The vehicle was repaired, but the failure recurred. The manufacturer was contacted, and informed the contact that there was no warranty coverage on the vehicle. There was no assistance provided. The approximate failure mileage was 46,000.

The contact owns a 2021 Ford Explorer. The contact stated while driving approximately 60 MPH, the contact observed that the driver’s side A-pillar trim had detached. The vehicle was steered to the side of the road and trim taped down. The vehicle was taken to a dealer where it was diagnosed that the A-pillar trim needed to be replaced. The vehicle was not prepared. The contact believed that the failure was associated with NHTSA Campaign Number: 24V031000 (Structure); however, the VIN was not included. The manufacturer was notified of the failure. The failure mileage was approximately 52,000.

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V675000 (Power Train) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. The manufacturer was not made aware of the issue. Parts distribution disconnect.

All of the ADAS along with the brakes of my vehicle fail. The dealership failed to inform me of the recalls prior to purchase. The dealership in town shows all of the parts in stock in their parts department but claim not to have any parts available. When I called, I was given the runaround then sent to a voicemail. When I showed up to the dealership they stated they can only order certain amount of parts and I wasn’t on the list yet was told over the phone I was placed on the list on May 22 2024.

The contact owns a 2021 Ford Explorer. The contact stated while driving at an undisclosed speed, the exhaust pipe detached and fell onto the ground underneath the vehicle. The vehicle was towed to the residence. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact researched online and discovered Customer Satisfaction Program: 21B35 (Certain 2020 Model Year Explorer Police Vehicles Equipped with a 3.0L EcoBoost Engine Right-Hand Catalytic Converter and Right-Hand and Left-Hand Exhaust Flexible Pipe(s) Inspection); however the contact was informed that the vehicle could not be repaired under the program. The manufacturer was made aware of the failure. The failure mileage was approximately 53,300.

The contact owns a 2021 Ford Explorer. The contact stated that while reversing, the back over prevention camera screen display was inoperable. The contact stated that a blue screen was displayed creating a visibility hazard for the driver. The cause of the failure was not yet determined. The contact was informed that the VIN was not included in NHTSA Campaign Number: 23V342000 (Back Over Prevention). The vehicle was not repaired. The contact stated that the vehicle had experienced the failure listed in the recall. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The failure mileage was 34,600.

Was trying to get gas and the door to the gas lid would not open. Waited for over an hour for someone to help me. Get the door open. Only had 10 miles to empty and the closest town is 20 miles.

The panel next the windows on both sides are cracking. The dealer said they need to be replaced on my dime. After doing a search for this problem, it appears that this is a common problem. It appears to be an issue with the seal and hot/cold weather creating the issue.

I had my car towed to mechanic because transmission would go into park. He ran a diagnostic and found multiple codes (mechanics Bill and list of codes he found will be included) relating to transmission. He searched on a data base he uses Shopkey.pro(copy of recall will be included) to check on recalls. He requested I have car towed to Dealership. I did that and the dealer has a letter about the recall(also included) showing the recall. My car falls in all the parameters of this recall. The vehicle year, the assembly plant and the build date as well as the 2.3L engine and a 10R60 transmission. The dealer says my vin number doesn't fall under this warranty and he doesn't understand why. He said I fit all parameters and Im experiencing all the reasons listed for this recall. Most importantly car can roll in park which is safety. It also had on occasions loss of motive power while driving. These are all reasons listed for this safety recall and as the dealership I am lost as to why the NHTSA and ford doesn't have my VIN included in this saftety recall,. I would like you to review this complaint and hopefully understand my vehicle should be included in this safety recall. There are numerous safety concerns with everything wrong. Please take careful consideration of all that I submitted and properly add this vehicle..2 safety Warnings messages I received are transmission not in park and please apply emergency brake before exiting the vehicle.

While driving down the interstate, the tires (rear passenger?) suddenly locked/stuck. This caused vehicle to lose control, 360, and slam into the guardrails. Prior to this incident, when the car was turned on, it stalled a bit like it was about to turn off. This lasted for a few seconds, but returned to normal. So may be a component of electrical and/or directly related to the rear tire. There were no warning messages. Driver was thankful injuries did not occur. Could have flipped, or slammed into other cars, trees, etc. This is a serious issue. While the vehicle was being loaded onto the wrecker, in neutral, the rear passenger tire was visibly stuck. This was observed by owner, husband, police officer and tow company. When offloading from the tow truck, the tire made a loud pop and movement returned to normal. Vehicle is currently at the shop (ford dealership). Will have more information next week from their diagnostic studies. It is available for inspection upon request.

I was driving and hood flew up and hit the windshield and caused it to cave inward despite hood not being popped since April. Dealership confirmed that hood was not popped that day according to censors and codes that were seen. I was unable to see and it could have caused a wreck and serious injury or worse the windshield almost fell on me and into my car with my one year old baby. Dealer confirmed latch was never popped. Therfore resulting in a malfunction with the hood. Vehicle has been inspected by dealership service center. No, there were no signs or indicators prior to the incident. The indicators did not illuminate until test at the dealership although they did not the day of the incident (confirmed by dealership service department)

Ford Explorer 2021 recall stems from a defective rear axle horizontal mounting bolt. Ford Motor Company has promised to cover the cost of replacing the subframe bushing and the rear axle bolt and repairing any resultant damage. The dealer, Payne Ford Weslaco, the Tech broke a tool to fix and Ford has failed to replace said tool.

On June 3, 2024, vehicle was taken to dealer for rattling noises under truck close to front passenger side and state inspection. Dealer informed flex pipe was rattling and offered repair. Repair declined. Dealer/service department emphasized vehicle was safe to drive, no impact on performance or safety. On June 18, 2024, while pulling up to home, metal noises were heard under car. Observed a pipe hanging from under car near passenger front. Towed to dealer. Informed on June 19, 2024, “flex pipe” needs replacing. Thank you

The contact owns a 2021 Ford Explorer. The contact stated that while the vehicle was idling at a traffic light, the vehicle made an abnormally loud sound. The vehicle was taken to the dealer the following day. The dealer diagnosed that both exhaust flex pipes had failed and needed to be replaced. The dealer informed the contact that it was a known failure. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 60,000.

The contact owns a 2021 Ford Explorer. The contact stated while attempting to shift into reverse, the contact became aware that the rear-view camera showed a blue screen. There was no warning light illuminated. The dealer was contacted; however, the vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 32,000.

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V675000 (Power Train); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

I have a catastrophic engine failure. The dealership (Doherty Ford) in Forest Grove Or acknowledges it. They are working with me. However, Ford has not responded to the dealers request for warranty work. It will be two weeks since I took the car to the dealer with a loud ticking noise. Dealer found a BUNCH of metal in the oil. I'm waiting to hear how Ford will fix it. The car has 45k on it. They also gave me an extended warranty because of all the issues I had with the car when I first got it. The [XXX] steering coupler to the rack was loose and almost came off when I drove it home. I have had a number of other issues. All dealer repaired. The car has also been to Doherty Ford almost exclusively for all its oil changes. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2021 Ford Explorer. The contact stated that while driving 70–75 MPH, the vehicle lost motive power and stalled. There were no warning lights illuminated. The vehicle was towed to the local dealer but was not diagnosed or repaired. The manufacturer was not contacted. The approximate failure mileage was 54,500.

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V675000 (Power Train); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and informed the contact that parts were available; however, the dealer failed to schedule an appointment. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V675000 (Power Train) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

rear axle bolt snapped that holds the rear differential to the subframe. there was already a recall on this before and my explorer had it snap before. this is the second time it snapped in less than two years.

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V675000 (Power Train) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V675000 (Power Train) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

On April 28, 2023, while driving our Forf Explore, we smelled gasoline from our vehicle. We immediately stopped at the next exit, and my husband looked under the vehicle and saw gas dripping from under the engine. We immediately went to the nearest Ford dealership where the vehicle had stayed for a week. We were advised that the leak was one of the metal fuel lines that rubbed onto the frame and caused the leak, also the engine light code was due to the small hole in the fuel line. Which we had taken to a Ford dealership previously due to the engine light on, but they cannot detect the problem. We have contacted Ford Headquarters via phone and mail for further assistance. And up to today, which is April 15, 2024 we have never received a response from Ford Headquarters. This was a very scary situation, which could’ve caused a vehicle fire.

The recall to replace the rear axle bolt was completed and new boil installed. They left the automatic emergency brake program engager which results in the vehicle lurching forward or backward when shifted into gear and results in collisions with other vehicles as the collision detection system is not working.

My driver side cv joint went out Dec 2023, noticed grease, throwing while a tire rotation was being done. April 2024 was completing a oil change and we decided to check the passenger side and now that CV joint is going out as well. This vehicle has less than 30,000 miles on it.

The vehicle looses power occasionally. When the accelerator is pressed it can take a second or 2 to start moving again. It happens when turning, changing lanes or going straight. I could be pulling into traffic and it will stop moving, even if the gas pedal is pressed down all the way. It will happen in every drive mode and when the traction control is off. The only time it hasn't happened yet is when I turn off the AdvaneTrac stability control. I have to hold down the traction control button for 5 seconds every time I start the vehicle. The dealer said they couldn't find the problem. The associate said it's a common issue with the Explorer's. It is very dangerous.

The contact owns a 2021 Ford Explorer. The contact stated that while driving at an undisclosed speed, the audio connection failed to function as intended. The contact stated that there was no audio power. The vehicle was taken to the dealer and the contact was informed that the radio audio connection was in the rear hatch of the vehicle and that water had been leaking into the rear hatch of the vehicle. The vehicle was not repaired. The manufacturer was made aware of the failure and agreed to assist with sixty-five percent of the repair cost. Additionally, the contact was advised to report the failure to the NHTSA Hotline. The failure mileage was 33,000.

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V675000 (Power Train) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

25,000 miles on it, transmission failed on my husband and I as we were pulling out onto a busy street. The car jerked forward and shot us out half way before locking completely as a semi truck was coming and almost smashed into the side of us. Luckily we were on a hill and were able to put the car into neutral & was able to roll back at the last second before we were severely injured. Car was towed to dealer as it would not drive at all. Dealer had for 3 weeks before coming back and saying the fluid was low and discolored and had several burnt clutches..again only has 25,000 miles on it..replaced the clutches and told me I was good to go. 7,000 miles later car AGAIN jerks me as im on a busy street and then completely loses all power and will not accelerate, I was barely able to pull over into a business parking lot before almost getting rear ended because I was going 30mph UNDER the speed limit!!! I didn’t even have to exit my vehicle because I could smell the burnt trans fluid from inside the cabin! Getting towed to dealer in 2 days.. this is a MAJOR SAFETY CONCERN! I have almost gotten hurt TWICE by this defect with the 10r80 transmissions! This is serious and ford needs to start addressing this problem before someone seriously gets hurt!!!!

While driving around 45 miles per hour the vehicle braked on its own without any vehicle in front and dropped to 5 miles per hour, the dash displayed Brake Assistance. While that happened a car behind me came close to rear-ended my car. At this time the vehicle is at the dealer, it was towed. This is the first time this happened, the vehicle showed no warning before the incident. The fact the vehicle behind came so close to rear-ending my car makes this a safety concern, if this happened at a higher rate of speed the consequences could have been more serious.

See attached document for complaint

When shifting from drive to reverse, there is a significant lag in shifting (3-5 seconds). This is especially dangerous when needing to back into a driveway from a busy road.

I hope this letter finds you well. I am writing to you regarding a persistent issue I have been experiencing with my 2021 Ford Explorer For some time now, I have noticed a loud sound when braking and when navigating obstacles such as speed bumps or when entering and exiting the ramp of my parking lot. Concerned about this situation, I took my vehicle to the service department at your dealership, where I was informed that there was a recall to replace a part related to this issue. I appreciate that you have identified and committed to addressing this problem through the recall. However, I am concerned that despite more than one or two months having passed since my initial visit, I have still not received any notification regarding the availability of the necessary part for the repair. This delay has been particularly frustrating as the problem persists and even seems to have worsened over time. The loud sound when braking and navigating obstacles is becoming increasingly pronounced, significantly affecting the driving experience and my safety on the road. I understand that manufacturing and distribution processes can be complicated, but I need an urgent solution to this problem. As a loyal customer of your dealership, I trust that you will take the necessary steps to resolve this situation quickly and effectively. Since my vehicle is my primary means of transportation, I strongly request that you expedite the repair process and keep me informed of any developments related to the recall and the availability of the necessary part. I look forward to receiving a prompt response and a satisfactory solution to this problem. I appreciate your attention and prompt action in addressing this matter.

My vehicle started to put up messages regarding going into power saver mode. The vehicle then said all wheel drive not available. After that electrical components started going unavailable such as power steering, brake assist, blind spot monitoring, cameras, and traction control. The vehicle then shut down while driving and all I could do was brake. When I attempted to restart the vehicle it did not restart. I jumped it and was able to safely pull it off the road. This is the 2nd time in three weeks this happened. Ford looked at the vehicle and tightened the battery cables. Then told me it was fine.

Roof trim blew off. Moon roof- yes Luggage rack- no Driver side

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V675000 (Power Train) however, the part for the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time to for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

While making a left turn on a city street there was a loud bang noise and a sudden shift of the rear of the car. The bang noise was immediately followed by a loud grinding noise (sounded like metal on metal). There was a sudden loss in power, and I was only able to drive the car a short distance to get to the side of the street. When the car was put in park, the car rolled downhill without resistance. The car was towed to a Ford dealer for repairs. The dealer's repair shop drained the fluid from the rear differential and found "large chunks of metal." The repair required the replacement of the rear differential. Had this event occured on a busy street, it could have resulted in a vehicle accident. The loss of vehicle control when the vehicle was placed in "park" could have also been a safety risk. This event is similar to the Ford recall of the Explorer for a rear axel bolt fracture (NHTSA recall 23V-199 and 22V-255). My vehicle VIN # has not been added to the recall list, therefore, Ford has refused to consider reimbursement for the cost of the repairs. I would like the NHTSA to consider adding my VIN# to the recall for this design defect.

The contact owns a 2021 Ford Explorer. The contact stated that the third-row seats were inoperable. The contact stated that the passenger’s and driver’s side seats were frozen in a semi-folded-down position and were not responding to the electronic control switch. The contact stated no warning light was illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the seat control unit needed to be replaced. The contact was advised by the dealer that the seat failure was a known failure; however, the vehicle was no longer under warranty. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was 40,438.

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V342000 (Back Over Prevention) however, the part to do the recall repair was not yet available. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that the camera intermittently failed, causing a visibility hazard for the driver. The failure mileage was 60,000. VIN tool confirms parts not available.

There was no incident yet. This concerns the ballistic panels mounted in the two front doors, the mounting tabs break and are broken in this vehicle and there is a TSB but Ford refuses to fix because they claim it's not a "Safety" issue which it is and because it has a salvage title. This needs to go to a recall or customer satisfaction "Safety issue". "SSM 51945 2020-2023 Police Interceptor Utility - Level III Ballistic Panel Mounting Tab Service Kit Now Available". "2020-2023 Police Interceptor Utility vehicles may require level III ballistic panels to be replaced due to broken mounting tabs. Level III ballistic panel mounting tab service kits are now available (right LB5Z-78201B68-F and left LB5Z-78201B69-F). Replacement of the level III ballistic panel assembly is not required for this condition. Level IV ballistic panels do not have removable mounting tabs and still require complete panel replacement. Level III vs. level IV ballistic panels can be identified by a large roman numeral label on the panel or by the vehicle window sticker if equipped".

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V342000 (Back Over Prevention) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that the back-over prevention camera intermittently failed to operate as needed while in use. The failure mileage was approximately 30,000. VIN tool confirms parts not available.

My complaint relates to: Manufacturer Recall Number: 23S23 NHTSA Recall Number: 23V342 INTERMITTENT EXPERIENCE OF A REAR CAMERA BLUE ON THE SYNC SCREEN WHEN THE VEHICLE IS PLACED IN REVERSE and notification that rear parking assistant is disabled. Per January 2024 I received a notification that a remedy is available (replacement of rear camera and software update of SYNC). The dealership was not able to perform the remedy as they told me that the Accessory Protocol Interface Module (APIM) showed error codes and could not be updated. I was told to replace the APIM on my own expenses of ~$1,800. I am not willing to pay for a hardware replacement as I strongly believe that the APIM was defected by two prior updates: 1. prior effort of Ford to solve blue screen issue via software update and 2. a subsequent botched Over-The-Air update to version 22251 which is know to having bugs and causing APIM issues according to various Internet forums: [XXX] [XXX] [XXX] [XXX] So I have a security relevant recall that won't be fixed unless I pay. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The startrover run clutch or whatever went out and they said it was bumper to bumper, not powertrain warranty! Don’t make any sense to me , the starter has to dtart everthing for there to be power and it’s attached to everything that’s powertrain related!

When driving at low speed, every uneven thing in the road surface creates a low resonating frequency sound (deep base) through out the cabin.

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V675000 (Power Train) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2021 Ford Explorer. The contact stated that the passenger’s side rear door glass fastener installed between the V-shaped glass and the door glass had fractured. The vehicle was taken to the dealer. The contact was informed that the passenger’s side rear door glass fastener needed to be replaced. The contact was informed that the repair could not be covered under warranty. The vehicle was repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 30,000.

Both rail roof luggage racks on roof are loose. Flap at high speeds. Ford advises it's not covered.

My digital dash would get wavy and flickery with lines through it almost like the LEDs in the screen we're going bad. They made lines going across which made it hard to read the speedometer. Since I brought this up it's been two or three times that I've tried to have them look at it and they finally saw what was going on and they decided that they were going to replace the instrument cluster in the dash and since they replaced it it has been fine. Also I am on battery number for due to the vehicle going in battery saver mode every time the battery starts to go bad and Ford has yet to figure out what is going on with my vehicle that is causing me to have bad batteries and causing it to go in the battery saver mode to preserve power within hours of the vehicle having been driven.

P25B4- TURBOCHARGER/SUPERCHARGER WASTE GATE (A) STUCK CLOSED P0299- TURBOCHARGER/SUPERCHARGER UNDERBOOST POWERTRAIN AND 4-WHEEL DRIVE IN-OPERABLE, TURNED ON VEHICLE TO DRIVE AND IMMEDIATELY THREW THE TWO CODES ABOVE. FORD SAYS THIS IS NOT A COVERED ISSUE.

FELT LINER ON THE BOTTOM OF VEHICLE HAS COME OFF WHILE DRIVING 3X. IN SNOW AND RAIN WITH FREEZING TEMPERATURES THE FELT LINER GETS WET AND HEAVY AND TIED UP IN THE TIRES. THE DESIGN AS WELL AS THE BOLTS CONTINUOUSLY FAIL.

The rear windshield shattered as I was driving. I did not hit anything, nor did anything hit the rear window. The temperature is -3. I had the defroster on and think the extreme cold mixed with the defroster caused the window to shatter. Is the glass faulty? Or the defroster?

Front windshield cracked n has expanded along the very bottom in the dark black area n spread up into clear glass for no reason whatsoever. Never heard a rock or anything else hit. One day it just started a small looping crack.

Strong egg odor from exhaust when temperature is below 0 degrees C or 32F. This is especially the case then the car is started and left to warm up for 5-10 min. The smell goes away after 15-20min.

With the Ford Intelli-Cruise enabled in settings, the vehicle automatically adjust the speed while using the cruise control. The vehicle will randomly, quickly, accellerate to a extreme new speed limit it thinks it has detected. For instance, several times while travelling on I-81, with a 70mph speed limit, the vehicle will think the new speed limit is suddenly 85mph and quickly accelerate to that speed. I have attached a photo of the dash displaying that setting the car set by itself. On the flip side, once on I-81, it thought the speed limit was 35mph and quickly slammed on the brakes to slow to 35mph from 70mph. Both are quickly overridden by the driver tapping the brake and cancelling the cruise control. However, both could lead to hazards to other drivers potentially resulting in a wreck, especially the sudden slow to 35mph on the interestate. The dealership says "Yea, it happens and people complain". I have no idea why the speed changes, there are no road signs or other indications to even cause the system to re-evaluate its settings. Ford says Intelli-Cruise uses road signage and other ways to also determine speed (whatever that means). This is a safety issue that needs to be remedied by Ford. However, without NHTSA enforcement, they don't seem interested in resolution. (This website isn't allowing me to upload the .jpg file, upload button disappears when I click it)

Vehicle blinker works at fast rate at all times. In the event that one of the rear turn signals stops working, the vehicle will not adjust the turn signal flash rate frequency to warn the driver that a turn signal is not working correctly. Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment." Ford says 'fast' blinker on all Explorer ST's is by design and normal.

11/9/23 our still under warranty, 2021 Ford Explorer Platinum with 20,152 miles on it died at stop sign and would not start. Locked in park and had to be towed to dealer who worked on it for one week and claimed it was fixed. Same problem second time a few days later and dealer claimed it was lose wires and returned to us on 11/28. This last time (happened at a very dangerous onramp location and I thought I was going to get hit by another car while waiting for the police to arrive) they have had it since 12/4 and can not diagnose or fix the problem despite claiming to have done numerous things. Ford (Detroit) CS has been of zero help and will not loan us a car or rent one for us to use. We are supposed to be leaving in a few days for our Florida residence for 4 months without our car being fixed. We have had the car a total of 10 days out of the last 51 and with the holiday weekend being tomorrow and Monday it will be 53 days. I have read about numerous Ford Explorers having this same problem and never getting fixed correctly, only to have repeated software issues. How much is enough for a consumer to finally have protection. Lemon Law has expired and I can not find any information for consumers in our current situation. Please advise. We are [XXX] and this is very stressful to say the least. Thank you! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2021 Ford Explorer. The contact stated that while reversing, the vehicle suddenly shifted into park, after which the vehicle went into LIMP mode. After restarting the vehicle, the vehicle was unable to shift out of park and displayed the "Automatic Emergency Braking Unavailable" message. The traction control, start-to-stop, and hill start assist warning lights were illuminated. The vehicle was taken to the dealer, who was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 30,500.

The contact owns a 2021 Ford Explorer. The contact stated that the screen display was blue and black and became inoperable. While reversing, the screen was blue. The contact was unable to use the GPS feature. There were no warning lights illuminated. The contact called the local dealer, and the contact was informed that the vehicle could be repaired under warranty. The system showed that the screen had connected and disconnected. The vehicle was not repaired. The contact stated that the failure was related to NHTSA Campaign Number: 23V342000 (Back Over Prevention). The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 42,000.

The oil crank case is getting fuel inside. In approximately 1000 to 1500 miles there is a 1 quart and a half of fuel in the oil making the oil level overfill. This oil diluting the fuel issue. Seems like it could be a safety issue if it continues to pour gasoline into the oil crank case. My local Ford dealer, Gary Yomans Ford in Daytona Beach Florida. Verified the concern and told me there’s no repair available yet. The technician further stated that it will eventually destroy the engine from the inside. This issue only started this year. There is at this time 30,959 miles on the vehicle.

The contact owns a 2021 Ford Explorer. The contact stated while driving approximately 30 MPH, the contact heard an abnormal sound coming from under the floorboards. The contact slowed the vehicle to listen for the sound, when the contact depressed the accelerator pedal to move forward, he heard the abnormal sound and described it as the sound of a motorcycle exhaust. The contact stated that he drove forward for a few minutes more when the abnormal noise from under the vehicle was louder and he felt that some object was trapped underneath the vehicle and was hitting the underside causing a loud banging noise. The contact stopped the vehicle and looked underneath the vehicle and observed that the passenger’s side exhaust pipe had detached from the catalytic converter. The contact then checked the driver's side and saw that a crack had opened approximately one inch from where the exhaust pipe was connected to the catalytic convert. The contact stated no warning light was illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the damage appeared to have been made during an attempt to steal the catalytic converter and referred the contact to a muffler specialist. The vehicle was not repaired. The contact took the vehicle to a muffler repair shop where it was diagnosed that the exhaust pipes had rusted, and the passenger’s side exhaust pipe had detached from the vehicle. The contact did not believe that the rust was the cause in the fracturing of the exhaust pipe from the catalytic converter. The contact researched online and related the failure to manufacturer Customer Satisfaction Program Number: 21E11 Emission Recall (Engine). The manufacturer was informed of the failure. The failure mileage was 58,691.

I haven’t been problem with the parking !When I set the packing bottoms it’s turns automatically into rear I already have an issues with that !! almost kill my son an nephew I’m scared this happened again in the parking lot at store almost crash other vehicle! I need my car fixed as soon is possible I hope I hear from your side! Thank you!!!

I already having problem with the parking !When I set the packing bottoms it's turns automatically into rear I already have an issues with that!! almost kill my son an nephew I'm scared this happened again in the parking lot at store almost crash other vehicle! I need my car fixed as soon is possible I hope I hear from your side! Thank you!!!

The contact's daughter owns a 2021 Ford Explorer. The contact stated that while his daughter was driving from a complete stop in a parking lot, the vehicle stalled. A message indicating a transmission failure was displayed. The vehicle failed to restart and was towed to an independent mechanic. The vehicle was not diagnosed and was towed to the dealer to be diagnosed. The dealer informed the contact's daughter that a diagnostic test cost would be charged because the vehicle was out of warranty. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 46,000.

The contact owns a 2021 Ford Explorer. The contact stated that while attempting to accelerate after coming to a complete stop, the vehicle briefly lunged forward. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 23V675000 (Power Train) the VIN was included but parts were not yet available. The manufacturer was not notified of the failure. The failure mileage was 15,000.

The contact owns a 2021 Ford Explorer. The contact stated that while reversing, the rearview camera image was blue. The vehicle was taken to the dealer, where an unknown software update was performed; however, the failure persisted. The contact later received notification of NHTSA Campaign Number: 23V342000 (Back Over Prevention) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 28,000. VIN tool confirms parts not available.

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V675000 (Power Train) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Two TPMS sensors have failed on this vehicle. Although these sensors are required under the TREAD act, Ford has advised through their dealer that this is not a safety issue and the TPMS sensor batteries failing less than 3 years from date of vehicle manufacture falls in the category of normal wear and tear. Note that the vehicle has 27,243 miles on it, and these are the original TPMS sensors/wheels/tires that the vehicle came equipped with from Ford.

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V675000 (Power Train) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 21V735000 (Back Over Prevention), 22V255000 (Power Train), and 23V675000 (Power Train) however, the parts to do the recall repairs were not yet available. The local dealer was contacted and determined that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V635000 (Power Train) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and confirmed parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

UNKNOWN My rear axle bolt may fracture. and this repair still has not been done. and Ford doesn't know. when the part will be in, I'm in fear. for my safety.

I have a 2021 Ford Explorer ST that I purchased as a new vehicle. On 8/27/23 I was driving my vehicle to work. I noticed a loud humming noise upon acceleration when I was approximately 1 mile from work. I drove my car to work, parked it. I attempted to get a Ford dealership to service my vehicle and was informed that it would be "3-4 weeks before they could even look at the vehicle" (Siloam Springs Superior Ford). I managed to find a repair shop 2 miles from the hospital that I work at. As I was driving the vehicle to the shop for repair- the loud humming noise upon acceleration was still present- something very loud fell out from under my car. The right side catalytic converter (a pipe several feet long) was hanging down under my car. I am thankful I was driving at a speed <15 mph and not on the highway. The car was repaired (I have attached the receipt for the repair). Upon further research I found that there were other ST Explorer and regular Explorer models with a customer "courtesy repair" that was offered. No such repair was offered to me. I called in a report to the Ford Dealership (general 1-800- 392-3673 line). I received the case #[XXX] at the conclusion of that call. I brought my car into the shop (Lewis Ford Fayetteville), as per Ford's recommendations, to inquire about reimbursement for my issues- since they are the same issues mentioned in the courtesy repair notice. I was not previously notified of a courtesy repair. Lewis Ford informed me that despite my issue being exactly the same issue noted in the courtesy repair- my VIN number was not a part of the repair. This is a dangerous issue. I am certain that if I was at a higher speed level- my car would have been wrecked. According to the repair shop, they have seen and heard of this same issue with Ford Explorer ST models. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owned a 2021 Ford Explorer. The contact stated while driving approximately 25 MPH he depressed the brake pedal to slow for a traffic signal and the vehicle experienced brake failure. The contact stated no warning light was illuminated. The contact drove over the median to avoid crashing into vehicles directly in front of his vehicle. The contact stated that he was pumping the brake pedal however, the vehicle seemed to accelerate independently. The contact stated that he attempted to shift the vehicle into neutral(N) however, the shifter dial would not move. The contact stated he had attempted to turn the vehicle off but could not turn off the vehicle. The contact stated he was finally able to stop the vehicle prior to crashing into traffic directional poles. The contact stated that the Police arrived on the scene and wrote a report. The contact had the vehicle towed to a dealer who diagnosed the vehicle and determined that the driver's side front shock absorber was damaged and needed to be replaced. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 22,000.

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V675000 (Power Train) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated while driving approximately 60 MPH, the vehicle started to vibrate. The contact stated that there were no warning lights illuminated. The contact stated that she drove the vehicle to a dealer and was informed that the failure could not duplicated. The vehicle had not been repaired. Additionally, the contact stated that when the vehicle was shifted into park(P), the parking brake automatically activated, and the contact did not manually set the parking brake. The failure mileage was approximately 28,000. VIN tool confirms parts not available. The contact took the vehicle to recall repaired and adjustments needed from the previous recall . The dealer stated the recall repair could not be done because they did not have the tool to perform the repairs. When the vehicle was delivered, it was detached from the part of the third row seats.

In relation to NHTSA Recall Number: 23V342, Ford has failed to remedy issues around reverse Automatic Emergency Breaking. Whenever the 360° camera screen is blue, the system in place to prevent collisions also fails. There is no pattern of failure. Nearly 60% of the time the vehicle is driven an error related to 23V342 occurs.

I bought my 2021 Ford Explorer brand new and at 44,675 miles my shock absorbers went bad. There was no damage to my vehicle that could have caused it, my car was never in an accident. The dealership that repaired them said there was no indication of what caused it and it is highly unusual. Driving without shocks on my vehicle caused the loss of ability to control the rate of weight transfer when going around corners; this also resulted in increased steering input to navigate turns and uneven tire wear.

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V342000 (Back Over Prevention) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that the image displayed was distorted whenever shifted into reverse. The failure was intermittent at first but became a constant failure with the screen displaying a blue image while shifted into reverse. The failure mileage was 55,887. VIN tool confirms parts not available.

I do realize there is a Recall for Back-up camera; which I've had issues with since early part of 2022 (we bought vehicle in April 2021). March of 2022 we had our suv to dealership about screen turning blue; which they supposedly did some deprogramming. Then, in July of 2022 had it back to dealership because the blue screen became worse; in which they said they replaced the whole system ( I have receipts/documents to prove this). Well, now when in Reverse we have blue screen or black. Occasionally when in drive while driving or sitting idling the screen either is blue, black or completely freezes to where none of options such as Navigation, hands-free calling, or anything can be done/used. I have video footages, I have pictures and the matter is only getting worse! I have called Ford Corporation, I have taken the suv recently to local dealership and just keep being told that all that is connected to back-up camera; THAT THERE IS NOTHING THEY CAN DO!! The Ford Explorer has had many electrical issues ranging from 3rd row seat (have receipt/documentation of this), to at times air/heat not wanting to work. Plus, it has had oil leak coming from front CV axle (have receipt/documentation of this). Anymore the local Ford dealership gives me the run around about repairs it seems to keep me coming back to pay for diagnostic repairs. Ford Corporation when I call them puts me on several holds while they "supposedly" call local dealership about the issues (Ford Corp acting like they don't know nothing). In addition I ve found out that all Services, repairs aren't being reported as required by law to do. I tried to upload my videos/media of the suv but it wouldn't upload to this website. If there is a specific email I could send the videos/media footage, the receipts/documents I'd do it immediately!! So, "please" let me know if there is an email!!

The contact’s daughter owns a 2021 Ford Explorer. The contact stated that while his daughter was reversing, the rear-view camera image was blue and black. The dealer was not notified of the failure. The vehicle was not diagnosed nor repaired. The manufacturer was notified of the failure and informed the contact that the VIN was not included in a recall. The failure mileage was approximately 75,000.

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V342000 (Back Over Prevention). However, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving in reverse mode, the back-over prevention camera displayed a blue screen. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 13000.

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V626000 (Electrical System) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Headlamps stay lit even in auto lamp mode. Indicator on the dial does not display which mode or setting the lights are in. This has occurred numerous times and seems to have increased frequency

It is extremely difficult to tighten the harness on this seat. As we have used the seat more, the harness has gotten nearly impossible to get snug enough to be safe. I am a CPST, so I am sure the seat was adjusted properly for my child. I also talked to a CPST at Britax to make sure I wasn’t missing something that could help. I was sent a new harness to see if it would help, but it did not make any difference. We have since stopped using this car seat and replaced it.

I was sitting at a stop light and when the light turned green I pushed on the gas pedal and I had NO POWER! However, all of my auxillary power worked. Everything inside the car still had power, from my dashboard to my Apple CarPlay but my engine would not turn on. The check engine light did come on but not until it had been sitting there for 20-30 minutes. The Auto Start/Stop was activated so I don't know if there was an issue with that and it just never turned back on. The alternator belt was still intacted. Had it towed to repair shop (took about an hour) when it got to repair shop it started and shop couldn't find anything wrong. It has started every time since. I am afraid to drive it because I don't know if or when it will happen again.

The vehicle was self accelerating and applying forward propulsion. It was behaving as if the cruise control was on, cruise control was verified off. When braking was applied an alert was posted on the dash stating Braking applied, power reduced and the engine would rev higher. Upon stopping the vehicle and letting off on the brake the vehicle would accelerate as if the gas pedal was depressed. Upon parking the vehicle the engine would rev up to 6k rpm and if I let go of the brake the vehicle would accelerate. Turing off the vehicle and turning the vehicle on did not reset the issue. I verified no inadvertent pressure was being applied to the gas pedal and have video demonstrating the failure. The videos I have are too large to upload via your limitations on this page.

Vehicle loses power while on freeway when 4WD, Pre-Collision Assist, Hill Start Assist, and other warning messages display. Vehicle lost power approximately 5 times while registering message, but messages have displayed approximately 40-50 times in the past week before being services. Vehicle dealership repair facility inspected and diagnosed a bad 4WD module.

I bought the car in 12/21/21 brand new from Hopkins Ford in Illinois drive the car just for work and school, we serviced the car and well mantained with all needed services around 1000 miles I start noticed lots of clunking noises coming out of the car right after exit the vehicle and took it to 2 diferent ford dealerships and they said was normal, which wasn't. kept driving the car I had also an issue with the panoramic roof having leaks and wasn't fixed too, around 15000 miles start noticed delay on the transmission when moving from park to reverse and also a very loud clunking noise , when moving from reverse to drive noticed de delay and and pull when the transmission engaged to drive, I use the highway around 1 time a week and noticed loose of power when accelerating so I decided to take it to the Hopkins dealership, initially they diagnose just need an update and will be ready in 5 days , they never contacted me and I call them back to ask the status because I need the SUV for my family and they gave me a Pickup TRUCK as loaner and is useless for my family, they told me it will be another 4 days, than at day 20 they said they have to replace the whole transmission , and I forced them to give me a another EXPLORER as loaner because I need that size car, I drove it and at day 29 called me and asked me for their car back and they gave me again a F150 but my car was not ready and will take another 4-5 days, magically my car was ready next day !! day 30 really? they dropped at home but with scratches in door panels and dents in the paint. they I drove the car for .3 miles and the car had the same issues , they told me to drive it for 500 miles and transmission will adapt, I drove it for 1000 miles and now the problems still and now are worse even with new transmission, vibration while driving on highway, clunking noises and lose of power , I dropped the car at the dealership already for a week and is no estimated time on repairs or how long this will take

The contact owns a 2021 Ford Explorer. The contact stated that upon starting or while driving the vehicle, the front camera screen image was black or gray before going blank. Additionally, the navigation system was inoperable. There were no warning lights illuminated. While driving at undisclosed speeds, the transmission was slipping. The vehicle was taken to the local dealer, where it was diagnosed that coolant had intruded into the transmission. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 50,000.

The vehicle infotainment system regularly displays "emergency" messages theoretically designed to alert drivers to fires or other hazardous conditions. These messages seize the infotainment screen and must be cleared manually. The problem is: all of these messages are false and/ or nonsensical, .i.e "Serious fire at the intersection of Main Street and Main Street." The messages are a distraction to the driver as they often appear when using the navigation system. Ford service tells me this problem is not fixable. I raised the issue with Ford Management and they have basically ignored my request for assistance.

The contact owns a 2021 Ford Explorer. The contact stated that while the vehicle was shifted into reverse, the audible alarm feature failed to alert the contact to an object or another vehicle nearby. The vehicle was taken to the dealer however, the technician was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 22,000.

While driving on a freeway on Sep 15th 2023, wrench light showed up and immediately vehicle speed dropped from 65 to 30mph. This is second time this issue has happened and luckily my family survived accidents. First incident occured on Aug 13th 2023, after which i towed my vehicle to dealership. They repaired and said its safe to drive now. But issue is recurring. Please help me on this as I am reporting this issue second time on NHTSA. I reported first incident also which happened on Aug 13 ,2023

On July 1, 2023, I had the vehicle parked on an incline with a trailer attached to the vehicle. The vehicle was in Park and the Parking Brake was set. As I attempted to unload the trailer, the vehicle started to move and rolled down the incline. I was on the trailer and was moving with the vehicle, I could have been injured but fortunately the vehicle rolled into a pile of topsoil before it could pick up too much speed. However, both the vehicle and trailer were damaged My safety was put at risk as the vehicle was moving without anyone in it. This occurred in my driveway but could have happened on a busy street. I still own the vehicle and it is available for inspection. There were no indications, warning lamps, etc. that would have notified me of the impending failure. I contacted Ford and they have been of little help. It took them 2-1/2 months to get me scheduled to have one of their field service engineers to inspect the vehicle. I was not allowed to talk to the field service engineer and that person did not attempt to duplicate the conditions which caused the failure. The report from Ford to me said they inspected the vehicle on a lift. They said they could not find a problem and said they will take no further action. They have been extremely uncooperative and do not seem the least concerned about the safety of the vehicle. I am concerned that the problem will recur and cause significant damage or injury so I take precautions whenever I park it.

The contact owns a 2021 Ford Explorer. The contact stated that the back over prevention screen was either black or blue. The contact received notification of NHTSA Campaign Number: 23V342000 (Back Over Prevention) however, the part to do the recall repair was not yet available. The local dealer was contacted. The vehicle was taken to the local dealer where the software was updated, and the camera was replaced however, the permanent fix was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. VIN tool confirms parts not available. The failure mileage was unknown.

The contact owns a 2021 Ford Explorer. The contact stated while driving approximately 60 MPH, the vehicle lost power steering functionality. The contact stated that prior to the failure she observed a "transmission code" warning that flashed twice but did not illuminate again. The contact pulled off the roadway and stopped the vehicle. The vehicle was restarted and regained power steering functionality. Additionally, the instrument cluster failed to operate as needed. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that a software update was needed. The vehicle was repaired. The contact stated that the instrument cluster failure reoccurred. The manufacturer had not been informed of the failure. The failure mileage was approximately 23,000.

The first window that exploded is The back windshield when my husband and I were sitting in the parking lot at the American Legion. I took the Explorer to Duval Ford they suggested I call Ford Corporate. They said they didn’t know why the window exploded. On Wednesday the right passenger back window exploded as I was traveling on Interstate 95. I called Corporate Ford and they said take it to Duval Ford to be assessed. This is two windows in 8 months that have exploded. It cost me out of pocket a total of $900 to replace both windows.

There is a $7.00 seal that leaks near my oil filter that has been replaced for the second time and this time i was not under warranty and the labor to repair the broken seal cost $1100.00 and would like for you to recall this seal so i can be made whole again

Due to a Sync system update the display has been unresponsive, thrown errors, shut off during driving, and been delayed during operation. Most noticeably during reverse. There is a significant delay when the reverse camera is supposed to turn on causing a potential safety hazard. Ford has not responded to the issue in a timely manner and hasn’t given an ETA on when the firmware will be updated.

I bought a new Ford Explorer XLT in 2021. I was driving with my kids on highway 101 at 70mph on 08/13/2023, wrench symbol came up and car speed immediately dropped down from 70mph to 30mph. Luckily the driver behind was very attentive and an accident was avoided and we were saved. After that car went into limp mode and had to be towed away. My car just have over 13k miles on it and is under every warranty. This wrench warning lamp came once on 07/31/2023 without impacting vehicle speed. I took the car to Ford dealership for inspection on 08/01/2023. After 3 days of inspection they said some sensor needs to be replaced which they don't have in inventory and will call me back when it is available. They handed over car to me telling it is totally safe to drive as they don't see any issue with driving. Now when I told the dealership about the harrowing experience they turned a deaf ear and said we will look into it without even caring to provide an answer. I insisted on providing a loner vehicle as they dont have a timeline on fixing the issue.I trusted the ford mechanics and ended up paying towing expenses for over 100 miles and best of all luckily survived. Me and my family are still in this shock.

Screen is blue by reverse

When starting the car, the digital screen either turns to blue or black as non-functional. The radio is not able to operate during this time. While in park, the screen is black. While in drive, the screen is either black or as shown I photo, the camera shows the parameters

Camera is not working and was recalled. Cannot be fixed or repaired. I requested to trade my vehicle for another one at a Ford Dealership or for the pay off and was told I couldn't do anything due to the recall. I am essentially stuck with a vehicle that is unsafe and I don't feel comfortable driving. The camera turns blue in the middle of backing up and I could hit any object or person in the middle of backing up with my view obstructed. I was advised that I just had to wait or go to a 3rd party dealer who would give me cash.

The contact owns a 2021 Ford Explorer. The contact stated while driving approximately 60 MPH, there was a rattling sound coming from the vehicle. The contact stated that the vehicle started shaking and vibrating before the vehicle lost motive power and stalled. The vehicle was towed to the local dealer who diagnosed that the engine was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 69,000.

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V342000 (Back Over Prevention) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that on several occasions the rear-view camera failed to show an image. The failure mileage was 30,839. VIN tool confirms parts not available.

Every 6 months, the rear cameras, cross traffic sensors and blind spot warning go out and completely stop functioning. I take it to the dealer tland they keep it for 1-2 weeks and eventually replace a fuse and send it home. This has happened four times. No one will actually correct the root cause ti the issue. It's going on its third week in the shop this time.

The fuse box got wet after a routine car wash. The hood was not opened at any point prior to the car wash, nor directly afterwards until the incident occurred. A few hours after the car wash, the horn went off on its own continuously for 5-10 minutes and had to be shut off manually via disconnecting the battery. The car was not running or turned on in any way at this point. Prior to disconnecting the battery, the car was turned on to try and deactivate the horn. The horn was still blaring and the car would not shut off. Upon inspection, there was smoke coming from the fuse box. Multiple vehicle alerts went off on the dash including Hill start assist warning, Powertrain malfunction/reduced power and pre-collision assist warning lights. The car was taken to the dealership for repairs. The following "story" was conducted at the dealership: Unhooked battery. Removed front cowl battery junction box. Removed battery junction box. Battery junction box is burnt up and engine bay harness is melted. Engine bay harness needs replaced. Have to remove engine assembly to gain access to harness. Removed engine transmission and subframe assembly. Removed inner plastic firewall. Removed harness and replaced. Reinstalled drive train assembly replaced all one time use fasteners. Reassembled car. Found horn is INOP. Diagnosed and found horn is burned up from being stuck on from melted harness. Removed front bumper cover. Replaced Horn and reassembled. Horn works now. Cleared all DTCs. No DTCs returned. Test drove car. Everything is working properly now and no codes returned. Total repairs are $3,300. I did not feel safe in any regards while driving it to the dealership. Through casual conversation with a friend who works at the dealership, they witnessed something similar happen with a Ford F-150. I don't believe that this has been inspected by the manufacturer, police or insurance representatives. There were no warning lamps, messages or other symptoms prior to the incident.

I am very disappointed in Ford. I cannot believe that I have a 2021 Ford Explorer and the back up camera will go out for no reason. Also, the GPS is not working. What is the company thinking, when I am told when I call the dealer to have this issue corrected that, "Ford had put a hold on the recall due to they have not made a decision on how to handle it." Let me make a suggestion that WILL WORK. Put NEW CAMERAS in all the vehicles that has the issue that I described above. If this issue is not corrected soon, I will be trading for another model vehicle. The back up camera could cause a very serious incident. People have grown used to the back up camera since they have been installed in vehicles for so many years. This could cause a pedestrian to be backed over and seriously injured or killed. Does your company want that on your conscious!!??? Also, I have an issue when I turn my vehicle in to the dealer, I am always told they do not have a loaner vehicle. What the heck!! It is your issue and you should provide a loaner for everyone that schedules a service on the recall.

This vehicle has a major defect and is unsafe to operate. The rear differential has only 1 rear bolt and is completely inadequate for the performance and duty of the car. It can break and cause gerat injury or death if it fails. It puts anyone operating and in the car at great risk of injury or death if the only remaining rear bolt breaks, dislogding the drive shaft and half shafts in catastrophic failure. I have had the vehicle inspected and compared to the 2020 Ex ST which has 2 rear bolts and my 2021 only has 1 rear differential bolt. This is a major defect and major safety concern. Lets not wait for someone to get injured or die. Thank you. [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

The contact owns a 2021 Ford Explorer. That contact stated that the silver plastic strip on the driver's side power window switch had started peeling away, creating the potential for her to lacerate her finger. The vehicle was not taken to the dealer or an independent mechanic. After investigating the failure, the contact related it to Customer Satisfaction Program: 22B37, but the VIN was not included. The manufacturer was notified of the failure. The failure mileage was unknown.

The camera system keeps going blue and will not work about 80 percent of the time since the repair has been completed. This has gotten progressively worse it seems. At times the whole radio screen will remain blue and can not use it until you turn the whole car off and wait for some time. The radio system also has lost all Bluetooth additions have added to it multiple times. There is a second recall for the blue screen but it appears they have put it on hold.

I have taken my Explorer in twice to have the infotainment system repaired. It will randomly shut down and go blank. Nothing will work to include the camera/backup assists. Sometimes an ignition cycle will clear it, but there have been times it will not. Both local dealers claim they could not duplicate despite bringing in and showing the service advisor during an event. Ford has also performed a "recall" for this 4 times, with the 3rd being canceled because it was not actually fixing the issue.

I have filled claims with Ford Motor Company as well as the BBB regarding my vehicle and not shifting and lunging into gear. Ford has replaced my transmission 3 times and denied my claim for a buy back under the Lemon Law and Magnuson Moss Warranty claim. Now I am reading Ford is recalling many 2021 Ford Explorers for the same issue that I had reported struggled and continue to struggle with for over a year now. Is there anything NHTSA can do to require Ford to purchase my vehicle back for at least what I paid for? I can provide claim numbers, if needed.

I had a reputable after market brake system installed on my 2021 Ford Explorer ST at Holman Ford in Turnersville,NJ a couple years back. Since this time I have taken back the vehicle for my brakes being too spongy. I explained to the dealership that the brakes needed to be bleed again. The technician did not and adjusted the actuator on the brakes. Last year around the same time I had almost complete brake failure. This was do to the brakes having air in the lines and leaking from a fitting. The same concern I had from the beginning. The dealership fixed the problem and also added the parking brake software due to my vehicle only having one rear bolt in the subframe. Since this time, I have received numerous parking brake fault codes on my instrument cluster. The parking brake also disengages violently to the point where my vehicle lunges forward. It wasn’t until several days ago that my 2021 Explorer went back to the dealership for the parking brake issue and then saying my parking brake actuator broke apart. I have had nothing but issues with my brakes installed by the dealer and now I’m experiencing an issue caused from the software update.

The recall that was previously issued for this issue was removed by the dealer because of 'many complaints from owners about the software fix'. The dealer told me that Ford was working on it and they would update later. However, you, on this website, will list this vehicle as 'recall completed'. Not sure why the disconnect. Also, for this vehicle, the rear subframe bushing failed last fall and was replaced under warranty. This bushing has failed again and I have an upcoming appt to have it fixed. This issue MUST be addressed by NHTSA as this is a severe safety issue that you are NOT pushing Ford hard enough to address. For 2023, Ford is producing 'some' Explorer ST models with the two bolt system (that is not under this recall), however, some are still being produced with the one bolt. The 2021-2022 models were, mostly, all made with the one bolt setup. The Fix is to simply use the correct rear subframe (Ford is doing this for owners that complain/push this issue, which I'll be doing now that this has happened twice). Please call me if you need details.

Numerous times over the recent 2 months, I have experienced different issues with my 2021 Ford Explorer. The vehicle was purchased used in 2022 with less than 10,000 miles on it. It currently has 36k miles. When the vehicle is stopped but in drive and then accelerated to merge into traffic, the vehicle stalls and will not engage. The accelerator has to be pressed repeatedly to get the vehicle to begin moving again. This can take anywhere from 2-3 presses and 10-20 seconds. This creates a hazard for moving traffic and a safety issue. This occurs repeatedly with no warning beforehand. The vehicle has no lights to reflect an issue. Additionally, while the vehicle has been parked and shut-off, the electronics will turn on. On two separate occasions, the lights have turned on on their own and the radio has done the same; there was nobody in the car either. Over the past weekend, while driving down the road, no rain or water on windshield, and the wipes started. The vehicle persistently has a blue screen during backup. There is a concern for the electronics as a whole with all of the issues occurring. When accelerating on the highway/interstate, often times, an odd smell can be sensed, as if the EcoBoost is not functioning appropriately. The recall for rear axle bolt was repaired by Ford in Yukon, OK, and was informed that is the only recall currently with a repair available. The vehicle is available for inspection, as necessary.

I had my suv service recall done on 6/04/22 for rear axle bolt fractures. When I got to driving my suv the transmission was acting funny, it was shifting up and down different than it was. So I took it back , and they said it had to get use to my driving. So it seemed ok in a couple of days. Then all of a sudden I was at a stop light one day and it wouldn’t shift out of first gear.so we pulled over to a parking lot, we went in and had lunch, after lunch we tried driving it and it seemed fine. And it was ok until about 3/08/23 when we were almost got home from a shopping trip when all of a sudden it just started making noise and acted different shifting. So I took it to my ford dealer,I asked them to look at it and tell me what they wanted to drive it or not.they said not drive it, so they gave me a loaner car. So I checked with them a couple of times and they had not looked at it. So after not looking at my suv for 30 days I got mad and traded in . So I don’t know for sure what happened to my suv I think it was in transmission or driveline.there was no warning lights or codes they told me when I dropped it off

I had my 2021 in the shop for NHSTA Recall 22V255 in June of 2022. They reprogrammed my parking break to auto-engage when the car is put in Park. The DID NOT replace the rear axle mounting bolt. The Ford letter to dealers describes the dangers of driving with a defective rear axle bolt. Why weren't these bolts replaced? I was told (by [XXX]) that no bolts were available. He agreed with me that the proper repair could not be completed without changing the bolt(s) in question. So does Ford only repair broken rear axle bolts? INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 21V735000 (Back Over Prevention) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was not made aware of the issue. The contact had not experienced a failure. The VIN was not available.

I am reporting countless incidences of my backup camera screen going to black or blue when the Gear Shift is selected to REVERSE. This has happened multiple times a day, week, month, etc. and is extremely frustrating. I am reporting in hopes to do anything I can to get the software fix expedited because it has been occurring for too long without a fix. t=The only "FIX" (if you can even call it that) for this problem is to stop what you are doing, put your car in PARK, turn the car OFF, open the driver's door to "reset", and then turn your car back on AGAIN in HOPES that the backup camera / 360 view is back to functioning within normal limits. That is unacceptable!!! It is not safe and anyone experiencing this issue should not have to stop their car, open a door, and restart it just to get the backup camera to work. I have contacted my dealership, Ford Corporate Offices, and now you guys in hopes to get this process going and the software to be fixed. Thank you - please contact for any questions or more information.

The back up camera fails basically 1 out of 5 times it's engaged between skipping or just straight blue/black screen. The screen is out and causes blind spots while backing up.

This vehicle has had multiple recalls for the same issue. Current recall is 23V022. This is a recurring issue with the sync screens. Now the entire screen is failing at all times rendering it impossible to drive hands free. Meaning navigation does not work, operating a phone through the car does not work, at times the reverse emergency brake does not work. All of these features are there to improve not only the safety of the vehicle occupants, but the safety of other motorists. It is unfortunate that the government has allowed a vehicle manufacturer to make its own rules when it comes to the safety of this nations motorists. All of the photos attached were taken on different days over the last couple of months and I would be happy to verify this upon request.

Recall on REAR CAMERA BLUE OR BLANK SCREEN

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V022000 (Back Over Prevention) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that his vehicle rental company owns a fleet of 105 2021 Ford Explorers, and the VINs were all included in the recall. The contact stated that 35% of the 105 vehicles had experienced a loss of rearview camera image. The dealer was made aware of the failure and confirmed that parts were not yet available. The vehicles were not repaired. The manufacturer was made aware of the failure. The failure mileage was unknown. VIN tool confirms parts not available.  

The contact owns a 2021 Ford Explorer. The contact stated while driving 30 MPH and attempting to slow down, the vehicle failed to properly respond. The contact desperately depressed the brake pedal, but the vehicle failed to respond. The contact activated the parking brake, and the vehicle was able to stop. The contact was able to drive back to the residence. The vehicle was towed to the dealer and the dealer stated that the ABS module needed to be replaced. The vehicle was repaired but the failure persisted. The vehicle was taken to the dealer and the dealer stated that the wiring harness needed to be replaced. The vehicle was not repaired. The manufacturer was contacted, and a case was filed. The failure mileage was 20,000.

Car rolled down driveway while in park three separate times. Could have killed someone.

After receiving a Ford issued recall for a potential rear axle bolt fracture, the dealer reprogrammed the PCM per Ford's reported repair solution. After this PCM update, the vehicle would randomly slam to a complete stop while driving. It happened several times with 3 different drivers (myself, my wife, and my son), each happening at 30-35 mph or less. It was usually preceeded by an audible clicking sound, but not always. We took the vehicle to the dealership several times, but they said they were not able to reproduce the issue, and continually returned the vehicle to us despite our grave concern for high risk of crash and injury. We even contacted Ford's customer service and legal departments several times, who ultimately refused to allow us to continue using a loaner vehicle and demanded that we return the loaner and retake possession of our Explorer because they said they had not received any other similar complaints, and their field engineer could not reproduce the issue and cleared the vehicle as safe, although Ford was never able to supply us with service records proving the repairs they purported despite our repeated inquiries. Ultimately, the issue happened again, and slammed while driving down a hill at about 40-50 mph, but this time the slamming was immediately followed by seemingly disengaging the drivetrain and causing the vehicle to roll downhill with no ability to accelerate, ultimately causing me to roll into a utility pole. Ford has since repurchased the vehicle, but given the severe safety risk associated with this issue and Ford's poor handling of our situation, I wanted others and the NHTSA to be aware in case other similar issues are reported in a effort to protect others from potential injury, especially in light of the increasing number if PCM-related issues and recalls reported against Ford...one of which was a PCM recall pertaining to our reported issue, but was not issued until after our repurchase was complete.

Last month out of the blue, my 2021 Ford Explorer ST with 15,500 miles would not start. Attempts to jump it were futile. I then had it towed in to the local Ford dealer. At first, they were thinking the starter. A few days later, I got a call saying they could not hand crank the motor as it seized up. In addition to that, they found pieces of metal from the piston in the oil pan. The dealer took apart the intake manifold and found that the valve keeper failed thus dropping the intake valve into the #5 cylinder. This necessitated replacement of the engine, both turbos and even the flywheel and torque converter. This is a known issue with the 2021 Broncos and is even being investigated by the NHTSA. I just wanted to bring awareness that this can happen to the 2021 Explorer with the 3.0 Ecoboost as it was built in the same factory as the Bronco 2.7 and is a similar engine. I can provide the repair invoice upon request. I couldn't get it to upload.

2021 ford explorer exterior windshield trim is loose and has been shown to come off while driving. it is also causing a wind noise inside of the vehicle while in operration. No warnings shown. Link below shows issue and repair guidelines. https://www.tsbsearch.com/Ford/22-2021

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 22V255000 (Power Train) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2021 Ford Explorer. The contact stated that while driving at various speeds, the rear end of the vehicle became very unstable, and the vehicle fishtailed. The vehicle was taken to the local dealer who performed a rear wheel alignment, but the failure persisted. The manufacturer was notified of the failure and informed the contact that the VIN was not included in the NHTSA Campaign Number: 21V870000 (Suspension). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 12,000.

Front passenger seat overheated and caused 2nd degree burns

At 13,000 miles this New vehicle started smoking blue gray smoke on startup I have videos. Yes the Dealer reproduced the problem. The dealer stated that both turbos were defective and leaking oil into the hot exhaust on both sides of the engine which could have lead to a fire and endangered our lives. The dealer removed the engine and transmission from the vehicle in the process broke numerous bolts and repaired with inferior quality parts.after four attempts to pick up the car hoses were left loose and short on antifreeze and Turbo boost hose fell off,now there is a antifreeze burning smell and a rough idle. There were no warning lights or messages. This car was meticulously maintained since brand new I have all records to back up . Ford Corporate has just denied a buy back request and said I don’t qualify for state Lemon law after 2 months at dealer.

Defective Starter - car will not start, battery, alternator check off ok.

The rear camera has not worked since the vehicle was purchased in spring of 2021. It has now been "repaired" 3 times based on open recalls. however the issue is a known issue and can not be fixed. We have now been told they will.nees to replace the camera which is on indefinite backorder. This is a huge vehicle safety issue Ford is aware of and yet not one of their alleged recalls actually resolves this serious issue.

The transmission hesitates for several seconds and shifts hard when being shifted into reverse. The dealership has made one repair attempt already.

loud popping metal sound from rear brakes as vehicle starts to move Ford has been contacted and replaced rear brake pads which made no difference. This problem started last August After Safety Recall 22S27 below is a link to videos with sound which clearly describe my safety concern https://www.dropbox.com/sh/a3iawirsizbc6iq/AAA3dgaCvZ9JcouFufKLLmGUa?dl=0

Issue with navigation system. Many times is shows no GPS. Navigation does not always recognize current vehicle position and many times navigation does not even work. On many occasions, upon starting the vehicle, the clock does not even work when the navigation system isn't being used. This is a safety issue when we are traveling out of town. We are not fans of using our phones for navigation as an alternative to the faulty vehicle onboard navigation. This first started happening December 2022.

While using Intelligent Adaptive Cruise, the vehicle suddenly thought the speed limit was 85mph and quickly started accelerating. Confused, I hit the brakes to stop the acceleration. I have uploaded a photo of the dash that I took showing that the system read the speed limit sign as 85. I saw no speed limit sign in the area, so, I have no idea what prompted the system to change speed. I was talking on the phone via Android Auto and using Waze, via Android Auto, USB direct connect. The only other problem I've ever had with this system is on interstates that have specific Truck speed limits in West Virginia. There, sometimes trucks have slower speeds and this system picks up those truck speeds and decelerates/brakes to comply. While it can be overridden in the moment, the next time it sees such sign, it slows again. This sudden deceleration poses a hazard to other drivers who do not expect a 'non-truck' vehicle to suddenly slow.

Vehicle developed a clicking noise when accelerating/decelerating. Noise also present when switching between drive/reverse. Ford dealer found that driveline was flexing. Closer inspection revealed that the bushing for the single bolt rear subframe mounting to rear differential was broken. Had this not been caught, the bolt would have broken releasing the rear driveline from the structure of the vehicle. The 2020 Ford Explorer ST had two bolts that connected the rear diff to the rear subframe. In 2021-2022 Ford changed this to a one bolt design. This triggered the current recall for the 2021-2022 in which the 'fix' was to apply the emergency brake if the bolt broke. On the 2023 Ford Explorer ST model, Ford has returned to the two bolt design used in 2020. Photos uploaded.

The contact owns a 2021 Ford Explorer. The contact stated while driving 10 MPH, there was a strong gasoline odor inside the cabin of the vehicle. Additionally, the contact stated while the vehicle was parked in the garage, there was a strong gasoline odor coming from the vehicle. The contact stated that the gasoline odor was present throughout the entire three-story residence. There was no warning light illuminated. The vehicle was taken to the dealer where it was diagnosed that the fuel line was leaking from a hole. The fuel line was replaced, and the diagnostic fault codes were cleared. The contact stated that upon reviewing photographs of the fuel line, he noticed that an unknown component had been rubbing against the fuel line, which caused the failure; however, the dealer did not inform him of the cause of the failure. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 41,000.

Back-up camera starts turning blue. Verified that there was an issue during manufacturing that they left a hole open and can cause malfunctioning of the back up camera causing the blue screen. Unable to spot blind spots when backing up and can put others safety in danger if behind vehicle especially children and I am not able to see them when reversing.

On or about 9 am on Tuesday, January 10, 2023, I entered a parking garage facility and drove up the ramp and continued on a level parking area and begin to turn into a parking space beside a large cement column. Just as I entered the parking space at a low rate of speed without my foot on the accelerator, I experienced sudden unintended acceleration which caused the vehicle to narrowly miss the cement column and the front cement wall of the parking space. Fortunately, I quickly braked to avoid a collision and then put the vehicle in park and shut off the vehicle. There were no warning lights on the vehicle dash, and I have not yet taken the vehicle to an authorized Ford Dealer to have it checked. Vehicle is still under factory order and has approx. 26,700 miles.

The contact owns a 2021 Ford Explorer. The contact stated that he recently had a manufacturer recall performed on the vehicle for Ford Customer Satisfaction Program Number 22N06 (Rear Axle Bolt Replacement). The contact stated that the dealer re-programed the E-brake to engage automatically when the vehicle was placed in park(P). The contact stated while reversing out of his driveway the vehicle would not move. The contact had been instructed to tap on the accelerator to release the E-brake. The contact stated that the RPM was raised to approximately 2,000 RPM, and only then would the high RPM release the E-brake; however, the vehicle would lurch into motion at approximately 10 MPH. The contact stated that the E-brake warning light was illuminated and then switched off once the E-brake was disengaged. The contact stated that the failure was more pronounced while reversing on a slope. The contact stated that the failure recurred while placing the vehicle in drive(D) however, the vehicle lurched and jumped forward. The contact stated that the motion was not as aggressive as while the vehicle was in reverse(R). The contact had taken the vehicle back to the local dealer where it had been reprogrammed. The contact was advised that all that could be done was to reprogram the E-brake. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 23,000.

Backup camera “blue screens” during critical times it is required. Software updates were updated but no resolution until Ford replaced the backup camera.

Rear subframe bolt bushing broke. (See existing recall for the rear subframe bolt breaking). This vehicle had recall performed which actually didn't address the engineering shortfall from Ford using the wrong, lighter duty, subframe on the ST model. This subframe only has one bolt holding the rear diff to the subframe. The 2020 model had two bolts, as do all MY of the Lincoln Aviator. While Ford is fixing this under warranty, using the same subframe will not fix this issue. Result will be that the bolt may break or the bushing may fail. A broken bolt will result in the drive shaft disconnecting while driving, loss of acceleration, potential wreck from drive shaft hitting ground at speed.

Numerous times no response when pushing gas pedal no acceleration when vehicle is in electric and switching to gas.This a Hybrid vehicle. I can't let my wife drive it. No warning lights come on. The recall for rear end states if the bolt fails the drive shaft and rear axles could move out of alignment and cause an accident .....yet they refuse to replace it.

When driving at lower speeds, typically under 30 MPH, the vehicle jerks & lurches. Also sometimes lurches, hesitates or doesn’t react on rapid acceleration such as highway merging or passing. Have had many near-misses. Parking, Reverse & Drive do not always engage immediately upon shifting. I nearly ran over my husband when the car was supposed to be in park and it was still in drive. Car will become extremely hot after extended driving causing the A/C to automatically turn to hot air in order to cool the engine. It smells bad and is not at all comfortable on long summer road trips.

The contact owns a 2021 Ford Explorer. The contact stated while it was raining, the windshield wipers were activated but failed to clear the windshield as needed. The vehicle was taken to the dealer and the wipers were replaced, but the failure continued. The vehicle was taken to the dealer and the windshield arm were replaced, but the failure reoccurred. The vehicle was taken back to the dealer and the contact was informed that the vehicle operated as designed. The manufacturer was notified of the failure but offered no assistance. The failure mileage was 5,000. The VIN was not available.

Vehicle began smoking after a cold start at around 9000 miles. Dealer confirmed the issue was happening and the engine was replaced, but the smoking problem remains. No warning lamps, indicators, or DTCs have been thrown to help in diagnostic. Thus far, there has been no safety impact due to the issue.

My Explorer ST has the issue of having the incorrect rear subframe for the high-performance engine with only one bolt holding the differential to the rear subframe. I have talked to all of the Ford dealerships in my area. They said that this is a problem, but Ford has not provided a solution or any timeframe to fix this major issue. Another example of Ford not caring about their customers and putting profits ahead of safety. Why did they think that they could get away with installing incorrect parts for the four-cylinder engine on a vehicle that develops substantially higher HP and torque. This is my first and last Ford product I will ever buy. Why doesn't the NHTSA force Ford to fix this potentially dangerous issue.

Ford has started a recall for vehicles with a single bolt in the rear differential mount. This is in reference to the roll away issue as their calling it. Some people have recieved notice for this and others have not. My production date is listed as 8/21. Which I believe is in part of the recall. Even if not this vehicle has only one bolt in the unit and not 2. Which is part of the recall issue.

Two issues. 1. After the software update that was supposed to fix the rear camera blue screen issue, it randomly shows a blue screen instead of the camera image when reversing. The issue doesn't correct until the vehicle is turned completely off and restarted. 2. The rear hatch randomly closes when getting items out or putting items in the cargo area. It cracks you on the head and DOES NOT STOP. If you can't get out from under it in time you fall to the ground. More than once it has made me see stars it struck my head so hard. Also sometimes when walking away from the vehicle the hatch will open on its own with no one near it. The dealer tried once to reproduce the issue but didn't happen while they had it.

The contact owns a 2021 Ford Explorer. The contact stated that he had received a recall notification for NHTSA Campaign Number: 22V255000 (Power Train). During a routine maintenance check, the recall was serviced; however, upon return of the vehicle, the brake pedal was depressed to the floorboard with the parking brake fault, uphill assist, and ABS warning lights illuminated. The contact also stated that while driving at various speeds, the brake pedal hardened and the vehicle failed to stop as needed. The contact's wife called the dealer and was informed that there were 5 other vehicles that had experienced the same failure. The contact attempted to reach the manufacturer but was unsuccessful. The vehicle was not repaired. The failure mileage was approximately 37,000.

My 2021 Ford Explorer should be included in safety recall NHTSA 22V255, Ford recall 22S27, Ford Program 22N06 My vehicle[XXX] was built in September 2021. Ford identified to NHTSA that Explorer vehicles built between June 4 2020 to November 10, 2021 were affected. My vehicle was built during that period. My vehicle has the V6 engine with AWD powertrain. My vehicle has the 52T trailer towing package. Trailer towing will put additional load on the powertrain and the rear axle mounting bolt. The bolt may fracture while towing the trailer leading to a serious injury and personal property damages. I have not received the recall letter from Ford. All letters were supposed to be sent by June 2022. Ford will not include my vehicle in the recall at my request. Ford will not apply the PCM update to automatically engage the electronic parking brake every time the vehicle is shifted into Park (P). Ford will not provide the one-time repair of the for 10 years or 150,000 miles. I'm concerned the vehicle may experience the rear axle mounting bolt fracture. Please help. Thank you. -------------------------------------- Safety Recall 22S27 / NHTSA Recall 22V255 / Customer Satisfaction Program 22N06 Certain 2020-2022 Model Year Explorer Vehicles Rear Axle Bolt Fractures REASON FOR THIS SAFETY RECALL In some of the affected vehicles, the rear axle mounting bolt may fracture during vehicle acceleration. A fractured rear axle bolt will allow the rear axle housing to move out of position, resulting in severe noise and vibration. If the rear axle bolt breaks, the driveshaft/half shafts may become disconnected, resulting in loss of transmission torque to the rear wheels which is necessary to hold the vehicle in park. If the parking brake is not applied, the loss of the primary park torque will allow the vehicle to roll in park increasing the risk of crash and injury. --------------------- INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

I recently had the recall addressed at my local Ford dealer, Performance Ford in Randolph, NJ. Ford is only allowing dealerships to reprogram the parking break to engage whenever the vehicle is placed in park. If the axle bolt were to shear, it would disengage, allowing the vehicle to roll in park. This remedy does not adequately address the underlying issue- which was the fact that Ford’s Chicago mfg facility used a part designed for the 4-cyl engine power train, not the 4 bolt design required in the Police Interceptor and Explorer ST versions. The police version will be getting the parts upgraded while consumers are left with a band-aid solution. NHTSA should force Ford to address the issue- which is an inadequate bolt configuration for the HP/Torque output of performance version Explorers. This is a safety hazard as the bolt can snap while in use, disconnecting the drive axle from the rear differential.

Our 2021 Ford Explorer Limited was purchased in December of 2020. It currently has been driven only 6,900 miles. Our apparent transmission problem has occurred three times so far. 1. On 27 June 2022, I experienced the first problem. While turning left on to a four-lane city street, which is largely flat in that area, a loud grinding/ringing sound occurred. Right in the middle of the four-lane street, the transmission dropped into neutral. It scared the crap out of us. We could have been hit by oncoming traffic. I brought it to a stop, then shifted to park and then into drive. We drove away normally as if nothing happened. 2. On 28 July 2022, after having the "bolt failure" recall completed (22S27/22V255/22N06), the transmission again made the loud grinding/ringing sound immediately after accelerating from stopping at a city street intersection. The road grade has a slight incline in the direction we were traveling. The vehicle dropped into neutral, then the newly programmed "auto braking" brought us to an abrupt stop in the middle of this intersection! Again, a scary situation. 3. Today, 25 August 2022, while backing out of our garage today, which has a slight downward driveway, the vehicle did an abrupt stop while halfway out of the garage. The message was "Hill Start Assist Warning." The message on my phone was "The Hill Start Assist System has detected a failure." This is the first and only time that this problem has happened. I think it is related to the problems mentioned above. It is a good thing I was not backing out into a busy street.

Backup and front cameras are not working consistently. Blue screen shows on display screen. Cannot reproduce at the Ford dealer. Blue screen camera issue started on June 13, 2022. Since then I have had 27 instances to date. There currently is a recall for this same problem on other Ford Explorer's.

The contact owns a 2021 Ford Explorer. The contact stated that while driving at an undisclosed speed, the driver's and passenger's side rear seats inadvertently moved forward while his children were seated in the seats. The contact was concerned about the safety of his children while riding in the vehicle. The vehicle was taken to the dealer; however, the dealer was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 14,700.

The car is struggling to switch gear and loosing power. While I am driving

2021 FORD EXPLORER. CONSUMER WRITES IN REGARD TO ISSUE WITH THE REAR SUBFRAME. THE CONSUMER STATED THE VEHICLE WAS MANUFACTURED WITH AN INCORRECT SUBRAME. THE CONSUMER BELIEVED THE SINGLE BOLTS WILL EVENTUALLY BREAK DUE TO STRESS. THE VEHICLE HAD A RECALL TO REPROGRAM THE PCM TO AUTOMATICALLY APPLY THE PARKING BREAK. THE CONSUMER WAS CONCERNED THE RECALL WOULD NOT STOP THE VEHICLE FROM ROLLING AWAY.

Gear(transmission), when put in reverse the car goes forward instead of reverse, and Jerks in reverse after 7-15 sec. And it also jerks while accelerating.

All of the sensors are out. Nothing is working. They were working fine then one day I noticed the lane keeping sensors were not working. Today I noticed the side sensors are not working which they were this morning. The middle row seat gets stuck if moved forward, it will not stay back. The button is always stuck so while on the road the seat randomly pops out of place. The wipers do not work properly, only on high speed. I have already called McCombs Ford West in San Antonio, Tx as I purchased the vehicle there in October of 2021 but they are not worried about it. They said I can go drop it off but they will check it when they get a chance and will not provide a loan car which I cannot do that as I have kids. All the safety features that it should have are not working. They told me it would be weeks before they even look at the vehicle.

My vehicle is throwing alerts about a power train malfunction. It reduces speeds by it self attempts to loose all power when having issues and the transmission feels like it is slipping or not shifting into gear. This has now happened on multiple occasions.

The contact owns a 2021 Ford Explorer. The contact stated that after his wife set the vehicle to "Park" while the engine was running, as she exited, the vehicle lurched forward and crashed into the garage back wall. There was no damage to the vehicle, however, there was damage to the garage back wall. The contact stated his wife saw no warning lights were illuminated. The contact's wife got back into the vehicle and observed that the gear shift lever was still in "Park" and she shut the vehicle off. The contact had not taken the vehicle to a local dealer, or an independent mechanic. The vehicle had not been diagnosed or repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 10,000.

While driving vehicle, reduced engine power occurred resulting in the vehicle being unable to safely maintain highway speeds. Once safely on side of roadway, vehicle lost all engine power and would start. Vehicle had 11,049 miles on it and had been properly maintained. Attempts to start vehicle were unsuccessfully and engine sounded like internal components had failed (like a bag of rocks inside the engine). Vehicle was towed to Ford dealer in East Peoria, Illinois for examination and repairs. Excessive metal shavings were found in the oil filter and it was discovered internal engine components had failed, causing catastrophic engine failure. Engine block was replaced. Dealer was provided all previous maintenance records to show that the vehicle was properly maintained.

The contact owns a 2021 Ford Explorer. The contact stated that while the transmission was either in park(P) or drive(D), the vehicle independently rolled away without warning. The contact stated that he forcefully depressed the brake pedal in an effort to stop the vehicle. The manufacturer was notified of the failure and transferred him to the NHTSA. Upon investigation, the contact discovered NHTSA Campaign Number: 22V255000 (Power Train) which he linked to the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 10,000.

Feedback on Manufacturer Recall Number 22S27, NHTSA Recall 22V255 Allowing Ford to reprogram the powertrain control unit (ECU) on this vehicle so that the vehicle applies the emergency brake whenever the vehicle is placed in park in order to prevent the vehicle from rolling away if/when this one bolt breaks on the rear differential is NOT sufficient. The 2020 MY Ford Explorer ST/Plantium models have two bolts attaching the rear differential to the rear subframe. The equivalent 2020-2022 Lincoln Aviator also has two bolts on this part. The issue is that Ford ran out of the correct rear subframe parts and substituted a part for a lower powered powertrain, or this was a cost cutting measure gone bad. Cross referencing Ford's own parts numbers with the VIN shows the incorrect rear subframe installed at the factory. NHTSA should require Ford to properly and securely attach the rear differential to the rear subframe of the vehicle to prevent this issue. Allowing a workaround, use of parking brake to prevent rollaway, is not ok. Additionally, the equivalent police interceptor is obtaining the correct rear subframe as part of the manufacture defect resolution. Why wouldn't the others receive the same fix?

The contact owns a 2021 Ford Explorer. The contact stated the adaptive cruise control and the collision avoidance systems would malfunction. The vehicle would suddenly deactivate the cruise control and the collision avoidance would detect a non-existing object and stop the vehicle from also turning to avoid the crash. The contact stated that while idled at a stop light when the vehicle suddenly accelerated rear-ending the vehicle in front. The air bags did not deploy however the acceleration did not reach high enough speeds for such a response. A police report was not filed. The vehicle was not towed. There were no injuries or medical attention needed. The contact took the vehicle to the dealer however the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failures. The approximate failure mileage was 10,000.

Ford sold a non sale vehicle to me on 11/05/2021 after Ford Critical Review Team on 8/9/2021 deemed wrong rear axle bolts being put on. Essentially, putting a no transit order on vehicle. I was made aware on this recall only after I updated my app on May 10th,2022. Read on app about the no remedy recall stating 2022-4-14. I have spoken with Ford Corporate as the service manager stated for me to do via phone. Ford's buyback department will not consider it. The buyback team is waiting on a recall remedy as of today. I do not feel safe in my vehicle, and have opened a claim with the BBB. I am only requesting Ford to either do a buyback or swap out vehicle for one year newer. No communication with Dealership about the problems both NOW and IMMEDIATELY after purchase of 2021 Ford Explorer ST.

In the last 2 months I have had a total of 3 back up cameras and the equipment is still turning blue on random. I have had the wiring replaced to “fix” the Bluetooth echo, and it is still doing it. The gas take also shakes enough to move the car when you come to a stop depending on amount of gas in the tank.

While in a driveway at a decline (approximately 5% grade), I placed the vehicle in park and set the emergency brake; when I decompressed the brake to turn the vehicle off it took off sliding down the street. A coworker was with me and was about to get out at the time as well. Fortunately I was able to gain control before I hit the mailbox in front of us and no one or thing was injured This was the second time this happened; however, the first time the emergency brake was not set. Also, starting at 23k miles, I am repeatedly getting a "Auto Hold system fault" error every few days. This occurs sometimes at startup and sometimes while driving and the Auto Hold will not work when it comes up. However, if I stop and restart the vehicle, it will go away and work. I am not sure these are related.

The contact owns a 2021 Ford Explorer. The contact stated while parking the vehicle on an incline, the transmission inadvertently shifted out of park(P). The contact stated no warning light was illuminated. The contact took the vehicle to the local dealer however, the mechanic was unable to duplicate the failure. The contact stated the failure occurred whenever the parking brake was not activated while parking the vehicle. The manufacturer had been informed of the failure. The failure mileage was approximately 50.

The contact owns a 2021 Ford Explorer. The contact stated that after she had parked her vehicle and retrieved items out of the liftgate compartment; the vehicle began to roll back independently towards her. A witness alerted her that the vehicle was rolling towards her; the contact moved out of the way. She then opened her driver-side door as the vehicle proceeded to roll back; the contact was pinned in between the concrete post and the driver-side door as the vehicle eventually stopped. Witnesses assisted her and aided her away from the vehicle which bruised her left arm. The contact did not seek medical attention for the injury. The contact called the dealer and they offered no assistance. The contact then had the vehicle towed to a different dealer Lithia Ford Idaho Falls(980 W Broadway St, Idaho Falls, ID 83402) where the driver-side door was replaced. The manufacturer was also notified of the failure and she was given a case number. The cement post was damaged as a result of the failure. The police were called after the failure and a report was filed. The vehicle was repaired; however, the cause of the failure had yet to be determined. The failure mileage was approximately 4,500.

Ford safety recall 22S27 dated April 19, 2022 DOES affect my car and I just called Ford corporate and they DO NOT confirm that my car should be on the recall list. I have visually inspected my car and I do have the improper 1 bolt, rather than 2 bolt design installed on my car. If the bolt breaks, my car will be disabled wherever this happens without warning. This can cause an accident and I do not understand how Ford is not at least including me on the recall list. The only way to fix this issue is to replace the axle structure with the 2 bolt design.

I am having major issues with the 3rd row seating on my Ford explorer getting stuck and not able to be moved. This is happening causing children to not have places to sit and seatbelts to secure themselves in for a safe commute. Each time the seats are stuck, they are not even able to be moved manually. The entire seat including the head rest becomes immobile and leaves the seat in either a half open/closed position or an open position with no headrest capability. While traveling out of town on January 23 with 6 people in my vehicle my 3rd row seats became stuck in positions where I was unable to safely transport 2 of the occupants of the car. I also had to travel home in an extremely unsafe situation where luggage had to remain in laps for a 4 hour car ride and could have been catastrophic had there been an accident. I reached out to the service department of Palmetto Ford on January 24th about this issue and they told me it would be 3 to 4 weeks until they could get my vehicle in to “look at it.” I reached out to my sales person who was able to coordinate with the service manager to get my vehicle looked at the next day. They did not have a loner for me to drive so they rented one from Enterprise and had me come back the next day to pick it up and began to repair my car. It took them about 2 days and they said they had to completely replace the computer brain of the 3rd row seating. When I left it was in working order. Two months later while once again out of town with 4 other people’s children to care for my 3rd row seating gets stuck again in an unusable position. This time I had no other alternative but to put these kids in seats together seatbelted in and pray that I did not get hit. When I got home on March 29th I called Palmetto Ford sales to let them know that my seats are once again broken and spoke to the sales manager Jake. I told him that I felt unsafe in the vehicle now and that I would like them to take it back. I told him I had more travel

I had the backup camera parts replaced 4/15/2022 and within 10 days of having the vehicle back the backup camera was turning blue again.

The auto rear trunk hands free lift gate likes to start closing on its own when you are moving around under it. For instance and could hit you in the head. It has before. Other manufacturers use a similar system and I've never had this happen. It's to sensitive to movement

(1)While reversing into the garage, the rear facing camera system turned blue and disabled the reverse braking system. (2) several instances: while reversing, the reverse braking system disables randomly.

I left a facility Friday evening, pulling out of the plaza I was second from front at a red. When the light turned green the car in front of me started going, I started going. I had to give it gas as MPH on the road I was on is 45mph. As I am accelerating through the light the car just would not accelerate. The traffic behind me was coming up FAST! I was panicked. The car in front of me turned into a gas station which gave me the additional 5 seconds for my vehicle to come back on. I never lost power inside the vehicle. It was almost as if I was running out of gas. I had gotten gas 2 days before and filled the tank. I actually called the gas station and they have not had anyone inquire so I don’t think it’s gas. It was very scary and had I had my children in the vehicle I’m not sure I would or honestly probably will not drive with them in this vehicle anymore.

Since purchasing this vehicle I have off and on experienced my bluetooth echoing for the party on the other end of the line. I have also experienced my gas tank shaking my entire car upon stopping depending how much gas is in the tank, usually full to 3/4 full. I have also experienced on multiple occasions my back up camera turning blue. There was a trend going for a while if it was hot outside it would turn blue all the time. However, over the winter months it periodically started changing blue. More recently, when I put my car into reverse it will take a few seconds to switch gears. I also experienced my front driverside window not going up. I had to turn the car off and back on again in order for it to go back up. Altogether, I have had multiple issues with my brand new car since the day of purchase. I immediately took the vehicle back in for the gas tank shaking and their response was because I was not used to driving a "smaller" car. I however find that extremely unsafe in the event I were to break too hard, I feel that my gas tank would come disassembled.

Got it in the car and pushed the push start button. The cars engine turned over only half way and started to restart and turn over multiple times even though the motor was running halfway. This went on for 15 minutes until i opened up the hood and looked down and after a couple minutes the engine seized and turned off and started smoking, shortly after started on fire from the bottom of the engine. The fire went on for 10 minutes until we turned it off.

Approximately 1.5 months ago, my ford explorer started having issues with shifting frm drive to reverse or reverse to drive, stopped to reverse and stop to drive. I had my oil changed and there were 2 updates to the transmission that were done. The problem persists. When going through a car wash in which you put the car in neutral and ride through as it washes, I placed the car in neutral and almost hit the vehicle in front of me due to it taking 3-4 seconds to shift from drive to neutral.

I'm writing to you to relay a serious safety issue that started with the 2021 Explorer ST manufacturing processes. When Ford designed the new Explorer ST, the rear subframe was engineered to allow the rear differential to be attached with four bolts (Attachment-A). This was needed to properly secure the differential in light of the ST motor putting out more horsepower than their other models. My 2020 Explorer ST had the correct subframe with two bolts (Attachment-B.) At some point during the manufacturing of the 2021 ST models, Ford started using base-model Explorer rear subframes that contained a single bolt (Attachment-C) on the rear portion of the subframe. This was likely done due to the global shortage of parts and materials that most automotive manufacturers encountered. The results were predictable, and many users in Explorer discussion groups have reported the single-bolt shearing off, dropping the differential and damaging the rear suspension components and exhaust (Attachment-D & E.) This is a glaring safety issue, especially with a performance car, as a failure at speed could result in loss of control of the vehicle. To date, Ford has not responded to my inquiries requesting more information and a resolution. They did recently release a Special Service Message acknowledging that this is an issue (Attachment-F.) The thread below on explorerst.org outlines the problem in detail. There are dozens of people there and in the Explorer ST groups on Facebook that have encountered this problem, with varying levels of successful resolution and attention from Ford. I'm happy to provide additional links to conversations about this, if needed. https://www.explorerst.org/threads/rear-end-damage.2602/ I represent a growing group of ST owners who would like Ford to issue a recall, and repair their vehicles before a failure occurs.

The contact leases a 2021 Ford Explorer. The contact stated while his wife was driving at 25 MPH with Co-pilot 360 assist mode and the evasive steering assist engaged, she lost control of the steering wheel. The contact stated that his wife could not feel the connection between the steering wheel and the front tires of the vehicle. The contact stated that the vehicle made a sharp right turn and crashed into a telephone pole. There were no warning lights illuminated. The air bags deployed. The contact 's wife sustained bruises and lesions on the ankle, knee cap, arms and on her left breast but did not seek medical assistance. A police report was filed. The vehicle was towed to a tow lot. The vehicle was then towed to another tow lot where it was totaled. The dealer was not notified of the failure. The manufacturer was notified of the failure and informed the contact that they could not assist. The failure mileage was approximately 12,000.

The contact owns a 2021 Ford Explorer. The contact stated while driving at 50 MPH, the vehicle started to hesitate as if the transmission was slipping. There were no warning lights illuminated. The contact drove the vehicle to an unknown dealer where it was diagnosed that no issues were found. The manufacturer was notified of the failure. The failure mileage was approximately 11,100.

Audio Control Module failed on 2/17/22. No audio for Forward Collision Warning, Rear Cross Traffic Warning, and reverse sensors. Dealer replace ACM, which fixed the issues on 2/22/22. However on 2/27/22, the speakers started making a popping crackling noise and front speakers went out. Then a few minutes later, no audio for about 15 minutes, but the popping noise still continued. After no audio for about 15 minutes the driver side speakers started to work, but the popping noise continued. Vehicle will be going back to the dealership.

The contact owns a 2021 Ford Explorer. The contact stated that while driving at various speeds, the transmission would suddenly downshift or upshift erroneously. Additionally, while operating the vehicle a grinding sound was present while the transmission was shifted into drive with a chemical odor inside the cabin of the vehicle. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure. The failure mileage was 7,500.

The contact owned a 2021 Ford Explorer which was used to haul a 2002 Opus OP. The contact stated that while the vehicle was at the RV dealer for installations to be performed the vehicle caught on fire and was destroyed. The contact was informed after the installation of an electronic brake controller was completed the vehicle was parked and approximately 20 minutes later flames were present coming from the engine compartment. The fire department was called to the scene and extinguished the flames. The vehicle was destroyed. Prior to the incident an electric brake controller was installed in the vehicle and wired DC to DC in order to send a charge to the tow vehicle. The manufacturer was made aware of the failure and a case was opened. The fire department indicated that the fire originated in the engine compartment. A fire report was taken at the scene. The failure mileage was 3,807.

Upon starting the vehicle, after it had been parked for about 30 min, I received an error message Stop Safely Now and the vehicle would not start. We attempted to jump start the battery with another vehicle, tested the voltage and it showed full at 12V, and then had a roadside service attempt to jump the vehicle. The accessory power (radio/lights/power windows) work. This has never happened before and the car had no indication of any issues, alerts or messages prior to this.

A police officer complained of a strong odor of exhaust coming through the hvac vents. Officer complained of a light dizziness feeling. Suv was grounded from service. Complaint was verified. Upon opening of the hood a odor of exhaust gas was smelled on the right side of the motor. No visible leaks could be heard or seen. Suv was driven to our local Ford dealer for repair.

I took possession of a Ford Explorer approximately October 12, 2021. Two weeks later on October 20, 2021, I took the car to a carwash and after paying with a credit card, the barrier went up and as I was putting my card back into my wallet, and my foot not on the accelerator, the car took off on its' own to approximately 20 to 25 mph, so I applied the brakes and the pedal went to the floor with no braking. I applied the brakes continually, as the car jumped a curb traveled through a meadow went through a fence and crashed into a tree. I had the car towed to the dealer so they could analyze what went wrong and they said they couldn't find anything wrong, but they couldn't say as to why the Explorer spontaneously accelerated without brakes. The carwash had a video surveillance system and the video clearly shows the car accelerating, jumping the curb and eventually going into the forest to hit a tree. It is a blessing that I was in a remote area with no people around as the only control I had for the vehicle was steering and had there been people around someone would have been injured or killed. I contacted the Texas DMV Lemon Law department and they couldn't help because I hadn't tried to get the malfunction repaired more than three times. They did recommend I contact the NHTSA as safety of this vehicle and possibly others of the type represent a major safety hazard. Is there anything the NHTSA can do to look into this case and first see that this malfunction is fixed on future products and second see that I can be treated fairly by the Dealer and Ford Motor Company? The car has been declared a total loss, as it would cost too much to repair. It is in a AAA Insurance lot.

The contact owns a 2021 Ford Explorer. The contact stated that he was driving approximately at 55 MPH when a deer jumped out in front of his vehicle. As a result, the contact crashed into the deer and the air bags did deploy, however when it did it was very aggressive. The contact stated that he and his wife were both sustained multiple injuries caused by the airbags. The contact stated the passenger suffered injuries to both her eyes causing blindness and isn't certain if it would be permeant. The contact stated that he sustained injuries to his wrist, neck, and leg. The contact stated the ambulance was called and took them to the hospital where they received treatment. The contact stated the vehicle was towed to a junkyard service, and from there towed to the dealer where it remains currently. The contact was advised that his vehicle may be totaled and that he should await further details. The failure mileage was 3,000.

The contact leased a 2021 Ford Explorer. The contact stated while driving approximately 25 MPH, the vehicle accelerated independently. The contact stated that five minutes later the vehicle went into safety mode and the vehicle failed to move. The low battery message was displayed. The vehicle was towed to the residence. The contact called the local dealer but, the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 7,600.

The vehicle was involved in a rear-end collision. When the collision occurred, both front seats dropped into a fully reclined position and locked fully reclined.

On 11/25/2021, I started the vehicle and drove about 2 miles when I noticed that the airbag light was illuminated on the dash. Knowing that this is a safety concern, I pulled into a parking lot and shut off the vehicle. I let the vehicle sit for about 30 seconds and restarted the car. When restarted, the light did not come back on. Took the vehicle in to have a recall performed and told the service advisor that the light had come on. They confirmed that there was a "stored code" but "not something that made sense". The dealership has had the vehicle for 9 days with no resolution. They say that a wiring pigtail harness needs replaced but also that there is a fault in the driver's seat airbag. The replacement airbag is not available due to a backorder (told 3-4 weeks). I feel that this is a large safety concern as I was told I could pick up the vehicle until the parts become available knowing that there is a fault in the airbag. The failure occurred with 3410 miles on the odometer.

On October 25, 2021; my wife and I were driving across country when we experienced a blow-out at 75 MPH in New Mexico (about 80 miles west of Amarillo. The blow-out was caused by body cladding, which came off the right rear door of our 2021 Ford Explorer - apparently attributable to 19+ MPH desert cross winds at highway speeds of 75 MPH. The trim lodged in the right rear wheel well; slicing the tire and cutting a gash from the aluminum rim. We had to get to California for a scheduled closing on our new home and were therefore unable to stay in Amarillo or Albuquerque for the three days required to receive a matching rim and tire, so I had a nearby tire store install a wheel of a different size with an offsetting tire size to approximate the circumference of the stock wheels and tires. Ford has thus far neglected to acknowledge the obvious defect that would allow a body part to blow off the car and has offered no assistance in repairing the car or reimbursing me for the wheel and tire I had to purchase to meet personal legal obligations. I've seen evidence in online forums indicating other incidents of body trim blowing off Ford Explorers at highway speeds. Ford must take responsibility for this defect and reimburse other owners and me for costs incurred to resolve implications of their defective body parts.

There is no way to securely lock the vehicle when someone with the key fob is near it. When fueling, someone can unlock the opposite side of the car, by pulling on the door handle, which unlocks it, enter and drive away. Not only does this open the possibility of easily stealing the car, but also abducting passengers, if any have the fob on them, or simply stealing contents, planting contents, etc. This is a serious security issue

When vehicle is up to temperature, there is an overpowering burning smell coming through the vents into the cab. It only occurs at idle and dissipates when the vehicle is in motion. With the hood open, there is some small noticeable amount of smoke coming from the left side of the engine compartment. The smell is not plastic or rubber.

Vibration: First use of the day, at about 35 MPH vehicle exhibits vibration throughout, especially around 40-41mph. Felt in steering wheel, seat, and with a loud rumble often heard. Has been since car was new. Has a vibration in rear view mirror at highway speeds. Goes away after driving for 15 miles or so, and at least a half hour. Returns after vehicle cools off. Cruise control: Adaptive cruise sometimes causes extreme braking at highway speeds for no reason. This happened while driving past a vehicle on Alligator alley causing all my passengers to comment, even though I had not touched the brake. Happened again 10/28 on 75 coming down from Sarasota. Braking: ABS engages on dry roads, especially when turning, for example into a driveway, but it cold be just a normal stop for a traffic light. The brakes also “grab” when coming to final stop, causing the car to stop suddenly

I had the safety recall 21V735000 performed on October 12, 2021. Within 2 days the same problem of rear-view backup camera blue screen recurred, just as it did before the recall. The problem happens in about 1/3 of trips. Once the blue screen occurs, it doesn't go away until powering off the vehicle, waiting a few minutes, and then upon powering the vehicle on the rear backup camera might work again for a while, but will usually break again the same day.

When putting the car in reverse it jerks back if the pedal is touched which has almost caused an accident. It takes about a minute or two to adjust backing up and the rear camera does not show until the clutch has adjusted.

Third row seat won't go up or down (it is an electrical seat for folding flat or to lift back up for seating). On Aug 12, 2021 took it to Ford dealership near me for any appointment to have fixed. In morning of Friday 13th dealership said still hadn't figured out the problem. By afternoon of 13th August dealership said it is either module or buttons issue and said they needed keep it over weekend. Dealership said they d call me by noon on Monday 16th August to let me know. Well, since I hadn't heard from then I called them again (as I have been doing since they dont seem to communicate with customers). Callie of Service dept said its the buttons/switches. That must order them; closest place had them is Tennessee she said. We are concerned for we had these exact issues with 2015 Explorer; started with 3rd row seat then all other electrical issues started happening. That explorer suv was in shop for several months.

Constant shuddering between 30-45mph. Local dealer fobs it off as typical, I've driven other 2020 and 2021 Explorers, none have exhibited similar symptoms. Dealer refuses to repair, Ford corporate will not investigate. Has already had one rear axle replaced under warranty, not waiting another 3 weeks for parts when this one breaks again.

Adaptive Cruise control reads the overhead electronic posted 65MPH speed limit signs as 85MPH. This only occurs when traveling on I-670 eastbound between Leonard Ave and I-270 on the east side of Columbus Ohio...This section of highway was recently upgraded with "Smart Lane" overhead electronic signs. The dash on this vehicle shows the posted speed limit at all times, but if the cruise control is on the vehicle with automatically go to what it reads and in this case goes to 85MPH! I have driven this vehicle over 5000 miles in 4 different states and this situation only occurs at this particular locatiion. I have contacted State of Ohio, Department of Trtansportation and discussing this issue with Drive Ohio representative Luke Stedke ( Luke.Stedke@drive.ohio.gov)

The transmission in the Ford Explorer failed on June 28th. This was noticed by observing the vehicle struggle to shift gears, and sometimes failing to shift at all resulting in extremely high RPMs. It also resulted in rough transitions from Park to Drive, combined with lurching forward suddenly. The vehicle is currently awaiting service at the Ford dealership, which was originally scheduled for June 29th. Upon notification to the dealership (where vehicle was purchased) of a transmission issue, the dealership moved the appointment to July 6th, thus encouraging me to drive a dangerous vehicle until then. During the next couple of days, the car intermittently exhibited both check engine and service lights, but neither consistently. It also produced another alert which automatically put the car into park from drive. Once the car turned off and back on, the alert did not repeat. The car was then taken to a separate dealership where it was diagnosed with a defective transmission due to an engine coolant leak. The dealership did not provide any means of transportation in response despite the vehicle being under warranty.

The front tires chewed to pieces, one blew, and the dealer initially felt it was an alignment issue from the factory. Up one further inspection, they found an aluminum toe rod with a 45 degree bend. I believe this was a factory issue as we hit nothing on the highway. It seems from an FMEA point of view, it is likely the blown tire and momentum of the car bent the tie rod and that the tire damage was caused by a part failure or some other issue with the car. It is a 3 month old car with 9,400 miles. The car struck Nothing on the highway.

I NOTICED TRANSMISSION FLUID ON THE GARAGE FLOOR. MARCH 27,2021. DROPPED THE CAR OF AT THE DEALERSHIP WHERE I BOUGHT THE CAR. 2021 FORD EXPLORER ST WITH 2120 MILES I PURCHASED ON JANUARY 30, 2021. PROBLEM WAS DIAGNOSED AS LEAKS AT THE TRANSFER CASE SEALS ON THE TRANSMISSION OUTPUT DRIVE TRAIN. THE BOOTS WERE LEAKING TRANSMISSION FLUID. THE TRANSFER CASE NEEDED TO BE REMOVED AND THE SEALS REPLACED. THIS RESULTED IN WAITING 6 WEEKS FOR THE PARTS TO BE DELIVERED AND 1 WEEK MORE TO REPAIR AND INSTALL. TODAY I STILL DO NOT HAVE MY CAR BACK. WEEK 7 WILL BE NEXT WEEK WHEN COMPLETION IS ESTIMATED TO BE .

I PURCHASED A FORD EXPLORER ST 2021 IN NEW YORK FROM CITY WORLD FORD ON BOSTON RD IN THE BRONX ON APRIL 22, 2021 AT APPROXIMATELY 9:37PM. I TOOK MY CAR HOME THE SAME SAME DAY. THE FOLLOWING DAY (SECOND DAY) I STARTED EXPERIENCING A PRE-COLLISION ASSIST NOT AVAILABLE AND POWERTRAIN MALFUNCTION/REDUCED POWER LIGHT ON MY DASHBOARD AT 12:49 PM. THE CAR BEGAN TO JERK AND FELT LIKE IT WAS ON AWD MODE. THE GAS PEDAL WAS HEAVY AND DIFFICULT TO DRIVE WHILE I WAS ON THE HIGHWAY WITH MY CHILDREN. I STARTED TO SMELL FIRE COMING FROM THE INSIDE OF MY CAR. ONCE I STARTED EXPERIENCING THOSE PROBLEMS FROM MY CAR I IMMEDIATELY PARKED THE CAR. I IMMEDIATELY CALLED THE DEALERSHIP DIDN'T GET AN ANSWER SO I DROVE TO THEM PERSONALLY AFTER I LET IT COOL DOWN FOR A COUPLE OF HOURS. I EXPLAINED THE PROBLEM I EXPERIENCED WITH THE CAR TO THEM. THE DEALERSHIP STATED TO ME TO TAKE IT TO THE REPAIR SHOP THE MONDAY AND I DID. THE NEXT DAY (TUESDAY) I PICKED UP THE CAR FROM REPAIR SERVICE CENTER. THE NEXT DAY I STARTED EXPERIENCING THE SAME PROBLEMS WITH THE FORD. I WENT BACK TO THE DEALERSHIP ON WEDNESDAY (NEXT DAY) AND STATED I WANTED A NEW CAR OR EXCHANGE FOR A DIFFERENT CAR. MANAGER STATED I HAD TO TAKE THE CAR FOR SECOND TIME FOR REPAIR. I THEN TOOK THE CAR FOR THE SECOND TIME FOR REPAIR ON WEDNESDAY. THE CAR IS CURRENTLY STILL IN THE REPAIR SERVICE CENTER AND STILL DISPLAYING MALFUNCTIONS AFTER BEING REPAIRED IN THE REPAIR SERVICE CENTER. I HAVE NOT YET RECEIVED MY CAR BACK AND REPAIR CENTER STATED THEY ARE NOT SURE WHEN WILL THE PROBLEM WILL BE FIXED AND WORKING PROPERLY.

THE WHEEL WELLS OF THE VEHICLE COLLECT LARGE AMOUNTS OF SNOW AND ICE. THIS BUILD UP CONSTRICTS THE WHEELS OF THE VEHICLE CONTACTING THE TIRES RESTRICTING ROTATION AND STEERING. THIS IS AN EXTREMELY DANGEROUS POTENTIALLY DEADLY SITUATION. WE HAVE CONTACTED FORD MOTOR COMPANY AND THE DEALERSHIP. NO REMEDY TO THIS SITUATION HAS BEEN OFFERED. PLEASE INVESTIGATE AND ANY ASSISTANCE IS APPRECIATED. I BELIEVE THIS IS A WIDE SPREAD PROBLEM FORD IS UNWILLING TO DEAL WITH. THIS CONDITION OCCURS IN COLD WEATHER AND SNOWY ICY CONDITIONS. THE BUILD UP HAZARD HAPPENS EVEN DRIVING SHORT HIGHWAY DISTANCES.